1999 DODGE NEON clock

(5) Lift module and disconnect the airbag and horn
wire connectors.
(6) Remove steering wheel retaining nut.
(7) Remove the steering wheel with a steering
wheel puller. While removing the steering wheel take
care to feed the wires gently through the holes in the
clockspring armature.
INSTALLATION
(1) Confirm that:
²The steering wheel position is a half turn (180
degrees) to the right (clockwise)
²The column is locked with the ignition cylinder
lock.
²Check that the turn signal stalk is in the neu-
tral position
(2) Install the steering wheel ensuring the flats on
hub align with the clockspring. Pull the horn lead,
airbag and speed control leads through the larger
slot. Ensure leads do not get pinched under the steer-
ing wheel.
(3) Install the steering wheel retaining nut, and
tighten it to 61 N´m (45 ft. lbs.) torque.
(4) Install the airbag module. Refer to Driver Air-
bag Module Removal and Installation for proper pro-
cedures.
(5) Do not connect the battery negative cable.
Refer to Diagnosis and Testing for Airbag System
Test procedures.
ADJUSTMENTS
CLOCKSPRING CENTERING PROCEDURE
If the rotating tape within the clockspring is not
positioned properly with the steering wheel and the
front wheels, the clockspring may fail during use.
The following procedure MUST BE USED to center
the clockspring if:²The clockspring is not known to be properly
positioned
²The front wheels were moved
²The steering wheel was moved from the half
turn (180 degrees) to the right (clockwise) position.
WARNING: DISCONNECT AND ISOLATE THE BAT-
TERY NEGATIVE (GROUND) CABLE BEFORE
BEGINNING ANY AIRBAG SYSTEM COMPONENT
REMOVAL OR INSTALLATION PROCEDURE. THIS
WILL DISABLE THE AIRBAG SYSTEM. FAILURE TO
DISCONNECT BATTERY COULD RESULT IN ACCI-
DENTAL AIRBAG DEPLOYMENT AND POSSIBLE
PERSONAL INJURY.
ALLOW SYSTEM CAPACITOR TO DISCHARGE
FOR 2 MINUTES BEFORE REMOVING ANY AIRBAG
COMPONENTS.
(1) Remove clockspring, refer to Clockspring
Removal.
(2) Rotate the clockspring rotor in the CLOCK-
WISE DIRECTION to the end of travel. Do not apply
excessive torque.
(3) From the end of travel, rotate the rotor two full
turns and a half in the counterclockwise direction.
The horn wire and the squib wire should end up at
the bottom. If not, rotate the rotor counter clockwise
until the wires are properly orientated, but not more
than half turn (180 degrees). Engage clockspring
locking mechanism.
(4) For installation, refer to Clockspring Installa-
tion
(5) Do not connect battery negative cable. Refer to
Diagnosis and Testing for Airbag System Test
procedures.
PLRESTRAINT SYSTEM 8M - 11
REMOVAL AND INSTALLATION (Continued)

parking lamps out put. Press the panic button and
check for a voltage pulse (Fig. 2).
(2) If no voltage pulse is measured, replace the
receiver. If voltage OK, repair circuit to the parking
lamps as necessary.
(3) Connect the meter to Pin 5 of the black connec-
tor and to ground to test head lamps out put. Press
the panic button and check for a voltage pulse (Fig.
2).
(4) If no voltage pulse is measured, replace the
receiver. If voltage OK, repair circuit to the head
lamps as necessary.
REMOTE KEYLESS ENTRY SYSTEM
When trouble shooting problems with the Remote
Keyless Entry System, always verify that the power
door lock/unlock switches are functional. If the doors
do not lock/unlock refer to Group 8W, Wiring Dia-
gram for Pin and wiring locations.
If the following items do not work:
²Remote keyless entry system
²Radio/clock
²Door lock switches
A blown fuse is the probable cause. Check fuses 2,
3 and 11 in the fuse block. To check for a blown fuse,
pull the fuse out slightly, but maintain contact
between the fuse terminals and the terminals in fuse
block. Using the voltmeter probe, check both termi-
nals for 12 volts. If only one terminal measures bat-
tery voltage, the circuit breaker is defective and must
be replaced. If neither terminal measures battery
voltage, check the high current fuses 3 and 11 in the
Power Distribution Center (PDC). The PDC is located
in the engine compartment. If fuse(s) are NOT OK,
replace fuse(s) or repair as necessary. If fuses are
OK, check for an open or shorted circuit to the Power
Distribution Center, repair as needed.
SERVICE PROCEDURES
HORN CHIRP CANCELLATION
During the programming operation the horn chirp
can be disabled or enable using the following proce-
dure. One or both transmitters can be program to be
disabled or enable.
(1) Retrieve the programming line from the upper
edge of the passenger side cowl trim panel upper
edge. The RKE Programming Line is a green wire
with a red bullet connector.
(2) Using a jumper wire, ground the RKE pro-
gramming line.
(3) Turn ignition switch to the ON position.
(4) Press any button on the transmitter. The locks
will cycle to confirm programming,
(5) To disable or enable horn chirp press the lock
button on the transmitter four times and the hornwill sound to confirm programming. Press the lock
button on the second transmitter four times and the
horn will sound to confirm programming.
(6) Disconnect the programming line from ground.
This returns the system to its normal operation
mode.
(7) Replace any removed components. Return pro-
gramming line chirpto its original position. Check for
system operation.
PANIC FUNCTION CANCELLATION
During the programming operation the panic func-
tion can be disabled or enable using the following
procedure. One or both transmitters can be program
to be disabled or enable.
(1) Retrieve the programming line from the upper
edge of the passenger side cowl trim panel. The RKE
Program Line is a green wire with a red bullet con-
nector.
(2) Using a jumper wire, ground the RKE Pro-
gramming Line.
(3) Turn ignition switch to the ON position.
(4) Press any button on the transmitter. The locks
will cycle to confirm programming,
(5) To disable or enable panic function press the
panic button on the transmitter four times and the
horn will sound to confirm programming. Press the
panic button on the second transmitter four times
and the horn will sound to confirm programming.
(6) Disconnect the programming line from ground.
This returns the system to its normal operation
mode.
(7) Replace any removed components. Return the
programming line to its original position. Check for
system operation.
PROGRAM REMOTE KEYLESS ENTRY MODULE
(1) Retrieve the programming line from the upper
edge of the passenger side cowl trim panel. The RKE
Programming Line is a green wire with a red bullet
connector.
(2) Using a jumper wire, ground the RKE pro-
gramming line.
(3) Turn ignition switch to the ON position.
(4) Press any button on the transmitter to set
code. The locks will cycle to confirm programming. If
there is a second transmitter it must be set at this
time. Press any button on the second transmitter and
wait for the locks to cycle to confirm programming.
(5) Disconnect the programming line from ground.
This returns the system to its normal operation
mode.
(6) Replace all removed components. Return pro-
gramming line to its original position. Check for sys-
tem operation.
PLPOWER DOOR LOCKS 8P - 5
DIAGNOSIS AND TESTING (Continued)

8W-02 COMPONENT INDEX
Component Page
A/C Compressor Clutch..................8W-42
A/C Compressor Clutch Relay.............8W-42
A/C Cycling Switch.....................8W-42
A/C Heater Blower Motor................8W-42
A/C Heater Control.....................8W-42
A/C Pressure Switches...................8W-42
ABS Warning Lamp Relay................8W-35
Airbag Control Module...................8W-43
Airbags..............................8W-43
Antenna..............................8W-47
Ash Receiver Lamp.....................8W-44
Automatic Shut Down Relay..............8W-30
Back-Up Lamp Switch...................8W-51
Back-Up Lamps........................8W-51
Battery..............................8W-20
Battery Temperature Sensor..............8W-30
Blower Motor Resistor Block..............8W-42
Brake Warning Lamp Switch...........8W-40, 50
Camshaft Position Sensor................8W-30
Center High Mounted Stop Lamp..........8W-51
Cigar Lighter Relay.....................8W-41
Cigar Lighter/Power Outlet...............8W-41
Circuit Breakers.......................8W-11
Clockspring.....................8W-30, 41, 61
Clutch Pedal Position Switch...........8W-10, 21
Combination Flasher....................8W-52
Controller Anti-Lock Brake...............8W-35
Crankshaft Position Sensor...............8W-30
Data Link Connector....................8W-30
Daytime Running Lamp Module...........8W-50
Diode No. 1........................8W-15, 42
Diode No. 2......................8W-10, 11, 44
Diode No. 3......................8W-11,44,70
Dome Lamp...........................8W-44
Door Ajar Switches.....................8W-44
Door Jamb Switches....................8W-44
Door Lock Motors......................8W-61
Door Lock Motors......................8W-61
Door Lock Switches.....................8W-61
Duty Cycle Evap/Purge Solenoid...........8W-30
EGR Transducer Solenoid................8W-30
Engine Coolant Temperature Sensor........8W-30
Engine Oil Pressure Switch...............8W-40
Engine Starter Motor....................8W-21
Engine Starter Motor Relay...............8W-21
Fog Lamp Relays....................8W-50, 51
Fog Lamp Switches..................8W-50, 51
Fog Lamps.........................8W-50, 51
Fuel Injectors..........................8W-30
Fuel Pump Module.....................8W-30
Fuel Pump Relay.......................8W-30
Fuse Block............................8W-11Component Page
Fuses (FB)............................8W-11
Fuses (PDC)...........................8W-10
Fusible Link........................8W-20, 21
Generator.............................8W-20
Glove Box Lamp And Switch..............8W-44
Grounds..............................8W-15
Halo Lamp............................8W-44
Headlamp Dimmer And Optical Horn Switch .8W-50
Headlamp Leveling Motors...............8W-50
Headlamp Leveling Switch...............8W-50
Headlamp Switch.......................8W-50
Headlamps............................8W-50
High Speed Warning Module..............8W-40
Horn Relay...........................8W-41
Horn Switches.........................8W-41
Horns................................8W-41
IAT/Map Sensor........................8W-30
Idle Air Control Motor...................8W-30
Ignition Coil Pack......................8W-30
Ignition Switch........................8W-10
Illumination Lamps.....................8W-40
Immobilizer...........................8W-61
Immobilizer Engine Sensor............8W-30, 61
Indicator Lamps........................8W-40
Instrument Cluster.....................8W-40
Intermittent Wipe/Wash Switch............8W-53
Key-In Switch.........................8W-40
Knock Sensor..........................8W-30
License Lamps.........................8W-51
Map/Reading Lamps....................8W-44
Noise Supressor.....................8W-10, 30
Oxygen Sensors........................8W-30
Park Brake Switch...................8W-40, 50
Park/Neutral Position Switch...........8W-30, 51
Park/Turn Signal Lamps..............8W-50, 52
Power Distribution Center................8W-10
Power Folding Mirror Relay...............8W-62
Power Mirror Fuse Holder................8W-62
Power Mirrors.........................8W-62
Power Steering Pressure Switch...........8W-30
Power Sunroof Motor....................8W-64
Power Window Motors...................8W-60
Power Window Switches.................8W-60
Powertrain Control Module...............8W-30
PRNDL Lamp.........................8W-44
Radiator Fan Motor.....................8W-42
Radio................................8W-47
Rear Window Defogger..................8W-48
Rear Window Defogger Switch.............8W-48
Remote Keyless Entry Module.............8W-61
Remote Keyless Entry Program
Module Connector....................8W-61
PL8W - 02 COMPONENT INDEX 8W - 02 - 1

8W-15 GROUND DISTRIBUTION
Component Page
A/C Compressor Clutch...............8W-15-5, 6
A/C Compressor Clutch Relay..........8W-15-5, 6
A/C Heater Control....................8W-15-9
ABS Warning Lamp Relay............8W-15-7, 8
Airbag Control Module...............8W-15-7, 8
Ash Receiver Lamp................8W-15-10, 11
Battery...........................8W-15-7, 8
Brake Warning Lamp Switch..........8W-15-2, 3
Center High Mounted Stop Lamp.....8W-15-12, 14
Cigar Lighter Relay...................8W-15-11
Cigar Lighter/Power Outlet..........8W-15-10, 11
Clockspring..........................8W-15-7
Combination Flasher.................8W-15-7, 8
Controller Anti-Lock Brake............8W-15-2, 3
Data Link Connector..................8W-15-4
Daytime Running Lamp Module..........8W-15-7
Diode No. 1........................8W-15-5, 6
Downstream Heated Oxygen Sensor.....8W-15-2, 3
Driver Door Lock Switch................8W-15-9
Driver Power Window Switch............8W-15-9
Engine Starter Motor Relay...........8W-15-2, 3
Fog Lamp Relay......................8W-15-3
Fog Lamp Switch....................8W-15-10
Front Fog Lamp Switch...............8W-15-11
Fuel Pump Module................8W-15-12, 13
G101.............................8W-15-2, 3
G102...............................8W-15-4
G103.............................8W-15-5, 6
G104.............................8W-15-7, 8
G105.............................8W-15-7, 8
G110.............................8W-15-7, 8
G111...............................8W-15-8
G201.............................8W-15-7, 8
G202.............................8W-15-7, 8
G203...............................8W-15-9
G204...........................8W-15-10, 11
G301...........................8W-15-12, 13
G302...........................8W-15-12, 14
G303...........................8W-15-12, 13
Glove Box Lamp And Switch.........8W-15-10, 11
Halo Lamp......................8W-15-10, 11
Headlamp Leveling Switch.............8W-15-11
Headlamp Switch.................8W-15-10, 11
High Speed Warning Module............8W-15-8
Horn...............................8W-15-2
Horn No. 1..........................8W-15-6
Horn No. 2..........................8W-15-3
Horn Switches.......................8W-15-7
Ignition Switch...................8W-15-10, 11Component Page
Immobilizer..........................8W-15-8
Instrument Cluster................8W-15-10, 11
Intermittent Wipe/Wash Switch........8W-15-7, 8
Left Back-Up Lamp................8W-15-12, 14
Left Fog Lamp.....................8W-15-5, 6
Left Headlamp.....................8W-15-2, 3
Left Headlamp Leveling Motor...........8W-15-3
Left License Lamp...................8W-15-14
Left Park/Turn Signal Lamp...........8W-15-2, 3
Left Rear Fog Lamp..................8W-15-14
Left Repeater Lamp...................8W-15-3
Left Tail/Stop Lamp..................8W-15-14
Left Tail/Stop/Turn Signal Lamp.........8W-15-12
Left Turn Signal Lamp................8W-15-14
License Lamp.......................8W-15-12
Map/Reading Lamps...............8W-15-10, 11
Power Folding Mirror Relay.............8W-15-9
Power Mirror Switch...................8W-15-9
Power Steering Pressure Switch..........8W-15-4
Power Sunroof Motor..................8W-15-9
Powertrain Control Module..............8W-15-4
PRNDL Lamp....................8W-15-10, 11
Radiator Fan Motor.................8W-15-2, 3
Radio.............................8W-15-7, 8
Rear Fog Lamp Switch................8W-15-11
Rear Window Defogger.............8W-15-12, 13
Rear Window Defogger Switch.........8W-15-7, 8
Remote Keyless Entry Module...........8W-15-7
Right Back-Up Lamp...............8W-15-12, 13
Right Fog Lamp....................8W-15-5, 6
Right Headlamp....................8W-15-5, 6
Right Headlamp Leveling Motor..........8W-15-6
Right License Lamp..................8W-15-14
Right Park/Turn Signal Lamp..........8W-15-5, 6
Right Rear Fog Lamp.................8W-15-13
Right Repeater Lamp..................8W-15-6
Right Tail/Stop Lamp.................8W-15-13
Right Tail/Stop/Turn Signal Lamp.......8W-15-12
Right Turn Signal Lamp...............8W-15-13
Seat Belt Switch..................8W-15-12, 14
Solid State Fan Relay................8W-15-2, 3
Stop Lamp Switch.....................8W-15-4
Sunroof Vent Switch...................8W-15-9
Underhood Lamp...................8W-15-2, 3
Upstream Heated Oxygen Sensor.......8W-15-2, 3
Vehicle Speed Control Servo.............8W-15-2
Vehicle Speed Control Switch............8W-15-7
Windshield Washer Pump Motor........8W-15-2, 3
PL8W - 15 GROUND DISTRIBUTION 8W - 15 - 1

1
B3
8
2
3
SWITCH WASH
WIPE/
INTERMITTENT
(IN FB) COMBINATIONMODULE LAMP
RUNNING
DAYTIME
SWITCH DEFOGGER
WINDOW
REARMODULE ENTRY
KEYLESS
REMOTE
S205
Z2
22
BK/LGZ2
20
BK/LGZ2
22
BK/LGZ2
22
BK/LGZ2
22
BK/LG
RADIO
Z2
20
BK/LGZ9
14
BK
G201 C1
FLASHER
BK18Z1
(IN PDC) RELAY
LAMP
WARNING
ABS41
G110
Z0
8
BK
G104
Z1
10
BK
G105 BATTERY
SWITCH CONTROL
SPEED
VEHICLE
SWITCHES
HORN
Z10
20
BK/TN
10
AIRBAG
CONTROL
MODULE
Z6
18
BK/PK
G202
2
CLOCKSPRING
(8W-47-2)(8W-61-6)
(8W-48-2) (8W-50-14)
(8W-52-2) (8W-53-3)
(8W-35-3)
(8W-30-14)
(8W-41-2) (8W-43-2)(8W-41-2)
(8W-30-14)
(8W-20-2)
PL8W-15 GROUND DISTRIBUTION
EXCEPT BUILT-UP-EXPORT8W - 15 - 7
8235J988W-1

8W-30 FUEL/IGNITION SYSTEMS
Component Page
A/C Compressor Clutch Relay...........8W-30-12
A/C High Pressure Switch..............8W-30-12
Airbag Control Module.................8W-30-4
Automatic Shut Down Relay...........8W-30-2, 3
Battery Temperature Sensor...........8W-30-3, 7
Camshaft Position Sensor............8W-30-7, 16
Center High Mounted Stop Lamp........8W-30-15
Clockspring.........................8W-30-14
Controller Anti-Lock Brake...........8W-30-4, 15
Crankshaft Position Sensor...........8W-30-7, 16
Data Link Connector.................8W-30-2, 4
Downstream Heated Oxygen Sensor.......8W-30-3
Duty Cycle Evap/Purge Solenoid.......8W-30-9, 10
EGR Transducer Solenoid............8W-30-9, 10
Engine Coolant Temperature Sensor.......8W-30-7
Engine Starter Motor Relay............8W-30-13
Fuel Injector No. 1....................8W-30-5
Fuel Injector No. 2....................8W-30-5
Fuel Injector No. 3....................8W-30-5
Fuel Injector No. 4....................8W-30-5
Fuel Pump Module...................8W-30-11
Fuel Pump Relay.....................8W-30-11
Fuse 10 (FB)...................8W-30-9, 10, 11
Fuse 21 (PDC).................8W-30-2, 3, 4, 11
Fuse 25 (PDC).......................8W-30-15
Fuse Block.....................8W-30-9, 10, 11
G101............................8W-30-3, 14
G102.......................8W-30-2, 4, 14, 15Component Page
G202..............................8W-30-14
G303..............................8W-30-11
Generator..........................8W-30-12
Iat/Map Sensor.......................8W-30-6
Idle Air Control Motor.................8W-30-8
Ignition Coil Pack.....................8W-30-5
Immobilizer.....................8W-30-3, 8, 16
Immobilizer Engine Sensor.............8W-30-16
Instrument Cluster............8W-30-7, 8, 11, 12
Knock Sensor........................8W-30-6
Noise Supressor......................8W-30-5
Park/Neutral Position Switch...........8W-30-13
Power Distribution Center.....8W-30-2, 3, 4, 11, 15
Power Steering Pressure Switch..........8W-30-4
Powertrain Control
Module..........8W-30-2, 3, 4, 5, 6, 7, 8, 9, 10,
11, 12, 13, 14, 15, 16
Solid State Fan Relay.................8W-30-12
Stop Lamp Switch.................8W-30-14, 15
Throttle Position Sensor................8W-30-6
Torque Converter Clutch Solenoid......8W-30-9, 10
Turn Signal/Hazard Switch.............8W-30-15
Upstream Heated Oxygen Sensor.........8W-30-3
Vapor Canister Leak Detector............8W-30-9
Vehicle Speed Control Servo.........8W-30-14, 15
Vehicle Speed Control Switch...........8W-30-14
Vehicle Speed Sensor................8W-30-8, 16
PL8W - 30 FUEL/IGNITION SYSTEMS 8W - 30 - 1

C14162C15C278C180C1MODULE CONTROL
POWERTRAIN
SPEED
CONTROL
SWITCH
SENSE SENSE SWITCHLAMPSTOP
(+) FEED SOLENOIDSCONTROLSPEED
V37
20
RD/LG
10C103
V37
22
RD/LG
1
2
43
Z12
20
BK/TN
K29
20
WT/PKV32
20
YL/RD
V32
20
YL/RD
8C160
3
412
V36
20
TN/RDV35
20
LG/RD
V40
20
WT/BR
SERVO CONTROL
SPEED
VEHICLE
Z1
20
BK
Z1
18
BK
S107
G101
3 2 140
4 ON 2 SET/COAST
3 RES/ACCEL VEHICLE
SPEED
CONTROL
SWITCH
1 CANCEL
0 OFF CLOCKSPRING
3
CLOCKSPRING
BK/TN20 Z10 2
S104
G102G202
Z12
18
BK/TN
DUMP
SOLENOID SPEED
CONTROL
VENT
SOLENOID
CONTROL
(-) (-)CONTROL SOLENOIDVACUUM CONTROLSPEED
STOP
LAMP
SWITCH
(8W-15-2)
(8W-15-3)
(8W-15-2)
(8W-15-3)(8W-15-4)
(8W-15-4)(8W-15-7)
(8W-15-8) (8W-30-15)
8W - 30 - 14 8W-30 FUEL/IGNITION SYSTEMPL
J988W-18261

8W-41 HORN/CIGAR LIGHTER
Component Page
Cigar Lighter Relay...................8W-41-5
Cigar Lighter/Power Outlet............8W-41-4, 5
Clockspring........................8W-41-2, 3
Fuse 1 (FB)........................8W-41-4, 5
Fuse 3 (PDC)......................8W-41-4, 5
Fuse 15 (FB).........................8W-41-5
Fuse 23 (PDC)......................8W-41-2, 3
Fuse Block........................8W-41-4, 5
G101.............................8W-41-2, 3
G103...............................8W-41-3
G202...............................8W-41-2Component Page
G204.............................8W-41-4, 5
Horn...............................8W-41-2
Horn No. 1..........................8W-41-3
Horn No. 2..........................8W-41-3
Horn Relay........................8W-41-2, 3
Horn Switches.......................8W-41-2
Left Horn Switch.....................8W-41-3
Power Distribution Center........8W-41-2, 3, 4, 5
Remote Keyless Entry Module...........8W-41-2
Right Horn Switch....................8W-41-3
PL8W - 41 HORN/CIGAR LIGHTER 8W - 41 - 1