2001 TOYOTA AVALON belt

SR0EN-06
F08851
Connector
Oil Pressure Switch
Union Bolt

Gasket
Return HoseDrive Belt
Clamp Plate
Pressure Feed Tube
Pressure Feed Tube
PS Vane Pump AssemblyHolder
Clamp Plate
Clamp Plate
Front Fender Apron Seal RH

Non-reusable part
43 (440, 32)
*29 (300, 22)
7.8 (80, 69 in.´lbf)
21 (210, 15)
52 (530, 38)
43 (440, 32)
25 (250, 18)
*22 (230, 17)
N´m (kgf´cm, ft´lbf): Specified torque
* For use with SST
- STEERINGPOWER STEERING VANE PUMP
SR-25
1488 Author
: Date
:
2001 AVALON (RM808U)
POWER STEERING VANE PUMP
COMPONENTS

SR0ES-07
F08856
Pressure
Feed
Tube
Stopper
F08855
A
B
Z19285
Clamp
Engine Wire
SST Fulcrum
Length
- STEERINGPOWER STEERING VANE PUMP
SR-35
1498 Author
: Date
:
2001 AVALON (RM808U)
INSTALLATION
1. INSTALL PRESSURE FEED TUBE
Install the pressure feed tube and gasket to the PS vane pump
assembly with union bolt.
HINT:
Make sure the stopper of the pressure feed tube touches the
front bracket as shown in the illustration, then install the union
bolt.
Torque: 52 N´m (530 kgf´cm, 38 ft´lbf)
2. INSTALL OIL PRESSURE SWITCH
Torque: 21 N´m (210 kgf´cm, 15 ft´lbf)
NOTICE:
Be careful to prevent oil seal from being attached to the
connector.
3. INSTALL PS VANE PUMP ASSEMBLY WITH PRESS-
ER FEED TUBE
Temporarily install the PS vane pump assembly with 2 (A and
B) bolts.
4. INSTALL DRIVE BELT
(a) Adjust drive belt tension (See page SR-3).
(b) Using SST, torque the bolt A.
SST 09249-63010
Torque: 29 N´m (300 kgf´cm, 22 ft´lbf)
HINT:

Use a torque wrench with a fulcrum length of 300 mm
(11.81 in.).

Disconnect the clamp with engine wire.
(c) Torque the bolt B.
Torque: 43 N´m (440 kgf´cm, 32 ft´lbf)
(d) Connect the connector to the oil pressure switch.

SR0EO-06
F13584
Pressure Feed TubeSST
F08855
A
B
- STEERINGPOWER STEERING VANE PUMP
SR-27
1490 Author
: Date
:
2001 AVALON (RM808U)
REMOVAL
1. REMOVE FRONT FENDER APRON SEAL RH
Remove the 2 bolts and front fender apron seal RH.
2. DISCONNECT RETURN HOSE
Remove the clip and disconnect the return hose.
NOTICE:
Take care not to spill fluid on the drive belt.
3. DISCONNECT PRESSURE FEED TUBE
(a) Remove the 2 clamp plate set nuts.
(b) Remove the bolt, 2 clamp plates and 2 holders from the
pressure feed tube.
(c) Using a spanner, hold the pressure feed tube steadily and
using SST, disconnect the pressure feed tube.
SST 09023-12700
4. REMOVE DRIVE BELT
Loosen the 2 (A and B) bolts and drive belt.
5. REMOVE PS VANE PUMP ASSEMBLY WITH PRES-
SURE FEED TUBE
(a) Disconnect the connector from the oil pressure switch.
(b) Loosen the bolt A sufficiently so that pump assembly can
be removed.
HINT:
Bolt A cannot be removed.
(c) Remove the bolt B and PS vane pump assembly.
6. REMOVE OIL PRESSURE SWITCH
NOTICE:
Be careful not to drop the switch.
If the switch is dropped or strongly damaged, replace it with a
new one.
7. REMOVE PRESSURE FEED TUBE
(a) Remove the oil pressure switch from the union bolt.
(b) Remove the union bolt, gasket and pressure feed tube.

SR0EC-02
SR-2
- STEERINGTROUBLESHOOTING
1465 Author
: Date
:
2001 AVALON (RM808U)
TROUBLESHOOTING
PROBLEM SYMPTOMS TABLE
Use the table below to help you find the cause of the problem. The numbers indicate the priority of the likely
cause of the problem. Check each part in order. If necessary, repair or replace these parts.
SymptomSuspect AreaSee page
Hard steering
1. Tires (Improperly inflated)
2. Power steering fluid level (Low)
3. Drive belt (Loose)
4. Front wheel alignment (Incorrect)
5. Steering system joints (Worn)
6. Suspension arm ball joints (Worn)
7. Steering column (Binding)
8. Power steering vane pump
9. Power steering gearSA-2
SR-5
SR-3
SA-4
-
SA-38
-
SR-25
SR-37
Poor return
1. Tires (Improperly inflated)
2. Front wheel alignment (Incorrect)
3. Steering column (Binding)
4. Power steering gearSA-2
SA-4
-
SR-37
Excessive play
1. Steering system joints (Worn)
2. Suspension arm ball joints (Worn)
3. Universal joint, Intermediate shaft, Sliding yoke (Worn)
4. Front wheel bearing (Worn)
5. Power steering gear-
SA-38
-
SA-9
SR-37
Abnormal noise
1. Power steering fluid level (Low)
2. Steering system joints (Worn)
3. Power steering vane pump
4. Power steering gearSR-5
-
SR-25
SR-37