1997 SSANGYONG KORANDO service

SSANGYONG MY2002
9E-10 INSTRUMENTATION, DRIVER INFORMATION
COOL
HOT
KAA9E030
KAA9E040
CENTER FACIA
Removal and Installation Procedure
1. Remove the floor console. Refer to Section 9G,
Floor Console
2. Remove the center tray. Refer to “Center Tray” in
this section.
3. Remove the center facia with the screws.
4. Installation should follow the removal procedure
in the reverse order.
ASHTRAY
Removal and Installation Procedure
1. Remove the center facia. Refer to “Center Facia”
in this section.
2. Remove the ashtray assembly from the center
facia.
3. Installation should follow the removal procedure
in the reverse order.
KAA9E020
ON-VEHICLE SERVICE
UNIT REPAIR
CENTER TRAY
Removal and Installation Procedure
1. Pull the center tray.
2. Installation should follow the removal procedure
in the reverse order.
REPAIR INSTRUCTIONS

Description and Operation.................................. 9F-2
Speakers............................................................ 9F-2
Mast Antenna..................................................... 9F-2
Tape Player and Cassette Care........................... 9F-2
Components Locator ........................................... 9F-3
Audio System..................................................... 9F-3
Repair Instructions............................................... 9F-4
SECTION 9F
AUDIO SYSTEM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless
otherwise noted.
TABLE OF CONTENTS
On-Vehicle Service Unit Repair............................... 9F-4
Stereo Cassette AM/FM Radio............................ 9F-4
Front Door Speakers........................................... 9F-4
Rear Speakers.................................................... 9F-5
Mast Antenna..................................................... 9F-5
Schematic and Routing Diagram....................... 9F-7
Audio System Circuit .......................................... 9F-7

SSANGYONG MY2002
9F-4 AUDIO SYSTEM
KAA9F030
KAA9F040
4. Disconnect the audio system electrical connectors.
5. Installation should follow the removal procedure
in the reverse order.
FRONT DOOR SPEAKERS
Removal and Installation Procedure
1. Disconnect negative battery cable.
2. Remove the front door trim panel. Refer to Section
9G, Interior Trim.
3. Disconnect the electrical connector.
4. Remove the screws and the front door speaker.
5. Installation should follow the removal procedure
in the reverse order.
KAA9F020
ON-VEHICLE SERVICE
UNIT REPAIR
STEREO CASSETTE AM/FM
RADIO
Removal and Installation Procedure
1. Disconnect negative battery cable.
2. Remove the audio system trim plate.
3. Remove the screws and the audio system.
REPAIR INSTRUCTIONS

Description and Operation..................................9G-2
Interior Trim Panels.............................................9G-2
Floor Console.....................................................9G-2
Floor Carpet........................................................9G-2
Components Locator ...........................................9G-3
Interior Trim........................................................9G-3
Repair Instructions...............................................9G-4
On-Vehicle Service Unit Repair...............................9G-4
Door Trim Panel..................................................9G-4
SECTION 9G
INTERIOR TRIM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless
otherwise noted.
TABLE OF CONTENTS
A-Pillar Trim Panel...............................................9G-5
Upper Quarter Trim Panel....................................9G-5
Lower Quarter Trim Panel....................................9G-6
Cowl Side Trim Panel ..........................................9G-6
Front Rocker Trim Panel......................................9G-7
Floor Console.....................................................9G-7
Floor Carpet........................................................9G-7
Specifications......................................................9G-9
Fastener Tightening Specifications......................9G-9

SSANGYONG MY2002
9G-4 INTERIOR TRIM



yyyy yyyy
yyyy
yyyy
KAA9G030
KAA9G040
3. Remove the power window control switch.
4. Disconnect the power window control switch
electrical connector.
5. Remove the door trim panel screws.
KAA9G020
ON-VEHICLE SERVICE
UNIT REPAIR
DOOR TRIM PANEL
Removal and Installation Procedure
1. Lower the window.
2. Pry off the inside door handle trim bezel.
REPAIR INSTRUCTIONS

SECTION 9H
SEATS
TABLE OF CONTENTS
Components Locator............................................9H-2
Seats ...................................................................9H-2
Repair Instructions................................................9H-3
On-Vehicle Service Unit Repair................................9H-3
Front Seat............................................................9H-3
Front Seat Cushion..............................................9H-3
Front Seatback....................................................9H-4
Front Seat Guide Rail ...........................................9H-4
Front Seat Recliner Lever.....................................9H-5
Front Seat Trim....................................................9H-5
Head Restraint.....................................................9H-5Walk In Device....................................................9H-6
Front Seat Armrest...............................................9H-6
Rear Seat Armrest ...............................................9H-6
Rear Seat............................................................9H-7
50/50 Split Rear Seat Cushion Hinge....................9H-7
50/50 Split Rear Seat Cushion Lock Striker...........9H-8
Child Seat Anchorage ..........................................9H-8
Specifications.......................................................9H-9
Fastener Tightening Specifications.......................9H-9
Schematic and Routing Diagram......................9H-10
Seat Heater.......................................................9H-10

SEATS 9H-3
SSANGYONG MY2002
REPAIR INSTRUCTIONS
KAA9H020
ON-VEHICLE SERVICE
UNIT REPAIR
FRONT SEAT
Removal and Installation Procedure
1. Remove the electrical connector from front seat.
KAA9H030
2. Remove the bolts with the front seat.
Installation Notice
•Dissimilar metals in direct contact with each
other may corrode rapidly. Make sure to use
the correct fasteners to prevent premature
corrosion.
3. Installation should follow the removal procedure
in the reverse order.
Tightening Torque19.6 - 31.4 Nm
(14.5 - 23.2 lb-ft)
KAA9H060
FRONT SEAT CUSHION
Removal and Installation Procedure
1. Remove the front seat from the vehicle. Refer to
“front seat” in this section.
2. Remove the front seatback. Refer to “Front Seat
back” in this section.
3. Remove the seat cushion bolts.
Installation Notice
Dissimilar metals in direct contact with each
other may corrode rapidly. Make sure to use
the correct fasteners to prevent premature
corrosion.
4. Installation should follow the removal procedure
in the reverse order.
Tightening Torque16.7 - 25.5 Nm
(12 - 18 lb-ft)

SECTION 9I
WATERLEAKS
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless
otherwise noted.
TABLE OF CONTENTS
Specifications........................................................9I-2
Recommended Materials for Waterleak Repairs....9I-2
Watertest Stand Specifications.............................9I-2
Diagnosis...............................................................9I-3Waterleak Diagnosis.............................................9I-3
Maintenance and Repair......................................9I-6
On-Vehicle Service..................................................9I-6
Waterleak Repair..................................................9I-6