2015 FORD TRANSIT fuel filter
[x] Cancel search: fuel filterPage 441 of 461
Other maintenance items
1
Replace spark plugs.
Every 100000 miles
(160000 km) Inspect accessory drive belt(s). 4
Change automatic transmission fluid and filter.
Every 150000 miles
(240000 km) Change rear axle fluid.
Replace accessory drive belt(s).
1 Perform these maintenance items within 3000 miles (4800 kilometers) of the last
engine oil and filter change. Do not exceed the designated distance for the interval.
2 Replace early if indicated by per Water In Fuel warning lamp. See Warning Lamps and
Indicators (page 75).
3 Initial replacement at six years or 100000 miles (160000 kilometers), then every three
years or 50000 miles (80000 kilometers).
4 After initial inspection, inspect every other oil change until replaced.
SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE
3.2L, 3.5L and 3.7L Engines
If you operate your vehicle primarily in any
of the f
ollowing conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle
occasionally
under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician. Perform the services shown in the
following tables when specified or within
3000 miles (4800 kilometers) of the oil
change required message appearing in the
information display.
•
Example 1
: The message appears at
28750 mi (46,270 km). Perform the
30000 mi (48,000 km) automatic
transmission fluid replacement.
• Example 2
: The message does not
appear, but the odometer reads
30000 mi (48,000 km)
(for example,
the Intelligent Oil-Life Monitor was
reset at
25000 mi (40,000 km)).
Perform the engine air filter
replacement. Towing a trailer or using a car-top carrier
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Scheduled
Maintenance chart.
As required
Inspect and lubricate U-joints.
Inspect frequently,
service as required
See axle maintenance items under Exceptions.
438Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Scheduled Maintenance
Page 443 of 461
Exclusive use of E85 (Flex fuel vehicles only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change interval
Exceptions
There are several exceptions to the Normal
Schedule:
Normal vehicle axle maintenance: Rear
a
xles and power take-off units with
synthetic fluid and light-duty trucks
equipped with Ford-design axles are
lubricated for life; do not check or change
fluid unless a leak is suspected, service is
required or the assembly has been
submerged in water. During long periods
of trailer towing with outside temperatures
above
70°F (21°C) and at wide-open
throttle for long periods above 45 mph
(72 km/h), change non-synthetic rear axle
fluid every 3000 mi (4,800 km) or three
months, whichever comes first. This
interval can be waived if the axle is filled
with 75W140 synthetic gear fluid meeting
Ford specification WSL-M2C192-A; GL-5
or equivalent. Add friction modifier XL-3
EST-M2C118-A or equivalent for complete
refill of Traction-Lok rear axles. See
Capacities and Specifications
(page
265).
Police, Taxi and Livery vehicle axle
maintenance: Change rear axle fluid every
100000 mi (160,000 km). Rear axle fluid
change may be waived if the axle was filled
with 75W140 synthetic gear fluid meeting
Ford specification WSL-M2C192-A; GL-5 or equivalent. Add four ounces (118
milliliters) of additive friction modifier XL-3
EST-M2C118-A, or equivalent, for complete
refill of Traction-Lok rear axles. Change
the axle fluid anytime the axle submerges
in water.
California fuel filter replacement: If you
register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot climate oil change intervals:
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 5000 mi (8,000 km).
If the available API SM or SN oils are not
available, then the oil change interval is
3000 mi (4,800 km).
Engine air filter replacement: The life of
the engine air fil
ter is dependent on
exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter.
440 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Scheduled Maintenance
Page 454 of 461
Climate Control..............................................89
Principle of Operation........................................ 89
Cold Weather Precautions
.........................174
Coolant Check See: Engine Coolant Check........................... 206
Crash Sensors and Airbag Indicator........42
Creating a MyKey............................................47 Programming/Changing Configurable
Settings............................................................... 48
Cruise Control
..................................................63
Principle of Operation....................................... 147
Cruise control See: Using Cruise Control................................ 147
Cup Holders....................................................105
C
ustomer Assistance...................................181
D
Data Recording..................................................9
Daytime Running Lamps
............................68
Diesel Particulate Filter..............................108 R
egeneration........................................................ 109
Digital Radio..................................................
292
HD Radio Reception and Station
Troubleshooting............................................ 293
Direction Indicators.......................................69
DPF See: Diesel Particulate Filter.......................... 108
Draining the Fuel Filter Water Trap........210 Changing the Fuel Filter.................................... 211
Purging Air From the Fuel System................212
Driver Alert
......................................................149
Principle of Operation....................................... 149
Using Driver Alert................................................ 149
Driver and Passenger Airbags...................34 Children and Airbags.......................................... 39
Passenger Airbag On and Off Switch ..........34
Proper Driver and Front Passenger Seating Adjustment........................................................ 39
Driving Aids.....................................................149
Driving Hints
....................................................173
Driving Through Water................................174
DRL S
ee: Daytime Running Lamps........................68
E
Economical Driving
.......................................173 Emission Control System...........................122
Diesel Exhaust System: Oxidation Catalyst
And Diesel Particulate Filter System
........................................................................\
...... 124
Noise Emissions Warranty, Prohibited Tampering Acts and Maintenance..........132
On-Board Diagnostics (OBD-II).................... 123
Readiness for Inspection/Maintenance (I/M) Testing.................................................... 124
Tampering With a Noise Control System................................................................ 131
End User License Agreement..................416 SYNC End User License Agreement
(EULA)............................................................... 416
Engine Block Heater....................................109 Using the Engine Block Heater....................... 110
Engine Coolant Check...............................206 Adding Engine Coolant................................... 206
Checking the Engine Coolant....................... 206
Recycled Engine Coolant................................ 207
Severe Climates................................................. 208
What You Should Know About Fail-Safe Cooling............................................................. 208
Engine Immobilizer See: Passive Anti-Theft System.....................59
Engine Oil Check..........................................204 Adding Engine Oil.............................................. 205
Engine Oil Dipstick - 3.2L Power Stroke Diesel............................................................204
Engine Oil Dipstick - 3.5L.........................204
Engine Oil Dipstick - 3.7L..........................204
Engine Specifications - 3.2L Power Stroke Diesel..............................................266
Drivebelt Routing............................................... 266
Engine Specifications - 3.5L....................265 Driv
ebelt Routing............................................... 265
Engine Specifications - 3.7L....................265 Drivebelt Routing............................................... 266
Entertainment..............................................368 A/V Inputs............................................................ 386
AM/FM Radio...................................................... 370
Bluetooth Audio................................................. 385
Browsing Device Content............................... 369
SD Card Slot and USB Port............................ 381
SIRIUS® Satellite Radio (If Activated)........................................................ 376
Supported Media Players, Formats and Metadata Information................................ 385
451 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Index
Page 455 of 461
Essential Towing Checks...........................164
Before Towing a Trailer..................................... 169
Launching or Retrieving a Boat or Personal Water Craft (PWC)........................................ 170
Safety Chains....................................................... 165
Tow Hitch............................................................... 165
Trailer Brakes........................................................ 165
Trailer Lamps....................................................... 169
Trailer Towing Connector................................ 164
When Towing a Trailer...................................... 169
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options...................................11
Extended Service Plan (ESP)
..................431
SERVICE PLANS (CANADA ONLY)............432
SERVICE PLANS (U.S. Only).......................... 431
Exterior Mirrors..................................................71 Fold-Away Exterior Mirrors................................. 71
Power Exterior Mirrors.......................................... 71
F
Fastening the Safety Belts.........................28 Safety Belt Extension Assembly....................30
Safety Belt Locking Modes............................... 29
Using Safety Belts During Pregnancy...........28
Floor Mats
........................................................174
Ford Credit.........................................................10
(U.S. Only)............................................................... 10
Fuel and Refueling.........................................111
Fuel C
onsumption........................................122
Calculating Fuel Economy............................... 122
Filling the Fuel Tank........................................... 122
Fuel Filter - Gasoline....................................212
Fuel Qu
ality - Diesel......................................113
Biodiesel.................................................................. 114
Diesel Fuel Additives ......................................... 115
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where
Ultra-Low Sulfur Diesel Fuel Is Not
Required ............................................................ 113
Fuel Requirements - Choosing the Right Fuel: Vehicles Operated Where
Ultra-Low Sulfur Diesel Fuel is Required
(United States/Canada/Puerto Rico/U.S.
Virgin Islands and Other Locales)............113 Fuel Quality - Gasoline................................112
Choosing the Right Fuel With a Flex Fuel
Vehicle (If Equipped)..................................... 112
Choosing the Right Fuel Without a Flex Fuel Vehicle (If Equipped)..................................... 112
Octane Recommendations............................. 112
Fuel Shutoff.....................................................177
Fuse Box Locations......................................187 Body Control Module Fuse Box..................... 187
Engine Compartment Fuse Box.................... 187
Passenger Compartment Fuse Box.............187
Pre-fuse Box......................................................... 187
Fuses.................................................................187
Fuse Specification Chart...........................188 Body Control Module......................................... 197
Engine Compartment Fuse Box................... 188
Passenger Compartment Fuse Panel.........192
Pre-fuse Box......................................................... 195
G
Gauges................................................................73 Engine Coolant Temperature Gauge.............73
Fuel Gauge.............................................................. 74
Information Display............................................. 73
Tripmeter Reset and Distance to Empty................................................................... 74
General Information on Radio Frequencies...................................................44
General Maintenance Information........433 Multi-point Inspection..................................... 435
Owner Checks and Services.......................... 434
Protecting Your Investment........................... 433
Why Maintain Your Vehicle?.......................... 433
Why Maintain Your Vehicle at Your Dealership?..................................................... 433
Getting Assistance Outside the U.S. and Canada..........................................................184
G
etting the Services You Need.................181
Away From Home................................................ 181
H
Handbrake See: Parking Brake............................................. 138
Hazard Warning Flashers...........................177
452 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Index