2013 SSANGYONG NEW ACTYON SPORTS sensor

01-16
(4) Sun-load sensor
Remove the sun-load sensor and measure the current between the terminals with the sensor
exposed to direct sunlight.
Measure the current again in the shade. If this value is lower than the measured value in the
sunlight, the sensor is intact.
Turn the ignition switch to the "ON" position.
Measure the voltage between the terminals of the sun sensor at the FATC connector. (approx. 2.5 V
under sunlight and approx. 4.8 V under shade)
If the voltage cannot be measured, check the wiring for open circuit. If the result is not as specified,
replace the FATC controller. A.
B.
C.
D.
E.

01-176810-01
1. SYSTEM LAYOUT (EXTERIOR)
Receiver drierA/C compressorLine and port
Ambient temperature sensorA/C condenserElectric fan

01-18
2. SYSTEM LAYOUT (INTERIOR)
Sun-load sensor
A/C controller
A/C Module assembly
Mode door actuatorAir mix door actuator

01-196810-01
Air source mode actuator
Duct temperature sensor
Thermo AMP
PTC
Power transistorBlower motor assemblyA/C filter

01-216810-01
1) Components
4. A/C MODULE
Mode door actuator
PTC heater assembly
Duct temperature sensor
Air mix door actuator
Air source door actuator
A/C antibacterial filter
Blower motor 1.
2.
3.
4.
5.
6.
7.Power transistor
Thermo AMP
Mode door
Heater core
Air mix door
Evaporator
Air source door 8.
9.
10.
11.
12.
13.
14.

01-22
2) Configuration
Air source door
caseA/C filter
Blower unit
(upper) case
Blower motor
assembly
Power
Transistor
A/C cable
assembly
Thermo AMP
Heater unit (right)
case
Air mix door
actuator
Lower duct
Mode door
link assembly Mode door
actuator Heater unit (left) case Mode doorHeater core Duct temperature
sensorEvaporatorBlower unit
(lower) case Air source door
actuator

01-236810-01
Mode door actuatorDuct temperature sensor
Air source door actuator
Power transistor
Blower motor
Thermo AMP Air mix door
actuator
A/C controller unit Interior
temperature
sensor Main wiring
connector
3) Wiring Layout

01-276810-01
7. FATC (FULL AUTO TEMP. CONTROL) CIRCUIT
1) PWM Motor, Compressor, Air Mix Motor, Sun Sensor