2003 Hyundai H-1 (Grand Starex) Automatic

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-6 I040A01P-GAT
Vehicle Interior
Vehicle Interior Vehicle Interior
Vehicle Interior
Vehicle Interior
The following should be checked each time when the vehicle is driven:
o Light operation
o Windshield wiper operation
o Horn operation
o Defroster, heater operation (and air condi- tioning, if equipped)
o Steering operation and condition
o Mirror condition and operation
o Turn signal operation
o Accelerator pedal operation
o Brake operation, including parking brake
o Manual transmission operation, including clutch operation
o Automatic transmission operation, including "Park" mechanism operation
o Seat control condition and operation
o Seat belt condition and operation
o Sunvisor operation
If you notice anything that does not operate correctly or appear to be functioning correctly,inspect it carefully and seek assistance fromyour Hyundai dealer if service is needed. Adequate care of your vehicle at regular inter- vals serves to preserve the value and appear-ance as long as possible. Some maintenance items can be carried out bythe owner (Consumer Information), while othershould be done only by an authorized dealer(Periodic Inspection and Maintenance). Thissection describes only those items which canbe carried out by the owner. In the event amalfunction or other problem is discovered,have it corrected by an authorized HYUNDAIdealer. This section contains information oninspection maintenance procedures that youcan do yourself, if you so desire. Follow theinstructions and cautions for each of the vari-ous procedures. When checking or servicing the inside of the engine compartment, be sure the engine isstopped and has had a chance to cool down. Ifit is necessary to do work in the engine com-partment with the engine running, be especiallycareful that your clothing, hair, etc., becomesnot caught by the fan, V-belts, or other movingparts. I050A01P-GAT
Inspection items
Inspection items Inspection items
Inspection items
Inspection items
( 1 ) Engine oil
( 2 ) Engine coolant
(3) Battery
( 4 ) Brake fluid
( 5 ) Clutch fluid (hydraulic clutch only)
( 6 ) Washer fluid
( 7 ) Wheel condition (including spare wheel)
(8) Tire inflation pressure (including spare
wheel)
I020A02P-GAT
GENERAL CHECKS
GENERAL CHECKS GENERAL CHECKS
GENERAL CHECKS
GENERAL CHECKS
Engine Compartment
Engine Compartment Engine Compartment
Engine Compartment
Engine Compartment The following should be checked regularly:
o Engine oil level and condition
o Transmission fluid level and condition
o Brake fluid level
o Clutch fluid level
o Engine coolant level
o Windshield washer fluid level
o Accessory drive belt condition
o Coolant hose condition
o Fluid leaks (on or below components)
o Power steering fluid level and condition
o Tire pressure and condition (including spare)
o Battery condition I030A02P-GAT
Vehicle Exterior
Vehicle Exterior Vehicle Exterior
Vehicle Exterior
Vehicle Exterior The following should be checked monthly:
o Overall appearance and condition
o Wheel condition and wheel nut tightness
o Air cleaner filter condition
o Exhaust system condition
o Light condition and operation
o Windshield glass condition
o Wiper blade condition
o Paint condition and corrosion
o Fluid leaks
o Door and hood lock condition

8-11
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I120D02P-GAT To Check the
To Check the To Check the
To Check the
To Check the T ransmission
Fluid Level
Fluid Level Fluid Level
Fluid Level
Fluid Level
D060A01P-GAG
Button
Park the vehicle on level ground with the park-
ing brake engaged. When the transmission fluid level is checked, the transmission fluidshould be at normal operating temperature andthe engine idling.
While the engine is idling, apply the brakes and
move the gear selector lever from "P" to eachof its other positions-"R", "N", "D", "2", "L"-andthen return to "N" or "P" with the engine stillidling:
I120D02P-GAG
Full mark Good
1. Open the hood, being careful to keep hands, long hair and clothing clear of any moving parts.
2. Remove the transmission dipstick, wipe it clean, reinsert the dipstick as far as it will go, then remove it again. Now check thefluid level on the dipstick. It should be in the"HOT" range on the dipstick.
3. If the transmission fluid level is low, use a funnel to add transmission fluid through thedipstick tube until the level reaches the"HOT" range. Do not overfill, otherwise thetransmission could be damaged.
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
The radiator fan is controlled by engine
The radiator fan is controlled by engine The radiator fan is controlled by engine
The radiator fan is controlled by engine
The radiator fan is controlled by engine
coolant temperature and may sometimes
coolant temperature and may sometimes coolant temperature and may sometimes
coolant temperature and may sometimes
coolant temperature and may sometimes
operate even after the ignition key has even
operate even after the ignition key has even operate even after the ignition key has even
operate even after the ignition key has even
operate even after the ignition key has even
turned off. Use extreme caution when work-
turned off. Use extreme caution when work- turned off. Use extreme caution when work-
turned off. Use extreme caution when work-
turned off. Use extreme caution when work-
ing near the blades of the cooling fan, so
ing near the blades of the cooling fan, so ing near the blades of the cooling fan, so
ing near the blades of the cooling fan, so
ing near the blades of the cooling fan, so
that you are not injured by a rotating fan
that you are not injured by a rotating fan that you are not injured by a rotating fan
that you are not injured by a rotating fan
that you are not injured by a rotating fan
blade. As the coolant temperature decreases,
blade. As the coolant temperature decreases, blade. As the coolant temperature decreases,
blade. As the coolant temperature decreases,
blade. As the coolant temperature decreases,
I120A01P-GAT
CHECKING THE AUTOMATIC
CHECKING THE AUTOMATIC CHECKING THE AUTOMATIC
CHECKING THE AUTOMATIC
CHECKING THE AUTOMATIC
TRANSMISSION FLUID (If installed)
TRANSMISSION FLUID (If installed) TRANSMISSION FLUID (If installed)
TRANSMISSION FLUID (If installed)
TRANSMISSION FLUID (If installed)
Transmission fluid in the automatic transmis-
sion should be changed at those intervals speci-fied in the vehicle maintenance schedule inSection 6.
I120B01P-GATRecommended Fluid
Recommended Fluid Recommended Fluid
Recommended Fluid
Recommended Fluid
Your Hyundai automatic transmission is specially
designed to operate with " DIAMOND ATF
DEXRON II" or "DIAMOND ATF SP I" type
fluid.
I120C02P-GATAA
AA
A
utomatic
utomatic utomatic
utomatic
utomatic transmission
fluid capacity
fluid capacity fluid capacity
fluid capacity
fluid capacity
The fluid capacity of the automatic transmis-
sion will be found on page 9-4.
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
The transmission fluid level should be
The transmission fluid level should be The transmission fluid level should be
The transmission fluid level should be
The transmission fluid level should be checked when the engine is at normal oper-
checked when the engine is at normal oper- checked when the engine is at normal oper-
checked when the engine is at normal oper-
checked when the engine is at normal oper-
ating temperature. This means that the en-
ating temperature. This means that the en- ating temperature. This means that the en-
ating temperature. This means that the en-
ating temperature. This means that the en-
gine, radiator, exhaust system etc., are very
gine, radiator, exhaust system etc., are very gine, radiator, exhaust system etc., are very
gine, radiator, exhaust system etc., are very
gine, radiator, exhaust system etc., are very
hot. Exercise great care not to burn yourself
hot. Exercise great care not to burn yourself hot. Exercise great care not to burn yourself
hot. Exercise great care not to burn yourself
hot. Exercise great care not to burn yourself
during this procedure.
during this procedure. during this procedure.
during this procedure.
during this procedure.

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-12 I150A01P-GAT
WHEEL CONDITION
WHEEL CONDITION WHEEL CONDITION
WHEEL CONDITION
WHEEL CONDITION Check the tires for cuts, cracks and other damage. Replace the tires if there are deepcuts or cracks. Also check each tire for piecesof metal or pebbles. The use of worn tires can be very dangerous because of the greater chance of skidding orhydroplaning. The tread depth of the tires mustexceed 1.6 mm (0.06 in.) in order for the tiresto meet the minimum requirement for use.If there are belt-line wear indicators on thetires, they will appear in six places on thesurface of the tire thereby indicating that thetire no longer meets the minimum requirementfor use. When these wear indicators appear,the tires must be replaced with new one. Con-firm that the wheel nuts are tightened sufficient-ly. Refer to the section of this manual entitled"In case of emergency" for information con-cerning care of the tires.
I140A02P-GAT
TAILGATE WINDOW WASHER FLUID
TAILGATE WINDOW WASHER FLUID TAILGATE WINDOW WASHER FLUID
TAILGATE WINDOW WASHER FLUID
TAILGATE WINDOW WASHER FLUID
LEVEL (Minibus, Van) (If installed)
LEVEL (Minibus, Van) (If installed) LEVEL (Minibus, Van) (If installed)
LEVEL (Minibus, Van) (If installed)
LEVEL (Minibus, Van) (If installed) After opening the cover of quarter trim panel which is located on the left side of quarter trim,check the fluid level. If the fluid level is low, refill the washer fluid.
I140A01P-1
I130A01P-GAT
WINDSHIELD WASHER FLUID LEVEL
WINDSHIELD WASHER FLUID LEVEL WINDSHIELD WASHER FLUID LEVEL
WINDSHIELD WASHER FLUID LEVEL
WINDSHIELD WASHER FLUID LEVEL
The washer fluid reservoir supplies fluid to the
windshield washer system.
A good quality washer fluid should be used to fill
the washer reservoir. The fluid level should be checked more frequently during bad weather orwhenever the washer system is in more fre-quent use.
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
oo
oo
o Radiator antifreeze (engine coolant)
Radiator antifreeze (engine coolant) Radiator antifreeze (engine coolant)
Radiator antifreeze (engine coolant)
Radiator antifreeze (engine coolant)
should not be used in the washer system
should not be used in the washer system should not be used in the washer system
should not be used in the washer system
should not be used in the washer system
because it will damage the car’s finish.
because it will damage the car’s finish. because it will damage the car’s finish.
because it will damage the car’s finish.
because it will damage the car’s finish.
oo
oo
o
The washer lever should not be pulled
The washer lever should not be pulled The washer lever should not be pulled
The washer lever should not be pulled
The washer lever should not be pulled
and the washer should not be operated if
and the washer should not be operated if and the washer should not be operated if
and the washer should not be operated if
and the washer should not be operated if
the washer reservoir is empty. This can
the washer reservoir is empty. This can the washer reservoir is empty. This can
the washer reservoir is empty. This can
the washer reservoir is empty. This can
damage the washer fluid pump.
damage the washer fluid pump. damage the washer fluid pump.
damage the washer fluid pump.
damage the washer fluid pump.
I130A01P-1
the fan will automatically shut off. This is a
the fan will automatically shut off. This is a the fan will automatically shut off. This is a
the fan will automatically shut off. This is a
the fan will automatically shut off. This is a
normal condition.
normal condition. normal condition.
normal condition.
normal condition.
Wear indicator
1.6 mm (0.06 in.)
HGK248

VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
VEHICLE SPECIFICATIONS
9-4 Quantity (liter)
Minibus, Van : 1.3 0.8
Minibus : 13, Van : 10, Truck : 7.2 As required As required
Minibus, Van : 2.6, Truck : 1.7
As required Diesel
2.6 N/A(long Van) : 8.5 2.6 N/A : 72.5 4D56 T/C : 8.52.5 4D56 TCI(3Van, 11/12Minibuss) : 8.52.5 4D56 TCI EURO III(3Van, 11/12Minibuss) : 7.53
2.5 4D56 TCI EURO III(6Van, 7/9Minibuss) : 7.53
2.5 4D56 TCI(4WD) : 9.832.5 CRDi TCI(2WD) : 8.32.5 CRDi TCI(4WD) : 11.7
Recommended in field
HYUNDAI GENUINE PARTS MTF 75W/90 (API GL-4) DIAMOND ATF DEXRON II, DIAMOND ATF SP I
DIAMOND ATF SP II
PSF-3 HIGH QUALITY ETHYLENE GLYCOL BASE FOR ALUMINUM RADIATORSAE J 1703 EQUIVALENTSAE J310a, MULTI-PURPOSE GREASE NLGI-2 OREQUIVALENT.
API GL-4 (MS517-15) : SAE 90, 140
API GL-5 (MS517-15) : SAE 80
Items
MANUAL TRANSMISSION OIL AUTOMATIC TRANSMISSION OIL TRANSFER CASE OIL POWER STEERING OIL COOLANT CLUTCH & BRAKE FLUIDFRONT, REAR WHEEL BEARING REAR AXLE STEERING GEAR BOX
Gasoline 2.0 Diesel
2.6 N/A : 2.0 2.5 4D56 T/C or TCI : 2.42.5 CRDi TCI : 3.2
Gasoline
7.53
J060A05P-GATLUBRCATION CHART
LUBRCATION CHART LUBRCATION CHART
LUBRCATION CHART
LUBRCATION CHART

10-1
INDEX
INDEX INDEX
INDEX
INDEX
BRAKE SYSTEM ....................................................................... 3-13 ~ 3-14
BRAKE WARNING AND PARKING BRAKE INDICATION
LAMP-RED ................................................................................................ 2-9
C CARE OF CASSETTE TAPES ..............................................2-56 ~ 2-57
CARE OF DISC ...................................................................................... 2-56
CARRYING CHILDREN ........................................................................ 1-12
CENTRAL DOOR LOCKS .................................................................... 1-10
CHANGING GEARS ................................................................................. 3-5
CHARGE WARNING LAMP-RED ......................................................... 2-9
CHILD PROTECTION SLIDE DOOR ................................................1-12
CHILD RESTRAINT SYSTEM ................................................1-25 ~ 1-28
CIGARETTE LIGHTER ......................................................................... 2-23
CLUTCH FLUID ....................................................................................... 8-10
CLUTCH PEDAL FREE PLAY ............................................................ 8-14
D DAYTIME RUNNING LIGHTS ............................................................. 2-13
DEFROSTING/DEFOGGING ............................................................... 2-26
DIGITAL CLOCK ..................................................................................... 2-24
DISEL ENGINE ROOM ................................................................ 8 - 1 ~ 8 - 4
DIESEL PREHEAT INDICATION LIGHT-AMBER ..............2-9 ~ 2-10
DOOR-AJAR WARNING LAMP-RED .................................................. 2-9
DRINK HOLDER ..................................................................................... 2-22
DURING COLD WEATHER ....................................................3-16 ~ 3-17
E ECONOMICAL DRIVING ......................................................... 3-14 ~ 3-15
EMERGENCY STARTING ................................................................... 4-14
K000A01P-GAT
10.
10. 10.
10.
10.
INDEX
INDEX INDEX
INDEX
INDEX
A ADJUSTABLE FRONT SEATS ........................................................... 1-18
AIR CONDITIONER OPERATION .....................................................2-27
ANTENNA ................................................................................................. 2-58
ALTIMETER ................................................................................................. 2-7
ANTI-FREEZE ............................................................................................. 8-9
ANTI-LOCK BRAKE SYSTEM ............................................................ 3-12
ANTI-LOCK BRAKE WARNING LIGHT ...........................................2-10
APPEARANCE CARE .............................................................................. 5-1
ASHTRAY (Front) ................................................................................... 2-23
ASHTRAY (Rear) .................................................................................... 2-23
A/T OIL TEMPERATURE WARNING LIGHT ..................................2-10
AUDIO FAULT CODE ........................................................................... 2-55
AUXILIARY SEAT ................................................................................... 1-22
AUTOMATIC TRANSMISSION OPERATION ........................ 3 - 5 ~ 3 - 8
AUTOMATIC TRANSMISSION FLUID CHECK .............8-11 ~ 8-12
B BATTERY ..................................................................................................... 8-9
BEFORE OPERATION PRECAUTIONS FOR NEW VEHICLE .... 1-1
BI-LEVEL HEATING ............................................................................... 2-25
BLEEDING THE FUEL SYSTEM ..........................................4-13 ~ 4-14
BRAKE FLUID ......................................................................................... 8-10
BRAKE PEDAL ........................................................................................ 3-11
BRAKE PEDAL FREE PLAY ............................................................... 8-14
1010
1010
10