2003 MITSUBISHI SHOGUN heater

N29B218E
Engine compartmentNO Symbol Electric systemCapacity
1
Alternator 120A
2Fuse (+B) 60A
3Ignition switch 40A
NO Symbol Electric systemCapacity
4
Electrical window control 30A
5Engine control 20A
6Fuel pump 20A
7Rear air conditioning 25A
8Accessory socket 15A
9Fuel line heater 25ADaytime running lamp 15A
10Condenser fan motor 25A
11Rear air conditioning 20A
12Horn 10AWiper deicer 15A
13Horn 10A
14Automatic transmission 20A
15Hazard warning flasher 10A
16Stop lamps 15A
NO Symbol Electric systemCapacity
17
Radio 10A
18Room lamp 10A
19Air conditioning 10A
20Front fog lamps 20A
21Horn 10A
22Windscreen wiper 20A
23Tail lamps (right) 10A
24Tail lamps (left) 10A
25Headlamp low beam
(right)10A
26Headlamp low beam (left) 10A
27Headlamp upper beam
(right)10A
28Headlamp upper beam
(left)10A
29 - - -
30Heater 50A
•Some fuses may not be installed on your vehicle,
depending on the vehicle model or specifications.
•The table above shows the main equipment corre-
sponding to each fuse.
For emergencies
8-32Div:
Out put date:

N26A143A
Engine coolant
EM36A-Tb
A translucent coolant reserve tank is
located in the engine compartment. The
coolant level in this tank should be kept
between the“LOW”and“FULL”marks
when measured while the engine is cold .
The cooling system is a closed system and
normally the loss of coolant should be very
slight. A noticeable drop in the coolant level
could indicate leakage. If this occurs, have
the system checked at an authorized
MITSUBISHI dealer as soon as possible.
If the level should drop below the“LOW”
level on the reserve tank, open the lid and
add coolant.
Also, if the reserve tank is completely
empty, remove the radiator cap and add
coolant until the level reaches the filler
neck.
WARNING
Do not open the radiator cap while
the engine is hot. The coolant sys-
tem is under pressure and any hot
coolant escaping could cause severe
burns.Anti-freezeThe engine coolant contains an ethylene
glycol anti-corrosion agent. The cylinder
head and water pump housing are cast alu-
minium alloy, and periodic changing of the
engine coolant is necessary to prevent cor-
rosion of these parts.
Use DIA QUEEN SUPER LONG LIFE
COOLANT or equivalent.
MITSUBISHI Genuine Coolant has excel-
lent protection against corrosion and rust
formation of all metals including alu-
minium and can avoid clogs in the radia-
tor, heater, cylinder head, engine block, etc.
Because of the necessity of this
anti-corrosion agent, the coolant must not
be replaced with plain water even in sum-
mer. The required concentration of
anti-freeze differs depending on the
expected ambient temperature.Ambient temperature
(minimum)°C–15–20–25–30–35–50
Anti-freeze
concentration %30 35 40 45 50 60
CAUTION
(1) Do not use alcohol or metha-
nol anti-freeze or any engine
coolants mixed with alcohol or
methanol anti-freeze. The use of
an improper anti-freeze can
cause corrosion of the alu-
minium components.
(2) For effective anti-corrosion and
anti-freeze performance, keep
the anti-freeze concentration
within the range of 30 to 60%.
Concentrations exceeding 60%
will result in a reduction of both
the anti-freeze and cooling per-
formance thus adversely affect-
ing the engine.
(3) Do not top up with water only.
Water by itself reduces the
rust-protective and anti-freeze
qualities of the coolant and has
a lower boiling point. It can also
cause damage to the cooling
system if it should freeze. Do not
use tapwater, as it can cause
corrosion and rust formation.
Maintenance
9-5
Div:
Out put date:

N o . Item Quantity Recommended libricants
5 Washer fluidFront 6.0 litres
−
Rear 1.4 litres
6 Power steering fluid 1.0 litre ATF DEXRON III or DEXRON II
7 Engine coolantWithout rear heater/
rear air conditioning9.0 litres
DIA QUEEN SUPER LONG LIFE COOLANT or equivalent
(Includes 0.65 litre in the reserve tank)
With rear heater/
rear air conditioning10.5 litres
8Manual transmis-
sion oilSuper select 4WD models 3.2 litres
Gear oil API classification GL-4 SAE 75W-85W or 75W-90 Part-time 4WD models 5.1 litres
9 Transfer oilSuper select 4WD models 2.8 litres
Part-time 4WD models 2.5 litres
10 Differential oilFront 1.15 litresHypoid gear oil API classification GL-5 or higher
Above 10°C SAE 90
Below 10°C SAE 80W Rear 1.6 litres
11Refrigerant
(air conditioning)Without rear air conditioning 480-520g
HFC-134a
With rear air conditioning 760-800g
NOTE
Points requiring routine inspection or replenishment such as the engine oil, coolant, brake fluid are marked white for easy identification.
Specifications
10-17
Div:
Out put date:

Accessory boxes ................................................ 6-62
Accessory socket ............................................... 6-61
Additional equipment ......................................... 9-21
Air purifier ........................................................... 6-55
Antenna .............................................................. 6-35
Anti-lock brake system (ABS) ............................ 5-45
Armrest .............................................................. 3-13
Ashtray ............................................................... 6-60
Audio system anti-theft feature ......................... 6-32
Automatic air conditioning .................................. 6-43
Automatic transmission fluid ................................ 9-4
Automatic transmissionINVECS-II Sport Mode 5A/T(Intelligent & Innovative
Vehicle Electronic Control SystemII ) ........... 5-17
Auto-speed (cruise) control ................................ 5-53
Backdoor ............................................................ 2-10
Battery ................................................................. 9-6
Bleeding the fuel system (diesel-powered vehicles only) ..................... 8-23
Bonnet .................................................................. 2-9
Brake fluid ............................................................ 9-8
Brake pedal free play ......................................... 9-18
Braking ............................................................... 5-44
Capacities ........................................................ 10-16
Catalytic converter ............................................... 5-6
Cautions on handling of 4WD vehicles .............. 5-42
CD (Compact-Disc) player ................................. 6-30
Central door locks ................................................ 2-8
Changing a fuse ................................................. 8-33
Chassis number ................................................. 10-2
“Child-protection” rear doors (5-door models) ..... 2-6
Child restraint ..................................................... 3-33
Cigarette lighter .................................................. 6-59
Cleaning the inside of your vehicle ...................... 7-2
Cleaning the outside of your vehicle .................... 7-4
Clutch fluid ......................................................... 9-10
Clutch pedal free play ........................................ 9-18
Combination head lamps, dipper and turn signal switch ................................................... 4-14
Correct 4-wheel drive operation ......................... 5-38
Cup tray ............................................................. 6-65 Dimensions ........................................................ 10-6
Doors ................................................................... 2-4
Driving and alcohol ............................................ 1-13
Economical driving ............................................... 5-7
Electric remote-controlled outside
rear-view mirrors ............................................ 5-51
Electric window control ...................................... 2-12
Electrical system .............................................. 10-10
Electronic immobilizer (Anti-theft starting system) ............................... 2-2
Emergency starting ............................................ 8-25
Engine ................................................................ 10-9
Engine coolant ..................................................... 9-5
Engine number ................................................... 10-2
Engine oil ............................................................. 9-2
Engine overheating ............................................ 8-21
Exterior and interior lamp operation ................... 9-18
Front fog lamp switch ......................................... 4-22
Front heater/ Manual air conditioning .................................. 6-36
Front seat ............................................................. 3-6
Fuel consumption ............................................. 10-12
Fuel gauge ........................................................... 4-4
Fuel, engine coolant, oil and exhaust gas leakage ......................... 9-17
Fuses ................................................................. 8-28
Genuine parts .................................................... 1-12
Glove box ........................................................... 6-63
Handling of cassette tapes ................................ 6-33
Hazard warning flasher switch ........................... 4-20
Headlamp levelling switch ................................. 4-16
Headlamps washer switch ................................. 4-19
Head restraints ................................................... 3-28
Heated seats ...................................................... 3-10
Hinges and latches lubrication ........................... 9-19
Horn switch ........................................................ 4-24
How to set a CD autochanger ........................... 6-31 If a tyre is punctured .......................................... 8-13
If the vehicle breaks down ................................... 8-2
Ignition switch ..................................................... 5-11
Indication and warning lamps .............................. 4-6
Inside rear-view mirror ....................................... 5-50
Installation of accessories .................................. 1-10
Installation position for warning triangle ............. 6-67
Instruments .......................................................... 4-2
Jack and jack handle ........................................... 8-5
Jacking up the vehicle ......................................... 8-8
Keyless entry system ........................................... 2-5
Keys ..................................................................... 2-2
Limited-slip differential ....................................... 5-48
Luggage compartment lamp .............................. 4-26
Luggage floor box .............................................. 6-66
Making a flat seat ............................................... 3-26
Making a luggage area ...................................... 3-14
Manual outside rear-view mirrors ...................... 5-51
Manual transmission .......................................... 5-15
Meter, gauge and indication/
warning lamp operation .................................. 9-18
MITSUBISHI active stability & traction control system (M-ASTC) .................. 5-57
Modifications/alterations to the electric or fuel systems ................................... 1-11
Multi centre display ............................................ 4-27
Notes regarding diesel fuel .............................. 10-14
Odometer/Tripmeter ............................................. 4-3
Operation under adverse driving conditions ......................................................... 8-2
Other specifications .......................................... 10-11
Outside rear-view mirror .................................... 5-50
Alphabetical index
1
0-18Div:
Out put date:

Parking ............................................................... 5-43
Parking brake ..................................................... 5-42
Parking brake lever stroke ................................. 9-19
Part time 4WD ................................................... 5-24
Performance ...................................................... 10-7
Power steering fluid ............................................. 9-9
Power steering system ...................................... 5-49
Pregnant women restraint .................................. 3-41
Rear differential lock .......................................... 5-34
Rear fog lamp switch ......................................... 4-22
Rear heater/Rear air conditioning ...................... 6-52
Rear seat (3-door models)/Second seat (5-door models) ......................... 3-12
Rear shelf (3-door models) ................................ 6-69
Rear side/quarter window .................................. 2-15
Rear window demister switch ............................ 4-21
Rear window wiper and washer switch .............. 4-19
Removal of water from the fuel filter (diesel- powered vehicles only) ...................... 8-24
Replacement of lamp bulbs ............................... 8-34
Rheostat (meter illumination control) ................. 4-23
Roof carrier precaution ....................................... 1-11
Room lamps ....................................................... 4-24
Running-in recommendations .............................. 5-2
RV meter ............................................................ 4-40
Safe driving techniques ..................................... 1-13
Seat adjustment ................................................... 3-3
Seat arrangement ................................................ 3-3
Seat belt inspection ........................................... 3-41
Seat belts ........................................................... 3-30
Side box ............................................................. 6-67
Snow tyres ......................................................... 9-16
Spare wheel ....................................................... 8-11
Speedometer ....................................................... 4-2
Starting ............................................................... 5-12
Steering wheel height adjustment ...................... 5-49
Sun visors .......................................................... 6-56
Sunroof .............................................................. 2-15
Super select 4WD II (SS4 II) ............................. 5-28
Supplemental restraint system (SRS)-air bag ... 3-42 Tachometer .......................................................... 4-3
Third seat (5-door models) ................................ 3-14
Tools and jack ...................................................... 8-3
Towing ................................................................ 8-17
Trailer towing ....................................................... 5-8
Transmission ...................................................... 10-9
Tyre chains ......................................................... 9-16
Tyre inflation pressure ....................................... 9-14
Tyre rotation ....................................................... 9-15
Tyres and wheels ............................................. 10-10
UKW/MW/LW electronic tuning radio
with CD player ................................................ 6-17
UKW/MW/LW electronic tuning radio with tape player ................................................ 6-2
Used engine oils safety instructions .................. 1-13
Vanity mirror ....................................................... 6-58
Vehicle identification number plate (RHD vehicles only) ....................................... 10-3
Vehicle information code plate ........................... 10-3
Ventilation slots .................................................. 9-21
Ventilators .......................................................... 6-35
Washer fluid ....................................................... 9-11
Water temperature gauge .................................... 4-5
Weatherstripping ................................................ 9-21
Weight ................................................................ 10-7
Wheel condition ................................................. 9-12
Windscreen wiper and washer switch ................ 4-17
Wiper blades ............................................... 7-7, 9-19
Wiper deicer switch ........................................... 4-24
Alphabetical index
10 -19
Div:
Out put date: