1989 MITSUBISHI GALANT ignition

35-50SERVICE BRAKES - Anti-lock Braking System Troubleshooting
E-5
I I
When diagnostic trouble codes “41 SOL V FRONT L”, “42 SOL V FRONT R” OR “43
SOL V DRIFT” are displayed
I
[Explanation]
The ABS ECU normally monitors the solenoid valve
drive circuit. If no current flows in the solenoid even if the ECU
turns the solenoid ON or if it continues to flow evenwhen turned OFF, the ECU determines the solenoid
coil wire is broken/short circuited or the harness is
broken short circuited and then these diagnostic
trouble codes are output.
IGNITION
SWITCH
llG1)
HU
1 / 2 / 3 14 15 16 I 7 ~8~9h0~11~12~13~14~15[16[17@,19bO~21i22~3~24~25)26~27~28~29~30)31$2~33)34[35j
:Non-Turbo tor and check with the HU
side connector.
Connect HU IOP connec-tor, disconnect ECU con-nector and check.
Is the solenoid valve resis-tance value within the ranae
The harness wire for thesolenoid valvecircuit1
nectar?
Standard value: 1.0-l .3 Q
YesIRepair ABS harness.1
Replace ABS ECU.1
I1 TSB Revision

SERVICE BRAKES - Anti-lock Braking System Troubleshooting35-51
E-5When diagnostic trouble code “51 VALVE RLY” is displayed
[Explanation]
When the ignition switch is turned ON, the ABS
ECU switches the valve relay OFF and ON for an
initial check, compares the voltage of the signal to
the valve relay and valve power monitor line voltage
to check whether the valverelay operationis
normal. In addition, normally it monitors whether or
not there is power in the valve power monitor line
since the valve relay is normally ON. Then, if the
supply of power to the valve power monitor line is
interrupted, this diagnostic trouble code will output.
MAIN FUSIBLE$tW&N
LINK @I(IGl)
gEli!z$; lf*x**
IT
510
IU-412 &-,8
ABS ECU
: Non-Turbo . Turbo: Non-Turbo y+iw+w;,aay;check thy
When the valve relay i
s
checked, are the following
conditions found?No. 85-No. 86:resistance
value 60-120 52No.30-No.87a: continuity
No. 30-No. 87: No continui-
When battery voltage is ap- plied between terminals
No. 86 and No. 85 grounded.
No.30-No.87: continuity
No. 30-No. 87a: no continui-
t
y
remove the HU connec-
\/
I With
the
ignition key “ON”
,
No c HU power harness wire is
does the voltage betweenbroken?the connector terminal No.
12 and ground indicate bat- tery voltage? I
IRepair harness.
YesIIIbI\I
Does resistance between
body connector termina
l
No. 2 and terminal No. 27 in-
dicate
60-120 ohm?
IYes
Is there continuity between
body connector terminal No.
22 and ground? Repair harness.
ABS ECU malfunction Replace ABS ECU.
1 TSB Revision1

35-68SERVICE BRAKES - Service Adjustment Procedures
A.B.S. warning light
Ignition switch
sT;!i;%
lARD175
Filter4
kR
14A0171
ANTI-LOCK BRAKING SYSTEM (A.B.S.) CHECK
(CHECKING BY THE A.B.S. WARNING LIGHT)
M35FOAK
By following the procedures described below, check whether
the system is good or not by checking the illumination and non-illumination of the A.B.S. warning light.
(1) Check to be sure that the A.B.S. warning light illuminates
when the ignition key is turned to the ON position, and
that it again illuminates two times during a short period of
time (approximately 0.5 second) after the engine is started, and that it then stops illumination.
(2) After checking that the A.B.S. warning light does not illuminate during a period of approximately 2 minutes
while the engine is left idling, test drive at a vehicle
speed of approximately 30 km/h (18.6 mph) or more for
about 30 seconds or longer and check that the A.B.S.
warning light does not illuminate during that time.
(3) If any abnormal condition is discovered during steps (1) and (2) above, check the system by following the anti-
skid brake system troubleshooting procedures.
Caution
Before checking the anti-lock braking system by the
A.B.S. warning light as described above, first check
the ordinary brake system that there are no problems
such as leakage of the brake fluid, incorrect connec-
tions of the brake tubes, etc.
WHEEL SPEED SENSOR OUTPUT VOLTAGE
CHECK
M3sFoAE
(1) Jack up the vehicle and release the parking brake.
(2) Disconnect the electronic control unit harness connector,
and measure the speed sensor output voltage at the
vehicle side harness connector.
(3) Rotate the wheel to be measured at a speed of about
one-
half to one rotation per second and while doing S
O
measure the speed sensor output voltage by using a
voltmeter or oscilloscope.
(4) If an oscilloscope is used, use the filter shown in the
figure at the left.
Speed sensor1-1 Standard value
1 Front left15-4 (22-4 I50 mV or more 1IIIII
IFront rightI1 23-21 1 23-21 1IIIII1 Rear right1 24-26 1 24-26 1II IIIIII Rear left( 7-9 18-9 1IIII1
NOTE
1. A voltmeter with AC mV range indication should be used
for measurement.
2. When disconnecting the adaptor from the body harness connector, attach a cord to the male connector and then
pull to disconnect.
TSB Revision

2ALPHABETICAL INDEX
BRAKE LINING ThicknessCheck

.., ..,............
Drum, Rear, Maintenanc
e
BRAKE LINING AND BRAKE DRUM, Connection Check..
BRAKE PAD
Drsc, Front, Check and Replacemen
t
Disc, Rear, Check and Replacement BRAKEPEDAL..
BRAKE PEDAL, Inspection and Adjustment
BUMPER..... 35-67-l
00-44-l
35-67-l
35-59-l
35-65-l
35-76-l
35-53-l
51-7-I
C
CABLEAccelerator, Inspection and Adjustment
13-398-l
Accelerator, Inspection and Adjustment Control> 13-329-I
High
Tensron, Spark Test ........
.
16-42-11Parking Brake................................

.
36-5-l
Spark
Plug, Tes
t
........................
16-42-11Speedometer, Replacement ...............
.
23-93-l
Speedometer, Replacement
.........
.
22-19-I
Speedometer, Replacement
............
.
22-5-l
CAMSHAFTDOH

C
...................
1 l-68-lSOHC.................................

.
11-19-I
CAMSHAFT OIL SEALS
DOHC
...................................
.
11-68-I
SOHC........................................

.
11-19-I
CAMSHAFT POSITION SENSOR
On-vehrcle Inspection
..................
.
13-277-l
On-vehicle Inspection
............
.
13-69-l
On-vehicle Inspection
........
.
13-165-I
CANISTER,
Evaporatjve Emission.................

.
17-21-l
CATALYTIC CONVERTER............................

.
17-24-l
CENTERMEMBER...................

.
....... 32-8-l
CENTRAL DOOR LOCKING SYSTEM..................

.
42-101-I
CHARGE AIR COOLER...............................

.
15-l

2-l
CHARGING..................
.
..... 55-17-I
CHARGING SYSTEM....................

.
...........
16-2-11CHARGING SYSTEM, Inspection.......................
.
16-5-11CHECK VALVE, Operation Check......................

.
35-54-l
CIGARETTE LIGHTER..........................

.
54-106-11
CLOCK........................................
.
54-109-11CLOSED THROTTLE POSITION SWITCHAdjustment GVALVE>
.................. 13-136-I
Frxed SAS, Adjustment
..................
.
13-250-I
On-vehicle inspection .................. 13-274-l
On-vehicle Inspection
............
.
13-61-I
On-vehicle Inspection

.........
. 13-160-I
CLUTCH CONTROL.................................

.
21-10-I
CLUTCH MASTER CYLINDER.........................

.
21-12-l
CLUTCH PEDAL.....................................

.
21-7-l
CLUTCH PEDAL, Inspection and Adjustment ................
21-5-1CLUTCH RELAY, A/C Compressor, On-vehicle Inspection
>
....................................... 13-285-l
CLUTCH RELEASE CYLINDER.........................
21-13-lCOIL
Ignition, On-vehicle
Inspectron 13-302-I
Ignition, On-vehicle
InspectIon
......
. 13-96-l
Ignition. On-vehicle Inspection
13-186-l
COLUMN SWITCH............................

.
54-100-11COMBINATION LIGHT, Rear.
.........................
.
54-95-11COMPRESSION PRESSURE
Check
...............................
.
1
i-59-1Check
..................................
11-8-l
COMPRESSOR...................................
.
55-38-l
COMPRESSOR, Air.......

.
........................ 338-125-I
COMPRESSOR DRIVE BELT, Adjustment, ................. 55-17-l
COMPRESSOR NOISE, Adjustment ...................... 55-23-l
CONDENSER, ............ .......................... 55-48-l
CONDENSER FAN MOTOR...........................

.
55-48-l
CONSOLE, Floor....................................

.
52-29-l
CONTROL
Engine
........................................
.
13-328-l
Transaxle ............................... 23-94-l
Transaxle
..........................
.
22-19-I
Transaxle
...........................
.
22-6-l
CONTROL SYSTEM
Evaporative Emission
.............................
.
17-15-l
Intake Charge Pressure, Inspection.
....................
15-7-lMixture (MFI
)
.............................. 17-29-l
Purge, Inspection .................... 17-17-l
Purge, Inspection ....................... 17-18-l
CONTROL UNIT
ABS
........................................
.
35-134-l
Active-ECS ................................... 338-140-I
EPS.....................................

.
...37A-59-lCONTROL VALVE <4WS>..........................

.
378-12-I
COOLANT
Engine, Concentration Test ..........................
14-8-lEngine, Leak Check ................................
.
14-8-l
Engine, Maintenance. ............................ 00-44-I
Engine, Replacement ...........
................... 14-8-lCRANKCASE VENTILATION SYSTEM, inspection..........

.
17-14-l
CRANKSHAFT POSITION SENSOR
On-vehicle Inspection
..................
.
13-280-I
On-vehicle Inspection
............
.
13-73-l
On-vehicle Inspection
13-167-l
CROSSMEMBER....................................

.
32-8-l
CURB IDLE SPEED
Inspection
.......
.
.................... 13-245-l
Inspection
13-32-l
Inspection
....................
.
13-133-l
CYLINDER
Master
.........................................
.
35-81 -IPower
.........................................
.
378-9-I
Wheel,RearBrake...............................

. 35-111-l
Wheel, Rear, Maintenance .......................... 00-44-I
CYLINDER HEAD GASKET
DOHC
.......................................
.
11-73-l
SOHC.................: ......................... 11-25-l
D
DASH POT, Inspection and Adjustment
1 l-58-lDEFOGGER, Rear Window 64-156-11
DEFOGGER RELA
Y
.54-163-11DEFOGGER SWITCH, Rear Window. 54-163-11
DEFOGGER TIMER 54-164-11
DELAY VALVE, Check
35-74-l
DIAPHRAGM, Rolling, Check 33B-89-l
DIFFERENTIAL CARRIER
27-26-l
DISC
Brake, Front, Run-out Check
35-63-l
Brake, Front, Run-out Correction 35-64-l
Brake, Front.
Thichness Check 35-65-l
Brake, Rear, Run-out Check 35-66-l
Brake, Rear, Run-out Correction 35-66-l
Brake, Rear,
Thichness Chec
k
35-66-l

ALPHABETICAL INDEX5
Fuel, Maintenance.
.
Power Steering
Transaxle
011 Cooler
Vacuum
..,...,..,.......
Water >
Water
Water
HUB
End Play inspection
End Play, Inspection
Front Axl
e
Rear Axle

Rear Axle

>
HYDRAULIC UNIT
HYDRAULIC UNIT, Inspection
I 00-39-I
37A-58-I
23-l
00-l
17-4-I
14-26-I
14-28-l
14-23-l
338-86-I
26-5-l
26-l-l
27-8-l
27-6-1
35-121-l
35-70-t
IAC VALVE POSITION SENSOR, On-vehicle Inspection........................

.
13-162-l
IDLE AIR CONTROL MOTOR
DC Motor,
On-vehicle
Inspection
13-184-I
Stepper Motor, On-vehicle Inspection ....... 13-298-l
IDLE SPEED
Basic, Adjustment
.....................
.
13-245-l
Basic, Adjustment
...............
.
13-33-l
Basrc. Adjustment ...........

.
13-133-l
Curb, Inspection ................
...... 13-245-I
Curb, Inspection
..
.
...
...........
.
13-32-I
Curb, Inspection
.............
.
13-133-I
IDLE SPEED CONTROL MOTOR (DC Motor),
On-vehrcle Inspectron .............
.
13-93-l
IDLE SPEED CONTROL MOTOR POSITION SENSOR,On-vehicle Inspection ..............

.
13-64-I
IDLE-UP OPERATION, Check ....................... 55-24-l
IGNITION COIL
On-vehtcle
Inspection ................. 13-302-I
On-vehicle
Inspectron .........
.
13-96-l
On-vehicle
Inspection
.......
.
13-186-I
IGNITION POWER TRANSISTOR
On-vehrcle
Inspection ................ 13-302-I
On-vehicle Inspection
............. 13-96-l
On-vehicle
inspection .........
.
13-186-l
IGNITION SWITCH
Chassis Electrical.
...........................
.
.....
54-6-11
On-vehicle Inspection ..................
.
13-284-l
On-vehicle Inspection A/T>....
... 13-78-l
On-vehicle Inspection M/T>........ 13-77-l
On-vehicle Inspection A/T>....... 13-172-l
On-vehicle inspection GVALVE. M/T> ......
.
13-171 -IIGNITION SYSTEM...........................

.
16-32-11.....

.
IGNITION TIMING Adjustment ...........................
16-40-11
Adjustment 16-39-11.......
.
....................
INDICATOR...........................
.
.......... 33B-140-l
INDIVIDUAL PARTS, Auto-cruise Control, Inspection .......
13-401 -I
INFLATION PRESSURE, Tire, Check......................
.
31-4-l
INJECTORS
On-vehicle Inspection
..................
.
13-295-I
On-vehicle Inspection
...........
.
13-90-I
On-vehicle Inspection
........... 13-l
81-l
INSTRUMENT PANEL ................................. 52-22-l
INTAKE AIR TEMPERATURE SENSOR
Emission Control
..............................
.
17-21 -I
On-vehicle inspection
.................
.
13-263-l
On-vehicle Inspection
............
.
13-51-IOn-vehicle Inspection

INTAKE CHARGE PRESSURE CONTROL SYSTEM,Inspection . . . . . . . . . . . . . . .
INTAKE MANIFOLD
DOHC
,.. . . . . . . . . . . ,,... SOHC-WALVE
SOHC-l
GVALVE
K
KEY INTERLOCK MECHANISM, Check

.
KICKDOWN SERVO, Adjustment
KNOCK SENSOR, On-vehicle Inspection
KNUCKL
E
L
LASH ADJUSTERS
Check
>
Check
LATCHDoor, Fron
t
Door, Rear
LATERAL ROD
Active-EC
S
Rear Suspesion

LEAK, Refrrgerant. Repair Procedure
LEVELFluid, Transaxle, Inspection
Oil, Transfer, Inspection.
LEVERParking Brak
e
Parking Brake, Stroke Check
Selector, Operation Check.
Shift

Shift
LIDTrunk ._, . . . . . . . . . . . . .
Trunk, Adjustmen
t
LIGHT
......
......
......
.....
......
......
.....
......
......
......
......
......
......
......
......
......
......
......
......
......
.......
........
.......
........
........
........
........
........
........
........
........
........
........
........
........
........
........
Alarm, Chec

k
Rear Combination
Stop, High Mounted
LIGHTING SYSTEM
LINEBrake
Fuel
Fuel
Fuel
Fuel
Refrigerant
.
Vapor

Vapor
Vapor
Vapor
LINE PRESSURE, Adjustment
LININGBrake, Thickness Check.
Rear Drum Brake, Maintenance
LOOSE PANE
L
LOWER ARMActive-KS
Front Suspensio

n
Rear Suspesion

........
...............
.......
........
........
........
........
........
........
........
........
.........
.........
.........
.........
.........
........ 13-152-I
15-7-l
15-21 -I
15-14-I
15-18-I
23-83-1
23-86-i
13-287-l
26-6-l
11-57-1
1 l-7-l
42-96-l
42-99-l
338-l 17-l
34-14-I
’
55-21-I
23-82-l
23-82-l
36-4-l
36-2-l
23-83-l
22-19-l
22-9-l
42-57-l
42-50-I
338-87-I
54-95-11
54-96-11
54-38-11
35-87-I
13-326-I
13-324-I
13-113-I
13-I
95-l
55-54-l
13-326-I
13-324-l
13-I 13-l
13-195-1
23-88-l
35-67-l
00-44-I
42-62-i
338-l
03-l
33A-10-I
34-28-l

ALPHABETICAL INDEX
PLUGSpark, Maintenance. 00-40-I
Spark, Test..
16-42-11
POSITIVE CRANKCASE VENTILATION SYSTEM 17-13-l
POSITIVE CRANKCASE VENTILATION (PCV) VALVE,Inspection
17-14-I
POWER AMPLIFIER
54-151-11POWER CYLINDE
R
378-9-I
POWER GROUND
Engine Control Module, On-vehicle
Inspection
13-257-l
Engrne Control Module, On-vehicle Inspection..........

.
13-45-l
Engine Control Module, On-vehicle Inspection
....................
.
13-146-I
POWER RELAY
ABS. Check
................................
.
35-74-l
Air
Conditionrng and Ventrlation. Check ........
.
55-24-l
POWER STEERING, Stationary Steering Effort Check......

.
37A-18-l
POWER STEERING FLUID
Level Check
.................................
.
37A-21-l
Replacement .................................... 37A-21-I
POWER STEERING GEAR 80X....................

.
37A-32-l
POWER STEERING HOSES...........

.
........ 37A-58-l
POWER STEERING OIL PUMP......................

.
37A-48-l
POWER STEERING OIL PUMP, Pressure Test...........

.
37A-23-l
POWER STEERING PRESSURE SWITCH
Check
........................................
.
37A-24-l
On-vehicle Inspection ................ 13-284-l
On-vehicle Inspection
..........
.
13-81 -IOn-vehicle Inspection .........

.
13-175-l
POWER SUPPLY
On-vehicle Inspectron
.................
.
13-255-l
On-vehicle Inspection
............
.
13-42-I
On-vehrcle Inspection ..........

.
13-143-l
POWER TRANSISTOR
Ignition, On-vehicle Inspection
............
.
13-302-I
Ignition, On-vehicle Inspection
......
.
13-96-l
Ignition, On-vehicle Inspection
13-186-I
POWER WINDOW..................................

.
42-86-l
PRESSURECompression, Check
....................
.
11-59-i
Compression, Check ...................
1 l-8-lFuel, On-vehicle Inspection .............
.
13-312-I
Fuel, On-vehicle Inspection

.......
.
13-102-I
Fuel, On-vehicle Inspection
......
.
13-192-l
Inflation,Tire,
Check
............................ 31-4-I
Line, Adjustment .................................. 23-88-l
Reducing, Adjustment ........................
23-91 -IPRESSURE SWITCH
Brake Fluid
....
.
35-133-I
Brake Fluid, Check AWD-ABS: Up to 1991 Models> ..... 35-75-l
PROPELLER SHAFT.................................

.
25-4-l
PROPORTIONING VALVE, Function Test................

.
35-56-l
PUMP
Fuel, On-vehicle Inspection .............. 13-258-l
Fuel, On-vehicle Inspection
........
.
13-46-l
Fuel, On-vehicle Inspection
......
.
13-147-l
OiLRear
....................................... 37B-15-l
Water
................................ 14-20-I
Water ................................
14-I 5-1PURGE CONTROL SYSTEM
Inspection
.........................
.
17-17-I
Inspection .............................. 17-18-I
PURGE CONTROL VALVE .................... 17-20-I
PURGE PORT VACUUM............................

.
17-19-I
Q
QUARTER WINDOW GLASS......................
.
42-70-I
R
RADIATOR.........................................

.
14-9-lRADIATOR CAP, Pressure Test
.......................
.
14-8-lRADIATOR FAN MOTOR
............................
.
14-12-lRADIO AND TAPE PLAYER
..........................
.
54-149-11REAR AXLE
Maintenance
.............................
.
00-45-I
Total Backlash Check
....................
.
27-15-I
REAR AXLE HUB
FWD-Rear Disc Brakes
.............................
.
27-8-l
FWD-Rear Drum Brakes ........................... 27-6-l
REAR BRAKE DISC
Run-out Check.
.................................
.
35-66-l
Run-out Correction .............................. 35-66-l
Thickness Check ............................... 35-66-l
REAR BRAKE WHEEL CYLINDER......................

.
35-l 1 l-lREAR COMBINATION LIGHT
..........................
.
54-95-IREAR DISC BRAKE.................................

.
35-l 14-lREAR DISC BRAKE PAD, Check and Replacement
.........
. 35-65-l
REAR DOOR DRIP LINE WEATHERSTRIP.............

.
42-l 14-lREAR DOOR GLASS.........................

.
42-83-l
REAR DOOR HANDLE............................

.
42-99-l
REAR DOOR LATCH................................

.
42-99-l
REAR DOOR
MOULDING
........................42-l 14-l
REAR DOOR REGULATOR..........................
.
42-83-l
REAR DOOR TRIM................................

.
42-78-l
REAR DOOR WATERPROOF FILM......................

.
42-78-l
REAR DRUM BRAKE...............................

.
35-108-I
REAR DRUM BRAKE LININGS, Maintenance ............... 00-44-I
REAR HUB, Rotary-sliding Resistance (Torque)
Adjustment
................................
.
27-5-l
REAR OIL LINE..................................

.
378-13-I
REAR OIL PUMP
Discharge Flow Volume Check .................... 378-6-I
4WS
........................................... 378-15-I
REAR SEAT......................................

.
52-37-l
REAR SUSPENSION
Active-ECS
...................................
.
338-l 14-lAWD
..........................................
.
34-24-l
FWD..........................................

.
34-6-l
REAR WHEEL ALIGNMENT Inspection
.............................
.
34-23-l
Inspection
...............................
.
34-5-l
REAR WHEEL BEARING
End Play Check .........................

.
27-15-I
‘Rotation Sliding Resistance Check
..........
.
27-16-I
REAR WHEEL CYLINDERS, Maintenance, 00-44-I
REAR WINDOW
DEFFOGER..........................
.
54-156-11REAR WINDOW DEFOGGER SWITCH..................

.
54-163-11REAR WINDOW GLASS..............................

.
42-72-l
REDUCING PRESSURE, Adjustment. ..................... 23-91-l
REFRIGERANT, Leak Repair Procedure.................

.
55-21-l
REFRIGERANT LINE..................................
55-54-l
REGULATOR
Door, Front
.....................................
.
42-80-I
Door, Rear ....................................... 42-83-l
RELAY
A/C Compressor Clutch, On-vehicle Inspection..............................

.
13-83-lA/C Compressor Clutch, On-vehicle Inspection.............................
13-176-I

ALPHABETICAL INDEX
EGR , On-vehicle Inspection13-191 -IEPS. Chec

k
37A-19-I
Evaporative Emission Purge
17-21 -IEvaporative Emission Purge, On-vehicle Inspection 13-307-I
Evaporative Emission Purge, On-vehicle Inspection
13-99-l
Evaporative Emission Purge, On-vehicle Inspection
13-189-l
Fuel Pressure , On-vehicle Inspection
>
13-307-I
Turbocharger Waste Gate, Inspectron
15-8-l
Turbocharger Waste Gate, On-vehicle Inspection 13-309-I
00-40-I
16-42-11
16-42-11
54-151-I
35-126-l
35-69-l
23-93-l
22-19-l
22-5-l
SPARK PLUG
Maintenanc
e
........
Test .........................
SPARK PLUG CABLE, Test........
.
SPEAKER.......................

.
SPEED SENSOR
Wheel.,..........

.
Wheel, Output Voltage Measurement
SPEEDOMETER CABLE
Replacement ..........
.
Replacement
.....
.
Replacement
...
.
STABILIZER BAR
Active-ECS
.........
.
Front
Suspensron...........
.
Rear Suspension
.....
.
STARTER MOTOR..................

.
STARTING SYSTEM................

.
STEERING GEAR BOX, Power.........

.
STEERING LINKAGE SEALS, Maintenance
STEERING SHAFT.................
.
STEERING WHEEL..............

.
STEERING WHEEL
AngleCheck.....................

. 37A-15-l
Centering ...................... 37A-16-l
Free Play Check. ............... 37A-15-l
Return to Center Check ............. 37A-19-l
STOP LIGHT, High Mounted ...........
54-96-l
I
STOPPER, Roll. Engine
................
. 32-6-i
STRUT
Active-ECS
338-97-I
.......
Front Suspension. ........................... 33A-6-l
...
SUNROOFBody
..........................
.
.......... 42-116-l
Fit Adjustment ................................ 42-53-l
SUPERCHARGING PRESSURE, Turbocharger, Inspection.....

.
15-7-l
SUSPENSIONRear .....................

.
33B-114-l
Rear.................................

.
34-24-l
Rear................................

.
34-6-i
SWITCHAccelerator, Inspection and Adjustment
..............
.
13-329-l
Air Conditioning ................. 17-21-l33B-106-l
33A-13-l
34-37-l
16-19-1116-14-I
37A-32-l
00-45-I
37A-25-1
37A-25-I
Air Conditioning 55-29-l
Air Conditioning, On-vehicle Inspection 13-285-l
Air Conditioning, On-vehicle Inspection
13-83-l
Air Conditioning, On-vehicle Inspection
13-176-l
Brake Fluid Pressure
35-l 33-1
Brake Fluid Pressure, Check 35-75-l
Closed Throttle Position, Adjustment
13-250-l
Closed Throttle Position, Adjustment
13-136-l
Closed Throttle Position, On-vehicle Inspection 13-274-l
Closed Throttle Position, On-vehicle Inspection

13-61-l
Closed Throttle Position, On-vehicle Inspection
13-160-I
Column
.54-100-11Engine Coolant Temperature 14-31-l
Engine Coolant Temperature
FogLight...
Hazar
d
., .._.
High-Pressure (High-Pressure Tank Side),Actuation Pressure Chec

k
Ignrtion, Chasscs Electrical
Ignition, On-vehicle Inspection
Ignition, On-vehicle Inspection
Ignition, On-vehicle Inspection A/T> 55-57-l
54-99-11
54-98-11
33B-94-l
54-6-11
13-284-i
13-284-l
13-78-l
Ignitron. On-vehicle Inspection
M/T> 13-77-1
Ignition, On-vehicle
Inspection
>
: 13-I 72-l
Ignition. On-vehicle Inspection
M/T> 13-171-l
Ignition. Power Supply, On-vehicle Inspection 13-255-l
Low-Pressure (Low-Pressure Tank Side),
Actuation Pressure Check
Parking
Brake. Check.
.
Park/Neutral
Posrtion, Adjustment
Park/Neutral
Posrtion, On-vehicle Inspection
>
Park/Neutral Position, On-vehicle Inspection A/T> 338-95-I
36-3-l
23-84-l
13-284-I
13-78-l
Park/Neutral Position, On-vehicle Inspection
_. 13-172-l
Power Steering Pressure, Check, Steering 37A-24-l
Power Steering Pressure, On-vehicle Inspection 13-284-l
Power Steering Pressure, On-vehicle Inspection
Power Steering Pressure, On-vehicle Inspection
Rear Window Defogge
r
Remote Controlled Mirror 13-81-l
13-175-l
54-163-11
51-34-l
T
TANK
Fuel ..........................

.
13-322-l
Fuel
............................
.
13-318-I
Reserve ....................................... 338-122-I
TENSIONDrive Belt Adjustment
>
11-61-1
Drive Belt Adjustment
11-12-I
Timing Belt Adjustment 11-10-I
TERMINAL VOLTAGE
Engine Control Module, On-vehicle Inspection
>
.................. 13-315-l
.. ....... ..........
Engine Control Module, On-vehicle Inspection
.................
.
13-l 05-i..
.........
.
Engine Control Module, On-vehicle Inspection

TEST PROCEDURE
S
THEFT ALARM SYSTEM THERMAL VACUUM VALVE 13-192-l
55-13-l
54-165-11
17-27-l

10ALPHABETICAL INDEX
THERMOSTAT
.............................
.
14-13-I
THICKNESS
Brake Lining, Check
............................
. 35-67-l
Front Brake Disc, Check.......................

. 35-65-l
Rear Brake Disc, Check........................

. 35-66-l
THROTTLE BODY (THROTTLE VALVE AREA)Cleaning
.........................
.
13-248-l
Cleaning
....................
.
13-35-I
Cleaning
....................
.
13-136-l
THROTTLE POSITION SENSOR
Adjustment
..........................
.
23-92-l
Adjustment ........................ 13-248-l
Adjustment
.....................
.
13-35-l
Adjustment
.................
.
13-136-1On-vehicle Inspection
..................
.
13-270-I
On-vehicle
Inspectron ............
.
13-57-l
On-vehicle Inspection
..........
.
13-157-l
TIE ROD END BALL JOINT
Startrng Torque Check.
.......................
. 37A-15-l
Variation Check .............................. 37A-15-l
TIMER. Defogger ..................................
54-164-11TIMING lgnition,Ad)ustment

......................
16-40-11Ignition, Adjustment .....................
.
16-39-11TIMING BELT
DOH

C
............................... 11-80-I
Maintenance ................................... 00-40-l
SOHC. .............. ............... 11-34-I
Tension Adjustment .................... 11-10-I
TIRE ...
..........
...........................
31-5-lTIRE, Wear Check ........
.
........................ 31-4-I
TIRE INFLATION PRESSURE, Check...................31-4-1TORSION ARM
Active-ECS
................................
.
338-l 19-lRear Suspension ........................

.
34-15-1
TORSION AXLE
Active-ECS
...................................
.
338-l 19-l
Rear Suspensron .......................

.
34-15-1
TORSION BAR, Trunk Lid, Adjustment
..................
. 42-51-f
TOTAL BACKLASH. Rear Axle.
Check ...........
.
27-15-I
TRAILING ARM
.........................
.
34-31 -ITRANSAXLE
Automatic ..........................

. 23-105-I
Automatic
.......................
.
23-101-I
Automatic. Maintenance .........................
00-43-1Manual Manual......... 22-20-I..I:.::: :::::.:::I::, 1:. 22-10-1
Manual. Maintenance
.......................
.
go-42-i
TRANSAXLE CONTROL
A/T
.......................................... 23-94-i
MIT ..................................
22-19-f
MIT .................................
.
22-6-l
TRANSAXLE FLUID
Level
hSp?CtiOn
.................................
23-82-lReplacement ...................................
.
23-82-f
TRANSAXLE MOUNTING..............................

. 32-5-t
TRANSAXLE OIL
Replacement 22-18-1OIL, Replacement ........................: :............
TRANSAXLE OIL COOLER HOSES............

.
: : : :
..........
23212;;:;
TRANSAXLE OIL LEVEL
Inspection .............................

. 22-17-l
Inspection
...............................
. 22-4-l
TRANSFER
A/

T
....................................... 23-108-IM/T-AWD
....................................... 22-23-l
TRANSFER OIL, Replacement .......................... 23-82-l
TRANSFER OIL Level Inspection ........................ 23-82-l
TRANSFER OIL SEAL, Replacement
............
.
22-19-l
TRANSISTOR, Ignition Power, On-vehicle Inspection ........................................ 13-302-I
TRIM
Door, Front ...................................... 42-76-l
Door, Rear.....................................

.
42-78-l
Interior ......................................... 52-33-l
TRUNK LID......................................

.
42-57-l
TRUNK LID, Adjustment .............................. 42-50-I
TRUNK LID TORSION BAR, Adjustment ................... 42-51-I
TUBE, air.......................................

.
338-133-I
TUBING, Handling ................................... 55-22-l
TURBOCHARGER...................................
15-24-l
TURBOCHARGER BYPASS VALVE,
Inspection.
..............15-8-ITURBOCHARGER SUPERCHARGING PRESSURE, Inspection 15-7-l
TURBOCHARGER WASTE GATE SOLENOID
Inspection
.......................................
.
15-8-l
On-vehicle Inspection .............. 13-309-t
U
UPPER ARM
34-28-l
v
VACUUM
EGR Valve Control ...............................
. 17-26-l
Manifold Inspection ..................... 11-60-I
Manifold Inspection .......................
1 l-9-l
Purge Port ...................................... 17-19-l
VACUUM HOSES ................................... 17-4-l
VACUUM HOSES, Routing .............................. 17-4-I
VALVE
Bypass, Turbocharger, Inspection ...................... 15-8-l
Check, Operation Check ........................... 35-54-l
Control ......................................... 378-12-I
Delay, Check
.......................
.
35-74-l
EGR...........................................

.
17-27-l
Fuel Tank Pressure control ..........................
17-21-1Positive Crankcase Ventilation (PCV). Inspection........
. 17-14-l
Proportioning, Function Test ......................... 35-56-l
Purge Control ........................... 17-20-I
Thermal Vacuum ...................... 17-27-I
VAPOR LINE
DOHC-AWD .................................... 13-326-I
DOHC-FWD....................................

. 13-324-l
SOHC-8VALVE
..................................
13-I 13-l SOHC-16VALVE
................................. 13-195-I
V-BELT, Tension Check ............................... 37A-21-l
VEHICLE HEIGHT, Normal, Check and Adjustment ......... 33B-88-l
VEHICLE SPEED SENSOR
On-vehicle Inspection
..................
. 13-284-l
On-vehicle Inspection
13-80-I
On-vehicle Inspection
..........
.
13-173-l
VENTILATION SYSTEM
Crankcase, Inspection .............................. 17-14-I
Positive Crankcase ................................ 17-13-I
VENTILATORS
Air Inlet and Air Outlet
.............................
. 55-56-l
Instrument Panel and Floor .......................... 55-55-l
VOLUME AIR FLOW SENSOR
Emission Control .................................. 17-21-I