2001 TOYOTA SEQUOIA steering column

R11910Red Mark
± INTRODUCTIONFOR ALL OF VEHICLES
IN±11
11 Author: Date:
2005 SEQUOIA (RM1146U)
(c) SPIRAL CABLE (in Combination Switch)
The steering wheel must be fitted correctly to the steering
column with the spiral cable at the neutral position, other-
wise cable disconnection and other troubles may result.
Refer to D I ± 111 8 concerning correct steering wheel
installation.

B06331
Example:
CorrectWrong
Z13950
Example: IN±12
± INTRODUCTIONFOR ALL OF VEHICLES
12 Author: Date:
2005 SEQUOIA (RM1146U)
(d) STEERING WHEEL PAD (with Airbag)
(1) When removing the steering wheel pad or handling
a new steering wheel pad, it should be placed with
the pad top surface facing up.
Storing the pad with its metallic surface upward may
lead to a serious accident if the airbag inflates for
some reason. In addition do not store a steering
wheel pad on top of another one.
(2) Never measure the resistance of the airbag squib.
(This may cause the airbag to deploy, which is very
dangerous.)
(3) Grease should not be applied to the steering wheel
pad and the pad should not be cleaned with any
kind of detergents.
(4) Store the steering wheel pad where the ambient
temperature remains below 93°C (200°F), without
high humidity and away from electrical noise.
(5) When using electric welding, first disconnect the air-
bag connector (yellow color and 2 pins) under the
steering column near the combination switch con-
nector before starting work.
(6) When disposing of a vehicle or the steering wheel
pad alone, the airbag should be deployed using an
SST before disposal (See page RS±23).
Carry out the operation in a safe place away from
electrical noise.

PP3JP±04
PP±60
± PREPARATIONSTEERING
11 8 Author: Date:
2005 SEQUOIA (RM1146U)
STEERING
SST (Special Service Tools)
09023±12701Union Nut Wrench 17mmPS gear
09023±38401Union Nut Wrench 14mmPS gear
09521±24010Drive Shaft Boot Clamping ToolPS gear
09527±20011Rear Axle Shaft Bearing RemoverPS gear
09612±00012Rack & Pinion Steering Rack
Housing StandPS gear
09612±07010Main Shaft Retaining Ring
Remover & ReplacerSteering column
09612±22011Tilt Handle Bearing ReplacerPS gear
09612±24014Steering Gear Housing Overhaul
Tool SetPS gear
(09613±22011)Steering Rack Shaft Bushing
Puller
09616±00011Steering Worm Bearing Adjusting
SocketPS gear
09631±12071Steering Rack Oil Seal Test ToolPS gear
09631±16010Cylinder End Stopper Nut WrenchPS gear

± PREPARATIONSTEERING
PP±61
11 9 Author: Date:
2005 SEQUOIA (RM1146U)
09631±20051Steering Rack Cover ºCºPS gear
09631±20081Seal Ring ToolPS gear
09640±10010Power Steering Pressure Gauge
Set
(09641±01010)Gauge AssyPower steering fluid
(09641±01030)Attachment BPower steering fluid
(09641±01060)Attachment EPower steering fluid
09816±30010Oil Pressure Switch SocketPS gear
09910±00015Puller Set
(09911±00011)Puller ClampSteering column
(09912±00010)Puller Slide HammerSteering column
09922±10010Variable Open WrenchPS gear
09950±50013Puller C Set
(09951±05010)Hanger 150Steering column

PP±62
± PREPARATIONSTEERING
120 Author: Date:
2005 SEQUOIA (RM1146U)
(09952±05010)Slide ArmSteering column
(09953±05020)Center Bolt 150Steering column
(09954±05021)Claw No.2Steering column
09950±60010Replacer Set
(09951±00180)Replacer 18PS gear
(09951±00250)Replacer 25PS gear
(09951±00260)Replacer 26PS gear
(09951±00300)Replacer 30PS gear
(09951±00310)Replacer 31PS gear
(09951±00320)Replacer 32PS gear
(09951±00330)Replacer 33PS vane pump
PS gear
(09951±00340)Replacer 34PS gear
(09951±00360)Replacer 36PS gear

± PREPARATIONSTEERING
PP±63
121 Author: Date:
2005 SEQUOIA (RM1146U)
(09951±00400)Replacer 40Steering column
(09951±00460)Replacer 46Steering column
PS gear
(09951±00490)Replacer 49PS gear
(09952±06010)AdapterPS gear
09950±70010Handle Set
(09951±07100)Handle 100PS vane pump
(09951±07150)Handle 150Steering column
(09951±07360)Handle 360Steering column

PP3JQ±02
PP±64
± PREPARATIONSTEERING
122 Author: Date:
2005 SEQUOIA (RM1146U)
RECOMMENDED TOOLS
09025±00010Torque Wrench (30 kgf±cm)PS vane pump
PS gear
09042±00010Torx Socket T30 .Steering column
Torx is a registered trademark of Textron Inc.

SS1MA±01
± SERVICE SPECIFICATIONSAUTOMATIC TRANSMISSION (A750E, A750F)
SS±25
167 Author: Date:
2005 SEQUOIA (RM1146U)
TORQUE SPECIFICATION
Part tightenedN´mkgf´cmft´lbf
Drain plug x Oil pan2020415
Overflow plug x Oil pan2020415
Refill plug x Transmission case3940029
No.1 vehicle speed sensor A750E
A750F9.8
11.5100
11 786 in.Vlbf
8
Speed sensor NT x Automatic transmission5.45548 in.Vlbf
Speed sensor SP2 x Automatic transmission5.45548 in.Vlbf
Transmission wire set bolt x Automatic transmission5.45548 in.Vlbf
Transmission wire clamp x Valve body A
B11
1011 2
1008
7
Oil pan x Transmission case4.44539 in.Vlbf
Park/neutral position switch Bolt
Nut13
6.9130
7010
61 in.Vlbf
Shift solenoid valve S1 x Valve body6.46556 in.Vlbf
Shift solenoid valve S2 x Valve body101027
Shift solenoid valve SR x Valve body6.46557 in.Vlbf
Shift solenoid valve SLU, SL2 x Valve body6.46557 in.Vlbf
Shift solenoid valve SLT, SL1 x Valve body6.46557 in.Vlbf
Valve body x Transmission case1111 28
Oil strainer x Valve body101007
Parking lock pawl bracket x Transmission case7.47565 in.´lbf
Oil cooler x Body1111 08
Transmission oil cooler bracket x Oil cooler4.95043 in.´lbf
Oil cooler tube clamp x Body5.05048 in.´lbf
Shift lever x Shift lever housing1818013
Shift lever housing x Steering column assemby121209
Parking lock cable No. 1 x Shift lever housing2.92925 in.´lbf
Parking lock cable No. 2 x Column upper bracket2.22319 in.´lbf
Parking lock cable housing x Steering column assembly10.511 08
Front suspension member bracket x Body3333624
Heat insulator1616412
Shift control cable x Transmission14.514811
Shift control cable bracket x Transmission19.519914
Oil cooler pipe clamp x Transmission121229
Oil cooler pipe x Transmission3434625
Stabilizer bar3737727
Rear end plate x Transmission1818513
Torque converter clutch x Drive plate4849035
Engine rear mounting insulator x Crossmember1818513
Crossmember x Frame7273453
Engine rear mounting insulator x Extension housing6566048
Automatic transmission x Engine 17 mm head
14 mm head71
37720
38053
27