2004 MITSUBISHI L200 fuel pump

FOR EMERGENCIES
2. Pump the hand pump (B) until there
are no more bubbles in the fuel
coming out of the air plug (A). When
doing this, place a cloth around the air
plug (A) to prevent the escaping fuel
from spraying about.
3. Tighten the air plug (A) when there
are no more bubbles in the fuel.
4. Continue pumping until the hand
pump (B) becomes stiff.
5. Finally, check to be sure that there is
no leakage of fuel.
If in doubt, consult your nearest au-
thorized MITSUBISHI dealer.
CAUTION
(1) Do not smoke or have any other
open flame near the vehicle
while bleeding the fuel system.
(2) Be sure to carefully clean away
any spilt fuel which could ignite
and cause a fire.
Removal of water from the
fuel filter (diesel- powered
vehicles only)
EN07B-Bc
If the warning lamp illuminates during
driving, it indicates that water has accu-
mulated in the fuel filter. If this occurs,
remove the water as described below.
1. Loosen the drain plug (A) at the bot-
tom of the fuel filter.
8-26
N07B011
A
N07A008
B
08engL2_240082_4 22-01-2004 13:10 Page 8-26

FOR EMERGENCIES
2. Operate the hand pump (B) slowly 6
or 7 times in order to force the water
out through the drain plug (A).
3. Tighten the drain plug (A) when water
no longer comes out.
4. Loosen the air plug and bleed the air.
(Refer to “Bleeding the fuel system.”)
5. Check to be sure that the warning
lamp illuminates when the ignition key
is turned to “ON”, and that it goes off
when the engine is started. If in doubt,
consult your nearest authorized
MITSUBISHI dealer.
Emergency startingEN28A-Te
If the engine cannot be started because
the battery is weak or dead, the battery
from another vehicle can be used with
jumper cables to start the engine.
WARNINGTo start the engine by use of jumper
cables from another vehicle, per-
form the correct procedures accord-
ing to the instruction manual. Incor-
rect procedures could result in a fire
or explosion or damage to the vehi-
cles.
1. Get the vehicles close enough so the
jumper cables can reach, but be sure
the vehicles aren’t touching each
other. If they are, it could cause a
ground connection you don’t want.
The vehicle will not start, and the bad
grounding could damage the electri-
cal systems.
CAUTIONCheck the other vehicle. It must have
a 12-volt battery.
If the other system isn’t 12-volt,
shorting can damage both vehicles.
CAUTION(1) Do not smoke or have any other
open flame near the vehicle
while bleeding the fuel system.
(2) Be sure to carefully clean away
any water drained out because
any fuel mixed with the water
could ignite and cause a fire.
8-27
N07B005
B
A
08engL2_240082_4 22-01-2004 13:10 Page 8-27

SPECIFICATIONS
Other specifications EP01IPO
*: Optional equipment
10-9

Item
Diesel-powered vehicles
2WD4WDWith turbochargerWithout turbocharger
Combustion type Indirect injection
Fuel injection pump Electronically controlled Mechanical Electronically controlled
Clutch Dry single disc clutch with diaphragm spring, hydraulic action
Steering system Recirculating ball type, power assisted*Recirculating ball type,
power assisted
SuspensionFront Independent type, wishbone, coil springIndependent type, wishbone,
torsion bar
Rear Rigid type, leaf spring
Service brakesType Hydraulic, front and rear splitted double circuit system with power assistance, anti-lock brake*
Front Ventilated disc brakes
Rear Drum brakes
Parking brake Parking brake acts mechanically on rear wheels
10engL2_240082_4 22-01-2004 13:14 Page 10-9

SPECIFICATIONS
Other specifications EP01IPE
*: Optional equipment
10-15

Item
Diesel-powered vehiclesPetrol-powered vehicles
Combustion type Indirect injection Electronic controlled injection
Fuel injection pump Electronically controlled Electric motor type
Clutch Dry single disc clutch with diaphragm spring, hydraulic action
Steering system Recirculating ball type, power assisted
SuspensionFront Independent type, wishbone, torsion bar
Rear Rigid type, leaf spring
Service brakes
Type Hydraulic, front and rear splitted double circuit system with power assistance, anti-lock brake*
Front Ventilated disc brakes
Rear Drum brakes
Parking brake Parking brake acts mechanically on rear wheels
10engL2_240082_4 22-01-2004 13:14 Page 10-15

SPECIFICATIONS
Other specifications EP01IPS
*: Optional equipment
10-23

Item
2WD4WD
With turbochargerWithout turbochargerWith catalytic converterWithout catalytic converter
Combustion type Indirect injection
Fuel injection pumpElectronically
controlledMechanicalElectronically
controlledMechanical
Clutch Dry single disc clutch with diaphragm spring, hydraulic action
Steering system Recirculating ball type, power assisted* Recirculating ball type, power assisted
SuspensionFront Independent type, wishbone, coil spring Independent type, wishbone, torsion bar
Rear Rigid type, leaf spring
Service brakesType Hydraulic, front and rear splitted double circuit system with power assistance, anti-lock brake*
Front Ventilated disc brakes
Rear Drum brakes
Parking brake Parking brake acts mechanically on rear wheels
10engL2_240082_4 22-01-2004 13:14 Page 10-23