2009 DODGE RAM 3500 DIESEL flat tire

circle, tightening the nut opposite to the nut just previ-
ously tightened until final torque is achieved. Recom-
mended torques are shown in the following chart.Disc
WheelsType Nut Stud Size Torque
Ft. Lbs.Torque
Newton
Meters
Cone 9/16-18 120-150 160-200
Flanged 9/16-18 130-160 190-220To Stow The Flat Or Spare
WARNING!
A loose tire thrown forward in a collision or hard
stop could injure the occupants in the vehicle. Have
the deflated (flat) tire repaired or replaced immedi-
ately. Turn the wheel so that the valve stem is down. Slide the
wheel retainer through the center of the wheel and
position it properly across the wheel opening.
For convenience in checking the spare tire inflation, stow
with the valve stem toward the rear of the vehicle.
Attach the wheel wrench to the extension tube. Rotate the
winch mechanism until the wheel is drawn into place
against the underside of the vehicle. Continue to rotate
until you feel the winch mechanism slip, or click three or
four times. It cannot be overtightened. Push against the
tire several times to be sure it is firmly in place.
HOISTINGA conventional floor jack may be used at the jacking
locations. Refer to the graphics that show jacking loca-
tions. However, a floor jack or frame hoist must never be
used on any other parts or the underbody.
418 WHAT TO DO IN EMERGENCIES

Temperature GradesThe temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
508 IF YOU NEED CONSUMER ASSISTANCE

Towing............................. 422
Emission Control System Maintenance ......429,482
Engine ............................... 427
Air Cleaner .......................... 434
Block Heater ......................... 254
Break-In Recommendations ................ 73
Compartment Identification ............... 427
Coolant (Antifreeze) .................... 479
Exhaust Gas Caution .................. 74,379
Flooded, Starting ...................... 252
Fuel Requirements ..................... 478
Oil ........................... 431,478,479
Oil Filler Cap ......................... 432
Oil Selection ....................... 432,478
Oil Synthetic ......................... 433
Temperature Gauge .................... 190
Equipment Identification Plate .............. 403
Event Data Recorder ...................... 58
Exhaust Gas Caution ..............74,179,379,439Exhaust System
....................... 74,438
Exterior Lighting ........................ 134
Exterior Lights .......................... 76
Filters Air Cleaner .......................... 434
Engine Oil ........................ 433,479
Engine Oil Disposal .................... 433
Flashers Turn Signal ...................... 76,136,188
Flat Tire Stowage ..................... 408,418
Flooded Engine Starting ................... 252
Fluid, Brake ........................... 480
Fluid Capacities ......................... 478
Fluid Leaks ............................. 76
Fluid Level Checks Automatic Transmission ................. 450
Brake .............................. 447
Power Steering ........................ 328514 INDEX

HazardDriving Through Flowing, Rising, or Shallow
Standing Water ........................ 305
Hazard Warning Flasher ................... 406
Head Restraints ......................... 123
Headlights ............................ 465
Cleaning ............................ 456
High Beam .......................... 137
High Beam/Low Beam Select Switch ........ 137
Lights On Reminder .................... 135
Passing ............................. 137
Switch .............................. 134
Heated Mirrors ......................... 172
Heated Seats ........................... 129
Heater ............................... 237
Heater, Engine Block ..................... 254
High Beam/Low Beam Select (Dimmer) Switch . . 137
Hitches Trailer Towing ........................ 388 Hoisting
.............................. 418
HomeLink (Garage Door Opener) Transmitter . . . 153
Hood Release .......................... 130
Hub Caps ............................. 414
Ignition ............................... 12
Key ................................ 12
Ignition Key Removal ..................... 12
Illuminated Entry ........................ 20
Immobilizer (Sentry Key) ................... 15
Infant Restraint ........................ 60,61
Inflation Pressure Tires .................... 360
Inside Rearview Mirror .................... 82
Instrument Cluster .................... 186,188
Instrument Panel and Controls ...........184,185
Instrument Panel Lens Cleaning ............. 457
Integrated Power Module (Fuses) ............ 458
Interior Appearance Care .................. 455
Interior Lights .......................... 132516 INDEX

SteeringPower ........................... 327,328
Wheel Lock ........................... 14
Wheel, Tilt ........................... 140
Steering Wheel Mounted Sound System
Controls .............................. 231
Storage, Behind the Seat ................... 167
Storage Compartment, Center Seat .........167,169
Storage, Vehicle ......................... 463
Storing Your Vehicle ...................... 463
Sun Roof .............................. 159
Supplemental Tire Pressure Information ........ 360
Sway Control, Trailer ..................... 345
Synthetic Engine Oil ...................... 433
System, Navigation (uconnect gps).......... 224
System, Remote Starting .................... 25
Tachometer ............................ 189
Tailgate ............................... 178 Temperature Gauge, Engine Coolant
.......... 190
Tether Anchor, Child Restraint .............64,68
Tilt Steering Column ..................... 140
Tip Start .............................. 252
Tire and Loading Information Placard ......350,360
Tire Identification Number (TIN) ............. 349
Tire Markings .......................... 346
Tire Pressure Monitor System (TPMS) Placard
“HI” (MAX) Load Switch ...............184,185
Tire Safety Information .................... 346
Tires ............................ 76,354,506
Aging (Life of Tires) .................... 359
Air Pressure .......................... 354
Chains .............................. 361
Dual ............................ 365,416
General Information .................... 354
High Speed .......................... 356
Inflation Pressures ..................... 355
Jacking ............................. 409524 INDEX

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VAN CONVERSIONS/CAMPERS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
A WORD ABOUT YOUR KEYS Ignition Key RemovalLocking Doors With A KeySTEERING WHEEL LOCK - IF EQUIPPED To Manually Lock the Steering WheelTo Release the Steering Wheel LockAutomatic Transmission Ignition Interlock SystemSENTRY KEY Replacement
KeysCustomer Key ProgrammingGeneral InformationVEHICLE SECURITY ALARM - IF EQUIPPED Rearming of the SystemTo Set the AlarmTo Disarm the SystemILLUMINATED ENTRY SYSTEM - IF EQUIPPED REMOTE KEYLESS ENTRY (RKE) - IF EQUIPPED To
Unlock the DoorsTo Lock the DoorsUsing the Panic AlarmProgramming Additional RKE TransmittersGeneral InformationRKE Transmitter Battery ServiceREMOTE STARTING SYSTEM - IF EQUIPPED How to Use Remote StartDOOR LOCKS Manual Door LocksPower
Door Locks - If EquippedChild Protection Door LockWINDOWS Power Windows-If Equipped Wind BuffetingOCCUPANT RESTRAINTS Lap/Shoulder BeltsAdjustable Upper Shoulder Belt AnchorageAutomatic Locking Retractors (ALR) Mode - If EquippedCenter Lap Belts
Seat Belt Pretensioners - If EquippedEnhanced Seat Belt Use Reminder System (BeltAlert) Seat Belts and Pregnant WomenSeat Belt ExtenderDriver And Right Front Passenger Supplemental Restraint System (SRS) - Airbags Event Data Recorder (EDR)Child Restraints
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Transporting PassengersExhaust GasSafety Checks You Should Make Inside the VehiclePeriodic Safety Checks You Should Make Outside the VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE
MIRRORS Inside Day/Night MirrorAutomatic Dimming Mirror - If EquippedOutside MirrorsOutside Mirrors Folding FeaturePower Mirrors - If EquippedHeated Mirrors - If EquippedTrailer Towing Mirrors - If Equippeduconnect phone - IF EQUIPPED OperationPhone Call
Featuresuconnect phone FeaturesAdvanced Phone ConnectivityThings You Should Know About Your uconnect phoneGeneral InformationVOICE RECOGNITION (VR) SYSTEM - IF EQUIPPED Voice Recognition (VR) System OperationCommandsVoice TrainingSEATS
Manual Seat Adjuster - If EquippedReclining Seats (Quad Cab Models)Reclining Seats (2500/3500 Models)Adjustable Head RestraintsManual Lumbar Support - If EquippedPower Seats - If EquippedRear Seat FeaturesHeated Seats - If EquippedTO OPEN AND CLOSE
THE HOOD LIGHTS Interior LightsBattery SaverHeadlight DelayHeadlights, Parking Lights and Panel LightsDaytime Running Lights (Canada Only and Fleet Vehicles)Lights-on ReminderFog Lights - If EquippedCargo Light - If EquippedMultifunction LeverWINDSHIELD
WIPERS AND WASHERS Intermittent Wiper SystemWindshield WashersTILT STEERING COLUMN DRIVER ADJUSTABLE PEDALS - IF EQUIPPED AdjustmentELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set a Desired SpeedTo DeactivateTo Resume
SpeedTo Vary the Speed SettingTo Accelerate for PassingOVERHEAD CONSOLE - IF EQUIPPED Courtesy/Reading LightsOVERHEAD CONSOLE WITH COMPASS/TEMPERATURE MINI-TRIP COMPUTER - IF EQUIPPED US/M ButtonReset ButtonGlobal ResetStep
ButtonAverage Fuel Economy (AVG ECO)Distance To Empty (DTE)Trip Odometer (ODO)Elapsed Time (ET)C/T ButtonAutomatic Compass CalibrationManual Compass CalibrationRecalibrating The CompassOutside TemperatureGARAGE DOOR OPENER - IF EQUIPPED
Programming HomeLinkGate Operator/Canadian ProgrammingUsing HomeLinkReprogramming A Single HomeLink ButtonSecurityTroubleshooting TipsGeneral InformationPOWER SUNROOF - IF EQUIPPED Open Sunroof - Express ModeClosing Sunroof - ExpressPinch
Protect FeaturePinch Protect OverrideVenting Sunroof - ExpressSunshade OperationWind BuffetingSunroof MaintenanceSunroof Fully ClosedELECTRICAL POWER OUTLETS CIGAR LIGHTER AND ASH RECEIVER CUPHOLDERS Front Instrument Panel Cupholders
(40-20-40 Seats) - Automatic TransmissionFront Instrument Panel Cupholders (Bucket Seats)Rear Cupholder (Quad Cab) - If EquippedSTORAGE Center Storage Compartment (40-20-40 Seat) - If EquippedCenter Storage Compartment (Bucket Seats) - If EquippedStorage
and Seats (Quad Cab Models)Plastic Grocery Bag Retainers - If EquippedREAR WINDOW FEATURES Rear Window Defroster and Heated Outside Mirrors - If EquippedPower Sliding Rear Window - If EquippedSliding Rear Window - If EquippedFOLD FLAT LOAD FLOOR
- IF EQUIPPED PICKUP BOX SLIDE-IN CAMPERS Camper ApplicationsEASY-OFF TAILGATE UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES RAM TRUCK POWER WAGON INSTRUMENT CLUSTER - BASE INSTRUMENT
CLUSTER - PREMIUM INSTRUMENT CLUSTER DESCRIPTION ELECTRONIC DIGITAL CLOCK Clock Setting ProcedureSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO), uconnect phone, AND VIDEO
ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperation Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperation Instructions - (CD Mode for MP3 Audio
Play)LOAD/EJECT Button (CD Mode for MP3 Play)SALES CODE REF - AM/FM/CD (SINGLE-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO) AND uconnect phone CAPABILITY Operating Instructions - Radio ModeOperating Instructions - CD Mode
Operating Instructions - Auxiliary ModeOperating Instructions - uconnect phone - If EquippedOperating Instructions - uconnect studios (Satellite Radio) - If EquippedSALES CODE REC - AM/FM/CD (6-DISC) RADIO WITH uconnect gps (NAVIGATION) Operating Instructions
- uconnect studios (Satellite Radio) - If EquippedREC Setting the Clockuconnect studios (SATELLITE RADIO) - IF EQUIPPED System ActivationElectronic Serial Number/Sirius Identification Number (ESN/SID)Selecting uconnect studios (Satellite) Mode in REF, RAQ, And
RAK RadiosSelecting A ChannelStoring And Selecting Preset ChannelsUsing The PTY (Program Type) Button - If EquippedPTY Button SCANPTY Button SEEKSatellite AntennaReception QualityVIDEO ENTERTAINMENT SYSTEM (VES) - IF EQUIPPED REMOTE SOUND
SYSTEM CONTROLS - IF EQUIPPED Radio OperationCD PlayerCD/DVD MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE CONTROLS Heater Only - If Equipped Air Conditioning and Heating - If Equipped Air Conditioning with Dual Zone
Temperature Control - If EquippedOperating TipsOperating Tips Chart STARTING AND OPERATING STARTING PROCEDURES Normal StartingAutomatic TransmissionIf Engine Fails To StartAfter StartingENGINE BLOCK HEATER - IF EQUIPPED AUTOMATIC
TRANSMISSION Automatic Transmission with OverdriveFOUR-WHEEL DRIVE OPERATION - IF EQUIPPED Manually Shifted Transfer Case Operating Information/PrecautionsShifting Procedure - Manually Shifted Transfer Case Transfer Case Position Indicator Light
Electronically Shifted Transfer Case Operating Information/Precautions (Five Position Switch) - If EquippedShifting Procedure - Electronically Shifted Transfer CaseElectronically Shifted Transfer Case Operating Information/Precautions (Four Position Switch) - If Equipped
Shifting Procedure - Electronically Shifted Transfer CaseAXLE LOCKER SYSTEM - POWER WAGON ONLY STABILIZER/SWAY BAR SYSTEM - POWER WAGON ONLY SAFE OFF-ROAD DRIVING - POWER WAGON ONLY Off-Road Driving Tips and Vehicle
CharacteristicsDriving In Snow, Mud And SandCrossing Obstacles (Rocks And Other High Points)Hill ClimbingDriving Through WaterAiring Down For Off-Road DrivingVehicle RecoveryAfter Driving Off-RoadLIMITED-SLIP DIFFERENTIAL - IF EQUIPPED DRIVING ON
SLIPPERY SURFACES DRIVING THROUGH WATER Flowing/Rising WaterShallow Standing WaterDRIVING OFF-ROAD - RAM TRUCK ONLY WINCH USAGE - IF EQUIPPED (POWER WAGON ONLY) Things To Know Before Using Your WinchUnderstanding The Features
Of Your Winch Winch AccessoriesOperating Your WinchRigging TechniquesPOWER STEERING Power Steering Fluid CheckPARKING BRAKE BRAKE SYSTEM 3500 Dual Rear Wheel Models OnlyFour-Wheel Anti-Lock Brake SystemELECTRONIC BRAKE CONTROL
SYSTEM - IF EQUIPPED Anti-Lock Brake System (ABS)Traction Control System (TCS)Brake Assist System (BAS)Hill Start Assist (HSA)Electronic Roll Mitigation (ERM)Electronic Stability Program (ESP)TSC (Trailer Sway Control)TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresTire Pressures for High Speed OperationRadial Ply TiresTire SpinningTread Wear IndicatorsLife of TireReplacement TiresSUPPLEMENTAL
TIRE PRESSURE
INFORMATION - IF EQUIPPED TIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS Dual Rear Wheels TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED Tire Pressure Monitor System (TPMS) Tire Light Load Inflation Switch Description
- If EquippedTire Pressure Monitor System ComponentsGeneral InformationFUEL REQUIREMENTS Reformulated GasolineGasoline/Oxygenate BlendsE-85 Usage In Non-Flex Fuel VehiclesMMT In GasolineMaterials Added To FuelFuel System CautionsCarbon Monoxide
WarningsADDING FUEL Loose Fuel Filler Cap (Gas Cap) MessageVEHICLE LOADING Certification LabelTRAILER TOWING Common Towing DefinitionsTrailer Hitch ClassificationTrailer Towing Weights (Maximum Trailer Weight Ratings)Trailer and Tongue WeightTowing
RequirementsTowing TipsSNOWPLOW RECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Recreational Towing - Two-Wheel Drive ModelsRecreational Towing - Four-Wheel Drive ModelsEQUIPMENT IDENTIFICATION PLATE WHAT TO DO IN EMERGENCIES
HAZARD WARNING FLASHER JACKING INSTRUCTIONS Jack LocationRemoving The Spare TireTire Changing ProcedurePreparationsInstructionsHub Caps/Wheel CoversHOISTING JUMP-STARTING PROCEDURES FREEING A STUCK VEHICLE EMERGENCY TOW
HOOKS - IF EQUIPPED TOWING A DISABLED VEHICLE 4-Wheel Drive Vehicles2-Wheel Drive VehiclesMAINTAINING YOUR VEHICLE ENGINE COMPARTMENT- 5.7L ONBOARD DIAGNOSTIC SYSTEM (OBD II) Loose Fuel Filler Cap MessageEMISSIONS
INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS DEALER SERVICE MAINTENANCE PROCEDURES Engine OilEngine Oil FilterEngine Air Cleaner FilterMaintenance-Free BatteryAir Conditioner MaintenanceFront Prop Shaft Lubrication -
2500/3500 (4X4) ModelsBody LubricationWindshield Wiper BladesAdding Washer FluidExhaust SystemCooling SystemBrake SystemRear Axle And 4x4 Front Driving Axle Fluid LevelTransfer CaseAutomatic TransmissionAppearance Care and Protection from Corrosion
FUSES Integrated Power ModuleVEHICLE STORAGE REPLACEMENT LIGHT BULBS BULB REPLACEMENT Headlight (Halogen)/Front Park and Turn LightsFog LightsTail, Stop, Turn and Backup LightsCenter High-Mounted Stoplight (CHMSL) With Cargo LightCab Top
Clearance Lights - If EquippedTailgate ID Lights (Dual Rear Wheels) - If EquippedRear Light Bar ID Marker (Dual Rear Wheel) - If EquippedSide Marker Lights (Dual Rear Wheels) FLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS EngineChassis
MAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM MAINTENANCE MAINTENANCE SCHEDULE Required Maintenance IntervalsIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For
The AppointmentPrepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE Chrysler LLC Customer CenterChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service Contract
WARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES
TreadwearTraction GradesTemperature GradesINDEX