2010 JAGUAR XFR Engine

Published: 17-Apr-2014
General Information - Diagnostic Trouble Code (DTC) Index Vehicles With:
6HP28 6-Speed Automatic Transmission, DTC: Transmission Control Module
(TCM)
Description and Operation

Transmission Control Module (TCM) 6 speed (6HP28 Applications)


CAUTION: Diagnosis by substitution from a donor vehicle is NOT acceptable. Substitution of control modules does not
guarantee confirmation of a fault, and may also cause additional faults in the vehicle being tested and/or the donor vehicle
NOTES:


If the control module or a component is suspect and the vehicle remains under manufacturer warranty, refer to the
warranty policy and procedures manual, or determine if any prior approval programme is in operation, prior to the installation
of a new module/component


Generic scan tools may not read the codes listed, or may read only 5-digit codes. Match the 5 digits from the scan tool to
the first 5 digits of the 7-digit code listed to identify the fault (the last 2 digits give extra information read by the
manufacturer-approved diagnostic system)


When performing voltage or resistance tests, always use a digital multimeter accurate to three decimal places and with a
current calibration certificate. When testing resistance, always take the resistance of the digital multimeter leads into account


Check and rectify basic faults before beginning diagnostic routines involving pinpoint tests


Inspect connectors for signs of water ingress, and pins for damage and/or corrosion


If diagnostic trouble codes are recorded and, after performing the pinpoint tests, a fault is not present, an intermittent
concern may be the cause. Always check for loose connections and corroded terminals


Where an 'on demand self-test' is referred to, this can be accessed via the 'diagnostic trouble code monitor' tab on the
manufacturers approved diagnostic system


Check DDW for open campaigns. Refer to the corresponding bulletins and SSMs which may be valid for the specific
customer complaint and carry out the recommendations as needed

The table below lists all diagnostic trouble codes (DTCs) that could be logged in the transmission control module, for
additional diagnosis and testing information refer to the relevant diagnosis and testing section
For additional information, refer to: Diagnostics (307-01 Automatic Transmission/Transaxle - V8 5.0L Petrol/V8 S/C 5.0L Petrol,
Diagnosis and Testing).

DTC Description Possible Causes Action P0121-86 Throttle/Pedal Position
Sensor A Circuit
Range/Performance -
Signal invalid
Throttle/Pedal Position
Sensor Fault (Data
received over CAN Bus)
Check Engine Control Module for stored DTCs P0219-86
Engine Overspeed
Condition - Signal invalid
Engine speed too low or
too high (Data received
over CAN Bus)
Check Engine Control Module for stored DTCs P0500-81
Vehicle Speed Sensor A -
Invalid serial data
received
Vehicle Speed Sensor
fault (Data received over
CAN Bus)
Check Dynamic Stability Control module for stored
DTCs P0501-81 Vehicle Speed Sensor A
Vehicle Speed receive
Check Dynamic Stability Control module for stored Range/Performance - Invalid serial data over CAN Bus does not DTCs. Check correct Differential is installed to the received match Transmission vehicle Output-Shaft speed

DTC Description Possible Causes Action P0561-1C System Voltage Unstable
- Circuit voltage out of
range
Power supply voltage out
of range when engine
running
Check Engine Control Module for stored DTCs.
Check Charging System and Battery condition P0562-21
System Voltage Low -
Signal amplitude <
minimum
Circuit low voltage.
Battery supply voltage to
Transmission Control
Module
Refer to Circuit diagrams and check Power and
Ground Circuit for fault. Check Engine Control
Module for stored DTCs. Check Charging System
and Battery condition P0563-22
System Voltage High -
Signal amplitude >
maximum
High Battery charge,
alternator fault
Check Engine Control Module for stored DTCs.
Check Charging System and Battery condition P0601-41
Internal Control Module
Memory Check Sum Error
- General checksum
failure
Software error
Transmission Control
Module failure
Re-configure the Transmission Control Module
using the manufacturer approved diagnostic
system, clear DTC and re-test. If DTC remains,
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0604-00
Internal Control Module
Random Access Memory
(RAM) Error - No sub type
information
Shift-by-Wire fault
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0605-41
Internal Control Module
Read Only Memory (ROM)
Error - General checksum
failure
General checksum failure
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0606-04 TCM Processor - System
Internal Failures
Micro controller
component faults
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0606-26 TCM Processor - Signal
rate of change below
threshold
Micro controller
component faults
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0606-49 TCM Processor - Internal
electronic failure
Micro controller
component faults
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0613-04 TCM Processor - System
Internal Failures
Micro controller
component faults
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0613-06 TCM Processor -
Algorithm Based Failures
Micro controller
component faults
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0613-11 TCM Processor - Circuit
Short to Ground
Watchdog fault
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. P0613-12 TCM Processor - Circuit
Short to Battery
Watchdog fault
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect.

DTC Description Possible Causes Action U0100-82
Lost Communication With
ECM/PCM "A" - Alive /
sequence counter
incorrect / not updated
Alive counter fault
Check Engine Control Module for stored DTCs U0100-83
Lost Communication With
ECM/PCM "A" - Value of
signal protection
calculation incorrect
Checksum fault
Check Engine Control Module for stored DTCs U0100-87
Lost Communication With
ECM/PCM "A" - Missing
message
CAN Timeout
NOTE: Do NOT install a new Engine Control Module
if an Engine Control Module Timeout DTC is only logged in
the Transmission Control Module, the failure is NOT with
the Engine Control Module

Check Engine Control Module for stored DTCs.
Check CAN Bus Circuit for fault U0103-82
Lost Communication With
Gear Shift Control Module
A - Alive / sequence
counter incorrect / not updated
Alive counter fault
Check Transmission Shift Module for stored DTCs.
Check CAN Bus Circuit for fault U0103-83
Lost Communication With
Gear Shift Control Module
A - Value of signal
protection calculation
incorrect
Checksum fault
Check Transmission Shift Module for stored DTCs.
Check CAN Bus Circuit for fault U0103-87
Lost Communication With
Gear Shift Control Module
A - Missing message
CAN Timeout
Check Transmission Shift Module for stored DTCs.
Check CAN Bus Circuit for fault U0122-82
Lost Communication With
Vehicle Dynamics Control
Module - Alive /
sequence counter
incorrect / not updated
Alive counter fault
Check Dynamic Stability Control (ABS) for stored
DTCs. Check CAN Bus Circuit for fault U0122-83
Lost Communication With
Vehicle Dynamics Control
Module - Value of signal
protection calculation
incorrect
Checksum fault
Check Dynamic Stability Control (ABS) for stored
DTCs. Check CAN Bus Circuit for fault U0122-87
Lost Communication With
Vehicle Dynamics Control
Module - Missing message
CAN Timeout
Check Dynamic Stability Control (ABS) for stored
DTCs. Check CAN Bus Circuit for fault U0126-00
Lost Communication With
Steering Angle Sensor
Module - No sub type
information
Lost Communication With
Steering Angle Sensor
Module
Check SAS for stored DTCs. Check CAN Bus Circuit
for fault U0128-87
Lost Communication With
Park Brake Control
Module - Missing message
CAN timeout electronic
parking brake module
Check Electronic Parking Brake Module (EPB) for
stored DTCs. Check CAN Bus Circuit for fault U0140-82
Lost Communication With
Body Control Module -
Alive / sequence counter
incorrect / not updated
Alive counter fault
Check Central Junction Box for stored DTCs. Check
CAN Bus Circuit for fault U0140-83
Lost Communication With
Body Control Module -
Value of signal protection
calculation incorrect
Checksum fault
Check Central Junction Box for stored DTCs. Check
CAN Bus Circuit for fault U0140-87
Lost Communication With
Body Control Module -
Missing message
CAN Timeout
Check Central Junction Box for stored DTCs. Check
CAN Bus Circuit for fault U0155-87
Lost Communication With
Instrument Panel Cluster
(IPC) Control Module - Missing message
CAN timeout instrument
cluster
Check Instrument Cluster for stored DTCs. Check
CAN Bus Circuit for fault U0300-68
Control Module - Event
information
Transmission software
does not match vehicle
network
Check Central Junction Box software level, Check
Transmission Control Module Software level,
Update software as required using the
manufacturer approved process

DTC Description Possible Causes Action U0401-08
Invalid Data Received
From ECM/PCM A - Bus
Signal Message Failures
Inaccurate engine speed,
torque information
Check Engine Control Module for stored DTCs,
Check CAN Bus circuit for faults U0401-68
Invalid Data Received
from ECM/PCM A - Event
information
Inaccurate engine speed,
torque information
Check Engine Control Module for stored DTCs.
Check CAN Bus Circuit for fault U0401-86
Invalid Data Received
from ECM/PCM A - Signal
Invalid
Inaccurate engine speed,
torque information
Check Engine Control Module for stored DTCs.
Check CAN Bus Circuit for fault U0404-68
Invalid Data Received
from Gear Shift Control
Module A - Event
information
Incorrect CAN data
received from
Transmission Shift
Module
Check Transmission Shift Module for stored DTCs.
Refer to Circuit diagrams and check CAN and LIN
Bus for Circuit fault U0404-81
Invalid Data Received
from Gear Shift Control
Module A - Invalid Serial
Data Received
Incorrect LIN data
received from
Transmission Shift
Module
Check Transmission Shift Module for stored DTCs.
Refer to Circuit diagrams and check CAN and LIN
Bus for Circuit fault U0416-68
Invalid Data Received
From Vehicle Dynamics
Control Module - Event
information
Event information brake
information
Check Engine Control Module for stored DTCs.
Check CAN Bus Circuit for fault U0422-68
Invalid Data Received
From Body Control
Module - Event
information
Event information invalid
Power mode information
Check Central Junction Box for stored DTCs. Check
CAN Bus Circuit for fault U101B-87
Lost Communication With
GSM - Multiple Bus -
Missing message
Missing message lost
communication with
Transmission Shift
Module (multiple Bus)
Check Transmission Shift Module for stored DTCs.
Refer to Circuit diagrams and check CAN and LIN
Bus for Circuit fault U3000-49
Control Module - Internal
electronic failure
Internal electronic failure
Suspect the Transmission Control Module. Install a
new Transmission Control Module as required,
refer to the warranty policy and procedures manual
if a module/component is suspect. U3000-4B
Control Module - Circuit
resistance above
threshold
Internal electronic failure
Check and correct oil level. Check hydraulic flow
through oil cooler and pipe circuit for restriction or
blockage. If no restrictions found, suspect the
Transmission Control Module. Install a new
Transmission Control Module as required, refer to
the warranty policy and procedures manual if a
module/component is suspect. U3000-81
Control Module - Invalid
serial data received
Vehicle or Engine type
signal incorrect from
Central Junction Box or
incorrect Transmission
Control Module software
installed
Reflash the Transmission Control Module using the
manufacturer approved process U3001-94
Control Module Improper
Shutdown - Unexpected
operation
Control Module Improper
Shutdown (voltage
related)
Check Engine Control Module For Power
(alternator) faults. Check Power and Ground
Circuit and Battery for fault. Clear DTCs. Road
Test. If DTC reoccurs suspect the Transmission
Control Module. Install a new Transmission Control
Module as required, refer to the warranty policy
and procedures manual if a module/component is
suspect.

Body Code - All except USA and Canada - 2010 and 2011 model years

VIN Position 4
VIN Code Description 05 Luxury 06 Premium luxury 07 Sport luxury/Portfolio/SV8 08 'R' Body Code (USA and Canada) 2010 and 2011 model years

VIN Position 4
VIN Code Description 0F Luxury 0G Premium luxury 0H Portfolio/SV8 0J 'R'
Body Code - All except USA and Canada - 2012 model year

VIN Position 4
VIN Code Description 04 Entry 05 Luxury 06 Premium luxury 07 Sport luxury/Portfolio/SV8 08 'R' 85 Luxury+speedpack 86 Premium luxury+speedpack 87 Sport luxury/Portfolio/SV8+speedpack 88 'R' + speedpack Body Code (USA and Canada) 2012 model year

VIN Position 4
VIN Code Description 0F Luxury 0G Premium luxury 0H Portfolio/SV8 0J 'R' 8E Luxury+speedpack 8F Premium luxury+speedpack 8G Sport luxury/Portfolio/SV8+speedpack 8H 'R' + speedpack Engine Emission System - 2009 model year

VIN Position 5
NOTES:


*1 EU. Includes the following markets; Austria, Belgium, Bulgaria, Cyprus, Czech Rep, Denmark, Eire, Estonia, Finland,
France, Germany, Greece, Holland, Hungary, Italy, Latvia, Lithuania, Luxembourg, Malta, Poland, Portugal, Romania, Slovenia,
Slovakia, Spain (incl. Canary Islands), Sweden and UK.


*2 East Europe. Includes the following markets; Albania, Bosnia, Croatia, Former Yugoslav Republic of Macedonia,
Kosovo, Montenegro and Serbia.


*3 Russia. Includes the following markets; Belarus, Kazakhstan, Ukraine and Uzbekistan.


*4 Middle East. Includes the following markets; Abu Dhabi, Bahrain, Dubai, Jordan, Kuwait, Lebanon, Oman, Qatar and
Saudi Arabia.


*5 Caribbean. Includes the following markets; Bahamas, Barbados, Grand Cayman, Grenada and Trinidad and Tobago.

VIN
Code
Engine
Market D 3.0L
*5 Caribbean, Chile, Dominican Rep, Guatemala, Indonesia, Malaysia, *4 Middle East, Morocco,
Panama, Phillipines, Singapore, Sri Lanka and Uruguay F 4.2L

VIN
Code
Engine
Market G 4.2L
Supercharged N/A 2.7L Diesel M 3.0L
China N/A 4.2L N/A 4.2L
Supercharged N/A 2.7L Diesel M 3.0L
*2 East Europe, *1 EU, Israel, Norway, *3 Russia, Switzerland and Turkey P 4.2L R 4.2L
Supercharged 1 2.7L Diesel W 3.0L
Brazil X 4.2L Y 4.2L
Supercharged N/A 2.7L Diesel S 3.0L
Egypt and Syria U 4.2L V 4.2L
Supercharged N/A 2.7L Diesel H 3.0L
Japan K 4.2L L 4.2L
Supercharged N/A 2.7L Diesel N/A 3.0L
USA B 4.2L C 4.2L
Supercharged N/A 2.7L Diesel N/A 3.0L
Canada B 4.2L C 4.2L
Supercharged N/A 2.7L Diesel N/A 3.0L
Mexico K 4.2L L 4.2L
Supercharged N/A 2.7L Diesel N/A 3.0L
South Korea B 4.2L C 4.2L
Supercharged 1 2.7L Diesel D 3.0L
South Africa F 4.2L G 4.2L
Supercharged 1 2.7L Diesel M 3.0L
Argentina, Australia, Cyprus, Hong Kong, Malta, New Zealand, Taiwan, Thailand and UK (and Eire) P 4.2L R 4.2L
Supercharged 1 2.7L Diesel Engine Emission System - 2010 model year

VIN Position 5
NOTES:


*1 EU. Includes the following markets; Austria, Belgium, Bulgaria, Cyprus, Czech Rep, Denmark, Eire, Estonia, Finland,
France, Germany, Greece, Holland, Hungary, Italy, Latvia, Lithuania, Luxembourg, Malta, Poland, Portugal, Romania, Slovenia,
Slovakia, Spain (incl. Canary Islands), Sweden and UK.


*2 East Europe. Includes the following markets; Albania, Bosnia, Croatia, Former Yugoslav Republic of Macedonia,

Kosovo, Montenegro and Serbia.


*3 Russia. Includes the following markets; Belarus, Kazakhstan, Ukraine and Uzbekistan.


*4 Middle East. Includes the following markets; Abu Dhabi, Bahrain, Dubai, Jordan, Kuwait, Lebanon, Oman, Qatar and
Saudi Arabia.


*5 Caribbean. Includes the following markets; Bahamas, Barbados, Grand Cayman, Grenada and Trinidad and Tobago.

VIN
Code
Engine
Market D 3.0L
Algeria, Brunei, *5 Caribbean, Dominican Rep, Guatemala, Indonesia, Libya, *4 Middle East, Morrocco,
Pakistan, Panama, Phillipines, Sri Lanka, Tunisia and Uruguay F 5.0L G 5.0L
Supercharged H 3.0L
China P 5.0L R 5.0L
Supercharged H 3.0L
Chile P 5.0L R 5.0L
Supercharged H 3.0L
Argentina P 5.0L R 5.0L
Supercharged H 3.0L
*1 EU, *2 East Europe, Israel, Norway, Switzerland and Turkey P 5.0L R 5.0L
Supercharged 2 3.0L Diesel W 3.0L
Brazil X 5.0L Y 5.0L
Supercharged S
3.0L - Egypt only Egypt and Syria F 5.0L G 5.0L
Supercharged H 3.0L
Japan P 5.0L R 5.0L
Supercharged A 4.2L
USA B 5.0L C 5.0L
Supercharged A 4.2L
Canada B 5.0L C 5.0L
Supercharged A 4.2L
Mexico B 5.0L C 5.0L
Supercharged B 5.0L
South Korea C 5.0L
Supercharged 2 3.0L Diesel H 3.0L
Malaysia P 5.0L R 5.0L
Supercharged D 3.0L
South Africa F 5.0L G 5.0L
Supercharged 2 3.0L Diesel

VIN
Code
Engine
Market H 3.0L
Taiwan P 5.0L R 5.0L
Supercharged 2 3.0L Diesel D 3.0L
Thailand F 5.0L G 5.0L
Supercharged D 3.0L
Singapore F 5.0L G 5.0L
Supercharged H 3.0L
Australia, Cyprus, Hong Kong, Malta, New Zealand and UK (and Eire) P 5.0L R 5.0L
Supercharged 2 3.0L Diesel Engine Emission System - 2011 model year

VIN Position 5
NOTES:


*1 EU. Includes the following markets; Andorra, Austria, Belgium, Bulgaria, Croatia, Cyprus, Czech Republic, Denmark,
Estonia, Finland, France, Germany, Greece, Hungary, India (gasoline only), Ireland, Italy, Latvia, Liechtenstein, Lithuania,
Luxembourg, Malta, Moldova, Monaco, Netherlands, Norway, Poland, Portugal, Romania, San Marino, Serbia, Slovakia, Slovenia,
Spain, Sweden, Switzerland, Turkey, UK; (Canary Islands, Azores, Madeira, Martinique, Guadeloupe, Reunion are included as
remote parts of sovereign states).


*2 With Diesel Particulate Filter (DPF), includes the following markets; Australia, Belarus, Gibraltar, Hong Kong, Iceland,
Israel, Korea (diesel), Macau, Morocco, New Zealand, Palestine, Singapore (diesel only), South Africa (Diesel), Taiwan, Tunisia.


*3 With-out DPF, includes the following markets; Argentina, Bermuda, Chile, China, Guadeloupe, India (diesel only),
Kazakhstan, Morocco, Ukraine, Russia.


*4 Rest Of World (ROW), includes the following markets; Barbados, Benin, Botswana, Burkina Faso, Burundi, Brunei,
Cameroon, Central African Republic, Chad, Congo, Costa Rica, Democratic Republic of Congo, Dominican Republic, Equatorial
Guinea, Ethiopia, Falklands, Fiji, Gabon, Gambia, Ghana, Guatemala, Guinea, Guinea Bissau, Guyana, Haiti, Honduras, Ivory
Coast, Lesotho, Liberia, Madagascar, Malawi, Mali, Mozambique, Mauritania, Namibia, New Caledonia, Niger, Panama, Papua
New Guinea, Rwanda, Sierra Leone, Singapore (gasoline only),Somalia, Swaziland, Tahiti, Tanzania, Togo, Trinidad & Tobago,
Uganda, Western Sahara, Zambia, Zimbabwe.


*5 Emergent World, With-out OBD, includes the following markets; Albania, Angola, Bolivia, Colombia, Ecuador, Georgia,
Indonesia, Jamaica, Kenya, Kyrgystan, Macedonia, Malaysia, Mauritius, Nigeria, Paraguay, Peru, Philippines, South Africa
(gasoline only), Sri Lanka, Turkmenistan, Uruguay, Uzbekhistan, Venezuela, Vietnam.


*6 Hot Climate, With-out OBD, includes the following markets; Algeria, Azerbaijan, Bahrain, Bangladesh for gasoline,
Bhutan, Dubai, Egypt, Iraq, Jordan, Kuwait, Lebanon (gasoline only), Libya, Oman, Pakistan, Qatar, Saudi Arabia, Sudan, Syria
(gasoline only), Thailand, Tunisia, United Arab Emirates, Yemen.
B 5.0L USA, Canada, Mexico and Korea C 5.0L Supercharged USA, Canada, Mexico and Korea D 3.0L *4 ROW, *5 Emergent World and *6 Hot Climate E 5.0L Supercharged USA, Canada, Mexico and Korea F 5.0L *4 ROW, *5 Emergent World and *6 Hot Climate G 5.0L Supercharged *4 ROW, *5 Emergent World and *6 Hot Climate H 3.0L #(*2 With DPF, *3 With-out DPF),* Japan and *1 EU J 5.0L Supercharged *1 EU, *2 With DPF, *3 With-out DPF and Japan K 5.0L Supercharged Brazil L 5.0L Supercharged *4 ROW, *5 Emergent World and *6 Hot Climate P 5.0L *1 EU, *2 With DPF, *3 With-out DPF and Japan R 5.0L Supercharged *1 EU, *2 With DPF, *3 With-out DPF and Japan W 3.0L Brazil X 5.0L Brazil