1994 PONTIAC BONNEVILLE fuel filter

Comfort Controls & Audio Systems
0
0 0
Electronic Climate Control
(OPTION)
When the engine is cold, the “AUTO’
blower is delayed/reduced until warm
air is available. Immediately selecting
90°F farenheit will NOT get the car
warmer any sooner than selecting
75
“AUTO”. The “DEFROST” blower
speed starts low to reduce windshield
fogging from any snow on the hood as
you start driving. The blower will
increase briefly after short stops when
the car had been turned
off to reduce
any stuffy feeling.
The A/C will only work when the
outside temperature gets above
42°F.
A “click” noise means the A/C
compressor is turned on. Besides
cooling, this is used to dehumidify and
filter the air for inside the car.
A hot, sunny parking lot or city traffic
will cause the system to start
re-circulating A/C air for quicker
cooling. The system is more efficient
by cooling the air already inside the
car.
EZ-Kool Glass is very effective in
filtering out the sun’s heat.
0 The direction of the cold A/C air can
be controlled by adjusting the outlets
in the dash. Aiming them just over
your shoulder will benefit both front
and rear passengers. Back-seat
passengers can also redirect airflow at
the rear of center console.
The air conditioner compressor operates
in all “AUTO” setting positions, and in
%? (Defrost) when the outside
temperature is above
42°F. When the air
conditioner is on, you may sometimes
notice slight changes in your vehicle’s
engine speed and power. This is normal,
because the system
is designed to cycle
the compressor on and off to keep the
desired cooling and help fuel economy.
TEMP: Sets the interior temperature you
want. The temperature you set will be
displayed on the digital screen.
Once you set the temperature, the system
will try to maintain the set temperature,
whether or not
you are using the heating
or cooling controls. But
if you set the
temperature for
60°F ( 16°C) or 90°F
(32”C), the fan will stay on “HI” speed
unless you select a different speed.
AUTO: To allow the system to
automatically control the temperature, air
Jistribution and fan speed:
1. Set the temperature you want with the
“TEMP” switch.
2. Press the “AUTO” switch.
EXT. TEMP: Press to have the exterior
temperature displayed
on the digital
screen (unless the system is off). Press
again to return to the inside temperature
setting. When the system is off, the
outside temperature will be displayed.
Use the following controls when “AUTO’
is not desired.
% : Sets the fan speed. Press the top of
the switch to raise the fan speed, the
bottom of the switch to lower the fan
speed.
“F/C: Press this to read the temperature in
degrees Fahrenheit or Celsius.
OFF: Shuts the system off. The outside
temperature will be displayed. Air
will
still flow through your vehicle if it is
moving. Also, the system will try to
maintain the temperature you set, but,may
... 116
ProCarManuals.com

Service & Appearance Care
Capacities and Specifications
Automatic Transaxle AT 4T60E (Overdrive)
When draining or replacing torque converter, more fluid may be needed.
Pan Removal and Replacement .................................. 6.5 quarts
After Complete Overhaul
...................................... 11 quarts
Cooling System ................................................... 13 quarts 6.00
L
10.50 L
12.00 L
Refrigerant (R134A), Air
Conditioning ............................... See refrigerant charge label under hood.
Not all air conditioning refiigerants are the same. If the air conditioning sys-
tem in your vehicle needs refrigerant, be sure the proper
refrigerant is used. If
you’re not sure, ask your Pontiac dealer.. For additional information, see
your “Warranty and Owner Assistunce Information” booklet.
Enginecrankcase ................................................. 4 quarts
When chunging filter, up to 1 quart (I liter) more oil may be needed.
FuelTank ........................................................ 18 gallons
Power Steering
PumpOnly ..................................................... 1 pint
Complete System
................................................ 1.5 pints
3.75 L
68.00 L
0.50
L
0.75 L
Tire Pressures, Sizes ............................................... See Tire-Loading Information label on
driver’s door.
Wheel Nut Torque ................................................. 100 Ib. ft. ( 140 Nom)
NOTE : All capacities are approximate. When adding, be sure to fill to the appropriate level, as recommended in this manual.
.. .242
ProCarManuals.com

TO BE SERVICED
Scheduled Maintenance (See “Explanation
of
MILES (000)
WHEN TO PERFORM
Services” following
Miles
(kilometers) or Months
Schedules
I and 11) (whichever occurs first) KILOMETERS (000)
Item No.
See “Explanation of Scheduled Maintenance 6. Transaxle Service
75 62.5 50 37.5 25
12.5
Services” following Schedules
I and I1
7. Spark Plug Replacement”
9. Supercharger Oil Check
a 8. Spark Plug Wire Inspection*?
a
a
Every 30,000 mi. (50 000 km) 11. Fuel Tank, Cap & Lines Inspection*$
0 Every 30,000 mi. (50 000 km) 10. Air Cleaner Filter Replacement*
a Every 30,000 mi. (50 000 km) or 36 months
Every
30,000 mi. (50 000 km)
The
services shown in this schedule up to 45,000 miles (75 000 km) should be performed after 45,000 miles at the same
intervals.
* An Emission Control Service.
f The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify thj emission warranty or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded in “Section E: Maintenance Record”.
253
ProCarManuals.com

6. Transaxle Service -- Change both the fluid and filter every
15,000 miles (25
000 km) if the vehicle is mainly driven
under one or more of these conditions:
0 In heavy city traffic where the outside temperature
regularly reaches
90°F (32 “C) or higher.
0 In hilly or mountainous terrain.
0 When doing frequent trailer towing. (With some
models, you shouldn’t ever tow a trailer. See “Towing a
Trailer”
in the Index.)
0 Uses such as found in taxi, police car or delivery
service.
If you do not use your vehicle under any of these
conditions, change both the fluid and filter every 100,000
miles (166
000 km).
7. Spark Plug Replacement* -- Replace spark plugs with the
proper type. See “Replacement Parts’’
in the Index.
8. Spark Plug Wire Inspection”? -- Inspect for burns,
cracks or other damage. Check the boot fit at the coils and
at the spark plugs. Replace wires as needed.
9. Supercharger Oil Check -- Check oil every 30,000 miles
(50
000 km) or 36 months. Add the proper synthetic oil.
See “Recommended Fluids and Lubricants’’ and
“Supercharger Oil”
in the Index. (Engine must be cold
before checking oil level. Oil is pressurized when hot and
will blow out of bearing case).
1 O.Air Cleaner Filter Replacement* -- Replace every
30,000 miles (50
000 km) or more often under dusty
conditions. Ask your dealer for the proper replacement
intervals for your driving conditions.
11. Fuel Tank, Cap and Lines Inspection”? -- Inspect fuel
tank, cap and lines (including fuel rails and injection
assembly) for damage or leaks. Inspect fuel cap gasket for
an even filler neck imprint
or any damage. Replace parts as
needed. Periodic replacement of the fuel filter is
not
required.
* An Emission Control Service.
The
U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the
emission warranty or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be
performed at the indicated intervals and the maintenance be recorded in “Section E: Maintenance Record”.
255 .
ProCarManuals.com

Maintenance Schedule
USAGE
Parking Brake
Guides
Power Steering
System
Automatic
Transaxle
Key Lock
Cylinders
Supercharger
Automatic
Transaxle Shift Linkage
Floor Shift
Linkage
Chassis
Lubrication
FLUIDILUBRICANT
Chassis lubricant (GM Part No.
1052497 or equivalent) or lubricant
meeting requirements of NLGI Grade
2, Category LB or GC-LB.
GM Hydraulic Power Steering Fluid
(GM Part
No. 1052884 or equivalent).
DEXRONa- IIE or DEXRONs- I11
Automatic Transmission Fluid.
Lubricate with Multi-Purpose Lubricant
(GM Part
No. 12345 120) or synthetic
SAE
5W-30 engine oil.
Supercharger Oil (GM Part No.
12345982).
Engine oil.
Engine
oil.
Chassis lubricant (GM Part No.
1052497 or equivalent) or lubricant
meeting requirements
of NLGI Grade
2, Category LB or GC-LB.
USAGE
Windshield
Washer Solvent
Hood Latch
Assembly
a. Pivots and
Spring Anchor
b. Release Pawl
Hood and Door
Hinges, Fuel Door
Hinge, Rear
Compartment Lid
Hinges
Weatherstrips
FLUIDlLUBRICANT
GM Optikleenm Washer Solvent (GM Part
No. 1051515) or equivalent.
a. Engine oil.
b. Chassis lubricant
(GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements of
NLGI Grade
2, Category LB or
GC-LB.
Engine oil or Lubriplate Lubricant
(GM Part No. 1050109).
Dielectric Silicone Grease (GM Part
No. 12345579 or equivalent).
See “Replacement Parts”
in the Index for recommended
replacement filters, valves and spark plugs.
. . .262
ProCarManuals.com

Electrical Equipment.
Adding
............... 85. 120. 237
Electronic Climate Control
....... 1 15
Electronic Compass
............. 105
Emergencies. Braking
........... 144
Emergencies. Steering
in ......... 145
Emergencies on the Road
......... 165
Emergency Starting
............. 167
Emergency Towing
............. I70
Engine. Starting Your
............. 53
Engine Block Heater
......... 55. 208
Engine Coolant
................. 2 13
Engine Coolant Heater
........ 55. 208
Engine Coolant Temperature
Gage
....................... 101
Engine Coolant Temperature
Warning Light
................. 92
Engine Exhaust ............. 65. 157
Engine Identification
............ 237
Engine Oil
.................... 205
Additives
................... 208
Checking
& Adding ...... 205. 206
Disposing of Used Oil
........ 208
Energy Conserving
........... 207
Oil Warning Light
............. 94
Check Level Light
............ 95
Pressure Gage
............... 10 1
When to Change ............. 208
Engine Overheating
............. 176
Engine Specifications
............ 243
Ethanol
in Gasoline ............. 196 Exhaust
Dangerous Gas
in ...... 65.66. 157
Parking with the Engine
Running
................ 64. 66
Expectant Mothers. Use of
Safety Belts
................... 24
Express Open Sunroof
............ 81
Expressway Driving ............. I5 1
Exterior Appearance (see “Appearance
Extender. Safety
Belt
............. 39
Care and Materials”)
Fabric Cleaning (see “Appearance Care
Fan Warnings
.......... 168. 169. 177
Filling Your Tank
............... 197
Filter
Air Cleaner
............. 209. 243
Oil
.................... 208. 243
Flashers. Hazard Warning
........ 166
Flat Tire ...................... 182
Flooded Engine ................. 54
Flow-Through Ventilation
........ I 18
Fluid
Brake
.................. 217. 261
Capacities
.................. 242
Transaxle
........... 2 11. 242. 262
Windshield Washer
.... 70. 2 17. 262
and
Materials”)
Finish Damage
................. 235
Power Steering
...... 2 16. 242. 262 Fog
Lights
................. 77. 244
Foreign Material
................ 234
Foreign Operation
.............. 196
Freeway Driving ............... 151
French Language Manual .......... 2
Fuel ......................... 195
Alcohol in Fuel .............. 196
Capacity ................... 242
Door Lock
.................. 197
Door Release. Manual
........ 198
Door Release. Remote
........ 197
Exhaust Warnings ...... 65. 66. 157
Filling Your Tank
............ 197
Fuels
with Alcohol ........... 196
Gage ...................... 100
In Foreign Countries .......... 196
Requirements ............... 195
Function Monitor
............... 103
Fuse Panel
................ 239. 240
Fuses
& Circuit Breakers ......... 238
Gages
........................ 99
Coolant Temperature ......... 101
Fuel ....................... 100
Oil Pressure ................. 101
Voltmeter ................... 102
Gas Station Information
.......... 288
Gasoline
...................... 195
Gasoline Tank. Filling Your
....... 197
281 ...
ProCarManuals.com