1999 DODGE RAM steering wheel

[x] Cancel search: steering wheel

air bleeding diagram oil capacities center console brake pads dead battery open trunk

Load previous 8 pages

Page 862 of 1691

DODGE RAM 1999 Service Repair Manual 1) Disconnect negative battery cable. On A/T models, turn
ignition switch to UNLOCK position and shift gear selector to "1"
position. On models equipped with tilt steering wheel, tilt wheel t

Page 866 of 1691

DODGE RAM 1999 Service Repair Manual Fig. 8: Removing Shift Indicator (Ram Van & Ram Wagon)
Courtesy of Chrysler Corp.
HEADLIGHT SWITCH
Removal & Installation (Ram Pickup)
1) Disconnect negative battery cable

Page 887 of 1691

$DODGE RAM 1999 Service Repair Manual LUBRICATION SPECIFICATIONS TABLE - DIESEL�\ \ \ \ \ \ \ M$

LUBRICATION SPECIFICATIONS TABLE - DIESEL\
\
\
\
\
\
\

Material Condition Specification

\
\
\
\
\
\
\
\f

Engine Oil Ambient Temperature Above 10\bF SAE 15W-40

(
1) (-12\bC) To Over 30\bF (-1\bC)

\
\
\
\
\
\
\f

Ambient Temperature Less Than SAE 10W-30

0\bF (-18\bC) To Over 30\bF(-1\bC)

\
\
\
\
\
\
\f

Ambient Temperature Less Than With Block Heater:

-10\bF(-23\bC) Up To 0\bF (-18\bC) SAE 10W-30

Without Block Heater:

SAE 5W-30

\
\
\
\
\
\
\
\f

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\
\
\
\
\
\
\
\f

Brake Fluid All DOT 3

\
\
\
\
\
\
\
\f

Automatic All ATF+2 Type 7176

Transmission

Fluid

\
\
\
\
\
\
\
\f

Transfer Case All ATF+2 Type 7176

Fluid Or DEXRON III ATF

\
\
\
\
\
\
\
\f

Manual All 75W-90 Synthc. API GL4

Transmission

Fluid

\
\
\
\
\
\
\
\f

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\
\f

Wheel Bearing All High Temperature Multi-

Grease -Purporse EP Grease

\
\
\
\
\
\
\
\f

Rear Axle All Mopar Hypoid Lubricant

Lubricant SAE 80W-90

(
2) GL-5 Gear Lube

\
\
\
\
\
\
\
\f

4x4 Front All Mopar Hypoid Lubricant

Axle SAE 80W-90

Lubricant GL-5 Gear Lube

\
\
\
\
\
\
\
\f

Power All Mopar Power Steering

Steering Fluid Or Equivalant

Fluid (
3) Petroleum Based

\
\
\
\
\
\
\
\f

Clutch All Multipurpose Grease

Linkage NLGI Grade 2 E.P.

Lubricant

\
\
\
\
\
\
\
\f

A/C All R-134a

Refrigerant

\
\
\
\
\
\
\
\f

A/C All Polyalkalene Glycol

Refrigerant SP10 PAG

Oil Refrigerant Oil

\

\
\
\

\
\
\
\f

Page 889 of 1691

$DODGE RAM 1999 Service Repair Manual \ \ \ \ \ \$

\
\
\
\
\
\
\
\f

Refrigerant A/C System Capacity 7.75 Oz. (230ML)

Oil

\
\
\
\
\
\
\
\f

Fuel Tank Capacity 35 Gal. (132L)

\

\
\
\

\
\
\
\f

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.

\
\
\
\
\
\
\

LUBRICATION SPECIFICATIONS - GAS
LUBRICATION SPECIFICATIONS TABLE - GAS\
\
\
\
\
\
\

Material Condition Specification

\
\
\
\
\
\
\
\f

Engine Oil Ambient Temperature Above 0 \bF SAE 10W-30

(
1) (-18\bC) To Over 100\bF (38\bC)

\
\
\
\
\
\
\f

Ambient Temperature Less Than SAE 5W-30

-20\bF (-29\bC) Up To 32\bF (0\bC)

\
\
\
\
\
\
\
\f

Engine All 50/50 Mixture Of

Coolant Distilled Water &

Ethylene Glycol

\
\
\
\
\
\
\
\f

Brake Fluid All DOT 3

\
\
\
\
\
\
\
\f

Automatic All ATF+2 Type 7176

Transmission

Fluid

\
\
\
\
\
\
\
\f

Transfer Case All ATF+2 Type 7176

Fluid Or DEXRON III ATF

\
\
\
\
\
\
\
\f

Manual NV-4500 75W-90 Synthc. API GL4

Transmission

\
\
\
\
\
\
\f

Fluid NV-3500 Mopar Manual

Transmission Fluid

\
\
\
\
\
\
\
\f

Steering All Mopar Multi-Mileage

Linkage Lubricant

Lubricant

\
\
\
\
\
\
\
\f

Wheel Bearing All High Temperature Multi-

Grease -Purporse EP Grease

\
\
\
\
\
\
\
\f

Rear Axle & All Mopar Hypoid Lubricant

4x4 Frt. Axle SAE 80W-90

Lubricant (
2) GL-5 Gear Lube

\
\
\
\
\
\
\
\f

Power All Mopar Power Steering

Steering Fluid Or Equivalant

Fluid (
3) Petroleum Based

\
\
\
\
\
\
\
\f

Clutch All Multipurpose Grease

Linkage NLGI Grade 2 E.P.

Lubricant

\
\
\
\
\
\
\
\f

A/C All R-134a

Page 891 of 1691

$DODGE RAM 1999 Service Repair Manual Limited Slip \ \ \ \ \ \ \f Differential Model 248 (4WD) 7.3 Pts. (3$

Limited Slip
\
\
\
\
\
\
\f

Differential Model 248 (4WD) 7.3 Pts. (3.4L)

\
\
\
\
\
\
\f

Model 267 (2WD) 7 Pts. (3.3L)

\
\
\
\
\
\
\f

Model 267 (4WD) 7.8 Pts. (3.6L)

\
\
\
\
\
\
\f

Model 286 (2WD) 6.8 Pts. (3.2L)

\
\
\
\
\
\
\f

Model 286 (4WD) 10.1 Pts. (4.8L)

\
\
\
\
\
\
\
\f

Front Axle Model 216 6.8 Pts. (3.6L)

Lubricant

\
\
\
\
\
\
\f

Model 248 7.6 Pts. (3.6L)

\
\
\
\
\
\
\
\f

Transfer Case NV231 HD 2.5 Pts. (1.2L)

Fluid

\
\
\
\
\
\
\
\f

Power Take NV021 4.6 Pts. (2.1L)

Off Adapter

\
\
\
\
\
\
\
\f

Power Drained 2.7 Pts. (1.3L)

Steering

Fluid

\
\
\
\
\
\
\
\f

A/C Charge Capacity 32 Oz. (.9Kg)

Refrigerant

\
\
\
\
\
\
\
\f

Refrigerant A/C System Capacity 7.75 Oz. (230ML)

Oil

\
\
\
\
\
\
\
\f

Fuel Tank 119" & 139" Wheelbase Vehicles 26 Gal. (98L)

\
\
\
\
\
\
\f

All Others 35 Gal. (132L)

\

\
\
\

\
\
\
\f

(
1) - Capacities are recommended or calculated levels. Always use

dipstick (if available) to measure level.

\
\
\
\
\
\
\

WHEEL & TIRE SPECIFICATIONS
TIRE REPLACEMENT
The tires on your new vehicle provide a balance of many
characteristics. They should be inspected regularly for wear and
correct inflation pressure. Chrysler strongly recommends that you use
tires equivalent to the originals in quality and performance when
replacement is needed. Failure to use equivalent replacement tires may
adversely affect the safety, handling and ride of your vehicle. We
recommend that you contact your original equipment tire dealer on any
questions you may have on tire specifications or capability.
TORQUE SPECIFICATIONS
TORQUE SPECIFICATIONS TABLE\
\
\
\
\
\

Lug Nut Ft. Lbs. (N.m)
BR1500 (5 Stud Wheel) ........................... 95 (130)
BR2500 (8 Stud Wheel) ........................... 135 (180)

Page 892 of 1691

$DODGE RAM 1999 Service Repair Manual BR3500 (8 Stud Dual Wheel)........................ 145 (195)\ \ \ \ \ \$

BR3500 (8 Stud Dual Wheel)........................ 145 (195)\
\
\
\
\
\

BATTERY SPECIFICATIONS
Vehicle is factory equipped with a maintenance free battery.
The top of the battery is permanently sealed, and water never has to
be added, and periodic maintenance is not required either. But,
periodically check the battery terminals and battery hold-down bracket
for corrosion. Replace with a battery of the same group number as
shown on original battery's label.
CAUTION: When battery is disconnected, vehicles equipped with
computers may lose memory data. When battery power is
restored, driveability problems may exist on some vehicles.
These vehicles may require a relearn procedure. See COMPUTER
RELEARN PROCEDURES article in the GENERAL INFORMATION
section.
CAUTIONS & WARNINGS
SUPPLEMENTAL RESTRAINT SYSTEM (AIR BAG)
NOTE: See the AIR BAGS article in the ACCESSORIES/SAFETY EQUIPMENT
Section.
Modifications or improper maintenance, including incorrect
removal and installation of the Supplemental Restraint System (SRS),
can adversely affect system performance. DO NOT cover, obstruct or
change the steering wheel horn pad in any way, as such action could
cause improper function of the system. Use only plain water when
cleaning the horn pad. Solvents or cleaners could adversely affect the
air bag cover and cause improper deployment of the system.
WARNING: To avoid injury from accidental air bag deployment, read and
carefully follow all warnings and service precautions. See
appropriate AIR BAGS article in ACCESSORIES/SAFETY EQUIPMENT.
WARNING: Any maintenance performed on or near the components of the
SRS must be performed only by an authorized dealer.
Do not permit anyone else to service, inspect maintain, or
service any SRS components or wiring. Similarly, no part of
the SRS should ever be handled or disposed of by anyone
except an authorized dealer.
Improper work on the SRS components or wiring could result in
inadvertent deployment of the airbags or could render the SRS
system inoperative. Either situation could result in serious
injury
WARNING: If the car has had any front-end damage, have the SRS system
inspected by an authorized dealer to ensure it is working
properly.
WARNING: If any of the following conditions occur, the SRS is not
working properly. Immediately have it inspected by an
authorized dealer:
* The SRS warning light does not illuminate when you start
the car.
* The SRS warning light does not go off after about 7 seconds.
* The SRS warning light illuminates while driving.

Page 893 of 1691

DODGE RAM 1999 Service Repair Manual CAUTION: Disconnect negative battery cable before servicing any air
bag system, steering column or passenger side dash
component. After any repair, turn ignition key to the ON

CAUTION: Disconnect negative battery cable before servicing any air
bag system, steering column or passenger side dash
component. After any repair, turn ignition key to the ON
position from passenger's side of vehicle in case of
accidental air bag inflation
AIR CONDITIONING SERVICING
WARNING: Avoid breathing R-134a refrigerant and PAG lubricant vapors,
exposure may irritate eyes, nose and throat. To remove
R-134a from system use R-134a recycling equipment that meets
SAE J2210 specifications. If accidental system discharge
occurs, ventilate work area before resuming service.
WARNING: R-134a service equipment or vehicle A/C systems SHOULD NOT
be pressure tested or leak tested with compressed air. Some
mixtures of air/R134a have shown to be combustible at
elevated pressures. These mixtures are dangerous and may
cause fire and/or explosions. See AIR CONDITIONING SERVICE
article in GENERAL INFORMATION section.
AIR CONDITIONING MAINTENANCE
WARNING: NEVER add A/C refrigerant to correct a non-cooling problem
unless pressure gauges are connected to the system by a
certified technician. Lack of cooling may be caused by a
restriction, therefore adding refrigerant can cause a
dangerous pressure rise.
ANTI-LOCK BRAKE SYSTEM
CAUTION: The anti-lock brake system contains electronic equipment that
can be susceptible to interference caused by improperly
installed or high output radio transmitting equipment. Since
this interference could cause the possible loss of the
antilock braking capability, such equipment should be
installed by qualified professionals.
On models equipped with anti-lock brake systems, ALWAYS
observe the following cautions:
* DO NOT attempt to bleed hydraulic system without first
referring to the appropriate ANTI-LOCK BRAKE SYSTEM article
in the BRAKES Section.
* DO NOT mix tire sizes. As long as tires remain close to the
original diameter, increasing the width is acceptable.
Rolling diameter must be identical for all 4 tires. Some
manufacturers recommend tires of the same brand, style and
type. Failure to follow this precaution may cause inaccurate
wheel speed readings.
* Use ONLY recommended brake fluids. DO NOT use silicone brake
fluids in an ABS-equipped vehicle.
AUTOMATIC TRANSAXLE FLUID SERVICE
WARNING: Make certain no fluid is spilled when the transaxle fluid
is inspected. Wipe up any spilled fluid completely.
AXLE FLUID
CAUTION: Axle lubricant should be changed whenever the axle has

Page 997 of 1691

$DODGE RAM 1999 Service Repair Manual ��\ ��\ ��\ ��\ ��\ ��\ ��\ �� Application$

\
\
\
\
\
\
\

Application Ft. Lbs. (N.m)\
Crankshaft Position Sensor Bolt
2.5L ..................................................... 14 (19)\
3.9L, 5.2L & 5.9L ............................................ (1)
8.0L ......................................................... ( 1)
Downstream Oxygen Sensor ................................... 22 (30)\
Distributor Hold-Down Bolt ................................. 17 (23)\
EVAP Canister-To-Mounting Bracket Nut
Dakota & Durango ......................................... 17 (23)\
Ram Pickup ................................................... ( 2)
Ram Van & Ram Wagon .......................................... ( 3)
Fuel Pump Module Lock Nut
Dakota ................................................... 40 (54)\
Ram Pickup ............................................... 32 (43)\
Ram Van & Ram Wagon ...................................... 40 (54)\
Fuel Rail Bolt
2.5L ......................................................... ( 4)
3.9L, 5.2L & 5.9L ........................................ 17 (23)\
8.0L ..................................................... 11 (15)\
Fuel Tank Strap Nut
Dakota & Durango ......................................... 40 (54)\
Ram Pickup ............................................... 30 (41)\
Ram Van & Ram Wagon .......................................... ( 5)
IAT Sensor ................................................. 20 (27)\
Park/Neutral Switch ........................................ 25 (34)\
Power Steering Pressure Switch (2.5L) ...................... 16 (22\
)
Spark Plug ................................................. 30 (41)\
Throttle Body Bolt
2.5L ......................................................... ( 4)
3.9L, 5.2L & 5.9L ........................................ 17 (23)\
Throttle Body Nut (8.0L) ................................... 16 (22\
)
Upper Intake Manifold Bolt (8.0L) ...................... ( 6) 16 (22)
Upstream Oxygen Sensor ..................................... 22 (30)\
Wheel Lug Nut (Dakota & Durango) ......................... 100 (136\
)
INCH Lbs. (N.m)
Air Cleaner Housing-To-Throttle
Body Nut (Dakota & Durango) ............................. 96 (10.8\
)
Camshaft Position Sensor Bolt (8.0L) ...................... 50 (5.6\
)
Engine Coolant Temperature Sensor ........................ 96 (10.8)\
EVAP Canister Mounting Bracket-To
Body Nut (Ram Van & Ram Wagon) .......................... 95 (10.7\
)
EVAP Leak Detection Pump Filter
Bolt (Ram Pickup, Ram Van & Ram Wagon) ................... 65 (7.3\
)
EVAP Leak Detection Pump Bolt ............................. 11 (1.2)\
EVAP Purge Solenoid Nut (Dakota & Durango) ................ 75 (8.5\
)
IAC Motor Bolt ............................................ 60 (6.8)\
Ignition Coil Bolt/Nut
Dakota, Durango, Ram Van & Ram Wagon ......................... ( 7)
Ram Pickup
3.9L, 5.2L & 5.9L ........................................... ( 7)
8.0L .................................................. 90 (10.2)\
MAP Sensor Bolt
Dakota & Durango ........................................ 25 (2.8)\
Ram Pickup
3.9L, 5.2L & 5.9L ...................................... 25 (2.8)\
8.0L ................................................... 20 (2.3)\
Ram Van & Ram Wagon ..................................... 25 (2.8)\
PCM Bolt .................................................. 35 (4.0)\
TP Sensor Bolt ............................................ 60 (6.8)\

Load next 8 pages

Page: < prev 1-10 ... 9-16 17-24 25-32 33-40 41-48 49-56 57-64 65-72 ... 120 next >

brake sensor trailer reset sun roof lane assist cabin filter rims