2001 TOYOTA AVALON engine sensor

DI07B-20
DI-14
- DIAGNOSTICSENGINE
170 Author
: Date
:
DIAGNOSTIC TROUBLE CODE CHART
HINT:
Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument
or other factors.
If a malfunction code is displayed during the DTC check in check mode, check the circuit for the codes listed
in the table below. For details of each code, turn to the page referred to under the ''See page '' for the respec-
tive ''DTC No.'' in the DTC chart.
SAE CONTROLLED
DTC No.
(See page)Detection ItemTrouble AreaMIL*1Memory
P0100
(DI-23)Mass Air Flow Circuit Malfunc-
tionOpen or short in mass air flow meter circuit
Mass air flow meter
ECM

P0101
(DI-27)Mass Air Flow Circuit Range/
Performance ProblemMass air flow meter
P0110
(DI-28)Intake Air Temp. Circuit Malfunc-
tionOpen or short in intake air temp. sensor circuit
Intake air temp. sensor (built into mass air flow meter)
ECM

P0115
(DI-32)Engine Coolant Temp. Circuit
MalfunctionOpen or short in engine coolant temp. sensor circuit
Engine coolant temp. sensor
ECM

P0116
(DI-36)Engine Coolant Temp. Circuit
Range/Performance ProblemCooling system
Engine coolant temp. sensor
P0120
(DI-38)Throttle/Pedal Position Sensor/
Switch ºAº Circuit MalfunctionOpen or short in throttle position sensor circuit
Throttle position sensor
ECM

P0121
(DI-42)Throttle/Pedal Position Sensor/
Switch ºAº Circuit Range/Perfor-
mance Problem
Throttle position sensor
P0125
(DI-43)Insufficient Coolant Temp. for
Closed Loop Fuel Control
Open or short in A/F sensor (bank 1, 2 sensor 1) circuit
A/F sensor (bank 1, 2 sensor 1)
Air induction system
Fuel pressure
Injector
Gas leakage on exhaust system
ECM

P0128
(DI-48)Thermostat Malfunction
Thermostat
Cooling system
Engine coolant temp. sensor
ECM
P0136
(DI-49)Oxygen Sensor Circuit Malfunc-
tion (Bank 1 Sensor 2)Open or short in heated oxygen sensor circuit
Heated oxygen sensor
P0141
(DI-51)Oxygen Sensor Heater Circuit
Malfunction (Bank 1 Sensor 2)Open or short in heater circuit of heated oxygen sensor
Heated oxygen sensor heater
ECM


- DIAGNOSTICSENGINE
DI-15
171 Author
: Date
:
P0171
(DI-53)System too Lean (Fuel Trim)
Air induction system
Injector blockage
Mass air flow meter
Engine coolant temp. sensor
Fuel pressure
Gas leakage on exhaust system
Open or short in A/F sensor (bank 1, 2 sensor 1) circuit
A/F sensor (bank 1, 2 sensor 1)
ECM

P0172
(DI-53)System too Rich (Fuel Trim)
Injector leak, blockage
Mass air flow meter
Engine coolant temp. sensor
Ignition system
Fuel pressure
Gas leakage on exhaust system
Open or short in A/F sensor (bank 1, 2 sensor 1) circuit
A/F sensor (bank 1, 2 sensor 1)
ECM

P0174
(DI-53)System too Lean
(A/F Lean Malfunction)Same as DTC P0171
P0175
(DI-53)System too Rich
(A/F Rich Malfunction)Same as DTC P0172
P0300
(DI-58)Random/Multiple Cylinder Misfire
Detected
P0301
(DI-58)Cylinder 1 Misfire DetectedOpen or short in engine wire
Connector connection
Vh tiP0302
(DI-58)Cylinder 2 Misfire Detected
Vacuum hose connection
Ignition system

Injector
P0303
(DI-58)Cylinder 3 Misfire Detected
Injector
Fuel pressure
Mass air flow meter
*2
P0304
(DI-58)Cylinder 4 Misfire Detected
Mass air flow meter
Engine coolant temp. sensor
Compression pressure
Vl lP0305
(DI-58)Cylinder 5 Misfire Detected
Valve clearance
Valve timing

ECM
P0306
(DI-58)Cylinder 6 Misfire Detected
ECM
P0325
(DI-64)Knock Sensor 1 Circuit Malfunc-
tion (Bank 1)Open or short in knock sensor 1 circuit
Knock sensor 1 (looseness)
ECM

P0330
(DI-64)Knock Sensor 2 Circuit Malfunc-
tion (Bank 2)Open or short in knock sensor 2 circuit
Knock sensor 2 (looseness)
ECM

P0335
(DI-67)Crankshaft Position Sensor ºAº
Circuit Malfunction
Open or short in crankshaft position sensor circuit
Crankshaft position sensor
Crankshaft timing pulley
ECM

P0340
(DI-69)Camshaft Position Sensor Circuit
Malfunction
Open or short in camshaft position sensor circuit
Camshaft position sensor
Camshaft timing gear
ECM

P0420
(DI-71)Catalyst System Efficiency Be-
low Threshold (Bank 1)
Gas leakage on exhaust system
A/F sensor (bank 1, 2 sensor 1)
Heated oxygen sensor (bank 1 sensor 2)
Three-way catalytic converter


DI-16
- DIAGNOSTICSENGINE
172 Author
: Date
:
P0440
(DI-74)Evaporative Emission Control
System Malfunction
Hose or tube cracked, holed, damaged or insufficient seal
Fuel tank cap incorrectly installed
Fuel tank cap cracked or damaged
Vacuum hose cracked, holed, blocked, damaged or discon-
nected
Fuel tank cracked, holed or damaged
Charcoal canister cracked, holed or damaged
Open or short in vapor pressure sensor circuit
Vapor pressure sensor
Fuel tank over fill check valve cracked or damaged
ECM

P0441
(DI-80)Evaporative Emission Control
System Incorrect Purge Flow
Vacuum hose cracked, holed blocked, damaged or discon-
nected ((1), (2), (3), (4), (5), (6), (7), (8), (9), (10) and (11) in
Fig. 1)
Fuel tank cap incorrectly installed
Fuel tank cap cracked or damaged
Open or short in vapor pressure sensor circuit
Vapor pressure sensor
Open or short in VSV circuit for EVAP
VSV for EVAP
Open or short in VSV circuit for CCV
VSV for CCV
Open or short in VSV circuit for pressure switching valve
VSV for pressure switching valve
Fuel tank cracked, holed or damaged
Charcoal canister cracked, holed or damaged
Fuel tank over fill check valve cracked or damaged
ECM

P0442
(DI-74)Evaporative Emission Control
System Leak Detected (Small
Leak)
Same as DTC No. P0440
P0446
(DI-80)Evaporative Emission Control
System Vent Control MalfunctionSame as DTC No. P0441
P0450
(DI-97)Evaporative Emission Control
System Pressure Sensor Mal-
function
Open or short in vapor pressure sensor circuit
V
P0451
(DI-97)Evaporative Emission Control
System Pressure Sensor Range/
PerformanceVapor pressure sensor
ECM
P0500
(DI-99)Vehicle Speed Sensor Malfunc-
tionCombination meter
Open or short in speed sensor circuit
ECM

P0505
(DI-102)Idle Control System Malfunction
Open or short in IAC valve circuit
IAC valve is stuck or closed
Open or short in A/C signal circuit
Air induction system
ECM

*1: MIL lights up
*2: MIL light up or blinking

- DIAGNOSTICSENGINE
DI-17
173 Author
: Date
:
MANUFACTURER CONTROLLED
DTC No.
(See page)Detection ItemTrouble AreaMIL*Memory
P1130
(DI-106)A/F Sensor Circuit Range/Perfor-
mance Malfunction (Bank 1 Sen-
sor 1)
Open or short in A/F sensor circuit
A/F sensor
Air induction system
Fuel pressure
Injector
ECM

P1133
(DI-1 11)A/F Sensor Circuit Response
Malfunction (Bank 1 Sensor 1)
Open or short in A/F sensor circuit
A/F sensor
Air induction system
Fuel pressure
Injector
ECM

P1135
(DI-1 15)A/F Sensor Heater Circuit Mal-
function (Bank 1 Sensor 1)Open or short in heater circuit of A/F sensor
A/F sensor heater
ECM

P1150
(DI-106)A/F Sensor Circuit Range/Perfor-
mance Malfunction (Bank 2 Sen-
sor 1)
Same as DTC No. P1130
P1153
(DI-1 11)A/F Sensor Circuit Response
Malfunction (Bank 2 Sensor 1)Same as DTC No. P1133
P1155
(DI-1 15)A/F Sensor Heater Circuit Mal-
function (Bank 2 Sensor 1)Same as DTC No. P1135
P1300
(DI-1 17)Igniter Circuit Malfunction (No.1)
Ignition system
Open or short in IGF1 or IGT1 circuit from No.1 ignition coil
with igniter to ECM
No.1 ignition coil with igniter
ECM

P1305
(DI-1 17)Igniter Circuit Malfunction (No.2)
Ignition system
Open or short in IGF2 or IGT2 circuit from No.2 ignition coil
with igniter to ECM
No.2 ignition coil with igniter
ECM

P1310
(DI-1 17)Igniter Circuit Malfunction (No.3)
Ignition system
Open or short in IGF2 or IGT3 circuit from No.3 ignition coil
with igniter to ECM
No.3 ignition coil with igniter
ECM

P1315
(DI-1 17)Igniter Circuit Malfunction (No.4)
Ignition system
Open or short in IGF1 or IGT4 circuit from No.4 ignition coil
with igniter to ECM
No.4 ignition coil with igniter
ECM

P1320
(DI-1 17)Igniter Circuit Malfunction (No.5)
Ignition system
Open or short in IGF2 or IGT5 circuit from No.5 ignition coil
with igniter to ECM
No.5 ignition coil with igniter
ECM

P1325
(DI-1 17)Igniter Circuit Malfunction (No.6)
Ignition system
Open or short in IGF1 or IGT6 circuit from No.6 ignition coil
with igniter to ECM
No.6 ignition coil with igniter
ECM


DI-18
- DIAGNOSTICSENGINE
174 Author
: Date
:
P1335
(DI-123)Crankshaft Position Sensor Cir-
cuit Malfunction (During engine
running)Open or short in crankshaft position sensor circuit
Crankshaft position sensor
Camshaft timing gear
ECM
-
P1345
(DI-1 11)VVT Sensor/Camshaft position
Sensor Circuit Malfunction (Bank
1)Open or short in VVT sensor (camshaft position Sensor) circuit
VVT sensor (camshaft position Sensor)
ECM

P1346
(DI-126)VVT Sensor/Camshaft position
Sensor Circuit Range/Perfor-
mance Problem (Bank 1)Mechanical system (Jumping teeth of timing belt, belt
stretched)
ECM

P1349
(DI-127)VVT System Malfunction (Bank
1)
Valve timing
OCV
VVT controller assembly
ECM

P1350
(DI-124)VVT Sensor/Camshaft position
Sensor Circuit Malfunction (Bank
2)
Same as DTC No. P1345
P1351
(DI-126)VVT Sensor/Camshaft position
Sensor Circuit Range/Perfor-
mance Problem (Bank 2)
Same as DTC No. P1346
P1354
(DI-127)VVT System Malfunction (Bank
2)Same as DTC No. P1349
P1520
(DI-134)Stop Light Switch Signal Mal-
functionShort in stop light switch signal circuit
Stop light switch
ECM

P1600
(DI-136)ECM BATT MalfunctionOpen in back up power source circuit
ECM
P1656
(DI-138)OCV Circuit Malfunction (Bank
1)Open or short in OCV circuit
OCVP1663
(DI-138)OCV Circuit Malfunction (Bank
2)OCV
ECM
P1780
(DI-141)Park/Neutral Position Switch
MalfunctionShort in park/neutral position switch circuit
Park/neutral position switch
ECM

B2795
(DI-605)Unmatched Key CodeImmobiliser system-
B2796
(DI-606)No Communication in Immobilis-
er SystemImmobiliser system-
B2797
(DI-609)Communication Malfunction No.1Immobiliser system-
*:


MIL lights up. -


MIL does not light up.

DI07C-09
A11424
Knock Sensor 1 DLC1
IAC Valve VSV for EVAP
Engine Coolant
Temp. Sensor
Injector
Crankshaft Position
Sensor
A/F Sensor
(Bank 2 Sensor 1)Park/Neutral Position SwitchDLC3 ECM
Heated Oxygen Sensor
(Bank 1 Sensor 2)
VVT Sensor
(Bank 2)VVT Sensor (Bank 1)
OCV (Bank 2)OCV (Bank 1)
Canister
Vapor Pressure Sensor A/F Sensor
(Bank 1 Sensor 1)
VSV for Pressure Switching Valve VSV for CCV
Ignition Coil
with lgniter
Mass Air Flow Meter
Throttle Position Sensor
Combination Meter
VSV for
No.1 ACIS
VSV for
No.2 ACIS
Knock Sensor 2
- DIAGNOSTICSENGINE
DI-19
175 Author
: Date
:
2001 AVALON (RM808U)
PARTS LOCATION

B04941
- DIAGNOSTICSENGINE
DI-1 1
167 Author
: Date
:
2001 AVALON (RM808U)
OK
8 Check for spark.
PREPARATION:
(a) Remove the ignition coil from the spark plug.
(b) Remove the spark plug.
(c) Install the spark plug to the ignition coil.
(d) Disconnect the injector connector.
(e) Be sure to ground the screw of the spark plug securely.
CHECK:
Check if spark occurs while the engine is being cranked.
NOTICE:

Do not crash the electrode gap.

To prevent excess fuel being injected from the injec-
tors during this test, don't crank the engine for more
than 5 - 10 seconds at a time.
NG Proceed to page IG-1, and continue to trouble-
shoot.
OK
Proceed to problem symptoms table on page
DI-22.
7. ENGINE OPERATING CONDITION
NOTICE:
The values given below for ºNormal Conditionº are representative values, so a vehicle may still be
normal even if its value varies differ from those listed here. So do not decide whether a part is faulty
or not solely according to the ºNormal Conditionº here.
(a) CARB mandated signals.
TOYOTA hand-held tester displayMeasurement ItemNormal Condition*
FUEL SYS #1
Fuel System Bank 1
OPEN: Air-fuel ratio feedback stopped
CLOSED: Air-fuel ratio feedback operating
Idling after warming up: CLOSED
FUEL SYS #2
Fuel System Bank 2
OPEN: Air-fuel ratio feedback stopped
CLOSED: Air-fuel ratio feedback operating
Idling after warming up: CLOSED
CALC LOADCalculator Load: Current intake air volume as a
proportion of max. intake air volumeIdling: 13.1 - 18.7 %
Racing without load (2,500rpm): 11.7 - 17.3 %
COOLANT TEMPEngine Coolant Temp. Sensor ValueAfter warming up: 80 - 95°C (176 - 203°F)
SHORT FT #1Short-term Fuel Trim Bank 10 ± 20 %
LONG FT #1Long-term Fuel Trim Bank 10 ± 20 %

DI-12
- DIAGNOSTICSENGINE
168 Author
: Date
:
2001 AVALON (RM808U)SHORT FT #2
Short-term Fuel Trim Bank 20 ± 20 %
LONG FT #2Long-term Fuel Trim Bank 20 ± 20 %
ENGINE SPDEngine SpeedIdling: 650 - 750 rpm
VEHICLE SPDVehicle SpeedVehicle stopped: 0 km/h (0 mph)
IGN ADVANCEIgnition Advance: Ignition Timing of Cylinder No.1Idling: BTDC 10 - 25.0°
INTAKE AIRIntake Air Temp. Sensor ValueEquivalent to Ambient Temp.
MAFAir Flow Rate Through Mass Air Flow Meter
Idling: 3.3 - 4.7 gm/sec.
Racing without load (2,500 rpm):
10.4 - 15.4 gm/sec.
THROTTLE POSVoltage Output of Throttle Position Sensor Calcu-
lated as a percentage: 0 V "0 %, 5 V "100 %Throttle valve fully closed: 7 - 11 %
Throttle valve fully open: 65 - 75 %
O2FT B1 S1Oxygen Sensor Fuel Trim Bank 1 Sensor 1
(Same as SHORT FT #1)0 ± 20 %
O2S B1 S2Voltage Output of Oxygen Sensor Bank 1 Sensor
2Driving 50 km/h (31 mph): 0.05 - 0.95 V
O2FT B2 S1Oxygen Sensor Fuel Trim Bank 2 Sensor 1
(Same as SHORT FT #2)0 ± 20 %
A/FS B1 S1Voltage Output of A/F Sensor Bank 1 Sensor 1Idling: 2.8 - 3.8 V
A/FS B2 S1Voltage Output of A/F Sensor Bank 2 Sensor 1Idling: 2.8 - 3.8 V
A/FFT B1 S1A/F Sensor Fuel Trim Bank 1 Sensor 1
(Same as SHORT FT #1)0 ± 20 %
A/FFT B2 S1A/F Sensor Fuel Trim Bank 2 Sensor 1
(Same as SHORT FT #1)0 ± 20 %
*: If no conditions are specifically stated for ºldlingº, it means the shift lever is at N or P position, the A/C switch
is OFF and all accessory switches are OFF.
(b) TOYOTA Enhanced Signals.
TOYOTA hand-held tester displayMeasurement ItemNormal Condition*
MISFIRE RPMEngine RPM for first misfire rangeMisfire 0: 0 rpm
MISFIRE LOADEngine load for first misfire rangeMisfire 0: 0 g/r
INJECTORFuel injection time for cylinder No.1Idling: 1.6 - 2.9 ms
IAC DUTY RATIOIntake Air Control Valve Duty Ratio
Opening ratio rotary solenoid type IAC valveIdling: 27 - 47 %
STARTER SIGStarter SignalCranking: ON
CTP SIGClosed Throttle Position SignalThrottle fully closed: ON
A/C SIGA/C Switch SignalA/C ON: ON
PNP SWPark/Neutral Position Switch SignalP or N position: ON
ELCTRCL LOAD SIGElectrical Load SignalDefogger switch ON: ON
STOP LIGHT SWStop Light Switch SignalStop light switch ON: ON
PS OIL PRESS SWPower Steering Oil Pressure Switch SignalTurn steering wheel: ON
FC IDLFuel Cut Idle: Fuel cut when throttle valve fully
closed, during decelerationFuel cut operating: ON
FC TAUFuel Cut TAU: Fuel cut during very light loadFuel cut operating: ON
CYL#1 - CYL#6Abnormal revolution variation for each cylinder0 %
IGNITIONTotal number of ignition for every 1,000 revolu-
tions0 - 3,000
INTAKE CTRL VSVIntake Air Control Valve VSV SignalVSV operating: ON
A/C CUT SIGA/C Cut SignalA/C S/W OFF: ON
FUEL PUMPFuel Pump SignalIdling: ON