2012 MITSUBISHI iMiEV battery

General information/Charging
1-39
1
Regular charging is
discontinued.There is no power coming from
the outlet.There may have been a electrical power failure, or the breaker may have
failed.Charging will resume when the power source is reset.
The EV charging cable has been
disconnected.Check that the EV charging cable has not been disconnected.
The button on the regular charge
connector has been pressed.If the charge connector button is pressed for a long period of time, charg-
ing will be stopped. Start the charging procedure again.
The temperature of the main
drive lithium-ion battery is too
hot or too cold to charge.Confirm the main drive lithium-ion battery temperature.
Refer to “Cautions and actions to deal with intense heat” on page 1-10
and “Cautions and actions to deal with intense cold” on page 1-12.
Charging is stopped by the regu-
lar charge timer.Charging will stop depending on the timer function setting of the regular
charge device. If you need to charge the main drive lithium-ion battery
more, start the charging procedure again.
Quick charging can-
not be started.The charge connector is not con-
nected correctly and/or not
locked.Check that the charge connector is connected correctly and that it is
locked.
The self-diagnostic function of
the quick charge device returns a
negative result.There is a possibility that the vehicle has a malfunction. Stop charging
and contact a certified i-MiEV dealer.
The power switch of the quick
charger is off.Check the power switch of the quick charger.
Symptom
Possible cause
Possible solution
BK0140800US.book 39 ページ ２０１１年９月２９日　木曜日　午後３時２８分

1-40 General information/Charging
1
Quick charge is dis-
continued.Charging is stopped by the quick
charge timer.Charging will stop depending on the timer function setting of the quick
charge device.If you need to charge the main drive lithium-ion battery
more, start the charging procedure again.
Charging stops at 80% capacity. Charging is designed to stop when the main drive lithium-ion battery
capacity reaches 80%. If you need to charge the main drive lithium-ion
battery more than 80%, start the charging procedure again.
The power supply for the quick
charger is off.Check whether the power supply for the quick charger is off.
Symptom
Possible cause
Possible solution
BK0140800US.book 40 ページ ２０１１年９月２９日　木曜日　午後３時２８分

General information/Charging
1-41
1 High-Voltage components
N01205700014
High voltage components and wiring cables are located as
shown in the figure below.
WA R N I N G
!
The EV (Electric Vehicle) system uses high voltage
up to DC 330 volt. The system can be hot during and
after starting and when the vehicle is shut off. Be
careful of both the high voltage and the high temper-
ature. Follow the warning labels that are attached to
the vehicle.
Never disassemble, remove or replace high-voltage
parts, cables or connectors. Failure to follow this
instruction can result in severe burns or electric
shock causing serious injury or death. High-voltage
cables are colored orange. The vehicle high voltage
system has no user serviceable parts. Take your
vehicle to a Certified i-MiEV dealer for any neces-
sary maintenance.
1- Regular charge port
2- MCU
3- Main drive lithium-ion battery
4- Heater
5- Air conditioner compressor
6- High voltage connector
7- Service plug
8- Electric motor (Electric motor unit)
9- On board charger/DC-DC converter
10- Quick charge port
BK0140800US.book 41 ページ ２０１１年９月２９日　木曜日　午後３時２８分

1-42 General information/Charging
1
In case of a collision
N01205800015
In case of a collision, follow the instructions described below
to avoid severe burns and electrical shock that may result in
serious injury or death.
WA R N I N G
!
If your vehicle is drivable, pull your vehicle off the
road in a safe place, move the selector lever to the P
(PARK) position, apply the parking brake and turn
the electric motor switch to the lock position.
Never touch high-voltage wiring, connectors, and
other high-voltage parts, such as inverter unit and
main drive lithium-ion battery. An electric shock
may occur if exposed electric wires are visible when
viewed from inside or outside of your vehicle. For
their locations, see “High-voltage components” on
page 1-41.
If the vehicle receives a strong impact to the floor
while driving, stop the vehicle in a safe place and
check the floor.
Leaks or damage to the main drive lithium-ion bat-
tery may result in a fire. If you discover them, con-
tact emergency services immediately. Since the fluid
leak may be lithium manganite from the Lithium-
ion battery, never touch a fluid leak inside or outside
the vehicle. If the fluid contacts your skin or eyes,
wash it off immediately with a large amount of
water and receive immediate medical attention to
help avoid serious injury.

If a fire occurs in this vehicle, leave the vehicle as
soon as possible. Only use a type ABC, BC or C fire
extinguisher that is meant for use on electrical fires.
Using water or the incorrect fire extinguisher can
result in serious injury or death from electrical
shock.
If your vehicle needs to be towed, transport the vehi-
cle on a flatbed truck or tow the vehicle either with
all wheels or the rear wheels (drive wheels) off the
ground. If the rear wheels are on the ground when
towing, this may cause damage to the electric
motors. Also this may cause a fire, if wiring in the
electric motor unit room becomes damaged. Refer to
“Towing” on page 6-19.
If you are not able to safely assess the vehicle due to
vehicle damage, do not touch the vehicle. Leave the
vehicle and contact emergency services. Advise
emergency responders that this is an electric vehicle.
In the event of an accident that requires body repair
and painting, the vehicle should be delivered to a
Certified i-MiEV dealer to have the main drive lith-
ium-ion battery and high voltage parts such as the
inverter, including the wiring harness, removed
prior to painting. The main drive lithium-ion bat-
tery when exposed to heat in the paint booth will
experience battery capacity loss.
A damaged main drive lithium-ion battery can also
pose safety risks to untrained mechanics and repair
personnel.
WA R N I N G
!
BK0140800US.book 42 ページ ２０１１年９月２９日　木曜日　午後３時２８分

General information/Charging
1-43
1
NOTE
The emergency shut-off system will be activated and the
high-voltage system will automatically turn off under the
following conditions:
• Front and side collisions in which the air bags are
deployed.
• Certain rear collisions.
• Certain EV (Electric Vehicle) system malfunctions

When the emergency shut-off system is activated, the
ready indicator is turned off. Refer to “Indicator and warn-
ing light package” on page 3-71.

If the emergency shut-off system activates, contact a Cer-
tified i-MiEV dealer.
MiEV Remote System
(if so equipped)
N01203400017
The MiEV Remote System has the following three functions.

Charging Timer
When the EV charging cable (regular charger) (Level 1
or Level 2) is connected, the batteries will only charge
during the pre-set time period selected using the MiEV
Remote.

Remote Climate Control
When the EV charging cable (regular charger) (Level 1
or Level 2) is connected, the air-conditioner can be acti-
vated for up to 30 minutes prior to vehicle usage. This
feature can be used to cool or heat the car and to acti-
vate the front and rear window defroster.

Main Drive Lithium-ion Battery Level Indicator
The charge remaining in the Main Drive Lithium-ion
Battery can be confirmed through the MiEV Remote.
MiEV
Remote
Glass antenna
BK0140800US.book 43 ページ ２０１１年９月２９日　木曜日　午後３時２８分

General information/Charging
1-47
1
Display1_ The indicator blinks during communication with the vehicle.
If a communication error occurs, the indicator blinks rapidly.
2_ The indicator lights up during charging. The indicator blinks
when the manual charging button is pressed. The indicator
will rapidly blink, if EV charging cable (regular charger) is
not connected when the Charging Timer or Remote Climate
Control is set.
3_ When communicating with the vehicle, the MiEV Remote
display blinks if a communication error occurs or the MiEV
Remote is not functioning properly. If the buzzer sounds
while this indicator blinks, a problem has been detected.
Refer to “Actions to be taken when the MiEV Remote sys-
tem does not operate correctly” on page 1-67.
NOTE
The buzzer can be turned off. Refer to “To turn on/off
melody and buzzer” on page 1-63.
4_ The indicator shows the charge status of the Main Drive
Lithium-ion Battery using dots. When the Remote Climate
Control is set, the indicator will blink if the Main
Drive Lithium-ion Battery is empty on charge.NOTE
The condition of the MiEV Remote's battery is not dis-
played.
5_
: When this is shown, time set by ON timer is shown
on 6.
: When this is shown, time set by OFF timer is
shown on 6.
6_ Time set by ON timer or OFF timer is shown.
7_ When the Remote Climate Control is set, the display lights
up.
COOL: Pre-Cooling Mode
HEAT: Pre-Heating Mode
: Pre-Defroster Mode
A/C OFF: Remote Climate Control OFF
BK0140800US.book 47 ページ ２０１１年９月２９日　木曜日　午後３時２８分

1-48 General information/Charging
1
Charging Timer
N01203700010
The Charging Timer can be set as follows.

ON timer: Time from the present to when charging will
begin.

OFF timer: Time from the start of charging to the end of
charging
To set the timer, the following conditions must be met.

Selector lever: “P” (PARK) position

Electric motor switch: “LOCK”position

EV charging cable (regular charger): ConnectedNOTE
Charging Timer cannot be used with a quick charging sys-
tem. (if so equipped)
CAUTION
!
Never leave the MiEV Remote in place where it will
be subject to high temperatures, such as in direct
sunlight, or subject to extreme low temperatures.
The MiEV Remote can be damaged and may not
properly operate.
Never drop or hit the MiEV Remote. Do not apply
force to bend the antenna. These can cause damage
to or failure of the remote.
If the MiEV Remote gets wet, please wipe water off
immediately. Water entering the MiEV Remote can
cause a failure.
WA R N I N G
!
Improper charging can result in a fire, property
damage, and serious injury or death.
Before Charging Timer, carefully read and follow
the instructions in “Precaution on Charging the
Main Drive Lithium-ion Battery” on page 1-18 and
“Regular charging (charging method with rated AC
120 V outlet)” on page 1-20.
BK0140800US.book 48 ページ ２０１１年９月２９日　木曜日　午後３時２８分

General information/Charging
1-55
1
3. Press the UP switch (C) or the DOWN switch (D) once.
The time set last time for the OFF timer will be displayed
and blink.
4. If you need to change the time for the OFF timer, press the
UP switch (C) or the DOWN switch (D) to change the
time.
• The time can be changed within the range from 0.5h to
19.5h by half hour and can be changed to “-h”.
• When “-h” is displayed, the charging will end when
Main Drive Lithium-ion Battery is fully charged.NOTE
To display “-h”, press the UP switch (C) when 19.5h is
displayed or press DOWN switch (D) when 0.5h is dis-
played.5. Press the power/communication switch (B) for less than 1
second to send the setting data to the vehicle.
The MiEV Remote will sound melodies on transmission
and reception.
NOTE
The melodies can be turned off. Refer to “To turn on/off
melody and buzzer” on page 1-63.

If a communication error occurs or the MiEV Remote
System is not functioning properly, the buzzer will sound.
Refer to “Display of MiEV Remote during communicat-
ing with vehicle” on page 1-57.

If the ON timer is unset when setting the OFF timer, the
ON timer will be automatically set with “0h”.
6. Turn off the MiEV Remote. Refer to “To turn the MiEV
Remote ON/OFF” on page 1-50.
BK0140800US.book 55 ページ ２０１１年９月２９日　木曜日　午後３時２８分