1989 MITSUBISHI GALANT wheel alignment

34-24’ REAR SUSPENSION - Rear Suspension Assembly
REAR SUSPENSION ASSEMBLY
REMOVAL AND INSTALLATIONM24GA.B
9-14 N
m
7- 10 ftlbs.
7-11
ft.lbs.
IO-15 Nm /7-l 1 ft.lbs.
Removal steps
1. Shock absorber
installation nut2.
Brake tube bracket
installation boltl +3. Parking
brake
cable
end4*4.
Caliper
assembly5. Center exhaust pipe6.
Gasket7.
Gasket** I)+8.
Propeller
shaft installation
bolt and nut
lo-15 N
m
7- 11 ft.lbs.
-30-40 N
m
22-29
ftlbs.
12AO514
Post-installation Operation*Check of Wheel Alignment(Refer to P.34-23.)aCheck of Parking Brake Lever Stroke(Refer to GROUP 36-Service
Adjust-ment Procedures.) *Installation
of Trunk Room Trim(Refer to GROUP 52-Trims.)
TSB RevisionI

REAR SUSPENSION - Trailing Arm34-31
TRAILING ARM
REMOVAL AND INSTALLATION
160-220 Nm116-15y
ft.lbs.
9-14 Nm
7-10 ftlbs.
50-60 Nm
36-43 ft.lbs.
\
55-65 N

m
40-47 ft Ibs\ . .\~- -
140-160 Nm*101-116 ft.lbs.*
Connecting rod// I
Yli0
60-7i Nm
43-52 ft.lbs.
90-110 Nm65-80 ftlbs.
Removal steps
1. Parking cable end
4*2. Rear brake assembly
3. Rear brake disc
4. Drive shaft and companion flange
installation bolt, nut
4I) l +5. Self locking nut
l + 6. Companion flange 7. Rear speed sensor installation bolt ABS8. O-ring+e l +9. Rear axle shaft10. Dust shield
::11. Self locking nut (upper arm)
12. Self locking nut (lower arm)
13. Parking brake cable and rear speed sensor
installation bolt
14. Trailing arm installation bolt, nut
15. Rear shock absorber installation bolt
16. Trailing arm
12AO621
Post-installation Operationl Zheck of Wheel Alignment(Refer to P.3423.)l Check of Parking Brake Lever Stroke(Refer to GROUP 36-Service
Adjust-ment Procedures.)@Rear Brake Disc Run-out Check(Refer to GROUP 35Service Adjust-ment Procedures.)
NOTE*:Indicates parts which should
first
be temporarily tight-ened, then fully
tightened with
the vehicle on the ground with
no load (cerb weight).
TSB Revision I

ALPHABETICAL INDEX1
A
ABS
Checking by the ABS Warnrng Light................
. 35-68-l
Troubleshooting ...........................
35-l 5-l
ABS POWER RELAY, Chec
k 35-74-l
ACCELERATOR CABLE
Inspection and Adjustment
13-398-l
Inspection and Adjustment ........ 13-329-l
ACCELERATOR SWITCH, Inspection and Adjustment 13-329-I
A/C COMPRESSOR CLUTCH RELAY
On-vehicle Inspection
.............
. 13-285-l
On-vehrcle
Inspection
.........
. 13-83-t
On-vehicle Inspection
......
. 13-176-l
ACTIVE-ECS ON-BOARD DIAGNOSTIC, Check......

. 338-88-I
ACTIVE-ECS RELAY.......................

. 338-141
-I
ACTIVE-ECS SENSOR....

.
...... ............ 338-138-I
ACTIVE-ECS SYSTEM
Checking by Using Alarm Light
.................
. 338-87-I
Operation Check ........................... 338-90-I
AERO PARTS..

.
........................... 51-18-l
AIR CLEANER...............................

. 15-9-I
AIR CLEANER ELEMENT
Inspection and Replacement
....................
. 15-6-l
Maintenance .......................... 00-39-l
AIR COMPRESSOR..........................

. 338-125-I
AIR CONDITIONING SWITCH
Emission control
...........................
.
17-21 -I
Heater, Air
Conditionrng
and Ventilation .............. 55-29-l
On-vehicle Inspection ................. 13-285-l
On-vehicle Inspection
...........
. 13-83-l
On-vehicle Inspection

..........
. 13-176-l
AIR TUBE..............

.
....................... 338-133-I
ALARM LIGHT, Check. ......................... 338-87-I
ALARM SYSTEM, Theft ..........................
54-165-11
ALIGNMENT
Front Wheel, Adjustment .......................
. 33A-5-l
Rear
Wheel, inspection ..................
. 34-23-l
Rear Wheel, Inspection
....................
. 34-5-l
ANTENNA ......................................
54-153-11
ANTI-LOCK BRAKING SYSTEM, Troubleshooting .........
.
35-15-1
ARM
Lower
......................
. 338-103-I
Lower Suspension>......................
.
33A-10-I
Lower
................... 34-28-l
Torsion
................
.
338-l 19-l
Torsion Suspension-FWD>
...................34-l 5-lTrailing
................. 34-31-l
Upper
.................. 34-28-l
AUDIO
SYSTEM................

.
.................
54-l 12-11
AUTO-CRUISE CONTROL. ..........................
. 13-408-I
AUTO-CRUISE CONTROL INDIVIDUAL PARTS, inspection..

. 13-401-I
AUTO-CRUISE CONTROL SYSTEM...................

. 13-332-l
AUTO-CRUISE CONTROL SYSTEM, Inspection..........

. 13-397-l
AUTOMATIC TRANSAXLE, Maintenance ................. 00-43-I
AXLE
Rear, Maintenance
...............................
. 00-45-I
Torsion
........................
.
338-l 19-l
Torsion .....

.
......................... 34-15-l
AXLE HUB
Rear
Disc Brakes> ...................... 27-8-l
Rear CFWD-Rear
Drum Brakes> ................... 27-6-l
AXLE SHAFT ..............................

.
27-17-1
B
BACKLASH. Total, Rear Axle, Check ............
. 27-15-l
BALL JOINT
Rotation Starting Torque Check ...................... 378-8-I
Tie Rod End, Staning Torque Check .................. 37A-15-l
Tie Rod End, Variation Check ....................... 37A-15-l
BALL JOINT SEALS, Maintenance ..................... 00-45-I
BAR
Stabilizer ....................

. 338-106-I
Stabilizer
...................
. 33A-13-l
Stabilizer Suspension-AWD>...............
. 34-37-l
BAROMETRIC PRESSURE SENSOR
On-vehicle Inspection
................
. 13-266-l
On-vehicle Inspection
13-53-l
On-vehicle Inspection
..........
. 13-154-l
BASIC IDLE SPEED
Adjustment
...........................
. 13-245-l
Adjustment
..................... 13-33-l
Adjustment
...................
. 13-133-l
BATTERY.........................................

.
54-2-11
BATTERY, Flat Remedy.
.............................
. 35-75-l
BEARING
Wheel, Adjustment ................

. 338-87-I
Wheel, Adjustment ............. 33A-5-l
BELT
Drive, Compressor, Adjustment
....................
. 55-17-l
Drive (For Water Pump and Generator), Maintenance ..... 00-41-I
Drive, Tension Adjustment ................. 11-61-I
Drive, Tension Adjustment ................. 11-12-l
Seat..........................................

. 52-39-l
Timing ...................... ......... 11-80-I
Timing................................

. 11-34-l
Timing, Maintenance ............................... 00-40-I
Timing, Tension Adjustment ................ 11-10-I
BLEEDING
Clutch
..........................................
. 21-6-l
4ws...........................................

. 370-4-I
Service Brakes. .................................. 35-57-l
Steering ........................................ 37A-22-l
BLOWER..........................................

. 55-32-l
BOOSTER
Brake
.........................................
. 35-85-l
Brake, Operating Inspection ......................... 35-54-l
BOOST METER, On-vehicle Inspection ... 13-311-l
BOOTS, Drive Shaft, Maintenance ....................... 00-45-I
BRAKE
Disc, Front
......................................
. 35-94-l
Disc, Rear.....................................

.
35-l 14-l
BRAKE BOOSTER
...................................
. 35-85-l
BRAKE BOOSTER, Operating Inspection .................. 35-54-l
BRAKE DISC
Front, Run-out Check.
.............................
. 35-63-l
Front, Run-out Correction ........................... 35-64-l
Front, Thickness Check ............................. 35-65-l
Rear, Run-out Check ............................... 35-66-l
Rear, Run-out Correction. ........................... 35-66-l
Rear, Thickness Check............................

. 35-66-l
BRAKE DRUM, tnside
Diameter, Check ................... 35-67-l
BRAKE FLUID LEVEL SENSOR, Check...................

. 35-54-l
BRAKE FLUID PRESSURE SWITCH
AWD-ABS (Up to 1991 Models)
....................
.
35-133-l
AWD-ABS
(Up to 1991 models), Check ...............
. 35-75-l
BRAKE HOSES, Maintenance ........................... 06-45-t
BRAKELINE
........................................
35-87-l

4ALPHABETICAL INDEX
DOHC-Turbo.................................
. 15-31-f
SOHC-8VALVE..................................

.
15-27-t
SOHC-1 GVALVE............................

.
15-28-l
EXHAUST PIPEDOH

C
......................... 15-33-I
SOHC.....................................

.
15-32-l
EXHAUST SYSTEM, Maintenance ..................... 00-45-I
F
FAN MOTOR
Condenser
.............................
.
55-48-l
Radiator...................

.
......... 14-12-I
FEEDER CABLE ..........................
54-l 55-11FENDER................................
.
42-61-t
FILLER DOOR, Fuel Tank.........................

.
42-60-I
FILLER TUBE CAP, Fuel Tank, Inspection...............

.
17-21 -I
FILTER
Engine 011. Maintenance ....................
. 00-41-I
Fuel ........................... 13-327-l
Fuel
....
.
...................
13-I 15-lFuel ........................
.
13-195
FITTINGS, Handling................................
. 55-22-l
FIXED SAS
Adjustment
........................
.
13-250-I
Adjustment
...................
.
13-138-I
FLAT BATTERY, Remedy............................

.
35-75-l
FLOOR CONSOLE................................

.
52-29-l
FLUID
Power Steering, Level Check
...................
. 37A-21-l
Power Steering, Replacement ................. 37A-21-l
Transaxle, Replacement ..................... 23-82-l
FLUID LEVEL, Transaxle, Inspection .................. 23-82-l
FOG LIGHT................

.
......................
54-94-11FOG LIGHT SWITCH................................
.
54-99-114WS, Function Check
..........................
. 37B-6-l
FRONT BRAKE DISC
Run-out Check
...................................
. 35-63-I
Run-out Correction ........................... 35-64-l
Thickness Check .............................. 35-65-l
FRONT DISC BRAKE.................................

. 35-94-l
FRONT DISC BRAKE PAD, Check and Replacement ......... 35-59-l
FRONT DOOR DRIP LINE WEATHERSTRIP 42-112-I
FRONT DOOR GLASS...............................

. 42-80-l
FRONT DOOR HANDLE.........................

. 42-96-l
FRONT DOOR LATCH...

.
......... .......... 42-96-l
FRONT DOOR
MOULDING
........................... 42-112-I
FRONT DOOR REGULATOR........................

. 42-80-I
FRONT DOOR TRIM.................................

. 42-76-l
FRONT DOOR WATERPROOF FILM....................

. 42-76-l
FRONT GRILLE..................................

. 51-12-l
FRONT SEAT,...................................

. 52-35-l
FRONT WHEEL ALIGNMENT Adjustment
.....................
. 338-86-I
Adjustment .................... 33A-5-l
FUEL FILTER
DOHC
.......................................
. 13-327-I
SOHC-8VALVE
.................................
13-l 15-l SOHC-IGVALVE
................................ 13-195-I
FUEL HOSES, Maintenance ............................
00-39-1
FUEL LINE
DOHC-AWD ..................................
.
13-326-l
DOHC-FWD....................................

.
13-324-l
SOHC-8VALVE
................................. 13-113-l
SOHC-1 ~VALVE............................

.
13-l 95-IFUEL PRESSURE
On-vehicle Inspection
On-vehicle Inspection

On-vehicle Inspection
FUEL PRESSURE SOLENOID ,
On-vehicle Inspection >
FUEL PUMP
On-vehicle Inspection
On-vehicle Inspection

On-vehicle Inspection
FUEL SYSTEM, Maintenanc

e
FUEL TANK
DOHC-AWD .,.......
DOHC-FW

D
SOHC-8VALVE
SOHC-16VALVE
FUEL TANK FILLER DOO

R
FUEL TANK FILLER TUBE CAP, Inspection
FUEL TANK PRESSURE CONTROL VALVE. 13-312-l
13-102-I
,.....13-I
92-l
13-307-I
......
13-258-l
....... 13-46-l
...... 13-147-l
....... 00-39-l
......
13-322-l
...... 13-318-l
..... 13-109-I
...... 13-195-I
....... 42-60-I
....... 17-21-I
....... 17-21-l
G
GARNISHES
51-13-l
GASKET
Cylinder Head 1 l-73-l
Cylinder Head 1 l-25-l
GAUGE UNIT, Engine Coolant Temperature
14-31-l
GEAR BOX, Power Steering 37A-32-l
GEAR OIL, Level Check
27-15-l
GENERATOR
16-g-11
GLASS
Door, Adjustmen
t
42-52-l
Door, Front 42-80-I
Door, Rear 42-83-l
Quarter Window 42-70-I
Window.............
.._......_...... 42-63-i
Window,Rear
42-72-i
GRILLE,Front
_. _. _.
51-12-l
G-SENSOR
Service Brakes
35-132-l
Output Voltage, Check 336-96-l
H
HANDLE
Door, Front
..........................
.
Door,Rear
...........................
Door Inside, Play Check. ..................
HAZARD SWITCH.........................
.
HEADLIGHTS............................

.
HEADLINING.............................

.
HEATED OXYGEN SENSOR, On-vehicle Inspection
>
...............................
HEATER CONTROL.......................
.
HEATER UNIT............................

.
HEIGHT SENSOR.........................

.
HIGH MOUNTED STOP LIGHT...............

.
42-96-1 42-99-l
42-52-l
54-98-11
54-92-11
52-31-l
13-290-I
55-25-l
55-30-I
338-l
35-l
54-96-11HIGH PRESSURE SWITCH (HIGH-PRESSURE TANK SIDE),Actuation Pressure Check. 338-94-I
16-42-11
42-55-l
42-50-I
54-l 03-11
54-105-11
HIGH TENSION CABLE, Spark Test
HOOD .__...._..._......__._...................
HOOD, Alignment Adjustment .
HOR

N
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . HORNRELAY

._.._._....___.........__.._._..___
HOSE
Brake, Maintenance
.
00-45-I

ALPHABETICAL INDEX
PLUGSpark, Maintenance. 00-40-I
Spark, Test..
16-42-11
POSITIVE CRANKCASE VENTILATION SYSTEM 17-13-l
POSITIVE CRANKCASE VENTILATION (PCV) VALVE,Inspection
17-14-I
POWER AMPLIFIER
54-151-11POWER CYLINDE
R
378-9-I
POWER GROUND
Engine Control Module, On-vehicle
Inspection
13-257-l
Engrne Control Module, On-vehicle Inspection..........

.
13-45-l
Engine Control Module, On-vehicle Inspection
....................
.
13-146-I
POWER RELAY
ABS. Check
................................
.
35-74-l
Air
Conditionrng and Ventrlation. Check ........
.
55-24-l
POWER STEERING, Stationary Steering Effort Check......

.
37A-18-l
POWER STEERING FLUID
Level Check
.................................
.
37A-21-l
Replacement .................................... 37A-21-I
POWER STEERING GEAR 80X....................

.
37A-32-l
POWER STEERING HOSES...........

.
........ 37A-58-l
POWER STEERING OIL PUMP......................

.
37A-48-l
POWER STEERING OIL PUMP, Pressure Test...........

.
37A-23-l
POWER STEERING PRESSURE SWITCH
Check
........................................
.
37A-24-l
On-vehicle Inspection ................ 13-284-l
On-vehicle Inspection
..........
.
13-81 -IOn-vehicle Inspection .........

.
13-175-l
POWER SUPPLY
On-vehicle Inspectron
.................
.
13-255-l
On-vehicle Inspection
............
.
13-42-I
On-vehrcle Inspection ..........

.
13-143-l
POWER TRANSISTOR
Ignition, On-vehicle Inspection
............
.
13-302-I
Ignition, On-vehicle Inspection
......
.
13-96-l
Ignition, On-vehicle Inspection
13-186-I
POWER WINDOW..................................

.
42-86-l
PRESSURECompression, Check
....................
.
11-59-i
Compression, Check ...................
1 l-8-lFuel, On-vehicle Inspection .............
.
13-312-I
Fuel, On-vehicle Inspection

.......
.
13-102-I
Fuel, On-vehicle Inspection
......
.
13-192-l
Inflation,Tire,
Check
............................ 31-4-I
Line, Adjustment .................................. 23-88-l
Reducing, Adjustment ........................
23-91 -IPRESSURE SWITCH
Brake Fluid
....
.
35-133-I
Brake Fluid, Check AWD-ABS: Up to 1991 Models> ..... 35-75-l
PROPELLER SHAFT.................................

.
25-4-l
PROPORTIONING VALVE, Function Test................

.
35-56-l
PUMP
Fuel, On-vehicle Inspection .............. 13-258-l
Fuel, On-vehicle Inspection
........
.
13-46-l
Fuel, On-vehicle Inspection
......
.
13-147-l
OiLRear
....................................... 37B-15-l
Water
................................ 14-20-I
Water ................................
14-I 5-1PURGE CONTROL SYSTEM
Inspection
.........................
.
17-17-I
Inspection .............................. 17-18-I
PURGE CONTROL VALVE .................... 17-20-I
PURGE PORT VACUUM............................

.
17-19-I
Q
QUARTER WINDOW GLASS......................
.
42-70-I
R
RADIATOR.........................................

.
14-9-lRADIATOR CAP, Pressure Test
.......................
.
14-8-lRADIATOR FAN MOTOR
............................
.
14-12-lRADIO AND TAPE PLAYER
..........................
.
54-149-11REAR AXLE
Maintenance
.............................
.
00-45-I
Total Backlash Check
....................
.
27-15-I
REAR AXLE HUB
FWD-Rear Disc Brakes
.............................
.
27-8-l
FWD-Rear Drum Brakes ........................... 27-6-l
REAR BRAKE DISC
Run-out Check.
.................................
.
35-66-l
Run-out Correction .............................. 35-66-l
Thickness Check ............................... 35-66-l
REAR BRAKE WHEEL CYLINDER......................

.
35-l 1 l-lREAR COMBINATION LIGHT
..........................
.
54-95-IREAR DISC BRAKE.................................

.
35-l 14-lREAR DISC BRAKE PAD, Check and Replacement
.........
. 35-65-l
REAR DOOR DRIP LINE WEATHERSTRIP.............

.
42-l 14-lREAR DOOR GLASS.........................

.
42-83-l
REAR DOOR HANDLE............................

.
42-99-l
REAR DOOR LATCH................................

.
42-99-l
REAR DOOR
MOULDING
........................42-l 14-l
REAR DOOR REGULATOR..........................
.
42-83-l
REAR DOOR TRIM................................

.
42-78-l
REAR DOOR WATERPROOF FILM......................

.
42-78-l
REAR DRUM BRAKE...............................

.
35-108-I
REAR DRUM BRAKE LININGS, Maintenance ............... 00-44-I
REAR HUB, Rotary-sliding Resistance (Torque)
Adjustment
................................
.
27-5-l
REAR OIL LINE..................................

.
378-13-I
REAR OIL PUMP
Discharge Flow Volume Check .................... 378-6-I
4WS
........................................... 378-15-I
REAR SEAT......................................

.
52-37-l
REAR SUSPENSION
Active-ECS
...................................
.
338-l 14-lAWD
..........................................
.
34-24-l
FWD..........................................

.
34-6-l
REAR WHEEL ALIGNMENT Inspection
.............................
.
34-23-l
Inspection
...............................
.
34-5-l
REAR WHEEL BEARING
End Play Check .........................

.
27-15-I
‘Rotation Sliding Resistance Check
..........
.
27-16-I
REAR WHEEL CYLINDERS, Maintenance, 00-44-I
REAR WINDOW
DEFFOGER..........................
.
54-156-11REAR WINDOW DEFOGGER SWITCH..................

.
54-163-11REAR WINDOW GLASS..............................

.
42-72-l
REDUCING PRESSURE, Adjustment. ..................... 23-91-l
REFRIGERANT, Leak Repair Procedure.................

.
55-21-l
REFRIGERANT LINE..................................
55-54-l
REGULATOR
Door, Front
.....................................
.
42-80-I
Door, Rear ....................................... 42-83-l
RELAY
A/C Compressor Clutch, On-vehicle Inspection..............................

.
13-83-lA/C Compressor Clutch, On-vehicle Inspection.............................
13-176-I

ALPHABETICAL INDEX
11
On-vehicle Inspection 13-261 -IOn-vehicle Inspection 13-49-l
On-vehicle Inspection
13-150-I
W
WASHER, Windshreld.........................

.
51-20-I
WATER HOSE
DOHC (Non-Turbo)
............
.
....... 14-26-l
DOHC (Turbo)....................

.
14-28-l
SOHC................

.
......... 14-23-l
WATER PIPE
DOHC (Non-Turbo)
......
.
14-26-l
DOHC (Turbo)............................

.
14-28-I
SOHC........

.
... ....... 14-23-l
WATERPROOF FILM
Door, Front
................................
.
42-76-l
Door, Rear................

.
... 42-78-l
WATER PUMP
DOHC
..........
.
................... 14-20-I
SOHC. ................................... 14-15-l
WATERTEST..................................

.
42-52-l
WEAR, Tire, Check..........................

.
31-4-l
WEATHERSTRIP
Front Door Drip Line
........................
.
42-l
12-l
Rear Door Drip Line. .......................... 42-114-l
WHEEL ................................... 31-5-l
WHEEL
RunoutCheck
.................................... 31-4-l
Steering ................................... 37A-25-l
WHEEL ALIGNMENT
Front, Adjustment .............

.
338-86-I
Front, Adjustment .............. 33A-5-l
Rear, Inspection
........................
.
34-23-l
Rear, Inspection
....................
.
34-5-I
WHEEL BEARING
Adjustment .....................

.
338-87-I
Adjustment .......... 33A-5-l
End Play Adjustment
....................
.
27-3-l
WHEEL CYLINDER
Rear Brake
....
.
............................... 35-111-l
Rear, Maintenance ............................. 00-44-I
WHEEL SPEED SENSOR
ABS
........................................
.
35-126-l
Output Voltage Check .......................... 35-68-i
Output Voltage Measurement .................. 35-69-l
WINDOW, Power ............................... 42-86-l
WINDOW GLASS..............

.
............. 42-63-i
WINDOW GLASS
Quarter
................................... 42-70-I
Rear........................................

.
42-72-l
WINDSHIELD...................................

. 42-66-l
WINDSHIELD WASHER...........................

.
51-20-I
WINDSHIELD WIPER...........................

. 51-20-I
RJAK206014-1602
I-,