2014.5 Citroen C4 DAG oil filter

9
C4-2_en_Chap00b_vue-ensemble_ed01-2014
9
C4-2_en_Chap00b_vue-ensemble_ed01-2014
TECHNICAL DATA - MAINTENANCE
Running out of Diesel fuel ............. 174
Checking   levels  
...................... 178-180
-

 
oil
-

 
brake
  fluid
-
 
coolant
-

 
power
  steering   fluid
-
 
screenwash
  /   headlamp   wash   fluid
-
 
additive
  (Diesel   with   particle  
emissions

  filter)
AdBlue
  additive....................... 183-189
Changing
  bulbs....................... 202-207
-
 
front
-

 
rear Petrol

  engines......................... 223-226
Diesel   engines  
........................ 227-231
Dimensions
 
.................................... 232
Identification
  markings  
................... 233
b

onnet  
........................................... 175
Petrol

  underbonnet  
........................ 176
Diesel

  underbonnet  
....................... 177Checking

  components  
............ 181-182
-

 
battery
-

 
air
  filter   /   passenger   compartment  
filter
-

 
oil
  filter
-
 
particle
  emissions   filter   (Diesel)
-
 
brake
  pads   /   discs
b
attery  
.................................... 212-214
Energy
  economy   mode.................. 215
Engine   compartment   fuses  
..... 208,
  211
oVERVIEW

11 
ECO-DRIVING
Limit the causes of excess consumption
Spread loads throughout  the  vehicle;  place  the  heaviest  items
 in  the  bottom  of  the  boot,  as  close  as  possible  to  the  
rear

  seats.
Limit
 
the
 
loads
 
carried
 
in
 
the
 
vehicle
 
and
 
reduce
 
wind
 
resis
-
tance
 
(roof
 
bars,
 
roof
 
rack,
 
bicycle
 
carrier
,  
trailer
...).  
Use
 
a
 
roof

  box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
 
the
 
end
 
of
 
winter
,  
remove
 
snow
 
tyres
 
and
 
refit
 
your
 
sum
-
mer
  tyres.
Observe the recommendations on maintenance
Check the  tyre  pressures  regularly ,  when  cold,  referring  to  the
  label   in   the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
before
  a   long   journey,
-
 
at
  each   change   of   season,
-
 
after
  a   long   period   out   of   use.
Don't
 
forget
 
the
 
spare
 
wheel
 
and
 
the
 
tyres
 
on
 
any
 
trailer
 
or
 
caravan.
Have

 
your
 
vehicle
 
serviced
 
regularly
 
(engine
 
oil,
 
oil
 
filter
,
 air

 
filter
,  
passenger
 
compartment
 
filter
...)  
and
 
observe
 
the schedule

 
of
 
operations
 
recommended
 
in
 
the
 
manufacturer's service

  schedule.
With
 
a
 
BlueHDi
 
Diesel
 
engine,
 
if
 
the
 
SCR
 
system
 
is
 
faulty
 
your

 
vehicle
 
becomes
 
polluting;
 
go
 
to
 
a
 
CITROËN
 
dealer
 
or
 
a

 
qualified
 
workshop
 
without
 
delay
 
to
 
have
 
the
 
emissions
 
of
 
nitrous

  oxides   brought   back   to   the   legal   level.
When
 
refuellin
g,  
do
 
not
 
continue
 
after
 
the
 
third
 
cut-of
f  
of
 
the
 
nozzle

  to   avoid   any   overflow.
At
 
the
 
wheel
 
of
 
your
 
new
 
vehicle,
 
it
 
is
 
only
 
after
 
the
 
first
 
1 

800  
miles
 
(3
 
000
 
kilometres)
 
that
 
you
 
will
 
see
 
the
 
fuel
 
consumption

  settle   down   to   a   consistent   average.

1010
176 
C4-2_en_Chap10_verification_ed01-2014
PETROL ENGINES
The various caps and covers allow access for checking the levels of the various fluids and for replacing certain components.
1.  
Power
  steering   reservoir.
2.
 
Screenwash
 
and
 
headlamp
 
wash
 
reservoir

.
3.
 
Coolant
  reservoir. 4.
 
Brake
  fluid   reservoir.
5.
 
Battery/Fuses.
6.

 
Fusebox.7.

 
Air
  filter.
8.
 
Engine
  oil   dipstick.
9.
 
Engine
  oil   filler   cap.
CHECKS

1010
177 
C4-2_en_Chap10_verification_ed01-2014
* According  to   engine.
DIESEL ENGINES
The various  caps  and  covers  allow  access  for  checking  the  levels  of  the  various  fluids,  for  replacing  certain  components  and  for
  priming   the   fuel   system.
1.
 
Power
  steering   reservoir.
2.
 
Screenwash
 
and
 
headlamp
 
wash
 
reservoir

.
3.
 
Coolant
  reservoir. 4.
 
Brake
  fluid   reservoir.
5.
 
Battery/Fuses.
6.

 
Fusebox.
7.

 
Air
  filter.8.
 
Engine
  oil   dipstick.
9.
 
Engine
  oil   filler   cap.
10.
 
Priming
  pump*.
11 .
 Bleed

  screw*.
CHECKS

1010
180 
C4-2_en_Chap10_verification_ed01-2014
Used products
Avoid prolonged contact  of  used  oil
  or   fluids   with   the   skin.
Most
 
of
 
these
 
fluids
 
are
 
harmful
 
to

 
health
 
or
 
indeed
 
very
 
corro
-
sive.
Do
 
not
 
discard
 
used
 
oil
 
or
 
fluids
 
into

  sewers   or   onto   the   ground.
Take
 
used
 
oil
 
to
 
a
 
CITROËN
 
dealer

 
or
 
a
 
qualified
 
workshop
 
(France)

 
or
 
to
 
an
 
authorised
 
waste

  disposal   site.
Additive level (Diesel with
particle emissions filter)
The additive reservoir  low  level  is  indi -
cated   by:
Topping up
The
 
reservoir
 
must
 
be
 
topped
 
up
 
with
-
out
 
delay
 
by
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified

  workshop.
-
 
fixed
 
illumination
 
of
 
the
 
par
-
ticle
 
emissions
 
filter
 
warning lamp,

 
accompanied
 
by
 
an
 
au
-
dible
 
signal
 
and
 
a
 
message that

 
the
 
particle
 
emissions filter

  additive   level   is   too   low.
Screenwash / headlamp wash
fluid levelSpecification of the fluid
To 
ensure
 
optimum
 
cleaning
 
and
 
to avoid

 
freezing,
 
the
 
fluid
 
should
 
never
 
be topped

  up   or   replaced   by   plain   water.
In
 
wintry
 
conditions,
 
the
 
use
 
of
 
a
 
fluid
 
with

 
an
 
ethyl
 
alcohol
 
or
 
methanol
 
base
 
is

  recommended.
To
 
check

 
the

 
level

 
or

 
top

 
up

 
the

 
fluid

 
on

 
vehicle

 
fitted

 
with

 
headlamp

 
washers,

 
immobilise

 
the

 
vehicle

 
and

 
switch

 
of

 
the

 
engine.
F

 
Open

 
the

 
bonnet

 
and

 
secure

 
it

 
with

 
the

 
stay.
F
 
Open

 
the

 
screenwash

 
reservoir

 
fill

-
er
 
cap.
F
 
T

ake
 
and

 
pinch

 
the

 
level

 
gauge

 
to

 
block

 
its
 
breather.
F
 
Remove

 
the

 
gauge

 
completely

 
from

 
the

 
reservoir

 
to

 
read

 
the

 
level

 
in

 
the

 
transparent

 
section.
F
 
T

op
 
up
 
if
 
necessary.
F
 
Refit

 
the

 
filler

 
cap

 
to

 
the

 
reservoir

 
and

 
close
 
the
 
bonnet.
CHECKS

1010
181 
C4-2_en_Chap10_verification_ed01-2014
CHECKSParticle emission filter (Diesel)
The start of saturation of the particle
emissions  filter   is   indicated   by:
-
 
fixed
 
illumination
 
of
 
the
 
par
-
ticle
 
emissions
 
filter
 
warning lamp,

 
accompanied
 
by
 
an audible

 
signal
 
and
 
a
 
message that

 
there
 
is
 
a
 
risk
 
of
 
blockage of

  the   particle   emissions   filter.
The presence of this label, in particular
with
 
the

 
Stop

 
&

 
Start

 
system,

 
indicates

 
the

 
use

 
of

 
a

 
specific

 
12

 
V

 
lead-acid

 
bat

-
tery
 
with

 
special

 
technology

 
and

 
specifi

-
cation.
 
The

 
involvement

 
of

 
a

 
CITROËN

 
dealer

 
or

 
a

 
qualified

 
workshop

 
is

 
essen

-
tial
 
when

 
replacing

 
or

 
disconnecting

 
the

 
battery

. On
 
a
 
new
 
vehicle,
 
the
 
first
 
op
-
erations
 
of
 
regeneration
 
of
 
the
 
particle

 
emissions
 
filter
 
may
 
be
 
accompanied

 
by
 
the
 
smell
 
of
 
"burning",

 
which
 
is
 
perfectly
 
nor
-
mal.
Following
 
prolonged
 
operation
 
of

 
the
 
vehicle
 
at
 
very
 
low
 
speed
 
or

 
at
 
idle,
 
you
 
may
,  
in
 
excep
-
tional
 
circumstances,
 
notice
 
the
 
emission

 
of
 
water
 
vapour
 
at
 
the
 
exhaust

 
on
 
acceleration.
 
This
 
does

 
not
 
af
fect  
the
 
behaviour
 
of
 
the

  vehicle   or   the   environment.
As
 
soon
 
as
 
the
 
traffic
 
conditions
 
per
-
mit,
 
regenerate
 
the
 
filter
 
by
 
driving
 
at
 
a
 
speed

 
of
 
at
 
least
 
40
 
mph
 
(60
 
km/h)
 
until
 
the

  warning   lamp   goes   off.
If
 
the
 
warning
 
lamp
 
stays
 
on,
 
refer
 
to
 
the

  "Additive   level"   section.
Unless
 otherwise
 indicated,
 check
 these
 components
 in
 accordance
 with
 
the

 
manufacturer's

 
service

 
schedule

 
and

 
according
 
to
 
your
 
engine.
Otherwise,
 
have

 
them

 
checked

 
by

 
a

 
CITROËN

 
dealer

 
or

 
a

 
qualified

 
work

-
shop.
Air filter and passenger compartment filter
Refer to  the  manufacturer's  service
 schedule  for  details  of  
the

 
replacement
 
intervals
 
for
 
these

  components.
Depending
 
on
 
the
 
environ
-
ment
 
(e.g.
 
dusty
 
atmosphere)
 
and
 
the
 
use

 
of

 
the
 
vehicle
 
(e.g.
 
city
 
driving),
 
re
-
place them twice as often if neces-
sary.
A
 clogged

 
passenger
 
compartment
 
fil
-
ter
 
may

 
have
 
an
 
adverse
 
ef
fect  
on
 
the
 
performance

 
of
 
the
 
air
 
conditioning
 
sys
-
tem
 
and
 
generate   undesirable   odours.
Oil filter
Replace the oil  filter  each  time  the
  engine   oil   is   changed.
Refer
 
to
 
the
 
manufacturer's
 
service

 
schedule
 
for
 
details
 
of

 
the
 
replacement
 
interval
 
for
 
this

 
component.
12 V battery
The battery  does  not  require  any
  maintenance.
However,
 
check
 
that
 
the
 
ter
-
minals
 
are
 
clean
 
and
 
correctly
 
tightened,

 
particularly
 
in
 
sum
-
mer
 
and
 
winter.
When
 
carrying
 
out
 
work
 
on
 
the
 
battery
,  
refer

 
to

 
the
 
"12 
V  
battery"
 
section
 
for
 
details

 
of
 
the
 
precautions
 
to
 
be
 
taken
 
before

 
disconnecting
 
the
 
battery
 
and
 
following

  its   reconnection.
CHECKS

227 
C4-2_en_Chap12_caracteristique_ed01-2014
*  The maximum  power  corresponds  to  the  value  type-approved  on  a  test  bed,  under  conditions  defined  in  European  legisla -
tion   (Directive   1999/99/EC).
DIESEL ENGINES AND GEARBOXES
.../S: model fitted with Stop & Start.
.../1:   model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
  model   fitted   with   very   low   rolling   resistance   tyres.
Diesel engine
HDi 90 HDi 90 FAP BlueHDi 100 e-HDi 115
Gearbox Manual
(5-speed) Manual
(5-speed) Manual
(5-speed) Manual
(6-speed) Electronic
(6-speed)
Model code:
NC... 9H j C
9H j C/1
9HP0 BHY6
BHY6/1
BHY6/2S 9HD8/S
9HD8/1S
9HD8/2S 9HD8/1PS
9HD8/2PS
Cubic capacity (cc) 1   560 1   560 1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3 75   x   88.3 75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
686873 84
Max   power   engine   speed   (rpm)
4   000 4   000 3   750
3   600
Max   torque:   EU   standard   (Nm)
230230254 270
Max   torque   engine   speed   (rpm)
1   750 1   750 1   750
1   750
Fuel
d
iesel
d
iesel
d
iesel
d
iesel
Catalytic converter Ye sYe sYe s Ye s
Particle   filter   (FAP)
n
o
Ye s Ye s Ye s
Engine oil capacity (in litres) 3.753.75 - 3.75

12
TECHNICAL DATA

228 
C4-2_en_Chap12_caracteristique_ed01-2014
*  The maximum  power  corresponds  to  the  value  type-approved  on  a  test  bed,  under  conditions  defined  in  European  legisla -
tion   (Directive   1999/99/EC).
.../S:
  model   fitted   with   Stop   &   Start.
.../1:
  model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
  model   fitted   with   very   low   rolling   resistance   tyres.
Diesel engine
BlueHDi 115BlueHDi 120HDi 150 FAP
Gearbox Manual
(6-speed) Manual
(6-speed) Manual
(6-speed)
Model code:
NC... BHXM/S
BHXM/1S
BHXM/2S BHZM/S
BHZM/1S
BHZM/2S RHE8
RHE8/1
Cubic capacity (cc) 1   560
1   560
1   997
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
85   x   88
Max   power*:   EU   standard   (kW)
858811 0
Max   power   engine   speed   (rpm)
3   500
3   500
3   750
Max   torque:   EU   standard   (Nm)
300300340
Max   torque   engine   speed   (rpm)
1   750
1   750
2   000
Fuel
d
iesel
d
iesel
d
iesel
Catalytic converter Ye sYe sYe s
Particle   filter   (FAP)
Ye sYe sYe s
Engine oil capacity (in litres) ---
12
TECHNICAL DATA