2000 TOYOTA CAMRY engine

Toyota Supports ASE CertificationPage 1 of 2
EG013±99
Title:
SINGLE CYLINDER MISFIRES
Models:
'99 Avalon, Camry, Sienna & Solara
Technical Service
BULLETIN
December 17, 1999

Some 1999 Avalon, Camry (1MZ±FE), Sienna & Solara (1MZ±FE) vehicles may exhibit a
rough idle, and or a M.I.L. ªONº condition, in which a single cylinder misfire code, or
codes are present. Changes have been made in the fuel injector production process to
correct this condition.
1999 TMMK produced Avalon, Camry (1MZ±FE), Sienna & TMMC produced Solara
(1MZ±FE) vehicles built between the VIN numbers listed below.
MODELSTARTING VINENDING VIN
Avalon4T1BF1#B * XU2985044T1BF1#B*XU319557
Camry4T1BF2#K * XU0764034T1BF2#K*XU081214
Camry (cont.)4T1BF2#K * XU9300244T1BF2#K*XU931330
Sienna4T3ZF1#C * XU0908874T3ZF1#C*XU122589
Solara (U.S.)2T1CF2#P * XC1110832T1CF2#P*XC757508
Solara (Canada)2T1CF2#P * XC7441132T1CF2#P*XC162681
APPLICABLE PARTSQUANTITYPART NAME
23209±0A0106Fuel Injector
OP CODEVWCDESCRIPTIONTIMEOPNT1T2
895221NR & R Fuel Injector Assembly ± All1.823209±0A0100256
Applicable Warranty*:
This repair is covered under the Toyota Federal Warranty. This warranty is in effect for
36 months or 36,000 miles, whichever occurs first, from the vehicle's in±service date.
Coverage is extended to 36 months or 50,000 miles, whichever occurs first, in the
states of California, Massachusetts, and Vermont due to state emission warranty
legislation.
* Warranty application is limited to correction of a problem based upon a customer's specific complaint.
NOTE:
Be sure to enter the DTC No. in the Condition/Cause/Remedy section, if a DTC Code
appeared.
ENGINE
Introduction
Applicable
Vehicles
Parts
Information
Warranty
Information

Toyota Supports ASE CertificationPage 1 of 1
EG009±99
Title:
M.I.L. ON" DTC P1133
Models:
'97±'99 Camry and '99 Solara: 5S±FE CA Spec.
Technical Service
BULLETIN
October 1, 1999

Under certain driving conditions, some 5S±FE equipped 1997±1999 Camry and 1999
Solara California emission specification vehicles may exhibit a M.I.L. ªONº DTC P1133.
An improved Air Fuel Ratio Sensor has been developed to correct this condition.
1997 ± 1999 Camry & 1999 Solara (5S±FE) with California emission
specification.
MODEL YEARORIGINENGINESTARTING VIN
JPNJT2BG2#K*X0363615
1999 Camry
NAP(5S±FE)4T1BG2#K*XU603913
4T1BG2#K*XU918675
2000 Solara±±
* # May be a 2 or an 8.
* * May be any number from 0 to 9 or an X.
PREVIOUS PART NUMERCURRENT PART NUMBERPART NAME
89467±3301089467±33011Sensor, Air Fuel
Should a M.I.L. ªONº condition with DTC P1133 be encountered, perform diagnostic
procedures as described in the Repair Manual.
If the problem source cannot be identified after checking all affected areas according
to the Repair Manual, the cause may be an Air/Fuel Ratio Sensor malfunction. In this
case, replace the Air/Fuel Ratio Sensor with the updated part.
If the Exhaust Manifold threads are damaged by removal of the sensor, they can be
repaired by the proper use of a M18 x 1.5 tap.
OPCODEDESCRIPTIONTIMEOPNT1T2
EL9006Sensor, Air Fuel Ratio0.389467±330109999
Applicable Warranty*:
This repair is covered under the Toyota Basic Warranty. This warranty is in effect for
36 months or 36,000 miles, whichever occurs first, from the vehicle's in±service date.
Coverage is extended to 36 months or 50,000 miles, which ever occurs first, in the
states of California and Massachusetts due to state emissions warranty legislation.
NOTE:
Please enter the DTC in the condition/Cause/Remedy section when applying for
warranty reimbursement.
* Warranty application is limited to correction of a problem based upon a customer's specific complaint.
ENGINE
Introduction
Applicable
Vehicles
Production
Change
Information
Parts
Information
Repair
Procedure
Warranty
Information

Toyota Supports ASE CertificationPage 1 of 1
EL006±99Title:
ENGINE IMMOBILIZER SYSTEM
PRECAUTIONS
Models:
All Models
Technical Service
BULLETIN
October 8, 1999

REVISION NOTICE:
The information contained in this TSB updates EL001±98 dated January 23, 1998.
This bulletin applies to 1998 and newer Toyota vehicles. When using an immobilizer key
containing a transponder chip, observe the following precautions while starting the engine.
1. The key ring should not
rest on or be
pressed against the key grip.
2. Do not
place any other transponder
devices on the same key ring. Such
devices would include transponder
equipped units used for charging fuel.
3. Do not
place any other immobilizer
keys on the same key ring with the
key used to start the vehicle.
4. If the above precautions are not
observed and an engine starting or
running problem occurs, remove all
items which may interfere with the
ignition key transponder signal. Turn
off the engine and then restart.
All Toyota models equipped with an engine immobilizer system.
OP CODEDESCRIPTIONTIMEOPNT1T2
N/ANot Applicable to Warranty±±±±
ELECTRICAL
Introduction
Applicable
Vehicles
Warranty
Information

CA/50 STATE CERTIFIED EMISSION CONTROL UNDERHOOD LABEL ORDERING ± PG006±00 March 31, 2000
Page 3 of 6
MODELENGINE NAMETRANSMISSIONEMISSIONS*PART NUMBERS
Tercel5E±FEAllUSA11298±11452
Paseo5E±FEAllCA11298±11452
Corolla
4A±FEAllCA11298±1D060
Corolla
7A±FEAllCA11298±1D090
Celica
7A±FEAllCA11298±1D120
Celica
5S±FEAllCA11298±7A390
5S±FEM/TMCA11298±7A330
Camry5S±FEA/TMCA11298±7A350
1MZ±FEAllCA11298±20110
S pra
2JZ±GEAllUSA11298±46121
Supra
2JZ±GTEAllUSA11298±46102
Avalon1MZ±FEA/TMCA11298±20110
Previa2TZ±FZEA/TMUSA11298±76083
RAV43S±FEAllCA11298±7A410
3RZ±FE (2WD)AllUSA11298±75220
4Runner3RZ±FE (4WD)AllUSA11298±75260
5VZ±FEAllCA11298±62450
2RZ±FE (2WD)AllCA11298±75210
3RZ±FE (4WD)M/TMCA11298±75200
3RZ±FE (4WD)AllUSA11298±75220
Tacoma5VZ±FE
(2WD XtraCab)AllUSA11298±62430
5VZ±FE
(4WD RegCab)M/TMUSA11298±62430
5VZ±FE
(4WD XtraCab)AllCA11298±62450
T 100
3RZ±FE (2WD)AllUSA11298±75240
T±1005VZ±FE
(2WD/4WD)AllCA11298±62500
Land Cruiser1FZ±FEA/TMUSA11298±66070
* CA = California Emission Specification, USA = 50 State Emission Specification
1997 MY CA/50
State Certified
Emission
Control Labels

CA/50 STATE CERTIFIED EMISSION CONTROL UNDERHOOD LABEL ORDERING ± PG006±00 March 31, 2000
Page 4 of 6
MODELENGINE NAMETRANSMISSIONEMISSIONS*PART NUMBERS
Tercel5E±FEAllCA11298±11453
Corolla1ZZ±FEAllCA11298±22040
Celica5S±FEAllCA11298±7A470
5S±FEAllCA11298±7A430
Camry1MZ±FEA/TMCA11298±20160
1MZ±FEM/TMCA11298±20190
Supra2JZ±GEA/TMCA11298±46122
Avalon1MZ±FEA/TMCA11298±20160
Sienna1MZ±FEAllCA11298±20140
RAV43S±FEAllCA11298±7A510
3RZ±FE (2WD)AllCA11298±75320
4Runner3RZ±FE (4WD)AllCA11298±75380
5VZ±FEAllCA11298±62540
2RZ±FE (2WD)AllCA11298±75300
3RZ±FE (4WD)M/TMCA11298±75310
Tacoma3RZ±FE (4WD)A/TMCA11298±75320
5VZ±FE (2WD)AllCA11298±62530
5VZ±FE
(4WD XtraCab)AllCA11298±62540
T 100
3RZ±FE (2WD)AllUSA11298±75360
T±1005VZ±FE
(2WD/4WD)AllCA11298±62580
Land Cruiser2UZ±FEA/TMCA11298±50200
* CA = California Emission Specification, USA = 50 State Emission Specification
1998 MY CA/50
State Certified
Emission
Control Labels

CA/50 STATE CERTIFIED EMISSION CONTROL UNDERHOOD LABEL ORDERING ± PG006±00 March 31, 2000
Page 5 of 6
MODELENGINE NAMETRANSMISSIONEMISSIONS*PART NUMBERS
Corolla1ZZ±FEAllCA11298±22041
Celica5S±FEAllCA11298±7A560
5S±FEAllCA11298±7A521
Camry1MZ±FEM/TMUSA11298±20240
1MZ±FEA/TMCA11298±20181
5S±FEAllCA11298±7A521
Camry Solara1MZ±FEM/TMUSA11298±20240
1MZ±FEA/TMUSA11298±20181
Avalon1MZ±FEAllCA11298±20181
Sienna1MZ±FEA/TMCA11298±20270
RAV43S±FE
(2WD/4WD)AllCA11298±7A541
4R nner
3RZ±FE
(2WD/4WD)AllUSA11298±75400
4Runner5VZ±FE
(2WD/4WD)AllCA11298±62660
2RZ±FE (2WD)AllUSA11298±75460
3RZ±FE
(PreRunner/4WD)A/TMUSA11298±75470
3RZ±FE (4WD)M/TMCA11298±75480
Tacoma3RZ±FE
(2WD XtraCab)A/TMUSA11298±75400
5VZ±FE
(2WD XtraCab)AllUSA11298±62590
5VZ±FE
(PreRunner/4WD)AllUSA11298±62600
Land Cruiser2UZ±FEA/TMUSA11298±50181
* CA = California Emission Specification, USA = 50 State Emission Specification
1999 MY CA/50
State Certified
Emission
Control Labels

CA/50 STATE CERTIFIED EMISSION CONTROL UNDERHOOD LABEL ORDERING ± PG006±00 March 31, 2000
Page 6 of 6
MODELENGINE NAMETRANSMISSIONEMISSIONS*PART NUMBERS
ECHO1NZ±FEAllUSA11298±21010
Corolla1ZZ±FEAllUSA11298±22032
Celica
1ZZ±FEAllUSA11298±22080
Celica
2ZZ±GEAllUSA11298±22050
5S±FEAllUSA11298±7A590
Camry1MZ±FEM/TMUSA11298±20320
1MZ±FEA/TMCA11298±20310
5S±FEAllUSA11298±7A590
Camry Solara1MZ±FEM/TMUSA11298±20320
1MZ±FEA/TMCA11298±20310
Camry Solara5S±FEA/TMUSA11298±7A590Camry Solara
Convertible1MZ±FEA/TMCA11298±20310
Camry (CNG)5S±FNEA/TMUSA11298±7A640
Avalon1MZ±FEA/TMUSA11298±20290
Sienna1MZ±FEA/TMUSA11298±20340
RAV43S±FE (2WD/4WD)AllUSA11298±7A620
3RZ±FE (2WD)AllUSA11298±75550
4Runner3RZ±FE (4WD)M/TMUSA11298±75550
5VZ±FE (2WD/4WD)AllUSA11298±62690
2RZ±FE (2WD)AllUSA11298±75510
3RZ±FE (2WD/4WD)A/TMUSA11298±75530
3RZ±FE
(4WD XtraCab)M/TMUSA11298±75530
Tacoma
3RZ±FE
(4WD XtraCab)A/TMUSA11298±75550
3RZ±FE
(PreRunner)A/TMUSA11298±75530
5VZ±FE
(2WD XtraCab)AllUSA11298±62670
5VZ±FE
(4WD & PreRunner)AllUSA11298±62690
T ndra
5VZ±FEAllCA11298±62640
Tundra
2UZ±FEA/TMUSA11298±50241
Land Cruiser2UZ±FEA/TMUSA11298±50182
* CA = California Emission Specification, USA = 50 State Emission Specification
2000 MY CA/50
State Certified
Emission
Control Labels

WARRANTY PARTS MARKING PROCEDURE ± PG006-03September 26, 2003
Page 2 of 3
Dealers are requested to mark the location of the failure of all warranty parts that are
listed below.
This list is not inclusive. There may be other components that can be
marked in the area of failure. All other parts that can be marked should be marked.
assist grip assy headlamps
audio (blemish) headliner
back door garnish hoses
bumper covers instrument panel safety pad sub±assy
cargo cover (retractable) Interior light assemblies and covers
carpet knobs, levers, handles
clutch disc l/pulley pump assy
clutch flywheel mirrors (side and rearview)
combination meter glass navigation or VES screens
console and components pillar garnish
cowl assy rack and pinion/power steering gear assy
cowl side trim sub±assy radiator
cupholders room partition board
cylinder head cover sub±assy rotors (mark where min. runout is exceeded or warped)
dash panel insulator assy seat covers/cushions
dashboard and trim seat tracks
disc wheel soft trim
display panels spare tire cover
door handle assy steering column cover
door moulding steering wheel
door trim panel & molding tail lamps and covers
emblems transmission oil pan
engine oil pan visor
exhaust manifold washer jar
floor and cargo mats wheel cap
gear shift knob wheels
grills
Parts
Marking
Requirement
Parts
Marking
List