1989 MITSUBISHI GALANT kickdown

AUTOMATIC TRANSAXLE - Service Adjustment Procedures
1_DTZii+!ilz$F~
I
\
B
-g----J a
----- .f-
iL (i
&Fgi
Tit\I;; ;gTjqy ?“,,,,,,
FWD . . . Up to MODEL 1990IOil pan gasketsurface
case0
1750435
7. Remove the valve body assembly. The manual valve can
come out, so be careful not to drop it.
8.Turn the adjustment screw of the regulator valve and adjust
so that the line pressure (kickdown brake pressure)
becomes the standard value.
When the adjustment screw is turned to the clockwise, the
line pressure becomes lower; when it is turned to
counter-clockwise, it becomes higher.
Standard value: 870-890 kPa (124-127 psi)
Oil pressure change for each turn of adjustment screw: 38
kPa (94 psi)
9. Check to be sure that the O-ring is installed on the upper
surface of the valve body at the place shown in the figure.
10. Replace the O-ring of the solenoid valve connector with a new one.
11. Install the valve body assembly to the case and then insert
the solenoid valve connector into the case. Be sure, at this
time, that the notched part of the connector faces as
shown in the figure.
Also be careful that the lead wiring isn’t caught.
TSB Revision
12. Replace the O-ring of the solenoid valve harness with a new one.
13. Tilt the solenoid valve harness over from the inner side of
the transaxle case to the harness grommet installation hole’
and install the harness grommet securely.
14. Install the harness grommet so that the lead wiring of the solenoid valve harness faces in the direction indicated by
the arrow in the illustration. (FWD . . . From MODEL
1990.5)

AUTOMATIC TRANSAXLE - Transaxle Assembly
TRANSAXLE ASSEMBLY
REMOVAL AND INSTALLATION
23-101
mz3u-
Pre-removal and Post-installation Op-eration@Draining and Supplying of the TransaxleFluid(Refer to GROUP 00-Maintenance Ser-vice.)*Removal and Installation of the Batteryand Battery TrayofRemoval and Installation of the Air Clean-
fRrefer to GROUP 15-Air
Cleaner.)*Removal and Installation of the Air Com-pressor(Vehicles with ACTIVE-ECS)(Refer to GROUP 33B-Air Compressor.)
cl989 models>27-34 Nm20-25ft.lbs.I360-80Nm43-58ft.lbS.60-80Nm43-58ft.lbs.
43-55 Nm
IO-12 Nm7.2-8.7 ft.lbs.
27-34 Nm20-25 ft.lbs.
30-35 km
b22-25 ft.lbs.
Iii ’30-35 Nm
22-25 ft.lbs.
ternoval steps
1. Snap pin
3. Connection for transaxle control cable
(Refer to
P.23-84.)4. Solenoid connector5. Park/neutral position switch connector
6. Pulse generator connector
7. Kickdown
servo switch connector
8. Oil temperature sensor connector 9. Connection for sppedometer cable
10. Connection for oil cooler hose
11. Connection for starter motor
12. Upper coupling bolt for transaxle assembly and engine assembly
13. Transaxle mount bracket
TSB Revision

23-102AUTOMATIC TRANSAXLE - Transaxle Assemblv

27-34 Nm220-25 ftlbs.
\
43-55 Nm
60-80 Nm
60-80 Nm
/43-58 ftlbs.
43-58
ftlbs.
/\ /\ 930-35 NmDm 30-35 N

m
22-25
ftlbs.22-25 ft.lbs.
Iemoval steps
2. Adjusting nut
3. Connection for transaxle control cable (Refer to
P.23-85.)4. Solenoid connector
5. Park/neutral position switch connector
6. Pulse generator connector
7. Kickdown
servo switch connector
8. Oil temperature sensor connector
9. Connection for speedometer cable
10. Connection for oil cooler hose
11. Connection for starter motor
12. Upper coupling bolt for transaxle assembly and engine assembly
13. Transaxle mount bracket
TSB Revision

AUTOMATIC TRANSAXLE - Transaxle Assembly 23-I 05
TRANSAXLE ASSEMBLY hl33lA-1
REMOVAL AND INSTALLATION
Pre-removal and Post-installation
Operation
eDraining and Supplying of the Trans-axle Fluid(Refer to GROUP 00-MaintenanceService.)l Removal and Installation of the Bat-tery and Battery Tray
*Removal
and Installation of the Air
Cleaner(Refer to GROUP 15-Air Cleaner.)20-27 Nmlo-14 Nm
14.5-19 ft.lbs.0 /7-10 ft.lbs.
/
, \ fp,/7-9 f%.lbs.
27-34 Nm20-25 ft.lbs.
-27-34 Nm20-25 ft.lbs.
30-35 Nm
22-25 ft.lbs.
30-35 Nm
22-25 ft.lbs. OSA0183
Removal steps
1. Connection for transaxle control cable
(Refer to P.23-86.)2. Connection for oil cooler hose
3. Automatic transaxle dipstick
4. Connection for solenoid connector 5. Park/neutral position switch (Refer to
P.23-86.)6. Connection for kickdown servo switch
connector 7. Connection for pulse generator connector
8. Connection for oil temperature sensor
connector
9. Connection for speedometer cable
10. Starter motor
11. Upper coupling bolt for transaxle
assembly and engine assembly
TSB Revision

ALPHABETICAL INDEX5
Fuel, Maintenance.
.
Power Steering
Transaxle
011 Cooler
Vacuum
..,...,..,.......
Water >
Water
Water
HUB
End Play inspection
End Play, Inspection
Front Axl
e
Rear Axle

Rear Axle

>
HYDRAULIC UNIT
HYDRAULIC UNIT, Inspection
I 00-39-I
37A-58-I
23-l
00-l
17-4-I
14-26-I
14-28-l
14-23-l
338-86-I
26-5-l
26-l-l
27-8-l
27-6-1
35-121-l
35-70-t
IAC VALVE POSITION SENSOR, On-vehicle Inspection........................

.
13-162-l
IDLE AIR CONTROL MOTOR
DC Motor,
On-vehicle
Inspection
13-184-I
Stepper Motor, On-vehicle Inspection ....... 13-298-l
IDLE SPEED
Basic, Adjustment
.....................
.
13-245-l
Basic, Adjustment
...............
.
13-33-l
Basrc. Adjustment ...........

.
13-133-l
Curb, Inspection ................
...... 13-245-I
Curb, Inspection
..
.
...
...........
.
13-32-I
Curb, Inspection
.............
.
13-133-I
IDLE SPEED CONTROL MOTOR (DC Motor),
On-vehrcle Inspectron .............
.
13-93-l
IDLE SPEED CONTROL MOTOR POSITION SENSOR,On-vehicle Inspection ..............

.
13-64-I
IDLE-UP OPERATION, Check ....................... 55-24-l
IGNITION COIL
On-vehtcle
Inspection ................. 13-302-I
On-vehicle
Inspectron .........
.
13-96-l
On-vehicle
Inspection
.......
.
13-186-I
IGNITION POWER TRANSISTOR
On-vehrcle
Inspection ................ 13-302-I
On-vehicle Inspection
............. 13-96-l
On-vehicle
inspection .........
.
13-186-l
IGNITION SWITCH
Chassis Electrical.
...........................
.
.....
54-6-11
On-vehicle Inspection ..................
.
13-284-l
On-vehicle Inspection A/T>....
... 13-78-l
On-vehicle Inspection M/T>........ 13-77-l
On-vehicle Inspection A/T>....... 13-172-l
On-vehicle inspection GVALVE. M/T> ......
.
13-171 -IIGNITION SYSTEM...........................

.
16-32-11.....

.
IGNITION TIMING Adjustment ...........................
16-40-11
Adjustment 16-39-11.......
.
....................
INDICATOR...........................
.
.......... 33B-140-l
INDIVIDUAL PARTS, Auto-cruise Control, Inspection .......
13-401 -I
INFLATION PRESSURE, Tire, Check......................
.
31-4-l
INJECTORS
On-vehicle Inspection
..................
.
13-295-I
On-vehicle Inspection
...........
.
13-90-I
On-vehicle Inspection
........... 13-l
81-l
INSTRUMENT PANEL ................................. 52-22-l
INTAKE AIR TEMPERATURE SENSOR
Emission Control
..............................
.
17-21 -I
On-vehicle inspection
.................
.
13-263-l
On-vehicle Inspection
............
.
13-51-IOn-vehicle Inspection

INTAKE CHARGE PRESSURE CONTROL SYSTEM,Inspection . . . . . . . . . . . . . . .
INTAKE MANIFOLD
DOHC
,.. . . . . . . . . . . ,,... SOHC-WALVE
SOHC-l
GVALVE
K
KEY INTERLOCK MECHANISM, Check

.
KICKDOWN SERVO, Adjustment
KNOCK SENSOR, On-vehicle Inspection
KNUCKL
E
L
LASH ADJUSTERS
Check
>
Check
LATCHDoor, Fron
t
Door, Rear
LATERAL ROD
Active-EC
S
Rear Suspesion

LEAK, Refrrgerant. Repair Procedure
LEVELFluid, Transaxle, Inspection
Oil, Transfer, Inspection.
LEVERParking Brak
e
Parking Brake, Stroke Check
Selector, Operation Check.
Shift

Shift
LIDTrunk ._, . . . . . . . . . . . . .
Trunk, Adjustmen
t
LIGHT
......
......
......
.....
......
......
.....
......
......
......
......
......
......
......
......
......
......
......
......
......
.......
........
.......
........
........
........
........
........
........
........
........
........
........
........
........
........
........
Alarm, Chec

k
Rear Combination
Stop, High Mounted
LIGHTING SYSTEM
LINEBrake
Fuel
Fuel
Fuel
Fuel
Refrigerant
.
Vapor

Vapor
Vapor
Vapor
LINE PRESSURE, Adjustment
LININGBrake, Thickness Check.
Rear Drum Brake, Maintenance
LOOSE PANE
L
LOWER ARMActive-KS
Front Suspensio

n
Rear Suspesion

........
...............
.......
........
........
........
........
........
........
........
........
.........
.........
.........
.........
.........
........ 13-152-I
15-7-l
15-21 -I
15-14-I
15-18-I
23-83-1
23-86-i
13-287-l
26-6-l
11-57-1
1 l-7-l
42-96-l
42-99-l
338-l 17-l
34-14-I
’
55-21-I
23-82-l
23-82-l
36-4-l
36-2-l
23-83-l
22-19-l
22-9-l
42-57-l
42-50-I
338-87-I
54-95-11
54-96-11
54-38-11
35-87-I
13-326-I
13-324-I
13-113-I
13-I
95-l
55-54-l
13-326-I
13-324-l
13-I 13-l
13-195-1
23-88-l
35-67-l
00-44-I
42-62-i
338-l
03-l
33A-10-I
34-28-l

8ALPHABETICAL INDEX
ACTIVE-KS
.............................
.
338-l
41-1
Defogger ................................
.54-163-11
Horn
,
...............
54-105-11
Lightrng System............................
.
54-97-l)
Power, Check .............................. 55-24-l
RELEASE CYLINDER, Clutch.......................

.
21-13-l
REMOTE CONTROLLED MIRROR SWITCH..............

.
51-34-l
RESERVE TANK ............... 338-122-I
RESISTANCE
Rotary-sliding. Rear Hub, Adjustment .....

. 27-5-l
fiotation
Sliding, Rear Wheel Bearing, Check
..
.
27-16-l
RESISTOR
Heater, Arr Conditioning and Ventilation
............
. 55-28-l
On-vehicle
Inspection ............ 13-298-t
RHEOSTAT.....

.
.........................
54-99-11
ROD
Lateral ......................
.
338-l 17-l
Lateral ..............

. 34-14-l
ROLLING DIAPHRAGM, Check .................. 338-89-I
ROLL STOPPER, Engine...........................

. 32-6-l
ROTARY-SLIDING RESISTANCE (TORQUE), Rear Hub,Adjustment ............................

. 27-5-l
ROTATION SLIDING RESISTANCE, Rear Wheel Bearing,Check....................................

. 27-16-l
RUNCHANNEL. Door
.............................
.
42-l 10-l
RUN-OUT
Front Brake Disc, Correction ...................
. 35-64-l
Rear Brake Disc, Check ......................... 35-66-l
Rear Brake Disc, Correction ...................... 35-66-i
WheeLCheck
................................. 31-4-I
S
SAFETY PRECAUTIONS
SEALS 55-12-l
Ball Joint, Maintenance
Steering Linkage, Maintenance
SEAT
Fron
t
.._........
Rear...

.
SEAT BELT
SELECTOR LEVER, Operation Check
SENSOR
........ 00-45-I
...... 00-45-I
........
52-35-l
....... 52-37-l
.... 52-39-l
........ 23-83-l
ACTIVE-ECS Barometric Pressure, On-vehicle Inspection
. . . . . . . . . . . . . . . . . . . . . . . . 33B-138-i
13-266-l
Barometric Pressure, On-vehicle inspection
13-53-l
Barometric Pressure, On-vehicle Inspection
_. 13-154-l
Brake Fluld Level, Chec
k
35-54-l
Camshaft Position, On-vehicle inspection 13-277-l
Camshaft Position, On-vehicle Inspectron

13-69-l
Camshaft Position, On-vehicle Inspection
13-l
65-l
Crankshaft Position, On-vehicle Inspection 13-280-I
Crankshaft Position, On-vehicle Inspection
13-73-l
Crankshaft Position, On-vehicle Inspection
13-167-I
EGR Temperature California 17-28-l
EGR Temperature California, On-vehicle Inspection
13-288-l
EGR Temperature California, On-vehicle Inspection
13-85-l
EGR Temperature California, On-vehicle Inspection
13-177-l Engine Coolant Temperature 14-31-l
Engine Coolant Temperature 17-21-l
Engine Coolant Temperature, On-vehicle Inspection . 13-268-l
Engine Coolant Temperature, On-vehicle
Inspection
13-55-l
Engine Coolant Temperature, On-vehicle Inspection

13-l 55-l
G 35-132-l
Heated Oxygen, On-vehicle Inspection 13-290-I
Height 338-135-I
IAC Valve Position, On-vehicle Inspection
13-162-l
idle Speed Control Motor Position, On-vehicle Inspection
13-64-l
Intake Air Temperature 17-21-l
Intake Air Temperature, On-vehicle Inspection 13-263-l
Intake Air Temperature, On-vehicle Inspection
13-51-l
Intake Air Temperature, On-vehicle Inspection

13-l 52-l
Knock, On-vehicle Inspection (1992 From models)>
Oxygen, On-vehicle Inspection


Oxygen, On-vehicle Inspection
Throttle Position, Adjustment >
Throttle Position, Adjustment
Throttle
Position, Adjustment
Throttle Position, Adjustment
Throttle Position, On-vehicle Inspection
13-287-1 13-87-l
13-179-l
23-92-l
13-248-l
13-35-l
13-136-I
13-270-I
Throttle Position, On-vehicle Inspection
13-57-1
Throttle Position, On-vehicle Inspection...........................
. 13-157-l
Vehicle Speed, On-vehicle Inspection ....... 13-284-l
Vehicle Speed, On-vehicle Inspection
..............................
. 13-80-I
Vehicle Speed, On-vehicle Inspection
.............................
13-l 73-l
Volume Air Flow, Emission Control ...................
.
17-21
-I
Volume Air Flow, On-vehicle Inspection ....
. 13-261-l
Volume Air Flow, On-vehicle Inspection
..............................
. 13-49-l
Volume Air Flow, On-vehicle Inspection
............................
. 13-150-I
Wheel Speed
...........................
. 35-126-l
Wheel Speed, Output Voltage Measurement ............ 35-69-l
SERVO, Kickdown. Adjustment
.......................... 23-86-l
SHAFT
Axle ..................................

. 27-17-I
Drive........................................

. 26-12-I
Drive
.................................
. 27-20-I
Propeller.......................................

. 25-4-l
Steering.......................................

. 37A-25-l
SHIFT LEVER
AWD
.........................................
. 22-19-l
FWD
22-9-l
............................................
SHIFT LOCK MECHANISM, Check......................
. 23-84-l
SHOCK ABSORBER
Active-ECS
...................................
. 338-110-l
RearSuspension........................

. 34-35-l
Rear Suspension
........................
.
34-l 1-ISOLENOID VALVE
Active-ECS
.................................
.
..33B-127- I
EGR
...............................
. 17-28-l
EGR , On-vehicle Inspection 13-307-I
EGR , On-vehicle Inspection
.............................. 13-101-I