2004 MITSUBISHI L200 run flat

STARTING AND DRIVING
5-7
(1)Starting
Avoid rapid acceleration and sudden
starts; such operation will result in
higher fuel consumption.
(2)Shifting
Shift only at an appropriate engine
speed. Always use the highest gear
possible.
The transfer shift lever should be set
to “2H” when driving 4WD vehicles on
normal roads and express ways to
obtain best possible fuel economy.
(3)City traffic
Frequent starting and stopping in-
creases the average fuel consump-
tion. Use roads with smooth traffic
flow whenever possible. When driving
on congested roads, avoid use of a
low gear at high engine speeds.
(4)Idling
The vehicle consumes fuel even dur-
ing idling. Avoid extended idling
whenever possible.
(5)Speed
The higher the vehicle speed, the
more fuel consumed. Avoid driving at
full speed. Even a slight release of the
accelerator pedal will save a signific-
ant amount of fuel.Trailer towingEC21APDd
In order to tow a trailer with your vehicle,
have a trailer towing device that meets all
pertinent regulations in your area mount-
ed at an authorized MITSUBISHI dealer.
The regulations concerning the towing of
a trailer may differ from country to country.
It is recommended that you obey the regu-
lations in each area.
CAUTIONDanger of Accident!
A towing bar should be fitted by an
authorized MITSUBISHI dealer.
NOTE
Fitting of a towing bar requires specialized
skills and equipment.
Contact an authorized MITSUBISHI dealer
for details. If you are going to tow a trailer,
pay careful attention to the following
points.
(6)Tyre inflation pressure
Check the tyre inflation pressures at
regular intervals. Low tyre inflation
pressure increases road resistance
and fuel consumption. In addition, low
tyre pressures adversely affect tyre
wear and driving stability.
(7)Load
Do not drive with unnecessary articles
in the luggage compartment. Espe-
cially during city driving where fre-
quent starting and stopping is ne-
cessary, the increased weight of the
vehicle will greatly affect fuel con-
sumption. Also avoid driving with un-
necessary luggage, etc., on the roof;
the increased air resistance will in-
crease more fuel consumption.
(8)Cold engine starting
Starting of a cold engine consumes
more fuel.
Unnecessary fuel consumption is also
caused by keeping a hot engine run-
ning. After the engine is started, com-
mence driving as soon as possible.
(9)Air conditioning*
The use of the air conditioning will in-
crease the fuel consumption.
05engL2_240082_4 22-01-2004 13:04 Page 5-7

FOR EMERGENCIES
NOTE
Take care when lowering the vehicle, as
sudden closure of the jack release valve
can cause damage to the jack.
3. Remove the jack.
NOTE
When the jack is difficult to remove by
hand, insert the jack handle into the holder
and hook the jack handle notch onto the
holder notch and secure it there. Then pull
the jack handle and remove the jack.
4. Press the piston down all the way,
and turn the release valve clockwise
as far as possible.
5. Store the jack and jack handle.
WARNING(1) Raise the vehicle so the tyre just
clears the ground. It is danger-
ous to raise the vehicle any
higher.
(2) Never get under the vehicle
while using the jack. Avoid jar-
ring the raised vehicle or leaving
it supported on the jack for any
longer than required. Both are
very dangerous.
(3) Do not start or run the engine
while the vehicle is on the jack.
The vehicle might start moving
and cause the vehicle to fall
down from the jack.
(4) Do not turn the jacked up
wheels. The tyres remaining on
the ground may turn, causing
the vehicle body to fall down
from the jack.
(5) No one should stay in the vehi-
cle while the jack is used.
(6) On vehicles with limited slip
differential, jack up the rear
wheel and keep it from turning.
If the raised wheel turns, the
wheel on the ground will roll the
vehicle off the jack.
CAUTIONUse only the jack supplied with the
vehicle and use it only for changing
wheels.
Spare wheelEN03APDd
The spare wheel is stored under the floor
of the cargo bed.
CAUTION(1) When removing the spare wheel,
it is recommended you wear
gloves. Removing the spare
wheel with your hands may
cause injury to the fingers.
(2) Check the air pressure in the
spare wheel weekly, making
sure it is ready for emergency
use at any time.
Driving with an insufficient tyre
pressure can lead to an acci-
dent. If you have no choice but
to drive with an insufficient tyre
pressure, keep your speed down
and inflate the tyre to the correct
pressure as soon as possible.
(Refer to “Tyre inflation pres-
sure” on page 9-11.)
Maintaining the spare wheel at
the highest specified air pres-
sure will ensure that it can al-
ways be used under any condi-
tions (city/high-speed driving,
varying load weight, etc.).
8-12
08engL2_240082_4 22-01-2004 13:10 Page 8-12

MAINTENANCE
This check must be carried out with the
vehicle on a flat level surface with the en-
gine at normal operating temperature, but
NOT running. If the engine has been run-
ning, wait for a few minutes to allow the
engine oil to return to the oil pan to ensure
an accurate measurement.
Remove the dipstick and wipe it with a
clean cloth, re-insert the dipstick as far as
it will go. Remove the dipstick and check
the oil level. This should always be within
the range as indicated.
If the oil level is below the specified limit,
remove the filler cap located on the rocker
cover and add oil. Then recheck the level.
When satisfied that the level is correct,
refit the oil filler cap making sure that it is
securely fitted.Selection of engine oil
(petrol-powered vehicle)
EM03B-Oe
(1) Select engine oil of the proper SAE
viscosity number according to the
atmospheric temperature.
For 0W-30, 5W-30 and 5W-40 viscos-
ity grade, use only ACEA A3 classifi-
cation.
(2) Use engine oil conforming to the fol-
lowing classification:
• ACEA classification:
“For service A1, A2 or A3”
• API classification:
“For service SG” or higher
NOTE
Use of additives is not recommended
since they may reduce the effectiveness
of additives already included in the engine
oil. It may result in failure of the mechani-
cal assembly. Use only the recommended oils with an
ACEA or API classification as specified in
this manual.
NOTE
(1) Engine oil consumption is greatly
influenced by payload, engine speed,
etc. It may reach 1.0 lit./1,000 km
depending on style of driving.
(2) The engine oil will deteriorate rapidly
if the vehicle is subjected to severe
conditions (for example, repeated op-
eration on rough roads, in mountain-
ous regions, on roads with many up-
hill and downhill gradients, or over
short distances). Consequently, the
oil will require earlier replacement.
(3) For handling of used engine oils, refer
to page 1-16.
9-3
M03A037
2400 model
M03B031
Petrol-powered vehicles
09engL2_240082_4 22-01-2004 13:12 Page 9-3

INDEX
Running-in recommendations ..................... 5-2
Safe driving techniques ............................. 1-16
Seat belts
Child restraint .......................................... 3-11
Inspection................................................ 3-20
Pregnant women restraint....................... 3-20
Seat belts .................................................. 3-8
Seat
Adjustment ................................................ 3-2
Armrest ..................................................... 3-7
Front seat .................................................. 3-3
Head restraints.......................................... 3-5
Heated seats ............................................. 3-7
Rear seat .................................................. 3-5
Snow tyres ................................................. 9-12
Spare wheel............................................... 8-12
Specifications ............................................ 10-2
Speedometer ............................................... 4-2
Starting ...................................................... 5-11
Starting the engine ........................... 5-11, 5-12
Steering
Power steering fluid ....................... 9-9, 10-26
Power steering system............................ 5-37
Steering lock ........................................... 5-11
Steering wheel height adjustment........... 5-36
Sun visors .................................................. 6-32
Supplemental restraint system
(SRS)-air bag .......................................... 3-20Washing....................................................... 7-4
Water temperature gauge ........................... 4-4
Waxing......................................................... 7-5
Weatherstripping ....................................... 9-17
Wheel
Caps........................................................ 8-15
Condition ................................................. 9-10
Windscreen wiper and washer switch ....... 4-15
Wiper blades ...................................... 7-7, 9-16 Tachometer ................................................. 4-3
Thermometer ............................................... 4-5
Tools..................................................... 8-3, 8-4
Towing ....................................................... 8-19
Trailer towing ............................................... 5-7
Transfer shift lever ..................................... 5-20
Transmission
Automatic transmission........................... 5-16
Fluid ............................................... 9-4, 10-26
Manual transmission ............................... 5-14
Tray under seat ......................................... 6-39
Tripmeter ..................................................... 4-3
Turn-signal
Indication lamps ........................................ 4-7
Switch ..................................................... 4-13
Tyre and wheels
Size................................... 10-8, 10-14, 10-22
Spare wheel ............................................ 8-12
Tyre chains ............................................. 9-13
Tyre inflation pressure ............................ 9-11
Tyre rotation .............................................. 9-11
UKW/MW/LW electronic tuning radio
with tape player ......................................... 6-2
Used engine oils safety instructions .......... 1-16
Vanity mirror .............................................. 6-32
Vehicle information code plate .................. 10-3
Ventilators.................................................. 6-18
Visor
Sun visors ............................................... 6-32
Voltage meter .............................................. 4-5
Washer fluid............................................... 9-10
10-29
10engL2_240082_4 22-01-2004 13:14 Page 10-29