2004 MITSUBISHI L200 air filter

GENERAL INFORMATION
Used engine oils safety
instructions
EB12A-A
WARNING(1) Prolonged and repeated contact
may cause serious skin disor-
ders, including dermatitis and
cancer.
(2) Avoid contact with the skin as
far as possible and wash thor-
oughly after any contact.
(3) Keep out of reach of children.
Protect the environment
It is illegal to pollute drains, water courses
and soil. Use authorized waste collection
facilities, including civic amenity sites and
garages providing facilities for disposal of
used oil and used oil filters. If in doubt,
contact your local authority for advice on
disposal.
Driving and alcoholEB25A-Aa
Driving under the influence of alcohol is
one of the most frequent causes of acci-
dents.
Your driving ability can even be seriously
impaired with blood alcohol levels below
the legal minimum. If you are drinking,
don’t drive. Ride with a designated non-
drinking driver, call a cab, a friend, or use
public transportation.
WARNINGDriving after drinking can lead to an
accident. Your perceptions are less
sharp, your reflexes are slower, and
your judgement is impaired when
you have been drinking.
NEVER DRINK AND THEN DRIVE.
Safe driving techniques
EB26A-Cb
Driving safety and protection against in-
jury cannot be fully ensured. However, we
recommend that you pay extra attention to
the following:
(1) Before starting the vehicle, make sure
that you and your passengers have
fastened your seat belts.
(2) Never leave your vehicle unattended
with the key in the ignition and
children inside the vehicle. Children
may play with the driving controls and
this could lead to an accident.
(3) Make sure that infants and small chil-
dren are properly restrained in accor-
dance with the laws and regulations,
and for maximum protection in case
of an accident.
1-17
01engL2_240082_4 22-01-2004 12:58 Page 1-17

FOR EMERGENCIES
4. Check the coolant level in the reserve
tank. If there is none, make sure that
the engine has cooled down before
removing the radiator cap, because
hot steam or boiling water otherwise
will gush from the filler port and may
scald you.
5. Add coolant to the radiator and/or
reserve tank if necessary (refer to the
“Maintenance” section).
CAUTIONAdding cold water rapidly when the
engine is hot could cause the cylin-
der head and/or block to crack, add
the water a little at a time while run-
ning the engine.
Bleeding the fuel system
(diesel-powered vehicles
only)
EN07A-La
The fuel system should be bled to remove
air as described below if the fuel supply is
exhausted during travel.
1. Loosen the air plug (A) at the top of
the fuel filter. 6. Examine the radiator hoses for
coolant leakage and the fan belts for
looseness or damage.
If there is anything wrong with the
cooling system or fan belt, have the
problem corrected at an authorized
MITSUBISHI dealer.
8-25
M36A003N07A007
A
08engL2_240082_4 22-01-2004 13:10 Page 8-25

FOR EMERGENCIES
2. Pump the hand pump (B) until there
are no more bubbles in the fuel
coming out of the air plug (A). When
doing this, place a cloth around the air
plug (A) to prevent the escaping fuel
from spraying about.
3. Tighten the air plug (A) when there
are no more bubbles in the fuel.
4. Continue pumping until the hand
pump (B) becomes stiff.
5. Finally, check to be sure that there is
no leakage of fuel.
If in doubt, consult your nearest au-
thorized MITSUBISHI dealer.
CAUTION
(1) Do not smoke or have any other
open flame near the vehicle
while bleeding the fuel system.
(2) Be sure to carefully clean away
any spilt fuel which could ignite
and cause a fire.
Removal of water from the
fuel filter (diesel- powered
vehicles only)
EN07B-Bc
If the warning lamp illuminates during
driving, it indicates that water has accu-
mulated in the fuel filter. If this occurs,
remove the water as described below.
1. Loosen the drain plug (A) at the bot-
tom of the fuel filter.
8-26
N07B011
A
N07A008
B
08engL2_240082_4 22-01-2004 13:10 Page 8-26

SPECIFICATIONS
*: Optional equipment
10-26

No.
ItemQuantityRecommended lubricants
1 Brake fluid As required Brake fluid DOT 3 or DOT 4
2 Clutch fluid As required Brake fluid DOT 3 or DOT 4
3 Engine coolant2500 models2WD 7.7 litres
DIA QUEEN SUPER LONG LIFE COOLANT or equivalent
[Includes 0.65 litre in the reserve tank] 4WD 7.8 litres
2400 models 7.7 litres
4 Automatic transmission fluid2WD 7.3 litres
ATF DEXRON II
4WD 7.7 litres
5 Manual transmission oilDiesel-powered vehicles 2.5 litres
Gear oil API classification GL-4, SAE 75W-85W or 75W-90
Petrol-powered vehicles 2.2 litres
6 Engine oilDiesel-powered
vehicles2WDOil pan 5.0 litres
Refer to page 9-2 Oil filter 0.8 litre
Oil cooler 0.4 litre
4WDOil pan 6.3 litres
Oil filter 0.8 litre
Oil cooler 0.4 litre
Petrol-powered vehiclesOil pan 4.0 litres
Oil filter 0.3 litre
7 Power steering fluid* As required ATF DEXRON III or DEXRON II
8 Washer fluid 5.0 litres –
9 Refrigerant (air conditioning)* 550 - 600 g HFC-134a
10 Differential oilFront 0.9 litreWithout limited slip differential:
Hypoid gear oil API classification GL-5 or higher
Above 10°C SAE 90
Below 10°C SAE 80W
With limited slip differential*:
DIA QUEEN LSD gear oil or CASTROL HYPOY LS
(Hypoid gear oil API classification GL-5 SAE 90) Rear2WD 1.6 litres
4WD 2.6 litres
11 Transfer oil 2.3 litres
Hypoid gear oil API classification GL-4 SAE 75W-85W or 75W-90
10engL2_240082_4 22-01-2004 13:14 Page 10-26

INDEX
4WD indication lamp
(4-wheel drive vehicles) .......................... 5-22
Accessory boxes ....................................... 6-35
Accessory (Installation) ............................. 1-13
Additional equipment ................................. 9-17
Antenna (Pillar antenna) ............................ 6-18
Anti-lock brake system (ABS) .................... 5-33
Armrest ........................................................ 3-7
Ashtray ...................................................... 6-34
Audio system
Anti-theft system ..................................... 6-15
Automatic air conditioning ......................... 6-25
Automatic transmission
Fluid .......................................................... 9-4
Possible driving speed ............................ 5-19
Selector positions.................................... 5-17
Warning lamp ............................................ 4-8
Battery ......................................................... 9-6
Charge warning lamp ................................ 4-8
Discharged battery
(Emergency starting) ............................ 8-27
Bonnet ......................................................... 2-7
Brake system
Anti-lock brake ........................................ 5-33
Braking .................................................... 5-32
Fluid .......................................................... 9-8
Parking brake .......................................... 5-30
Pedal free play ........................................ 9-14
Warning lamp ............................................ 4-9
Bulb capacity, replacement ....................... 8-34Door-ajar warning lamp ............................... 4-7
Doors ........................................................... 2-4
Central door locks ..................................... 2-7
Child protection ......................................... 2-6
Lock and unlock ........................................ 2-4
Economical driving ...................................... 5-6
Electric remote-controlled
outside rear-view mirrors ........................ 5-38
Electric window control ................................ 2-9
Electronic immobilizer.................................. 2-2
Emergency starting.................................... 8-27
Engine number .......................................... 10-2
Engine
Coolant...................................................... 9-5
Number ................................................... 10-2
Oil .............................................................. 9-2
Used oil ................................................... 1-16
Exterior and interior lamp operation .......... 9-14
Fluid
Automatic transmission fluid ..................... 9-4
Brake fluid ............................................. 10-26
Clutch fluid ..................................... 9-9, 10-26
Manual transmission fluid ..................... 10-26
Power steering fluid ....................... 9-9, 10-26
Washer fluid ............................................ 9-10
Fuel filter indication lamp ............................. 4-9
Fuel
Capacity /(Filling the fuel tank).................. 5-3
Fuel gauge ................................................ 4-3
Low fuel indication lamp............................ 4-7
Fuse load capacity..................................... 8-31
Fuses ......................................................... 8-30 Capacities ................................................ 10-25
Catalytic converter ....................................... 5-5
Cautions on handling of 4WD vehicles...... 5-29
Central door locks........................................ 2-7
Changing a fuse ........................................ 8-33
Charge warning lamp .................................. 4-8
Chassis number......................................... 10-2
“Child-protection” rear door ......................... 2-6
Child restraint ............................................ 3-11
Cigarette lighter ......................................... 6-33
Cleaning the inside of your vehicle .............. 7-2
Genuine leather ........................................ 7-3
Plastic, Vinyl leather, etc. .......................... 7-3
Cleaning the outside of your vehicle............ 7-4
Chrome parts ............................................ 7-6
Damaged paint.......................................... 7-6
Polishing ................................................... 7-6
Washing .................................................... 7-4
Waxing ...................................................... 7-5
Clock (Digital) ............................................ 6-34
Clutch
Fluid .......................................................... 9-9
Pedal free play ........................................ 9-14
Combination headlamps,
dipper and turn signal switch .................. 4-12
Coolant (Engine).......................................... 9-5
Correct 4-wheel drive operation ................ 5-26
Cup tray ..................................................... 6-37
Day/Night Type inside rear-view mirror ..... 5-37
Diesel fuel ................................................ 10-24
Diesel preheat warning lamp ..................... 4-10
Digital clock ............................................... 6-34
Dimensions ......................... 10-5, 10-11, 10-17
10-27
10engL2_240082_4 22-01-2004 13:14 Page 10-27

INDEX
Gauges ........................................................ 4-3
Genuine parts ............................................ 1-15
Glove box .................................................. 6-35
Hazard warning flasher switch .................. 4-18
Hazard warning indication lamp .................. 4-7
Headlamp
Headlamp levelling switch ...................... 4-14
Headlamps
Headlamps, Dipper, Passing .................. 4-12
Replacement ........................................... 8-35
Washer switch......................................... 4-17
Head restraints ............................................ 3-5
Heated seats ............................................... 3-7
Heater/Air conditioning .............................. 6-19
High-beam indication lamp .......................... 4-7
Hinges and latches lubrication................... 9-16
Horn switch ................................................ 4-20
Ignition switch .............................................. 5-9
Inclinometer ................................................. 4-4
Indication and warning lamps ...................... 4-6
Inside rear-view mirror ............................... 5-37
Installation of accessories ......................... 1-13
Instruments .................................................. 4-2
Jack ............................................................. 8-5
Jack handle ................................................. 8-7
Jacking up the vehicle ................................. 8-8
Jump starting (Emergency starting) .......... 8-27
Keyless entry system................................... 2-5
Keys............................................................. 2-2Leakage (Fuel, engine coolant,
oil and exhaust gas) ................................ 9-14
Light
Bulb capacity........................................... 8-34
Headlamps .............................................. 4-12
Room lamps ............................................ 4-20
Limited-slip differential ............................... 5-35
Low fuel indication lamp .............................. 4-7
Manual transmission
Driving speed .......................................... 5-14
Shifting .................................................... 5-14
Manual window control ................................ 2-9
Meter, gauge and indication/warning
lamp operation ........................................ 9-14
Meter illumination control........................... 4-20
Mirrors
Day/Night Type inside rear-view mirror .. 5-37
Electric remote-controlled
outside rear-view mirrors ...................... 5-38
Vanity mirror............................................ 6-32
Octane rating ............................................... 5-3
Odometer/Tripmeter .................................... 4-3
Oil pressure warning lamp ........................... 4-9
Oil
Engine oil ....................................... 9-2, 10-26
Manual transmission oil ........................ 10-26
Operation under adverse
driving conditions ...................................... 8-2
Overheating (Engine) ................................ 8-23Parking ............................................. 5-20, 5-32
Parking brake ............................................ 5-30
Performance ....................... 10-5, 10-11, 10-18
Pillar antenna............................................. 6-18
Polishing ...................................................... 7-6
Power steering
Fluid ............................................... 9-9, 10-26
System .................................................... 5-37
Pregnant women restraint ......................... 3-20
Punctured .................................................. 8-16
Quarter window ......................................... 2-11
Rear differential lock .................................. 5-23
Rear fog lamp switch ................................. 4-19
Rear gate ................................................... 2-12
Rear heater................................................ 6-30
Rear seat ..................................................... 3-5
Rear secret box ......................................... 6-37
Rear window demister switch .................... 4-18
Rear-view mirrors ...................................... 5-37
Removal of water from the fuel filter
(diesel-powered vehicles only) ............... 8-26
Replacement of lamp bulbs ....................... 8-34
Front turn-signal and position lamps ....... 8-36
Headlamps .............................................. 8-35
High-mounted stop lamps ....................... 8-38
Side turn-signal lamps ............................ 8-36
Number-plate lamps ............................... 8-37
Rear combination lamps ......................... 8-37
Rear fog lamps........................................ 8-38
Rheostat .................................................... 4-20
Roof drip moulding .................................... 1-14
Room lamps .............................................. 4-20
10-28
10engL2_240082_4 22-01-2004 13:14 Page 10-28