1993 VOLKSWAGEN GOLF warning light

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT
Dashboard and Controls ..... 4

. ey s, Cen tral locking . . .... 6, 7

::"tl-thef t warning system .... 8
Joors .......................... .... 9
oot lid .... ........... . . . . . 10
::Iectric windows .. . .. 10

• ~Irrors . . ..... . ... 12
Seal belts 13
"" rbag System . . . . . 18
Safe ty for children .. ... 21
ead restraints . . . . . .. 24

= ro nt seats . . . . . . . . . . . .. 25
Rear seat . . . 27

L u ggage compartment ... . ... . ...... 28

M esh partition (Estate) ...... 29

L u ggage compartment cover /

F olding/sliding cover
... 30
Pedals, Hand brake .. 31
Manual gearbox .... ... .... 31
Automati c gearbox . . . .. .......... 32

H eig ht-adjustable steering wheel ..... 35

I gnition lock. . . . . .. 35

Starting/stopp ing engine 36, 38
\lIstrumellts .. .... 39
Warning lamps ....... 46

Switches . . . . . . . . . . . . . . 50

Turn signal and dip lever ............. 53
Cruise control system ........... 54
Wi ndscreen wipe r and washer system 55
Heating an d ventilation .. . ...... 56
Air cond itioner ......' 59
Sliding/ti ltin g roof. . . . . . . . . . . . ... 65
Sun visors / Interior lights 66,67
Cigarette lighter, Ash tray ..... 68

Shelves and boxes . . . . . . . . . . . ... 69
Roof rack / Roof ra ilings ... 70

DRIVING TIPS
The firs t 1500 km -and after wards .... 71
Driving economically and ecologically .. 72
Brakes. . . . . . . . . . . . . . . . 75
Tra iler tow ing . .. ..... . .... ... ...... 77
Driving a four- wheel drive vehicle .. 79

GENERAL MAINTENANCE
Filling the tan k, Fuel. 81, 82

Care of vehicle ........ .. . . 85

Bonnet . . ... 90

Engine compartment .. ...... .... .... 91
Engine oil ..... .......... ........... 92
Automatic transmission fluid (ATF)* ... 96
Power-assisted steering .. 96

Cooling system . . . . . . . . . . .. . 97

B rake fluid ...... 99

Battery . . . . .. 100

Spark plugs. V-belts . . . . . . . . . 102

Washer system
... . .. 103

Windscreen w iper blades . . . 104

Dust a
nd pollen filter * . 104

Wheel s . 105

D riving abroad ..... ............... 110

Accessories, modifications and
renewa l ot parts .............. III
Mobile telephones and tw o-way rad ios 111

DO -lT-YOURSELF
First -aid kit, Warn ing triangle ........ 112

Storage of vehicle tools, spare wheel

a n d ball coupling trailer bracket ...... 113
Vehicle tools, Spare wheel 114

CONTENTS
Changing w heels . 116

F uses . ........ .. .. . . . ... . .... 119

Changing bulbs. . .... .. . 121
Installing radio . . . . .. 127

E mergency starting .. .. 128
Tow starting / to wing . . .. 129

L ift ing vehicle ......... 131

SPECIAL INFORMATION
Body ..... .... . .......... 132

Environmental compatibility ... 133

TECHNICAL DATA
Engine data . .. , .... .... . 134

P er forman ce .. ... ... ... . .. 136

Fuel consump tion .. 137

Wh eels
. . 139

T yre pressures
.. .. ... .. . . .. ... 1 4 1

Weights ... 143

Trailer weights .. 144

Dimensions. ...... .. ... 145

Capacities " ..... 146

Vehicle identification data ... 147

ALPHABETICAL INDEX
Alph abetical index ... 148

3

Downloaded from www.Manualslib.com manuals search engine __CONTROLS AND EQUIPMENT

Page
1 Switch for electric front windows 10
2 Door lock release lever 9
3
Remote controlled outside mirror 12
4 Warning lamps 49
5 Air vents 57
6 Light switch 50
7 Instrument lighting regulator 50
8 Headlig ht range control 51
9 Lever for heig ht adjustable steeri ng w heel 35
1 0
Combi instrument:
Instruments
Warning lamps
39
46
1 1 Emer gency light system switch 51
' 2 Ignition lock 35
' 3
Knurled wheel for seat heating 51
'4 A ir ve nts 57
' 5 Radio 1)
·6 Controls and switches for heating and
ventilation/air conditioner 56
59
17 Glove box or passenger side Airbag 69,1 8
18 Bonnet release handle 90
'9 Fuse box behind shelf 119
Page
20 Cold starting aid/idling speed boost (Diesel engines) 37
21 Turn signal and headlight dip lever
Cruise control system 53
54
22 Horn (on ly functions with ign ition switched on)
or driver's airbag 18
23 Windscreen w iper/washer lever
w ith switch for multi function indica tor 55 42
24 Push buttons for air conditi oner 59
25 Ash tray 68
26 Gear lever (manua l ge arbox) Sel ector lever (automa tic gea rbox) 31 32
Xl-Handbrake leve r 31
28 Cassette or CD storage box
29 Cigarette lighter/elec tric soc ket 68
30
Heated rear windo w switch 52
31 Switch for rear electric w indows 10
• Some of the items listed are only fitted on certain models or are op tional extras .
• On right-hand drive vehicles the
arrangement of the switches
and the location of some items can vary. However the symbo ls on
th e switc hes are the same as for left-hand drive vehic les.
n Vehicl es with a facto ry fitted radio have a rad io ins truction le aflet sup­plied Whe n re trof ittin g a radio pay atte ntion to the instructions on
page 127 in the" Do-it-yours elf " sect ion.
5

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT
Anti-theft warning
system*
Tailgate
• When the key slot is horizont al (a) the
tailgate is locked or unloc ked automatically
by the central locking system. The tallgate can also be locked or unloc ked separately with the key. • When key slot is vertical (b) the tailgate
will be locke d all the time after closing . It can the n only be unlocked with the key. To unlock tailgate , insert key and turn It fully
to the right (c) Hold in this position and press button in .
The alarm system is switched on automati­cally when the driver's or front passenger's door is locked. Simply hold the key briefly in the locking position until a warni ng light
near the driver's door locking knob flashes
t o show that the system IS operative. The
system becomes active about 30 seconds
lat
er.
If the warning lamp does not flash, check
the doors and tailgate and close if necess­ary.
The alarm will be triggered if, with the ve­
hicle locked, one of
• the doors,

• the bonnet,

• the tailgate/boot
lid
is opened or

• the ignition is switched
on.

When the alarm is triggered the horn

sounds and a flashi ng signal is activated for

about 30 seconds (in Switz erland a continu­

ous note for about 30 seconds), and the en­

gine cannot be started .

The windows and sun roof* are not separ­

ately monitored .
Note
• The wa mi ng lamp goes out after approx . 24 hours. T hiS pre ven ts the battery becom­
ing disc harged when the vehicle is not used for a long peri od
• The
tailgate/boo t lid can be opened sep­
arate ly wi th the key even w hen the system is active . This wi ll not trigger the alarm .
Whe n the lid is closed the luggag e compart­ment wili again be included In the alarm cir­cu it.
•
The alarm signal will be triggered a sec­
ond time if one of the protecte d part s of the
car
is inte rfered w ith again aher th e alarm
si gnal has stopped (for insta nce if the tail­gate/boo t lid is opened after one of the
doors has been opened)
8

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT
Airbag-System*
Vehicles with Airbag System for the driver and passenger can be recognized by an inscription "AI RBAG" on the steering wheel padded plate and on the right end of the dash panel.
Supplementary to the three point seat belts the Airbag System offers additional protection for the driver's and passenger's head and chest In a serious
frontal collision.
Apart
from its normal protective function the seat belt also has the task of keeping the
driver or passenger in such a position so
that the Airbag can offer maximum protec­
tion in the case of a frontal collision.
The Airbag system will not be trig­gered for:
• Side collisions
• Rear collisions
•
Rol l i ng-over
• Minor frontal collisions
Therefore the seat belts should al­ways be used not only for reasons of statutory regulations, but also for safety reasons!
Essentially the system consists of
• The electronic control and monitoring
unit

• Both airbags (air sack
with gas gener­

ator) with gas generator for the:

- Driver (in steering wheel),

- Passenger (in right of dash panel)

• A
warning lamp in the dash panel -see

page 49.

The functional readiness of the Airbag
System is electronically monitored.

Each
time the ignition is switched on the

warning lamp lights for about 3 seconds

(self diagnosis).

The system has a fault, if
• When switching on the ignition the warn ing lam p does not light.
•
After swi tching on the ignition the warn­
ing la m p does not extinguish after about 3
second s
• The warning lamp
comes on or flickers
du rin g the Journey.
Attention
When a fault is present the sys­
tem should be checked by a
Volkswagen dealer immediately.
Otherwise there is the danger
that the Airbag will not be acti­
vated in the case of an accident.

18

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EaUIPMENT ------------------------------~---
Pedals
- _ movement of the peda ls must never be ~S ncted .
::-thIs reason, do not put articles in the '00 well which cou ld roll or slide under­
- 3ath th e pedals.
- • In t
he case of defects on the brake sys­
'em, a greater pedal travel may be necess­a , t should always be possib le to depress
- "'e clut ch and acce le rator pedals fully.
All peda ls must be able to return , unh in-Jere d, to their rest positions. .
= o r these reasons, the only foot mats which e 'Y'\ay be used are those which leave the
ed al area compl ete ly free and which are pre ve nted from slipping .
'11
Hand brake
To apply the handbrake pull lever up firmly . On hills th e 1 st gear, or with automatic gear­
box the parking lock, sho uld also be en­
gaged. The handbrake should a lways be ap­plied so firmly that it is not possible to drive inadve rtentl y with the handbrake on.
W h
en handbrake is applied with the ignition on, the brake warning lam p* comes on.
To release handbrake, pu ll lev er up slightly ,
press locking knob in and push lever right
do w n.
Manual gearbox
• Only engage reverse gear when vehicle is st ationary With the engin e is running, de­
press clutch fully and wait a fe w seconds before mo ving gear lever. ThiS prevents
g rating noises .
When
rev erse gear is engaged with ignition on , the reversing lights come on.
Note
When driving you shou ld not rest your hand
on th e gear lever . The pressure of your hand is transmitted to the selector forks In the
gearb ox and can cause premature wear on the forks .
31

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Stopping engine
66 kW engine
Starting a cold engine
Ambient temperature above +5 0C:

The engine can be started without pre­
glow Do not depress throttle during the

starting procedure.

Ambient temperature below +5 0C:

• Turn the key in the ignition lock to posi­
tion 2 (see page 35) -the glow plug warning
lamp comes on It goes out when the igni­
tion temperature is reached (see page 47). While the glow plugs are working do not switch on any other heavy cur­rent consumers because this would place an unnecessary load on the battery.
• When the warning lamp goes out, start
the engine immediately
If the engine does not start, repeat
preglow and try starting it again as described. If the
engine still does not start the fuse for the glow plugs may have blown -see page 120.
Starting a warm engine
The glow plug lamp does not come on -the
engine can be started straight away
When engine has been running fast for a long time, let it idle for about 2 minutes so that it can cool down slightly before being switched off.
Attention After the engine has been stopped the fan can continue running for a while (up to about 10 minutes) with the ignition switched off. It can also start to run again suddenly after a short time if -the coolant temperature in­creases due to heat build-up
-when engine is hot and the en­gine compartment is heated additionally by strong sun­light.
Special care must therefore be taken when working in the en­gine compartment.
On vehicles with a catalytic con­verter, the ignition must not be switched off as long as the vehicle is rolling with a gear engaged, other­wise, unburnt fuel can pass into the catalytic converter and cause dam­age.
38

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

~DC _ Engine oil temperature
Oil temperatures (within a range of + 50°C
to 160 °C) are shown. When no oil tempera­
ture indication is sho wn, the eng ine is still
not warm, and it should not therefore be worked hard . The engine speed should be reduced if the oil temperature rises to + 145°C.
,I,.e·DC'1' -Ambient temperature)2)
The measuring range is from -40°C to
+ 50°C. When the vehicle is stationary or
only moving very slowly , the ind ic at ed tem­
perature could be slightly higher than the
actual ambient temperature due to heat
radiation from the engine.
A fter switching off the ignition the last indi­
cated temperature
is sto red in memory for
about 45 minutes . If the ig nition is switched on after 45 minutes or the vehicle is moved at about 30 km/h with in the 45 minute
period, a new up-to-date temperature w ill
be displayed.
Attention
If the ambient temperature read­
ing is used as an ice warning, re­
member that ice can form on the
road at temperatures above O°C.

2) On vehic le s with Climatr onic 1he amb ient
t empe rature is shown in the C limatr onlc dis­play.
44

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

3 -Coolant temperature _~_
gauge
-I - ar e the needle reache s its final posi tion.
' he n ignition
is switched on the warning amp (c) light s up for a few seconds as a
- u ncti onal check.
3 -Cold
~old high engin e speeds and do no t work engine too hard yet.
b-Normal

When the ~ehicle is dri~en normally the

needle should settle down in the central

zone.

When engine
is working hard and th e ambi­

ent temperature is high, the needle may

move a long way to the right.

This is not serious as long as the warning lamp (c) does not flash.
c -Warning lamp
If the lamp flashes when driving , check first
what the coolant temperature is.
If th e needle
is in th e normal zone, top the
coolan t up at the next opportu nity.
If the needle is over to th e rig ht, the coolant
temperat ure is to o high. Stop. switch en­gine off an d try to determine cause of trouble -see page 46 .
Notes
• Additional lights in front of the radiator grille interfere with the flow of cooling air. At high ambient temperatures and full tt:arottl~ there is a danger that the engme Will then overheat!
4 -Fuel gauge
This gauge works when ign ition is. switched
on but it takes a few seconds for the need le
to reach its fina l posit ion.
The ta holds about
-55 ItL (1 2 gallons) on the Golf saloon
- 60
Itr. (1 3 gallons) on the Golf estat e
- 65 Itr.
(14 gallons) on the Golf syncro
W
hen the needle reaches the start of the re­
serve zone (arrow) th ere is about 7 litres (1. 5
gallons) of fue l left in the tank .
45