Page 489 of 636
489 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_EE (OM0K132E)
Battery
Check the battery as follows.
Caution symbols
The meanings of each caution symbol on the top of the battery are as
follows:
Battery exterior
Make sure that the battery terminals are not corroded and that
there are no loose connections, cracks, or loose clamps.
Terminals
Hold-down clamp
No smoking, no
naked flames, no
sparks
Battery acid
Shield eyesNote operating
instructions
Keep away from chil-
drenExplosive gas
Page 490 of 636
490 4-3. Do-it-yourself maintenance
HILUX_EE (OM0K132E)Checking battery fluid
Check that the level is between
the upper and lower lines.
Upper line
Lower line
If the fluid level is at or below the
lower line, add distilled water.
Adding distilled water
Remove the vent plug.
Add distilled water.
If the upper line cannot be seen, check the fluid level by looking
directly at the cell.
Put the vent plug back on and close it securely.
Low O.K.
STEP1
STEP2
STEP3
Page 491 of 636

491 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_EE (OM0K132E)
Before recharging
When recharging, the battery produces hydrogen gas which is flammable
and explosive. Therefore, observe the following before recharging:
If recharging with the battery installed on the vehicle, be sure to discon-
nect the ground cable.
Make sure the power switch on the charger is off when connecting and
disconnecting the charger cables to the battery.
CAUTION
Chemicals in the battery
Batteries contain poisonous and corrosive sulfuric acid and may produce
hydrogen gas which is flammable and explosive. To reduce the risk of death
or serious injury, take the following precautions while working on or near the
battery:
Do not cause sparks by touching the battery terminals with tools.
Do not smoke or light a match near the battery.
Avoid contact with eyes, skin and clothes.
Never inhale or swallow electrolyte.
Wear protective safety glasses when working near the battery.
Keep children away from the battery.
Where to safely charge the battery
Always charge the battery in an open area. Do not charge the battery in a
garage or closed room where there is insufficient ventilation.
Page 492 of 636

492 4-3. Do-it-yourself maintenance
HILUX_EE (OM0K132E)
CAUTION
Emergency measures regarding electrolyte
If electrolyte gets in your eyes
Flush your eyes with clean water for at least 15 minutes and get immedi-
ate medical attention. If possible, continue to apply water with a sponge or
cloth while traveling to the nearest medical facility.
If electrolyte gets on your skin
Wash the affected area thoroughly. If you feel pain or burning, get medical
attention immediately.
If electrolyte gets on your clothes
It can soak through clothing on to your skin. Immediately take off the cloth-
ing and follow the procedure above if necessary.
If you accidentally swallow electrolyte
Drink a large quantity of water or milk. Follow with milk of magnesia,
beaten raw egg or vegetable oil. Get emergency medical attention immedi-
ately.
NOTICE
When recharging the battery
Never recharge the battery while the engine is running. Also, be sure all
accessories are turned off.
When adding distilled water
Avoid overfilling. Water spilled during battery recharging may cause corro-
sion.
Page 493 of 636
493 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_EE (OM0K132E)
Washer fluid
Vehicles without washer fluid level gauge
If any washer does not work, the
washer tank may be empty. Add
washer fluid.
Vehicles with washer fluid level gauge
If the washer fluid level is at
“LOW”, add washer fluid.
Page 494 of 636
494 4-3. Do-it-yourself maintenance
HILUX_EE (OM0K132E)
Using the gauge (if equipped)
CAUTION
When adding washer fluid
Do not add washer fluid when the engine is hot or running as washer fluid
contains alcohol and may catch fire if spilled on the engine etc.
NOTICE
Do not use any fluid other than washer fluid
Do not use soapy water or engine antifreeze instead of washer fluid.
Doing so may cause streaking on the vehicle’s painted surfaces.
Diluting washer fluid
Dilute washer fluid with water as necessary.
Refer to the freezing temperatures listed on the label of the washer fluid bot-
tle.
The washer fluid level can be checked by
observing the position of the level on the
liquid-covered holes in the gauge.
If the level falls below the second hole
from the bottom (the “LOW” position),
refill the washer fluid.
Current
fluid level
Page 495 of 636
495 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_EE (OM0K132E)
Draining the fuel filter water
The water in the fuel filter must be drained immediately when the fuel
system warning light flashes.
Place a small tray under the drain plug or drain hose to catch
the water.
Turn the drain plug about 2 to
2 1/2 turns.
Loosening more than this will
cause water oozing from around
the drain plug.
Operate the priming pump
until the fuel begins to run out.
After draining, retighten the drain plug. Do not use a tool.
STEP1
STEP2
STEP3
Page 496 of 636
496
4-3. Do-it-yourself maintenance
HILUX_EE (OM0K132E)
Tires
Replace or rotate tires in accordance with maintenance schedules
and treadwear.
Checking tires
New tread
Treadwear indicator
Worn tread
The location of treadwear indi-
cators is shown by the “TWI” or
“” marks, etc., molded on the
sidewall of each tire.
Check spare tire condition and
pressure if not rotated.
Tire rotation
Vehicles with spare tire of a different wheel type from the
installed tires
Rotate the tires in the order
shown.
To equalize tire wear and help
extend tire life, Toyota recom-
mends that tire rotation is car-
ried out approximately every
10000 km (6000 miles).
Front