2004 MITSUBISHI L200 oil filter

GENERAL INFORMATION
Used engine oils safety
instructions
EB12A-A
WARNING(1) Prolonged and repeated contact
may cause serious skin disor-
ders, including dermatitis and
cancer.
(2) Avoid contact with the skin as
far as possible and wash thor-
oughly after any contact.
(3) Keep out of reach of children.
Protect the environment
It is illegal to pollute drains, water courses
and soil. Use authorized waste collection
facilities, including civic amenity sites and
garages providing facilities for disposal of
used oil and used oil filters. If in doubt,
contact your local authority for advice on
disposal.
Driving and alcoholEB25A-Aa
Driving under the influence of alcohol is
one of the most frequent causes of acci-
dents.
Your driving ability can even be seriously
impaired with blood alcohol levels below
the legal minimum. If you are drinking,
don’t drive. Ride with a designated non-
drinking driver, call a cab, a friend, or use
public transportation.
WARNINGDriving after drinking can lead to an
accident. Your perceptions are less
sharp, your reflexes are slower, and
your judgement is impaired when
you have been drinking.
NEVER DRINK AND THEN DRIVE.
Safe driving techniques
EB26A-Cb
Driving safety and protection against in-
jury cannot be fully ensured. However, we
recommend that you pay extra attention to
the following:
(1) Before starting the vehicle, make sure
that you and your passengers have
fastened your seat belts.
(2) Never leave your vehicle unattended
with the key in the ignition and
children inside the vehicle. Children
may play with the driving controls and
this could lead to an accident.
(3) Make sure that infants and small chil-
dren are properly restrained in accor-
dance with the laws and regulations,
and for maximum protection in case
of an accident.
1-17
01engL2_240082_4 22-01-2004 12:58 Page 1-17

INSTRUMENTS AND CONTROLS
Indication and warning lampsED50APDc
1 - Automatic transmission indication lamp
(vehicle with automatic transmission) →p. 5-16
2 - Turn-signal indication lamps / Hazard warning indication
lamps
3 - High-beam indication lamp
4 - Low fuel indication lamp
5 - Check engine indication lamp (diesel-powered vehicles)*
6 - Supplemental restraint system (SRS) warning lamp*
→p. 3-29
7 - Door ajar warning lamp
8 - Anti-lock brake (ABS) warning lamp
(diesel-powered vehicles)* →p. 5-34
9 - Overdrive off indication lamp
(vehicle with automatic transmission) →p. 5-18
10 - Rear fog lamp indication lamp*11 - A/T (automatic transmission) temperature warning lamp*
12 - 4WD indication lamp (4-wheel drive vehicles) →p. 5-22
13 - Charge warning lamp
14 - Oil pressure warning lamp
15 - Fuel filter indication lamp (diesel-powered vehicles)
16 - Brake warning lamp
17 - Diesel preheat warning lamp (diesel- powered vehicles)
18 - Check engine indication lamp (petrol-powered vehicles)
19 - Anti-lock brake (ABS) warning lamp
(petrol-powered vehicles)* →p. 5-34
NOTE
To find information concerning the indication or warning lamps
marked by the symbol “ →p. x-xx”, refer to the specified pages.
For the other indication and warning lamps, refer to the subse-
quent pages.
4-6
D50A467
12 32
4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
04engL2_240082_4 22-01-2004 13:19 Page 4-6

INSTRUMENTS AND CONTROLS
Oil pressure warning lamp - redED25A-Ai
This lamp illuminates when the ignition key is
turned “ON”, and goes off after the engine has
started. If it illuminates while the engine is run-
ning, the oil pressure is too low.
If the warning lamp illuminates while the engine is
running, turn the engine off. And contact your near-
est authorized MITSUBISHI dealer for inspection.
CAUTION(1) If this lamp illuminates when the engine
oil level is not low, contact your nearest
authorized MITSUBISHI dealer for in-
spection.
(2) This warning lamp does not indicate
the amount of oil in the crankcase. This
must be determined by checking the oil
level on the dipstick, while the engine
is switched off.
(3) If you continue driving with low engine
oil level or with this warning lamp illu-
minated, engine seizure may occur.
NOTE
The oil pressure warning lamp should not be
treated as an indication of the engine’s oil level.
The oil level must be checked using the dipstick.
Fuel filter indication lamp - amber
(diesel-powered vehicles only)
ED59A-Bc
This lamp illuminates when the ignition switch is
turned to the “ON” position and goes off after the
engine has started. If it lamps up while the engine
is running, it indicates that water has accumul-
ated inside the fuel filter; if this happens, remove
the water from the fuel filter.
When the lamp goes out, you can resume driving.
If it either does not go out or comes on from time to
time, have the vehicle inspected at an authorized
MITSUBISHI dealer.
Brake warning lamp - redED23A-Ie
With the ignition switch “ON”, the brake warning
lamp illuminates under the following conditions:
(1)
When the parking brake lever has been engaged.(2) When the brake fluid level in the reservoir
falls to a low level.
(3) If a malfunction develops in the brake servo
system. (Diesel-powered vehicles only)
(4)
If the brake warning lamp and charge warning
lamp come on at the same time while the en-
gine is running, it is possible that the alternator
belt is broken. (Diesel-powered vehicles only)
4-9
04engL2_240082_4 22-01-2004 13:19 Page 4-9

FOR EMERGENCIES
4. Check the coolant level in the reserve
tank. If there is none, make sure that
the engine has cooled down before
removing the radiator cap, because
hot steam or boiling water otherwise
will gush from the filler port and may
scald you.
5. Add coolant to the radiator and/or
reserve tank if necessary (refer to the
“Maintenance” section).
CAUTIONAdding cold water rapidly when the
engine is hot could cause the cylin-
der head and/or block to crack, add
the water a little at a time while run-
ning the engine.
Bleeding the fuel system
(diesel-powered vehicles
only)
EN07A-La
The fuel system should be bled to remove
air as described below if the fuel supply is
exhausted during travel.
1. Loosen the air plug (A) at the top of
the fuel filter. 6. Examine the radiator hoses for
coolant leakage and the fan belts for
looseness or damage.
If there is anything wrong with the
cooling system or fan belt, have the
problem corrected at an authorized
MITSUBISHI dealer.
8-25
M36A003N07A007
A
08engL2_240082_4 22-01-2004 13:10 Page 8-25

SPECIFICATIONS
*: Optional equipment
10-26

No.
ItemQuantityRecommended lubricants
1 Brake fluid As required Brake fluid DOT 3 or DOT 4
2 Clutch fluid As required Brake fluid DOT 3 or DOT 4
3 Engine coolant2500 models2WD 7.7 litres
DIA QUEEN SUPER LONG LIFE COOLANT or equivalent
[Includes 0.65 litre in the reserve tank] 4WD 7.8 litres
2400 models 7.7 litres
4 Automatic transmission fluid2WD 7.3 litres
ATF DEXRON II
4WD 7.7 litres
5 Manual transmission oilDiesel-powered vehicles 2.5 litres
Gear oil API classification GL-4, SAE 75W-85W or 75W-90
Petrol-powered vehicles 2.2 litres
6 Engine oilDiesel-powered
vehicles2WDOil pan 5.0 litres
Refer to page 9-2 Oil filter 0.8 litre
Oil cooler 0.4 litre
4WDOil pan 6.3 litres
Oil filter 0.8 litre
Oil cooler 0.4 litre
Petrol-powered vehiclesOil pan 4.0 litres
Oil filter 0.3 litre
7 Power steering fluid* As required ATF DEXRON III or DEXRON II
8 Washer fluid 5.0 litres –
9 Refrigerant (air conditioning)* 550 - 600 g HFC-134a
10 Differential oilFront 0.9 litreWithout limited slip differential:
Hypoid gear oil API classification GL-5 or higher
Above 10°C SAE 90
Below 10°C SAE 80W
With limited slip differential*:
DIA QUEEN LSD gear oil or CASTROL HYPOY LS
(Hypoid gear oil API classification GL-5 SAE 90) Rear2WD 1.6 litres
4WD 2.6 litres
11 Transfer oil 2.3 litres
Hypoid gear oil API classification GL-4 SAE 75W-85W or 75W-90
10engL2_240082_4 22-01-2004 13:14 Page 10-26

INDEX
4WD indication lamp
(4-wheel drive vehicles) .......................... 5-22
Accessory boxes ....................................... 6-35
Accessory (Installation) ............................. 1-13
Additional equipment ................................. 9-17
Antenna (Pillar antenna) ............................ 6-18
Anti-lock brake system (ABS) .................... 5-33
Armrest ........................................................ 3-7
Ashtray ...................................................... 6-34
Audio system
Anti-theft system ..................................... 6-15
Automatic air conditioning ......................... 6-25
Automatic transmission
Fluid .......................................................... 9-4
Possible driving speed ............................ 5-19
Selector positions.................................... 5-17
Warning lamp ............................................ 4-8
Battery ......................................................... 9-6
Charge warning lamp ................................ 4-8
Discharged battery
(Emergency starting) ............................ 8-27
Bonnet ......................................................... 2-7
Brake system
Anti-lock brake ........................................ 5-33
Braking .................................................... 5-32
Fluid .......................................................... 9-8
Parking brake .......................................... 5-30
Pedal free play ........................................ 9-14
Warning lamp ............................................ 4-9
Bulb capacity, replacement ....................... 8-34Door-ajar warning lamp ............................... 4-7
Doors ........................................................... 2-4
Central door locks ..................................... 2-7
Child protection ......................................... 2-6
Lock and unlock ........................................ 2-4
Economical driving ...................................... 5-6
Electric remote-controlled
outside rear-view mirrors ........................ 5-38
Electric window control ................................ 2-9
Electronic immobilizer.................................. 2-2
Emergency starting.................................... 8-27
Engine number .......................................... 10-2
Engine
Coolant...................................................... 9-5
Number ................................................... 10-2
Oil .............................................................. 9-2
Used oil ................................................... 1-16
Exterior and interior lamp operation .......... 9-14
Fluid
Automatic transmission fluid ..................... 9-4
Brake fluid ............................................. 10-26
Clutch fluid ..................................... 9-9, 10-26
Manual transmission fluid ..................... 10-26
Power steering fluid ....................... 9-9, 10-26
Washer fluid ............................................ 9-10
Fuel filter indication lamp ............................. 4-9
Fuel
Capacity /(Filling the fuel tank).................. 5-3
Fuel gauge ................................................ 4-3
Low fuel indication lamp............................ 4-7
Fuse load capacity..................................... 8-31
Fuses ......................................................... 8-30 Capacities ................................................ 10-25
Catalytic converter ....................................... 5-5
Cautions on handling of 4WD vehicles...... 5-29
Central door locks........................................ 2-7
Changing a fuse ........................................ 8-33
Charge warning lamp .................................. 4-8
Chassis number......................................... 10-2
“Child-protection” rear door ......................... 2-6
Child restraint ............................................ 3-11
Cigarette lighter ......................................... 6-33
Cleaning the inside of your vehicle .............. 7-2
Genuine leather ........................................ 7-3
Plastic, Vinyl leather, etc. .......................... 7-3
Cleaning the outside of your vehicle............ 7-4
Chrome parts ............................................ 7-6
Damaged paint.......................................... 7-6
Polishing ................................................... 7-6
Washing .................................................... 7-4
Waxing ...................................................... 7-5
Clock (Digital) ............................................ 6-34
Clutch
Fluid .......................................................... 9-9
Pedal free play ........................................ 9-14
Combination headlamps,
dipper and turn signal switch .................. 4-12
Coolant (Engine).......................................... 9-5
Correct 4-wheel drive operation ................ 5-26
Cup tray ..................................................... 6-37
Day/Night Type inside rear-view mirror ..... 5-37
Diesel fuel ................................................ 10-24
Diesel preheat warning lamp ..................... 4-10
Digital clock ............................................... 6-34
Dimensions ......................... 10-5, 10-11, 10-17
10-27
10engL2_240082_4 22-01-2004 13:14 Page 10-27

INDEX
Gauges ........................................................ 4-3
Genuine parts ............................................ 1-15
Glove box .................................................. 6-35
Hazard warning flasher switch .................. 4-18
Hazard warning indication lamp .................. 4-7
Headlamp
Headlamp levelling switch ...................... 4-14
Headlamps
Headlamps, Dipper, Passing .................. 4-12
Replacement ........................................... 8-35
Washer switch......................................... 4-17
Head restraints ............................................ 3-5
Heated seats ............................................... 3-7
Heater/Air conditioning .............................. 6-19
High-beam indication lamp .......................... 4-7
Hinges and latches lubrication................... 9-16
Horn switch ................................................ 4-20
Ignition switch .............................................. 5-9
Inclinometer ................................................. 4-4
Indication and warning lamps ...................... 4-6
Inside rear-view mirror ............................... 5-37
Installation of accessories ......................... 1-13
Instruments .................................................. 4-2
Jack ............................................................. 8-5
Jack handle ................................................. 8-7
Jacking up the vehicle ................................. 8-8
Jump starting (Emergency starting) .......... 8-27
Keyless entry system................................... 2-5
Keys............................................................. 2-2Leakage (Fuel, engine coolant,
oil and exhaust gas) ................................ 9-14
Light
Bulb capacity........................................... 8-34
Headlamps .............................................. 4-12
Room lamps ............................................ 4-20
Limited-slip differential ............................... 5-35
Low fuel indication lamp .............................. 4-7
Manual transmission
Driving speed .......................................... 5-14
Shifting .................................................... 5-14
Manual window control ................................ 2-9
Meter, gauge and indication/warning
lamp operation ........................................ 9-14
Meter illumination control........................... 4-20
Mirrors
Day/Night Type inside rear-view mirror .. 5-37
Electric remote-controlled
outside rear-view mirrors ...................... 5-38
Vanity mirror............................................ 6-32
Octane rating ............................................... 5-3
Odometer/Tripmeter .................................... 4-3
Oil pressure warning lamp ........................... 4-9
Oil
Engine oil ....................................... 9-2, 10-26
Manual transmission oil ........................ 10-26
Operation under adverse
driving conditions ...................................... 8-2
Overheating (Engine) ................................ 8-23Parking ............................................. 5-20, 5-32
Parking brake ............................................ 5-30
Performance ....................... 10-5, 10-11, 10-18
Pillar antenna............................................. 6-18
Polishing ...................................................... 7-6
Power steering
Fluid ............................................... 9-9, 10-26
System .................................................... 5-37
Pregnant women restraint ......................... 3-20
Punctured .................................................. 8-16
Quarter window ......................................... 2-11
Rear differential lock .................................. 5-23
Rear fog lamp switch ................................. 4-19
Rear gate ................................................... 2-12
Rear heater................................................ 6-30
Rear seat ..................................................... 3-5
Rear secret box ......................................... 6-37
Rear window demister switch .................... 4-18
Rear-view mirrors ...................................... 5-37
Removal of water from the fuel filter
(diesel-powered vehicles only) ............... 8-26
Replacement of lamp bulbs ....................... 8-34
Front turn-signal and position lamps ....... 8-36
Headlamps .............................................. 8-35
High-mounted stop lamps ....................... 8-38
Side turn-signal lamps ............................ 8-36
Number-plate lamps ............................... 8-37
Rear combination lamps ......................... 8-37
Rear fog lamps........................................ 8-38
Rheostat .................................................... 4-20
Roof drip moulding .................................... 1-14
Room lamps .............................................. 4-20
10-28
10engL2_240082_4 22-01-2004 13:14 Page 10-28