1990 VOLKSWAGEN TRANSPORTER check engine light

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
ENGINE OIL FILTER
: he oil
filter
should be changed at the inter-

,als
listed in your Maintenance booklet.
• Remove old oil
filter
element and dis­

card.

• Use
only
Oil
filter
part
No.:

070115561
as
otherwise
engine
damage

can occur.
• Lightly coat seal of new
filter
element

with
oil. • Screw on
filter
element and hand-
tighten according to manufacturer's instructions on the carton or on the
filter

element.
• Fill engine
with
appropriate amount of
engine oil.
• Run engine at various speeds for three
to five minutes and check for leaks.
• Check dipstick for correct oil level, top
up if necessary.

Always
heed
WARNINGS
on
page
96 and 97. 101


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE

Refill
tank

Checking
the coolant level

The coolant level should
be
checked from time
to
time, and always before going on
a
longer
trip.

WARNING

To
reduce the risk of being burned, never open the hood if you see or hear
steam or coolant
escaping
from the en­
gine compartment.
Wait
until
no steam

or
coolant can be seen or heard before
carefully opening the
hood.
Expansion
tank
The refill tank and
the
expansion tank are in
the
engine compartment.
The coolant level
is
normally checked only in
the
refill tank (behind
the
license plate
lid).
The expansion tank needs checking only
if
a
large amount
of
coolant
is
lost
or if the

warning
light
in the
water temperature gauge lights up.
On
the
refill
and the
expansion tank,
the

cap
need
not
be taken
off,
since the tanks
are transparent.

On
the refill tank, the coolant level must
be

between
the
min.
and
max. marks when
engine
is
cold
and not
running. When
engine
is
warm, coolant level
may be

slightly above max. mark.
The expansion tank
is
equipped
with
an
electric coolant level checking device.
When the coolant level is too low, the warn­ ing
light
in the
coolant temperature gauge

(see
page
43)
will flash
until
the
coolant
level has been restored
to
normal.

Always heed WARNINGS on page 97.
105


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
BRAKE FLUID 3 ATT
108 Brake fluid reservoir
The brake fluid reservoir is located under the instrument cluster in the dashboard
panel.

To gain access to the reservoir, grasp the two recesses provided on back of the frame cover and pull up.
When replacing the cover, insert the front edge first, then press the cover down
firmly. Make sure it is correctly seated.
Checking fluid level
The correct fluid level is important for the proper functioning of the brake system.
The fluid level in the brake fluid reservoir should always be between the MAX and MIN markings. Your brake fluid level is automatically monitored by the brake
warning light (see page 43).
The fluid level may drop slightly after some time due to the automatic adjustment of
the brake pads. This is no cause for alarm.
If the brake fluid level falls considerably
below the mark
"MIN",
the brake warning
light will come on. Do not continue to oper­
ate the vehicle. The complete brake sys­
tem should be thoroughly checked by your
Volkswagen dealer and the cause cor­
rected.

WARNING • Brake fluid is poisonous. Brake fluid
is also harmful to the paint of your
vehicle.
When adding or replacing brake fluid, make certain to avoid spilling. Brake
fluid will damage fabric, paint, plastics and metal. Cover the areas sorround-ing the reservoir before removing the
filler cap.
• If brake fluid must be added to the
reservoir, use only new and unused
DOT 4 brake fluid that meets SAE
specification J 1703 and conforms to Federal Motor Vehicle Safety Standard

116.
• Do not use any other brake fluid, or
brake fluid that has absorbed moisture
from the open air, or brake fluid that is
dirty. It may cause premature wear or unreliable braking action.
• Do not add or mix DOT 5 silicone
type brake fluid with the brake fluid in your vehicle as severe component cor­rosion may result. Such corrosion
could lead to brake system failure.
Changing brake fluid Brake fluid absorbs moisture from the at­
mosphere. If the watercontent in the brake
fluid is too high, corrosion in the brake sys­
tem may result after a period of time. The boiling point of the brake fluid will also de­
crease considerably. If the brakes are under constant and extreme use, a vapc
lock may result impairing the effectiveness
of the brakes and the vehicle safety. -e s
Dn seat arc
WARNING
The brake fluid must be replaced every 2 years. Your Volkswagen dealer will perform this service for you.
Always heed WARNINGS on page 97.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE
General notes

The original equipment tires
and
wheel
rims
on
your
vehicle comply with
all

applicable
Federal Motor Vehicle Safety

Standards.

If you
wish
to
equip
your
vehicle with tires
or wheels other than those installed
at the

factory, please note
the
following:

•
If
you plan
to
install other than the
ori­

ginal
equipment tires
and
wheel rims,

ask
your
Volkswagen dealer.

•
For
technical reasons
it is not
possi­

ble
in
every
case
to use
wheels from
other vehicles
-
under certain condi­
tions
not
even wheels from
the
same
vehicle
model.

•
Wheel rims
and
wheel bolts
or lug

nuts are matched to fit
your
Volkswagen.

•
When installing different wheels
(for

example,
wheels with winter tires),
the

correct wheel bolts
or
lug nuts with
the
proper length
and
conical shape must
be used. The secure fit of the wheels and
the proper functioning
of the
brake system are dependent upon this.
•
Using tires and/or wheels which have
not been approved
by
the manufacturer
for
your
vehicle
type
can be detrimental
to vehicle safety.

•
If
wheel trim discs
or a
front
spoiler
are

installed,
make
sure the airflow for cooling
the brakes
is not
obstructed.

•
Before
you
plan
on
exchanging steel
wheels, light alloy wheels,
or
snow tires
already mounted on wheel rims, consult

your
Volkswagen dealer. He has the tech­
nical
information necessary
to
advise
you which wheel rims and wheel bolts
or
lug
nuts are compatible with the original
factory installations.
WARNING
•
The
use of the wheel rims and wheel
bolts
or
lug nuts that do not meet
speci­

fications
of the
original factory
install­

ed equipment will affect the safe oper­
ation
of
your
vehicle and may cause an
accident and personal
injury.
Tire specifications

Tire
specifications
are
imprinted
on the
sidewall
of
the tires.
If in
doubt, check with

your
Volkswagen dealer.

All
passenger car and some light trucks tires must conform
to
Federal Safety
Requirements
in
addition
to
these
grades.

Treadwear

The treadwear grade
is a
comparative
rating
based
on the
wear rate
of the
tire
when tested
on a
government test course. For example,
a
tire graded
150
would wear
one
and a
half
(IV2)
times
as
well
as a
tire
graded 100.
The
relative performance
of

tires depends
on
actual conditions
of use,
however,
and may
depart significantly
from
the
norm
due to
variations
in
driving
habits,
service practices
and
differences
in road characteristics and
climate.

Traction A, B, C

The traction grades, from highest
to
lowest,
are A, B and C and
represent
the

tire's ability
to
stop
on wet
pavement
as
measured
on
government test surfaces
of

asphalt
and concrete. Atire marked
C
may
have poor traction performance.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF-SERVICE
• Fully unscrew wheel nuts or bolts and

dace
them into the hub cap. Take the top
nut or bolt off last.
Place
the spare wheel against the wheel hub and slightly rotate
:he wheel until a bolt hole in the wheel is in ine
with
a threaded stud in the wheel hub.

Reinstall
nuts or bolts and tighten them

crosswise
by hand before jacking the car

down.

Step
7 • To
lower
the vehicle,
turn
the handle

counterclockwise.
Step
8
• Then go crosswise from one nut or bolt
to another tightening them firmly
with
the lug wrench.
• Correct
tightness
of the
wheel
nuts
is

important.

• Correctly tightened nuts or bolts should

have
a torque of 130 ft lb/180 Nm. This
tor­

que can be obtained
with
the lug wrench by any person of average strength. If in
doubt about the correct tightness of the
wheel nuts, have them checked
with
a
tor­

que wrench by your dealer or at service
station.
Step
9
• To install the hub cap, place it around
the lower part of the wheel center. With a

firm
blow of your hand on the upper part,
the hub cap will snap into place. Make sure it is firmly seated.

Step
10 • Fully lower the vehicle and remove
jack.
• Correct the air pressure of the
tire
you

have
just
put on. For correct
tire
inflation

pressures,
see the sticker on the
left
door-
jamb.
• Store the jack and tools under the
driver's seat.
• Store damaged
tire
in spare wheel
metal plate under
front
of vehicle.
• Engage lock for metal plate and firmly

secure
plate
with
bolt.
• Have
flat
tire
repaired and replaced
promptly.
127


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF-SERVICEI
• Remove the four screws (arrows) and
take the headlight out. | B16-251

Outer
headlights
• Disconnect wire connector (1)
• Twist lock ring (2) counterclockwise,
pull bulb (3) out ot headlight housing and

discard.

• Install new bulb so
that
the locating lugs
on the headlight housing engage the
recesses
on the bulb.
• Reinstall lock ring so
that
its recesses

engage
the locating lugs on the headlight
housing.

• Twist lock ring clockwise until firmly

seated.

• Reconnect wire connector. Have head­
light beam alignment checked.
Auxiliary
driving
lamps

• Turn cap to
left
and take off.
• Pull wire connector off.
• Unhook spring clip holding bulb and
swing it away.
• Take bulb out and insert new bulb so

that
the locating lug on bulb plate engages
recess
in reflector.
• Swing spring clip over bulb plate.

Squeeze
clip together and engage it in the retaining lugs.
• Attach wire again.
• Install cap and
turn
to
right.

• Have headlight setting checked.
131


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

page

Accessories
122

Air
cleaner 103

Air
Conditioner 54 All-wheel-drive 75
Alternator warning
light
44

Ashtrays
64
Assist
handles and coat hooks ... 67
Automatic safety belts 14
Automatic Transmission 35
Automatic Transmission Fluid .... 102 Auxiliary Heater 57, 60
Battery 109
Battery charging 110

Brake
fluid reservoir 108

Brake
warning
light
43
Brakes
29

Break-in
period 69

Bulb
chart 130

Bulb
replacing 130
Buzzer
7,35

Capacities
147

Catalytic
converter 144

Central
locking system 8
Cigarette lighter 63
Child
safety 15

Chime
7,35

Cleaning
products 89

Climate
controls 51
Clock
41 page

Coolant
temperature gauge .... 41

Cooling
system 104

Consumer
information 152
Corrosion
protection 94

Cruise
control 49

Curtains
27

Cup
holder 66

Dashboard
4

Data
146
Defogging/defrosting 52 Differential lock 33

Dimensions
148
Do-it-yourself service 123

Doors
9

Economically
driving 72

Electric
windows 12

Emergency
equipment 70
Emergency
flasher 46

Emergency
starting 136

Emergency
towing 138

Emission
Control System 144
Engine
code letter 151

Engine
compartment lid 97

Engine
cooling 41,104
Engine
exhaust 144

Engine
number 151

Engine
oil changing 100
pace

Engine
oil checking 9?

Engine
oil grades 9E

Expansion
tank 105

Fan
41, 10c

Folding
table 65

Foreign
country driving 120 Front seats 20

Fuel
economy 72

Fuel
gauge 42
Fuel
injection 142

Fuel
supply 86

Fuel
tank 85

Fuses
12E

Gas
Station
Information
156

Gasoline
additives 86
Gearshift lever 32

Glove
compartment 64
Headlight dimmer and flasher .... 48 Headlights 13C
Headlight adjustment 134
Headlight switch 46

Head
restraints 19 HeatingA/entilation 51
High beam 45,48
Horn 4
Identification label and number ... 151
Ignition/steering lock 38
Indicator lights 43


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans