2003 CHEVROLET C/K manual

6-47 Electric Air Compressor (If Equipped)
Your vehicle may be equipped with an electric air
compressor. This compressor is used to run options that
require pressurized air, such as an air horn, air seat,
exhaust restrictor or an exhaust brake.
This air compressor is used when vehicles are not
equipped with an air brake system.
The air supply for this
system must be maintained
by releasing the drain
valve to eject any moisture
that may have built up in
the system.
It is recommended that this system be drained on a
weekly basis.
Clutch Pedal Free Travel
If you have a manual transmission, your clutch will need
adjustment when pedal free travel gets down to about
1/4 inch (32 mm), as measured at the clutch pedal pad.
You should have 1 1/2 to 2 inches (38 to 51 mm) of
clutch pedal free travel. See ªMaintenance Scheduleº in
the Index for more information.
If your clutch ever needs service, be sure to use only
genuine GM clutch replacement parts.
Chassis Lubrication
Your Maintenance Schedule provides all of the required
chassis lubrication intervals and identifies proper
lubricants to use. Be sure to see your Maintenance
Schedule before performing any chassis lubrication
service. To determine location of chassis lubrication
items, use the following charts.

6-50
ITEM NO. ITEM REMARKS
12 Clutch Release Bearing* Cup or fitting.
13 Battery Terminal
(except ªSTº type)Keep coated with petroleum jelly.
14 Transmission Fill to level of filler plug.
15 Propshaft Slip Joints Lubricate with GM Part No. 1051344
Wheel Bearing Lubricant.
16 Parking Brake Clevis Pins$ Apply chassis lubricant.
17 Parking Brake Lever Pivot*$ Apply chassis lubricant.
18 Clutch Release Cross Shaft,
Master Cylinder$Apply chassis lubricant, Fill to 1/4, (6 mm) below opening.
19 Release Bearing,
Clutch Cross ShaftTwo fittings, Apply chassis lubricant
20 Clutch Release Fork Two fittings.
* Applies to some vehicles.

Applies to air brakes only.

Refer to Allison Transmission Operator's Manual.
$ Applies to hydraulic brakes only.

6-68
Don't use any of these unless this manual says you can.
In many uses, these will damage your vehicle:

Alcohol

Laundry Soap

Bleach

Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and loose
dirt. Wipe vinyl, leather, plastic and painted surfaces
with a clean, damp cloth.
Cleaning of Fabric/Carpet
Your dealer has cleaners for the cleaning of fabric and
carpet. They will clean normal spots and stains very
well. You can get GM
-approved cleaning products from
your dealer. See ªAppearance Care and Materialsº in
the Index.
Here are some cleaning tips:

Always read the instructions on the cleaner label.

Clean up stains as soon as you can
-- before they set.
Carefully scrape off any excess stain.

Use a clean cloth or sponge, and change to a clean
area often. A soft brush may be used if stains are
stubborn.

If a ring forms on fabric after spot cleaning, clean the
entire area immediately or it will set.
Using Cleaner on Fabric
1. Vacuum and brush the area to remove any loose dirt.
2. Always clean a whole trim panel or section. Mask
surrounding trim along stitch or welt lines.
3. Follow the directions on the container label.
4. Apply cleaner with a clean sponge. Don't saturate
the material and don't rub it roughly.
5. As soon as you've cleaned the section, use a sponge
to remove any excess cleaner.
6. Wipe cleaned area with a clean, water
-dampened
towel or cloth.
7. Wipe with a clean cloth and let dry.

6-87 Cooling System Capacity
The following approximate capacities are given in
English and metric conversions.
Please refer to ªRecommended Fluids and Lubricantsº
in the Index for more information.
C4/C5 Models Quarts (Liters). . . . . . . . . . . . . . . . .
8.1L with manual transmission 30.1 (28.5). . . . . . . .
8.1L with automatic transmission 29.8 (28.2). . . . . .
6.6L with manual transmission 27.6 (26.1). . . . . . . .
6.6L with automatic transmission 27.3 (25.8). . . . . .
C6/C7/C8 Models Quarts (Liters). . . . . . . . . . . . . .
8.1L with manual transmission 33.3 (31.5). . . . . . . .
8.1L with manual transmission,
air conditioning and increased
cooling 34.9 (33.0). . . . . . . . . . . . . . . . . . . . . . . . . . .
8.1L with automatic transmission 32.5 (30.8). . . . . .
7.8L 200
-230 hp engine with
manual transmission 31.6 (29.9). . . . . . . . . . . . . . . .
7.8L 200
-230 hp engine with manual
transmission, air conditioning and
increased cooling 35.3 (33.4). . . . . . . . . . . . . . . . . . . C6/C7/C8 Models Quarts (Liters). . . . . . . . . . . . . .
7.8L 200
-215 hp engine with
automatic transmission 33.7 (31.9). . . . . . . . . . . . . .
7.2L 175
-230 hp engine with
manual transmission 29.3 (27.7). . . . . . . . . . . . . . . .
7.2L 175
-230 hp engine with
manual transmission, air conditioning
and increased cooling 33.0 (31.2). . . . . . . . . . . . . . .
7.2L 175
-210 hp engine with
automatic transmission 31.4 (29.7). . . . . . . . . . . . . .
7.8L 250
-275 hp engine with
manual transmission 34.9 (33.0). . . . . . . . . . . . . . . .
7.8L 250
-275 hp engine with
manual transmission, air conditioning
and increased cooling 35.4 (33.5). . . . . . . . . . . . . . .
7.8L 230
-275 hp engine with automatic
transmission 33.3 (31.5). . . . . . . . . . . . . . . . . . . . . .
7.2L 250
-300 hp engine with manual
transmission 32.8 (31.0). . . . . . . . . . . . . . . . . . . . . .
7.2L 250
-300 hp engine with manual
transmission, air conditioning and
increased cooling 33.3 (31.5). . . . . . . . . . . . . . . . . . .
7.2L 250
-300 hp engine with automatic
transmission 31.2 (29.5). . . . . . . . . . . . . . . . . . . . . .

6-89 Transmission Capacity
For manual transmissions, the correct oil level is to the
bottom of the fluid fill plug opening. The oil capacity
will vary, due to the angle of the transmission, with the
vehicle. For automatic transmissions, see the Allison
Automatic Transmission Operator's Manual for oil
check and maintenance information.
Manual Transmission Pints (Liters). . . . . . . . . . . .
ZF S6
-650 12.7 (6.0). . . . . . . . . . . . . . . . . . . . . . . . .
RT6609 12.5 (5.9). . . . . . . . . . . . . . . . . . . . . . . . . . .
RT8709B 25.1 (11.8). . . . . . . . . . . . . . . . . . . . . . . . .
FS4205A, FS4205B, FS4205C 11.1 (5.3). . . . . . . . .
FS5205A, FS5205C 11.6 (5.5). . . . . . . . . . . . . . . . .
FS5406 18.4 (8.7). . . . . . . . . . . . . . . . . . . . . . . . . . .
FS6305A, FS6305B 18.4 (8.7). . . . . . . . . . . . . . . . .
FS6406 18.4 (8.7). . . . . . . . . . . . . . . . . . . . . . . . . . .
FS8406 18.5 (8.8). . . . . . . . . . . . . . . . . . . . . . . . . . .
RT8908LL 29.1 (13.8). . . . . . . . . . . . . . . . . . . . . . . . Automatic Transmission Pints (Liters). . . . . . . . . .
MD 3060 P 52.0 (24.6)*. . . . . . . . . . . . . . . . . . . . .
MD 3560 P 52.0 (24.6)*. . . . . . . . . . . . . . . . . . . . .
1000 Series 16.0 (8.9)*. . . . . . . . . . . . . . . . . . . . . .
2000 Series 35.0 (13.5)*. . . . . . . . . . . . . . . . . . . . .
2200 Series 35.0 (13.5)*. . . . . . . . . . . . . . . . . . . . .
2400 Series 35.0 (13.5)*. . . . . . . . . . . . . . . . . . . . .
*Add two pints (one liter) when changing spin-on or
remote filter.

6-90 Rear Axle Lubricant Capacity
Single Speed Axle Pints (Liters). . . . . . . . . . . . . . . .
80 10.0 (4.7). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
S135 26.0 (12.3). . . . . . . . . . . . . . . . . . . . . . . . . . . .
19060S 31.0 (14.7). . . . . . . . . . . . . . . . . . . . . . . . . .
21060D 31.0 (14.7). . . . . . . . . . . . . . . . . . . . . . . . . .
21060S 31.0 (14.7). . . . . . . . . . . . . . . . . . . . . . . . . .
S150 28.0 (13.0). . . . . . . . . . . . . . . . . . . . . . . . . . . .
23090S 40.0 (19.0). . . . . . . . . . . . . . . . . . . . . . . . . .
23105S 56.0 (26.5). . . . . . . . . . . . . . . . . . . . . . . . . .
26105S 54.0 (25.5). . . . . . . . . . . . . . . . . . . . . . . . . .
Tw o
-Speed Axle Pints (Liters). . . . . . . . . . . . . . . . .
19060T 38.0 (18.0). . . . . . . . . . . . . . . . . . . . . . . . . .
21060T 38.0 (18.0). . . . . . . . . . . . . . . . . . . . . . . . . .
23082T 40.0 (19.0). . . . . . . . . . . . . . . . . . . . . . . . . .
26080T 44.0 (20.8). . . . . . . . . . . . . . . . . . . . . . . . . .
Tandem Axles Pints (Liters). . . . . . . . . . . . . . . . . . .
DS344 (front) 32.0 (15.1). . . . . . . . . . . . . . . . . . . . .
RS344 (rear) 31.0 (14.7). . . . . . . . . . . . . . . . . . . . . .
DSH44 (front) 32.0 (15.1). . . . . . . . . . . . . . . . . . . . .
RSH44 (rear) 31.0 (14.7). . . . . . . . . . . . . . . . . . . . . .
DS404, DS404P (front) 32.0 (15.1). . . . . . . . . . . . . .
RS404 (rear) 31.0 (14.7). . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Refrigerant
Capacity
If you do your own service work, you'll need the proper
service manual. See ªDoing Your Own Service Workº in
the Index for additional information. It is recommended
that service work on your air conditioning system be
performed by a qualified technician.
Air Conditioning Refrigerant
R134a 2.1 lbs. (1.0 kg). . . . . . . . . . . . . . . . . . . . . . .
Use Refrigerant Oil, R143a Systems
Normal Maintenance
Replacement Parts
Allison Transmission External Filters
See the Allison Transmission Operator's Manual in your
vehicle for external filter part numbers and information.
Air Compressor Filter
Air Compressor Part Number
Bendix Tu
-Flo
550 (13.2 CFM)2467368

7-2
Have you purchased the GM Protection Plan? The Plan
supplements your new vehicle warranties. See your
Warranty and Owner Assistance booklet or your dealer
for details.
Introduction
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle in good working condition, but also helps the
environment. All recommended maintenance procedures
are important. Improper vehicle maintenance can even
affect the quality of the air we breathe. Improper fluid
levels or the wrong tire inflation can increase the level
of emissions from your vehicle. To help protect our
environment, and to keep your vehicle in good
condition, please maintain your vehicle properly.
Maintenance Requirements
Maintenance intervals, checks, inspections and
recommended fluids and lubricants as prescribed in this
manual are necessary to keep your vehicle in good
working condition. Any damage caused by failure to
follow recommended maintenance may not be covered
by warranty.

7-4
Part A: Scheduled Maintenance
Services
Using Your Maintenance Schedule
We at General Motors want to help you keep your
vehicle in good working condition. But we don't know
exactly how you'll drive it. You may drive very short
distances only a few times a week. Or you may drive
long distances all the time in very hot, dusty weather.
You may use your vehicle in making deliveries or in
many other ways.
Because of all the different ways people use their
vehicles, maintenance needs vary. You may need more
frequent checks and replacements. So please read the
following and note how you drive. If you have any
questions on how to keep your vehicle in good
condition, see your dealer.
This part tells you the maintenance services you should
have done and when you should schedule them. If you
go to your dealer for your service needs, you'll know
that GM
-trained and supported service people will
perform the work using genuine GM parts.The proper fluids and lubricants to use are listed in
Part C. Make sure whoever services your vehicle uses
these. All parts should be replaced and all necessary
repairs done before you or anyone else drives
the vehicle.
This schedule is for vehicles that:

carry passengers and cargo within recommended
limits. You will find these limits on your vehicle's
GVW Rating label. See ªLoading Your Vehicleº in
the Index.

are driven on reasonable road surfaces within legal
driving limits.

use the recommended fuel. See ªFuelº in the Index.
Scheduled Maintenance Supplements
If your vehicle has a Caterpillar diesel engine, your
owner's manual is supplemented by the Caterpillar
Diesel Engine Operation & Maintenance Manual. If
your vehicle has an Allison transmission, your owner's
manual is supplemented by an Allison Transmission
Operator's Manual. Always refer to these manuals for
related maintenance services.