2014.5 Citroen C4 DAG fuel cap

20 
C4-2_en_Chap01_controle-de-marche_ed01-2014
Warning/indicator lampis onCause Action/Observations
Anti-lock Braking
System (ABS) fixed.
The
  anti-lock   braking   system  
has

  a   fault.The
  vehicle   retains   conventional   braking.
Drive
  carefully   at   reduced   speed   and  
contact

  a   CITROËN   dealer   or   a   qualified  
workshop

  without   delay.
Engine
autodiagnosis system flashing.
The
  engine   management  
system

  has   a   fault.Risk
  of   destruction   of   the   catalytic   converter.
Have
  it   checked   by   a   CITROËN   dealer   or   a
 qualified

  workshop.
fixed. The
  emission   control   system  
has

  a   fault.The
  warning   lamp   should   go   off   when   the
 engine

  is   started.
If
  it   does   not   go   off,   contact   a   CITROËN
 dealer

  or   qualified   workshop   without   delay.
Low fuel level fixed,
 
accompanied

 
by

  and   audible  
signal

  and   a  
message.When

  it   first   comes   on   there  
remains

  approximately  
6

litres   of   fuel   in   the   tank.
At
  this   point,   you   begin   to   use  
the

  fuel   reserve.Refuel
  as   soon   as   possible   to   avoid  
running

  out   of   fuel.
Until
  sufficient   fuel   is   added,   this   warning  
lamp

  will   come   on   every   time   the   ignition  
is

  switched   on,   accompanied   by   an  
audible

  signal   and   a   message.  
This

  audible   signal   and   message   are  
repeated

  with   increasing   frequency   as  
the

  fuel   level   drops   towards   "0".
Fuel
  tank   capacity:   approximately  
60

litres.
Never
  continue   to   drive   until   you   run  
out

  of   fuel,   as   this   could   damage   the  
emission

  control   and   injection   systems.
1
MONITORING

1010
171 
C4-2_en_Chap10_verification_ed01-2014
FUEL TANK
Capacity of the tank: approximately
60 litres.
When the low fuel level in the
tank
 
is
 
reached,
 
this
 
warning
 
lamp

 
comes
 
on
 
in
 
the
 
instru
-
ment
 
panel,
 
accompanied
 
by
 
an

 
audible
 
warning
 
and
 
the
 
dis
-
play
 
of
 
an
 
alert
 
message.
 
When
 
it

 
first
 
comes
 
on,
 
around
6 li-
tres
  of   fuel   remain   in   the   tank.
Until
 
sufficient
 
fuel
 
has
 
been
 
added,
 
ev
-
ery
 
time
 
the
 
ignition
 
is
 
switched
 
on,
 
this
 
warning

 
lamp
 
appears,
 
accompanied
 
by

 
an
 
audible
 
signal
 
and
 
an
 
alert
 
mes
-
sage.
 
When
 
driving,
 
this
 
audible
 
signal
 
and

 
the
 
display
 
of
 
this
 
alert
 
message
 
are

 
repeated
 
with
 
increasing
 
frequency
,  
as

  the   level   drops   towards   0.
You
 
must
 
refuel
 
as
 
soon
 
as
 
possible
 
to
 
avoid

  running   out.
If you run out of fuel (
d iesel), refer also
to
  "Checks".
Low fuel level Refuelling
Additions of
 fuel  must  be  of  at  least  
5  litres  to  be  registered  by  the  fuel  
gauge.
Opening

 
the
 
filler
 
cap
 
may
 
result
 
in
 
an
 
inrush

 
of
 
air
.  
This
 
vacuum
 
is
 
entirely
 
normal

 
and
 
results
 
from
 
the
 
sealing
 
of
 
the

  fuel   system.
F

Press control
A  
until
 
the
 
automatic
 
opening

  of   the   fuel   flap   is   heard.
 This

 
control
 
remains
 
active
 
for
 
a
 
few
 
minutes

 
after
 
switching
 
of
f  
the
 
igni
-
tion.
 
If
 
necessary
,  
switch
 
the
 
ignition
 
on

  again   to   reactivate   it.
F
 
T
ake  
care
 
to
 
select
 
the
 
pump
 
that
 
delivers

 
the
 
correct
 
fuel
 
for
 
your
 
ve
-
hicle.
If you are filling your tank to the top,
do not persist after the third cut-off;
this could cause your vehicle to mal-
function.
With Stop & Start, never refuel
with
 
the

 
system

 
in

 
ST

OP
 mode;

 
you

 
must

 
switch

 
of

f
 
the

 
ignition

 
with

 
the
 
key. F
 
Introduce
 
the
 
nozzle
 
so
 
as
 
to
 
push
 
in

  the   metal   non-return   flap   B.
F
 
Make
 
sure
 
that
 
the
 
nozzle
 
is
 
pushed
 
in

 
as
 
far
 
as
 
possible
 
before
 
starting
 
to

  refuel   (risk   of   blowback).
F

Maintain this  position  while  refuelling.
F Push  the   fuel   flap   to   close   it.
CHECKS

1010
173 
C4-2_en_Chap10_verification_ed01-2014
MISFUEL PREVENTION
(D IESEL )*
Mechanical device  which  prevents  fill -
ing  the  tank  of  a  Diesel  vehicle  with  
petrol.

 
It
 
avoids
 
the
 
risk
 
of
 
engine
 
dam
-
age
 
that
 
can
 
result
 
from
 
fillin
g  
with
 
the
 
wrong

  fuel.
Located
 
in
 
the
 
filler
 
neck,
 
the
 
misfuel
 
prevention

 
device
 
appears
 
when
 
the
 
filler

  cap   is   removed.
Operation
When a petrol  filler  nozzle  is  introduced  into
 the  fuel  filler  neck  of  your  Diesel  
vehicle,

 
it
 
comes
 
into
 
contact
 
with
 
the
 
flap.

 
The
 
system
 
remains
 
closed
 
and
 
prevents

  filling.
Do not persist but introduce a Diesel
type filler nozzle.
It
 
remains
 
possible
 
to
 
use
 
a
 
fuel
 
can

  to   fill   the   tank.
In
 
order
 
to
 
ensure
 
a
 
good
 
flow
 
of
 
fuel,

 
do
 
not
 
place
 
the
 
nozzle
 
of
 
the

 
fuel
 
can
 
in
 
direct
 
contact
 
with
 
the

 
flap
 
of
 
the
 
misfuel
 
prevention
 
device

  and   pour   slowly.*
 
According
  to   country   of   sale.
Travelling abroad
As
 
Diesel
 
fuel
 
pump
 
nozzles
 
may

 
be
 
dif
ferent  
in
 
other
 
coun
-
tries,  
the
 
presence
 
of
 
the
 
misfuel
 
prevention

 
device
 
may
 
make
 
re
-
fuelling   impossible.
Before  
travelling
 
abroad,
 
we
 
recommend

 
that
 
you
 
check
 
with
 
the

 
CITROËN
 
dealer
 
network,
 
whether your vehicle is suitable
for

 
the
 
fuel
 
pumps
 
in
 
the
 
country
 
in

  which   you   want   to   travel.
CHECKS

1010
177 
C4-2_en_Chap10_verification_ed01-2014
* According  to   engine.
DIESEL ENGINES
The various  caps  and  covers  allow  access  for  checking  the  levels  of  the  various  fluids,  for  replacing  certain  components  and  for
  priming   the   fuel   system.
1.
 
Power
  steering   reservoir.
2.
 
Screenwash
 
and
 
headlamp
 
wash
 
reservoir

.
3.
 
Coolant
  reservoir. 4.
 
Brake
  fluid   reservoir.
5.
 
Battery/Fuses.
6.

 
Fusebox.
7.

 
Air
  filter.8.
 
Engine
  oil   dipstick.
9.
 
Engine
  oil   filler   cap.
10.
 
Priming
  pump*.
11 .
 Bleed

  screw*.
CHECKS

1010
183 
C4-2_en_Chap10_verification_ed01-2014
ADBLUE® ADDITIVE AND SCR SYSTEM
FOR
B
LUE HD I D IESEL
ENGINES
To assure  respect  for  the  environment  and
 conformity  with  the  new  Euro  6  
emissions

 
standard,
 
without
 
adversely
 
af

fecting  
the
 
performance
 
or
 
fuel
 
con
-
sumption
 
of
 
Diesel
 
engines,
 
CITROËN
 
has

 
taken
 
the
 
decision
 
to
 
equip
 
its
 
ve
-
hicles
 
with
 
an
 
ef
fective  
system
 
that
 
associates SCR (Selective Catalytic
Reduction)

 
with
 
a
 
particle
 
filter
 
(F
AP)  
for

  the   treatment   of   exhaust   gases.
Presentation of the SCR system
Using an additive  called  AdBlue® con-
taining
 urea,
 a
 catalytic
 converter
 turns  
up

 
to

 
85%

 
of

 
nitrous

 
oxides

 
(NOx)
 
into
 
nitrogen

 
and

 
water

,
 
which

 
are

 
harmless
 
to

 
health
 
and
 
the
 
environment. The
 
AdBlue® additive
 is  held  in  a  spe -
cial
 tank
 located  under  the  boot  at  the  
rear

 
of

 
the

 
vehicle.
 
It
 
has
 
a
 
capacity
 
of
 
17

 
litres:

 
this

 
provides
 
a
 
driving
 
range
 
of
 
about

 
12

 
500
 
miles
 
(20
 
000
 
km),
 
after
 
which

 
an

 
alert
 
is
 
triggered
 
warning
 
you
 
when

 
the

 
reserve
 
remaining
 
is
 
enough
 
for

 
just
 
1
 
500   miles   (2   400   km).
During
 
each

 
scheduled
 
service
 
of
 
your
 
vehicle

 
by

 
a

 
CITROËN
 
dealer
 
or
 
a
 
qual
-
ified
 
workshop,
 
the
 
AdBlue® additive  tank
 is
 refilled
 in
 order
 to
 allow  normal  
operation

 
of
 
the
 
SCR
 
system.
If
 
the

 
estimated

 
mileage

 
between
 
two
 
services

 
is

 
greater

 
than

 
12

 
500
 
miles
 
(20

 
000

 
km),

 
we

 
recommend

 
that
 
you
 
go

 
to

 
a

 
CITROËN

 
dealer

 
or

 
a
 
qualified
 
workshop

 
to

 
have

 
the

 
necessary
 
top-up
 
carried

 
out. Once
 
the
 
AdBlue® tank is
 empty ,  a
 system
 required
 by  regulations  
prevents

 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from

 
your
 
vehicle
 
will
 
no

 
longer

 
meet

 
the
 
Euro
 
6
 
stan
-
dard:
 
you

 
vehicle

 
becomes
 
pol
-
luting.
In
 
the

 
event

 
of

 
a

 
confirmed
 
fault
 
with

 
the

 
SCR

 
system,
 
you
 
must
 
go

 
to

 
a

 
CITROËN
 
dealer
 
or
 
a
 
qualified

 
workshop
 
as
 
soon
 
as
 
possible:

 
after

 
a

 
running
 
dis
-
tance
 
of

 
650

 
miles
 
(1 
100  
km),
 
a

 
system

 
will

 
be

 
triggered
 
au
-
tomatically
 
to

 
prevent
 
engine
 
starting.
CHECKS

1010
187 
C4-2_en_Chap10_verification_ed01-2014
Topping-up the AdBlue®
additive
Filling the  AdBlue® tank is  an  operation  included
 in
 every
 routine  service  on  
your

 
vehicle

 
by

 
a

 
CITROËN
 
dealer
 
or
 
a
 
qualified

 
workshop.
Nevertheless,
 
given
 
the
 
capacity
 
of
 
the
 
tank,

 
it

 
may

 
be

 
necessary
 
to
 
top-up
 
the
 
additive

 
between

 
services,
 
more
 
partic
-
ularly
 
if

 
an

 
alert

 
(warning
 
lamps
 
and
 
a
 
message)

 
signals
 
the   requirement.
You
 
can

 
got

 
to

 
a

 
CITROËN
 
dealer
 
or
 
a
 
qualified

 
workshop.
If
 
you

 
envisage

 
topping-up
 
yourself,
 
please

 
read

 
the

 
following
 
warnings
 
carefully

. Precautions in use
The
 AdBlue® additive is  an  urea-based  solution.
 This  liquid  is  non-flammable,  
colourless

 
and
 
odourless
 
(kept
 
in
 
a
 
cool
 
area).
In

 
the

 
event

 
of
 
contact
 
with
 
the
 
skin,
 
wash

 
the

 
af

fected  
area
 
with
 
soap
 
and
 
water

.
 
In

 
the
 
event
 
of
 
contact
 
with
 
the
 
eyes,

 
wash

 
(irrigate)
 
the
 
eyes
 
with
 
large
 
amounts

 
of

 
water
 
or
 
with
 
an
 
eye
 
wash
 
solution

 
for

 
at
 
least
 
15
 
minutes.
 
If
 
a
 
burning

 
sensation
 
or
 
irritation
 
persists,
 
get

 
medical
 
attention.
If
 
swallowed,
 
immediately
 
wash
 
out
 
the
 
mouth

 
with

 
clean
 
water
 
and
 
then
 
drink
 
plenty

 
of
 
water.
In
 
certain

 
conditions
 
(high
 
ambient
 
tem
-
perature,
 
for

 
example),
 
the
 
risk
 
of
 
re
-
lease
 
of

 
ammonia
 
cannot
 
be
 
excluded:
 
do

 
not

 
inhale
 
the
 
product.
 
Ammonia
 
vapour

 
has

 
en
 
irritant
 
ef
fect  
on
 
mucous
 
membranes

 
(eyes,   nose   and   throat).
Keep
 
AdBlue® out of the reach
of
 
children,
 
in
 
its   original   bottle.
Never
 
transfer
 
AdBlue® to an-
other
 container:
 it
 would  loose  
its

 
purity. Use
 
only
 
AdBlue® additive
 that  meets  the
 
ISO
 
22241
 
standard.
Never
 
dilute
 
the
 
additive
 
with
 
water

.
Never
 
pour

 
the
 
additive
 
into
 
the
 
Diesel

 
fuel
 
tank.
The supply  in  a  non-drip  bottle  simplifies  toping-up.
 Y ou  can  obtain  1.89  litre  (half  a  
US

 
gallon)
 
bottles
 
from
 
a
 
CITROËN 
deal-
er
  or   a   qualified   workshop.
Never top-up from  an  AdBlue®
dispenser
 reserved
 for
 heavy
 
goods

 
vehicles.
CHECKS

223 
C4-2_en_Chap12_caracteristique_ed01-2014
*  The maximum  power  corresponds  to  the  value  type-approved  on  a  test  bed,  under  conditions  defined  in  European  legisla -
tion   (Directive   1999/99/EC).
PETROL ENGINES AND GEARBOXES
.../1: model fitted with low rolling resistance tyres.
.../2:  model   fitted   with   very   low   rolling   resistance   tyres.
Petrol engine
VTi 95THP 110 VTi 120
Gearbox Manual
(5-speed) Manual
(5-speed) Manual
(5-speed) Automatic
(4-speed)
Model code:
NC... 8FR0HNZ6
HNZ6/1
HNZ6/2 5FS0
5FS9
5FS9/D
Cubic capacity (cc) 1   397
1   199
1   598
Bore   x   stroke   (mm)
77   x   72.5 75   x   90.5
77   x   85.8
Max   power*:   EU   standard   (kW)
7081 88
Max   power   engine   speed   (rpm)
6   000
5   500
6   000
Max   torque:   EU   standard   (Nm)
135205 160
Max   torque   engine   speed   (rpm)
4   000
1   500
4   250
Fuel Unleaded Unleaded Unleaded
Catalytic converter Ye sYe s Ye s
Engine oil capacity (in litres) 4.25- 4.25
12
TECHNICAL DATA

224 
C4-2_en_Chap12_caracteristique_ed01-2014
*  The maximum  power  corresponds  to  the  value  type-approved  on  a  test  bed,  under  conditions  defined  in  European  legisla -
tion   (Directive   1999/99/EC).
.../S:
  model   fitted   with   Stop   &   Start.
.../1: model
  fitted   with   low   rolling   resistance   tyres.
Petrol engine
e-THP 130THP 155
Gearbox Manual
(6-speed) Electronic
(6-speed)
Model code:
NC... HNYM/S
HNYM/1S 5FV8/P
Cubic capacity (cc) 1   199
1   598
Bore   x   stroke   (mm)
70   x   90.5
77   x   85.8
Max   power*:   EU   standard   (kW)
96 11 5
Max   power   engine   speed   (rpm)
5   500
6   000
Max   torque:   EU   standard   (Nm)
230 240
Max   torque   engine   speed   (rpm)
1   750
1   400
Fuel UnleadedUnleaded
Catalytic converter Ye sYe s
Engine oil capacity (in litres) -4,25
12
TECHNICAL DATA