2004 MITSUBISHI L200 brake fluid

MAINTENANCE
Power steering fluid*EM09A-Jd
Check the fluid level in the reservoir while
the engine is idling.
Unscrew the reservoir cap; the level in this
tank should be kept between the “MAX”
and “MIN” lines.
Use “ATF DEXRON III or DEXRON II”.To replace the fluid
Recommended brake fluid conforming to
DOT 3 or DOT 4 should be used.
The reservoir cap must be fully tightened
to avoid contamination from foreign matter
or moisture.
DO NOT ALLOW PETROLEUM-BASED
FLUID TO CONTACT, MIX WITH, OR
OTHERWISE CONTAMINATE THE
BRAKE FLUID. SEAL DAMAGE WILL
RESULT.
WARNINGTake care in handling brake fluid as
it is harmful to the eyes and may
also cause damage to painted sur-
faces. Wipe up any spills immedi-
ately.
Clutch fluid*EM10A-Eg
To check the clutch fluid
The clutch fluid in the master cylinder
should be checked when performing other
underhood services. In addition, the sys-
tem should be checked for leakage at the
same time.
Check to make certain that the clutch fluid
level is always between the MAX and MIN
level markings on the fluid reservoir and
refill the fluid, if necessary.
A rapid fluid loss indicates a leak in the
clutch system which should be inspected
by your authorized MITSUBISHI dealer
and repaired immediately.
9-9
M10A004M09A005
09engL2_240082_4 22-01-2004 13:13 Page 9-9

SPECIFICATIONS
*: Optional equipment
10-26

No.
ItemQuantityRecommended lubricants
1 Brake fluid As required Brake fluid DOT 3 or DOT 4
2 Clutch fluid As required Brake fluid DOT 3 or DOT 4
3 Engine coolant2500 models2WD 7.7 litres
DIA QUEEN SUPER LONG LIFE COOLANT or equivalent
[Includes 0.65 litre in the reserve tank] 4WD 7.8 litres
2400 models 7.7 litres
4 Automatic transmission fluid2WD 7.3 litres
ATF DEXRON II
4WD 7.7 litres
5 Manual transmission oilDiesel-powered vehicles 2.5 litres
Gear oil API classification GL-4, SAE 75W-85W or 75W-90
Petrol-powered vehicles 2.2 litres
6 Engine oilDiesel-powered
vehicles2WDOil pan 5.0 litres
Refer to page 9-2 Oil filter 0.8 litre
Oil cooler 0.4 litre
4WDOil pan 6.3 litres
Oil filter 0.8 litre
Oil cooler 0.4 litre
Petrol-powered vehiclesOil pan 4.0 litres
Oil filter 0.3 litre
7 Power steering fluid* As required ATF DEXRON III or DEXRON II
8 Washer fluid 5.0 litres –
9 Refrigerant (air conditioning)* 550 - 600 g HFC-134a
10 Differential oilFront 0.9 litreWithout limited slip differential:
Hypoid gear oil API classification GL-5 or higher
Above 10°C SAE 90
Below 10°C SAE 80W
With limited slip differential*:
DIA QUEEN LSD gear oil or CASTROL HYPOY LS
(Hypoid gear oil API classification GL-5 SAE 90) Rear2WD 1.6 litres
4WD 2.6 litres
11 Transfer oil 2.3 litres
Hypoid gear oil API classification GL-4 SAE 75W-85W or 75W-90
10engL2_240082_4 22-01-2004 13:14 Page 10-26

INDEX
4WD indication lamp
(4-wheel drive vehicles) .......................... 5-22
Accessory boxes ....................................... 6-35
Accessory (Installation) ............................. 1-13
Additional equipment ................................. 9-17
Antenna (Pillar antenna) ............................ 6-18
Anti-lock brake system (ABS) .................... 5-33
Armrest ........................................................ 3-7
Ashtray ...................................................... 6-34
Audio system
Anti-theft system ..................................... 6-15
Automatic air conditioning ......................... 6-25
Automatic transmission
Fluid .......................................................... 9-4
Possible driving speed ............................ 5-19
Selector positions.................................... 5-17
Warning lamp ............................................ 4-8
Battery ......................................................... 9-6
Charge warning lamp ................................ 4-8
Discharged battery
(Emergency starting) ............................ 8-27
Bonnet ......................................................... 2-7
Brake system
Anti-lock brake ........................................ 5-33
Braking .................................................... 5-32
Fluid .......................................................... 9-8
Parking brake .......................................... 5-30
Pedal free play ........................................ 9-14
Warning lamp ............................................ 4-9
Bulb capacity, replacement ....................... 8-34Door-ajar warning lamp ............................... 4-7
Doors ........................................................... 2-4
Central door locks ..................................... 2-7
Child protection ......................................... 2-6
Lock and unlock ........................................ 2-4
Economical driving ...................................... 5-6
Electric remote-controlled
outside rear-view mirrors ........................ 5-38
Electric window control ................................ 2-9
Electronic immobilizer.................................. 2-2
Emergency starting.................................... 8-27
Engine number .......................................... 10-2
Engine
Coolant...................................................... 9-5
Number ................................................... 10-2
Oil .............................................................. 9-2
Used oil ................................................... 1-16
Exterior and interior lamp operation .......... 9-14
Fluid
Automatic transmission fluid ..................... 9-4
Brake fluid ............................................. 10-26
Clutch fluid ..................................... 9-9, 10-26
Manual transmission fluid ..................... 10-26
Power steering fluid ....................... 9-9, 10-26
Washer fluid ............................................ 9-10
Fuel filter indication lamp ............................. 4-9
Fuel
Capacity /(Filling the fuel tank).................. 5-3
Fuel gauge ................................................ 4-3
Low fuel indication lamp............................ 4-7
Fuse load capacity..................................... 8-31
Fuses ......................................................... 8-30 Capacities ................................................ 10-25
Catalytic converter ....................................... 5-5
Cautions on handling of 4WD vehicles...... 5-29
Central door locks........................................ 2-7
Changing a fuse ........................................ 8-33
Charge warning lamp .................................. 4-8
Chassis number......................................... 10-2
“Child-protection” rear door ......................... 2-6
Child restraint ............................................ 3-11
Cigarette lighter ......................................... 6-33
Cleaning the inside of your vehicle .............. 7-2
Genuine leather ........................................ 7-3
Plastic, Vinyl leather, etc. .......................... 7-3
Cleaning the outside of your vehicle............ 7-4
Chrome parts ............................................ 7-6
Damaged paint.......................................... 7-6
Polishing ................................................... 7-6
Washing .................................................... 7-4
Waxing ...................................................... 7-5
Clock (Digital) ............................................ 6-34
Clutch
Fluid .......................................................... 9-9
Pedal free play ........................................ 9-14
Combination headlamps,
dipper and turn signal switch .................. 4-12
Coolant (Engine).......................................... 9-5
Correct 4-wheel drive operation ................ 5-26
Cup tray ..................................................... 6-37
Day/Night Type inside rear-view mirror ..... 5-37
Diesel fuel ................................................ 10-24
Diesel preheat warning lamp ..................... 4-10
Digital clock ............................................... 6-34
Dimensions ......................... 10-5, 10-11, 10-17
10-27
10engL2_240082_4 22-01-2004 13:14 Page 10-27

INDEX
Gauges ........................................................ 4-3
Genuine parts ............................................ 1-15
Glove box .................................................. 6-35
Hazard warning flasher switch .................. 4-18
Hazard warning indication lamp .................. 4-7
Headlamp
Headlamp levelling switch ...................... 4-14
Headlamps
Headlamps, Dipper, Passing .................. 4-12
Replacement ........................................... 8-35
Washer switch......................................... 4-17
Head restraints ............................................ 3-5
Heated seats ............................................... 3-7
Heater/Air conditioning .............................. 6-19
High-beam indication lamp .......................... 4-7
Hinges and latches lubrication................... 9-16
Horn switch ................................................ 4-20
Ignition switch .............................................. 5-9
Inclinometer ................................................. 4-4
Indication and warning lamps ...................... 4-6
Inside rear-view mirror ............................... 5-37
Installation of accessories ......................... 1-13
Instruments .................................................. 4-2
Jack ............................................................. 8-5
Jack handle ................................................. 8-7
Jacking up the vehicle ................................. 8-8
Jump starting (Emergency starting) .......... 8-27
Keyless entry system................................... 2-5
Keys............................................................. 2-2Leakage (Fuel, engine coolant,
oil and exhaust gas) ................................ 9-14
Light
Bulb capacity........................................... 8-34
Headlamps .............................................. 4-12
Room lamps ............................................ 4-20
Limited-slip differential ............................... 5-35
Low fuel indication lamp .............................. 4-7
Manual transmission
Driving speed .......................................... 5-14
Shifting .................................................... 5-14
Manual window control ................................ 2-9
Meter, gauge and indication/warning
lamp operation ........................................ 9-14
Meter illumination control........................... 4-20
Mirrors
Day/Night Type inside rear-view mirror .. 5-37
Electric remote-controlled
outside rear-view mirrors ...................... 5-38
Vanity mirror............................................ 6-32
Octane rating ............................................... 5-3
Odometer/Tripmeter .................................... 4-3
Oil pressure warning lamp ........................... 4-9
Oil
Engine oil ....................................... 9-2, 10-26
Manual transmission oil ........................ 10-26
Operation under adverse
driving conditions ...................................... 8-2
Overheating (Engine) ................................ 8-23Parking ............................................. 5-20, 5-32
Parking brake ............................................ 5-30
Performance ....................... 10-5, 10-11, 10-18
Pillar antenna............................................. 6-18
Polishing ...................................................... 7-6
Power steering
Fluid ............................................... 9-9, 10-26
System .................................................... 5-37
Pregnant women restraint ......................... 3-20
Punctured .................................................. 8-16
Quarter window ......................................... 2-11
Rear differential lock .................................. 5-23
Rear fog lamp switch ................................. 4-19
Rear gate ................................................... 2-12
Rear heater................................................ 6-30
Rear seat ..................................................... 3-5
Rear secret box ......................................... 6-37
Rear window demister switch .................... 4-18
Rear-view mirrors ...................................... 5-37
Removal of water from the fuel filter
(diesel-powered vehicles only) ............... 8-26
Replacement of lamp bulbs ....................... 8-34
Front turn-signal and position lamps ....... 8-36
Headlamps .............................................. 8-35
High-mounted stop lamps ....................... 8-38
Side turn-signal lamps ............................ 8-36
Number-plate lamps ............................... 8-37
Rear combination lamps ......................... 8-37
Rear fog lamps........................................ 8-38
Rheostat .................................................... 4-20
Roof drip moulding .................................... 1-14
Room lamps .............................................. 4-20
10-28
10engL2_240082_4 22-01-2004 13:14 Page 10-28