IN04I-01
- INTRODUCTIONTERMS
IN-33
33 Author: Date:
1997 SUPRA (RM502U)
TERMS
ABBREVIATIONS USED IN THIS MANUAL
AbbreviationsMeaning
ABSAnti-Lock Brake System
ALRAutomatic Locking Retractor
APPROX.Approximately
A/T, ATMAutomatic Transmission
AT FAutomatic Transmission Fluid
BTDCBefore Top Dead Center
CBCircuit Breaker
CDCompact Disc
CRSChild Restraint System
DOHCDouble Over Head Cam
DPDash Pot
ECUElectronic Control Unit
ELREmergency Locking Retractor
ESAElectronic Spark Advance
EXExhaust (Manifold, Valve)
FIPGFormed in Place Gasket
FLFusible Link
FrFront
H-FuseHigh Current Fuse
IGIgnition
INIntake (Manifold, Valve)
J/BJunction Block
LEDLight Emitting Diode
LHLeft-Hand
LLCLong Life Coolant (Year Around Coolant)
LSDLimited Slip Differential
Max.Maximum
Min.Minimum
MPMultipurpose
M/TManual Transmission
O/D, ODOverdrive
O/SOversize
P&BVProportioning and Bypass Valve
PCVPositive Crankcase Ventilation
PPSProgressive Power Steering
PSPower Steering
RHRight-Hand
RrRear
SRSSupplemental Restraint System
SSMSpecial Service Materials
SSTSpecial Service Tools
STDStandard
MA01F-02
MA-4
- MAINTENANCEUNDER HOOD
41 Author: Date:
1997 SUPRA (RM502U)
UNDER HOOD
GENERAL MAINTENANCE
1. GENERAL NOTES
Maintenance items may vary from country to country. Check the owner's manual supplement in which
the maintenance schedule is shown.
Every service item in the periodic maintenance schedule must be performed.
Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).
Maintenance service after the last period should be performed at the same interval as before unless
otherwise noted.
Failure to do even one item an cause the engine to run poorly and increase exhaust emissions.
2. WINDSHIELD WASHER FLUID
Check that there is sufficient fluid in the tank.
3. ENGINE COOLANT LEVEL
Check that the coolant level is between the ºFULLº and ºLOWº lines on the see-through reservoir.
4. RADIATOR AND HOSES
(a) Check that the front of the radiator is clean and not blocked with leaves, dirt or bugs.
(b) Check the hoses for cracks, kinks, rot or loose connections.
5. BATTERY ELECTROLYTE LEVEL
Check that the electrolyte level of all battery cells is between the upper and lower level lines on the case.
6. BRAKE AND CLUTCH FLUID LEVELS
Check that the brake and clutch fluid levels are near the upper level line on the see-through reservoirs.
7. ENGINE DRIVE BELT
Check drive belt for fraying, cracks, wear or oil contamination.
8. ENGINE OIL LEVEL
Check the level on the dipstick with the engine turned off.
9. POWER STEERING FLUID LEVEL
Check the level on the dipstick.
The level should be in the ºHOTº or ºCOLDº range depending on the fluid temperature.
10. AUTOMATIC TRANSMISSION FLUID LEVEL
(a) Park the vehicle on a level surface.
(b) With the engine idling and the parking brake applied, shift the selector into all positions from ºPº to ºLº,
and then shift into ºPº position.
(c) Pull out the dipstick and wipe off the fluid with a clean rag. Re-insert the dipstick and check that the
fluid level is in the HOT range.
(d) Do this check with the fluid at normal driving temperature (70 - 80°C, 158 - 176°F).
HINT:
Wait until the engine cools down (approx. 30 min.) before checking the fluid level after extended driving at
high speeds, in hot weather, in heavy traffic or pulling a trailer.
11. EXHAUST SYSTEM
If any change in the sound of the exhaust or smell of the exhaust fumes is noticed, have the cause located
and corrected.
B03051Boots
MA01I-02
- MAINTENANCECHASSIS
MA-7
44 Author: Date:
1997 SUPRA (RM502U)
CHASSIS
INSPECTION
1. INSPECT STEERING LINKAGE
(a) Check the steering wheel freeplay.
(See page SR-8)
(b) Check the steering linkage for looseness or damage.
Check that:
Tie rod ends do not have excessive play.
Dust seals and boots are not damaged.
Boot clamps are not loose.
2. INSPECT SRS AIRBAG (Seep page RS-9)
3. INSPECT STEERING GEAR HOUSING OIL
Check the steering gear housing for oil leakage.
4. INSPECT BALL JOINT DUST COVERS
Visually check the dust covers for damage.
5. INSPECT TRANSMISSION OIL (FLUID) AND
DIFFERENTIAL OIL
Visually check the transmission and differential for oil (fluid)
leakage.
If leakage is found, check for the cause and repair it.
6. REPLACE MANUAL TRANSMISSION OIL
(W58: See page MT-4)
(V160: See page MT-3)
7. REPLACE AUTOMATIC TRANSMISSION FLUID
(2JZ-GE: See page AT-2)
(2JZ-GTE: See page AT-2)
8. REPLACE DIFFERENTIAL OIL (See page SA-60)
