1997 TOYOTA SUPRA transmission oil

R08621
R06872
SST
R06864
SST
R06865
Matchmarks
R08620
- PROPELLER SHAFTPROPELLER SHAFT ASSEMBLY
PR-5
1678 Author
: Date
:
1997 SUPRA (RM502U)
(d) Separate the flexible coupling from the differential side.
HINT:
If the flexible coupling cannot be easily separated by hand, in-
sert a screwdriver into the bolt hole of the flexible coupling, as
shown in the illustration, then pry the coupling out.
NOTICE:
Do not bring the screwdriver blade in direct contact with
the flexible coupling's rubber portion.
(e) Pull the yoke from the transmission.
(f) M/T:
Install SST in the transmission to prevent oil leakage.
SST 09325-20010
(g) A/T:
Install SST in the transmission to prevent oil leakage.
SST 09325-40010
7. 2JZ-GTE:
REMOVE PROPELLER SHAFT
(a) Using SST, loosen the adjusting nut until it can be turned
by hand.
SST 09922-10010
HINT:
Use 2 of the same type SST.
(b) Place matchmarks on the differential companion flange
and flexible coupling.
(c) Remove the 3 bolts inserted in the differential companion
flange.
NOTICE:
The bolts inserted in the propeller shaft companion flange
should not be removed.
(d) Separate the flexible coupling from the differential side.
HINT:
If the flexible coupling cannot be easily separated by hand, in-
sert a screwdriver into the bolt hole of the flexible coupling, as
shown in the illustration, then pry the coupling out.
NOTICE:
Do not bring the screwdriver blade in direct contact with
the flexible coupling's rubber portion.

26SUPRAÐNEW FEATURES
 DIFFERENTIAL
1. General
A differential gear ratio has been changed on the 2JZ±GE engine model.
A Helical gear type torque±sensing LSD (Limited Slip Differential) is available as an option on the SJZ±GE engine
model and 2JZ±GTE engine with automatic transmission model.
As in the '96 model, a worm gear type torque±sensing LSD is used on the model with the SJZ±GTE engine and
manual transmission.

Specifications
Model
'97 Model '96 Model
Engine Type2JZ±GE2JZ±GTE2JZ±GE2JZ±GTE
Transmission TypeManualAutomaticManualAutomaticManualAutomaticManualAutomaticItemManualAutomaticManualAutomaticManualAutomaticManualAutomatic
Differential Gear Ratio 4.803u3.1333.7694.272u3.1333.769
No. ofDrive Pinion12u151311u1513No. of
TeethRing Gear49u474947u4749
Ring Gear Size
mm (in.)205
(8.07)
u222
(8.74)205
(8.07)uu222
(8.74)205
(8.07)
No. of Differential
Pinion 2,8*1,
3u6*2 2,8*1,
3 2,6*2,
3u6*2u
*1 : Models with Helical Gear Type Torque±Sensing LSD
*
2 : Models with Worm Gear Type Torque±Sensing LSD
*
3 : Option
2. Helical Gear Type Torque±Sensing LSD
Characteristics
Good traction of high bias ratio design is obtained through the utilization of two types of friction: One is the friction
that is generated between the planet gear's tooth tips and the differential case's inner wall. The other is the friction
that is generated between the side gear end face and the thrust washer.
Quick response and minimum time lag until differential limiting force is generated.
The bias ratio sustains minimal changes due to aging and maintains a stable performance.
A simple, compact, and lightweight differential configuration has been achieved through the use of the helical gear.
Ordinary differential oil must be used; do not use special LSD oil.

MA0688
Outside
Inside
- DIAGNOSTICSENGINE (2JZ-GTE)
DI-153
381 Author
: Date
:
1997 SUPRA (RM502U)
4 Check are filter.
PREPARATION:
Remove air filter.
CHECK:
Visually check that the air cleaner element is not dirty or exces-
sively oily.
HINT:
If necessary, clean element with compressed air. First blow from
inside throughly, then blow from outside of element.
NG Repair or replace.
OK
5 Check idle speed.
PREPARATION:
(a) Warm up engine to normal operating temperature.
(b) Switch off all accessories.
(c) Switch off air conditioning.
(d) Shift transmission into ºNº position.
(e) Connect the OBD II scan tool or TOYOTA hand-held tester to DLC3 on the vehicle.
CHECK:
Use CURRENT DATA to check the engine idle speed.
OK:
Idle speed: 650 ± 50 rpm
NG Proceed to matrix chart of problem symptoms
on page DI-169.
OK

Position of Parts in Engine Compartment
E 4 Engine Coolant Temp. Sender
E 5 Engine Coolant Temp. SW
E 6 Engine Hood Courtesy SW
E 7 Engine Oil Level Sensor
F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light RH and Parking Light RH
F 9 Front Wiper Motor
G 1 Generator
G 2 Generator
H 1 Headlight Hi LH
H 2 Headlight Hi RH
H 3 Headlight Lo LH
H 4 Headlight Lo RH
H 5 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 8 Horn LH
H 9 Horn RH A 1 A/C Ambient Temp Sensor
A 2 A/C Condensor Fan Motor
A 3 A/C Triple Pressure SW
(A/C Dual and Single Pressure SW)
A 4 A/C Magnetic Clutch and Lock Sensor
A 5 A/T Fluid Temp. Sensor
A 6 ABS Actuator
A 7 ABS Actuator
A10 ABS Speed Sensor Front LH
A11 ABS Speed Sensor Front RH
B 1 Back-Up Light SW (M/T)
B 2 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor No.1
C 2 Camshaft Position Sensor No.2
C 3 Crankshaft Position Sensor
C 4 Cruise Control Actuator
D 1 Data Link Connector 1
D 2 Daytime Running Light Relay No.3
D 3 Daytime Running Light Relay No.3
E 1 EGR Gas Temp. Sensor
E 2 Electronically Controlled Transmission Solenoid
E 3 Engine Coolant Temp. Sensor
[2JZ-GTE]
24
26
G ELECTRICAL WIRING ROUTING

Position of Parts in Engine Compartment
[2JZ-GTE]
R 1 Radiator Fan Motor No.1
R 2 Radiator Fan Relay No.1
R 3 Radiator Fan Relay No.2
R20 Radiator Fan Motor No.2
S 1 SFI Resistor
S 2 Starter
S 3 Starter
S 5 Sub Throttle Position Sensor
S18 Sub Throttle Valve Motor
T 1 Theft Deterrent Horn
T 2 Throttle Position Sensor
T14 Turbo Pressure Sensor
V 2 VSV (EGR)
V 3 VSV (EVAP)
V 4 VSV (Exhaust Bypass Valve)
V 5 VSV (Exhaust Gas Control Valve)
V 6 VSV (Fuel Pressure Up)
V 7 VSV (Intake Air Control Valve)
V 8 VSV (Waste Gate Valve)
V10 Vehicle Speed Sensor No.1 (Combination Meter)
V11 Vehicle Speed Sensor No.2 (Electronically
Controlled Transmission)
W 1 Washer Motor I 1 Idle AIr Control Valve
I 2 Igniter
I 3 Igniter
I 6 Ignition Coil No.1
I 7 Ignition Coil No.2
I 8 Ignition Coil No.3
I 9 Ignition Coil No.4
I10 Ignition Coil No.5
I11 Ignition Coil No.6
I12 Injector No.1
I13 Injector No.2
I14 Injector No.3
I15 Injector No.4
I16 Injector No.5
I17 Injector No.6
K 1 Knock Sensor (on Front Side)
K 2 Knock Sensor (on Rear Side)
M 1 Mass Air Flow Meter
N 1 Noise Filter
O 1 O/D Direct Clutch Speed Sensor
O 2 Oil Pressure SW
P 1 PPS Solenoid
P 2 Park/Neutral Position SW, Back-Up Light SW and
A/T Indicator Light SW (A/T)
P13 Parking Light LH
25
G

26
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[2JZ-GE]
E 1 EGR Gas Temp. Sensor
E 2 Electronically Controlled Transmission Solenoid
E 3 Engine Coolant Temp. Sensor
E 4 Engine Coolant Temp. Sender
E 6 Engine Hood Courtesy SW
E 7 Engine Oil Level Sensor
F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
F 7 Front Turn Signal Light LH
F 8 Front Turn Signal Light RH and Parking Light RH
F 9 Front Wiper Motor
G 1 Generator
G 2 Generator A 1 A/C Ambient Temp. Sensor
A 3 A/C Dual Pressure SW
A 4 A/C Magnetic Clutch and Lock Sensor
A 5 A/T Fluid Temp. Sensor
A 6 ABS Actuator
A 7 ABS Actuator
A 8 ABS Relay
A 9 ABS Relay
A10 ABS Speed Sensor Front LH
A11 ABS Speed Sensor Front RH
B 1 Back-Up Light SW (M/T)
B 2 Brake Fluid Level Warning SW
C 3 Crankshaft Position Sensor
C 4 Cruise Control Actuator
D 1 Data Link Connector 1
D 4 Distributor

27
G
Position of Parts in Engine Compartment
[2JZ-GE]
O 2 Oil Pressure SW
P 1 PPS Solenoid
P 2 Park/Neutral Position SW, Back-Up Light SW and
A/T Indicator Light SW (A/T)
P 3 Power Steering Pressure SW
P13 Parking Light LH
S 2 Starter
S 3 Starter
T 1 Theft Deterrent Horn
T 2 Throttle Position Sensor
V 1 VSV (ACIS)
V 2 VSV (EGR)
V 3 VSV (EVAP)
V 6 VSV (Fuel Pressure Up)
V10 Vehicle Speed Sensor No.1 (Combination Meter)
V11 Vehicle Speed Sensor No.2 (Electronically
Controlled Transmission)
W 1 Washer Motor H 1 Headlight Hi LH
H 2 Headlight Hi RH
H 3 Headlight Lo LH
H 4 Headlight Lo RH
H 8 Horn LH
H 9 Horn RH
I 1 Idle Air Control Valve
I 4 Igniter
I 5 Ignition Coil
I 12 Injector No.1
I 13 Injector No.2
I 14 Injector No.3
I 15 Injector No.4
I 16 Injector No.5
I 17 Injector No.6
K 1 Knock Sensor (on Front Side)
K 2 Knock Sensor (on Rear Side)
M 1 Mass Air Flow Meter
M 2 Main Heated Oxygen Sensor (Bank 1 Sensor 1)
M 3 Main Heated Oxygen Sensor (Bank 2 Sensor 1)
N 1 Noise Filter

1 21 2
2 1
1 2
1 2
1 2 2 1
E16 E16 E16
IEIJ1 11
IJ2 12 IJ2 3 B 21 B1A 4 A 20
B 42 B63 B44 B24 B46 A3A18 B27 B7
3 12 8
43124 VTA2 IDL2 THW OIL THG K D M NE NE-
W- B W- B W- BL- R B- R
L- Y
O
BR- Y GR - RY- L
W- B W- B W- B GR- RW- BY- L L- R
W- B W- B
W- B
G- Y
B- R
BRG- YYY- L
G- WYL
G- W WB- R
Y- L
(
SHIELDED)(
SHIELDED) NCO+ NCO-STP TE 1FROM POWER SOURCE SYSTEM (
SEE PAGE 56)
STOP LIGHT
SW DATA LINK
CONNECTOR 1
O/D DIRECT CLUTCH
SPEED SENSOR
S11 D 1
O 1
Y
S 5
SUB THROTTLE
POSITION SENSOR
ENGINE COOLANT TEMP. SENSOR
A/T FLUID TEMP. SENSOR
EGR GAS TEMP. SENSOR
KICK DOWN SW E 3
A 5
E 1
K 4
ELECTRONICALLY CONTROLLED
TRANSMISSION PATTERN
SELECT SW
CRANKSHAFT
POSITION SENSOR
E 8
C 3
ENGINE CONTROL MODULEA E 9 , E1 0B
E14 W- B
W- B
B 65E2
15A
STOP
1I 10
TE1 +B
NORMAL
MANUAL
1J 11H 13
142
ELECTRONICALLY CONTROLLED TRANSMISSION