1996 TOYOTA TERCEL headlight bulb

BE0QP-02
- BODY ELECTRICALBODY ELECTRICAL SYSTEM
BE-1
1023 Author
: Date
:
1996 TERCEL (RM440U)
BODY ELECTRICAL SYSTEM
PRECAUTION
Take care to observe the following precautions when performing inspections or removal and replacement
of body electrical related parts.
1. HEADLIGHT SYSTEM
Halogen bulbs have pressurized gas inside and require special handling. They can burst if scratched or
dropped. Hold a bulb only by its plastic or metal case. Don't touch the glass part of a bulb with bare hands.
2. SRS (SUPPLEMENTAL RESTRAINT SYSTEM)
The TERCEL is equipped with an SRS (Supplemental Restraint System) such as the driver airbag and front
passenger airbag. Failure to carry out service operation in the correct sequence could cause the SRS to
unexpectedly deploy during servicing, possibly leading to a serious accident. Before servicing (including re-
moval or installation of parts, inspection or replacement), be sure to read the precautionary notices in the
RS section.
3. AUDIO SYSTEM

If the negative (-) terminal cable is disconnected from the battery, the preset AM, FM 1 and FM 2 sta-
tions stored in memory are erased, so be sure to note the stations and reset them after the terminal
is reconnected.

If the negative (-) terminal cable is disconnected from the battery, the ºANTI-THEFT SYSTEMº will
operate when the cable is reconnected, but the radio, tape player and CD player will not operate. Be
sure to input the correct ID number so that the radio, tape player and CD player can be operated again.
4. MOBILE COMMUNICATION SYSTEM
If the vehicle is equipped with a mobile communication system, refer to precautions in the IN section.

BE0QQ-05
BE-2
- BODY ELECTRICALBODY ELECTRICAL SYSTEM
1996 TERCEL (RM440U)
PROBLEM SYMPTOMS TABLE
The table below will be useful for you in troubleshooting these electrical problems. The most likely causes
of the malfunction are shown in the order of their probability. Inspect each part in the order shown, and re-
place the part when it is found to be faulty.
USA:
HEADLIGHT AND TAILLIGHT SYSTEM
TroubleParts nameSee page
ºLight-on warning systemº does not operate.
3. Integration Relay (I/P J/B)
4. DOME Fuse (Engine Room R/B)
5. GAUGE Fuse (I/P J/B)
6. TAIL Fuse (I/P J/B)
7. CIG/RAD Fuse (I/P J/B)
8. Wire Harness
9. Door Courtesy SwitchBE-16
-
-
-
-
-
BE-38
Only one side headlight does not light up.
1. HEAD Fuse (LH, RH) (Engine Room R/B)
2. Headlight Bulb
3. Wire Harness-
-
-
ºLo-Beamº does not light up.1. Headlight Dimmer Switch
2. Wire HarnessBE-16
-
ºHi-Beamº does not light up.1. Headlight Dimmer Switch
2. Wire HarnessBE-16
-
ºFlashº does not light up.1. Headlight Dimmer Switch
2. Wire HarnessBE-16
-
Headlight does not light up. (Taillight is normal)
1. Headlight Control Relay (Engine Room R/B)
2. Headlight Dimmer Switch
3. Light Control Switch
4. Headlight Bulb
5. Wire HarnessBE-16
BE-16
BE-16
-
-
Headlight does not light up. (Taillight does not light up)
1. Light Control Switch
2. Wire Harness
3. Headlight BulbBE-16
-
-
Only one side taillight does not light up.1. Taillight Bulb
2. Wire Harness-
-
Taillight does not light up. (Headlight is normal)
1. TAIL Fuse (I/P J/B)
2. Taillight Control Relay (I/P J/B)
3. Light Control Switch
4. Headlight Bulb
5. Wire Harness-
BE-16
BE-16
-
-
Taillight does not light up. (Headlight does not light up)
1. Light Control Switch
2. Headlight Bulb
3. Wire HarnessBE-16
-
-

- BODY ELECTRICALBODY ELECTRICAL SYSTEM
BE-3
1996 TERCEL (RM440U)
CANADA:
HEADLIGHT AND TAILLIGHT SYSTEM
TroubleParts nameSee page
ºLight-on warning systemº does not operate.
1. Integration Relay (I/P J/B)
2. DOME Fuse (Engine Room R/B)
3. GAUGE Fuse (I/P J/B)
4. TAIL Fuse (I/P J/B)
5. CIG/RAD Fuse (I/P J/B)
6. Wire Harness
7. Door Courtesy SwitchBE-16
-
-
-
-
-
BE-38
Only one side headlight does not light up.1. Headlight Bulb
2. Wire Harness-
-
ºLo-Beamº does not light up. (ALL)1. Headlight Control Relay (Engine Room R/B)
2. Wire HarnessBE-16
-
ºLo-Beamº does not light up. (ONE SIDE)
1. HEAD LH-LWR Fuse (R/B No.5)
2. HEAD RH-LWR Fuse (R/B No.5)
3. Headlight Bulb
4. Wire Harness-
-
-
-
ºHi-Beamº does not light up. (ALL)
1. DRL Fuse (Engine Room R/B)
2. Headlight Dimmer Switch
3. D.R.L. Main Relay
4. D.R.L. No.4 Relay (R/B No.5)
5. Daytime Resistor
6. Wire Harness-
BE-16
BE-16
BE-16
BE-16
-
ºHi-Beamº does not light up. (ONE SIDE)
1. HEAD LH-UPR Fuse (R/B No.5)
2. HEAD RH-UPR Fuse (R/B No.5)
3. Headlight Bulb
4. Wire Harness-
-
-
-
ºFlashº does not light up.
1. DRL Fuse (Engine Room R/B)
2. Headlight Dimmer Switch
3. D.R.L. Main Relay
4. D.R.L. No.4 Relay (R/B No.5)
5. Daytime Resistor
6. Wire Harness-
BE-16
BE-16
BE-16
BE-16
-
Headlight does not light up. (Taillight is normal)
1. Headlight Control Relay (Engine Room R/B)
2. D.R.L. Main Relay
3. D.R.L. No.4 Relay (R/B No.5)
4. Daytime Resistor
5. Headlight Dimmer Switch
6. Light Control Switch
7. Headlight Bulb
8. Wire HarnessBE-16
BE-16
BE-16
BE-16
BE-16
BE-16
-
-
Headlight does not light up. (Taillight does not light up)
1. D.R.L. Main Relay
2. D.R.L. No.4 Relay (R/B No.5)
3. Daytime Resistor
4. Light Control Switch
5. Headlight Bulb
6. Wire HarnessBE-16
BE-16
BE-16
BE-16
-
-
Only one side taillight does not light up.1. Taillight Bulb
2. Wire Harness-
-
Taillight does not light up.
(Headlight is normal)
1. TAIL Fuse (I/P J/B)
2. Taillight Control Relay (I/P J/B)
3. Light Control Switch
4. Headlight Bulb
5. Wire Harness-
BE-16
BE-16
-
-

BE-4
- BODY ELECTRICALBODY ELECTRICAL SYSTEM
1996 TERCEL (RM440U) Taillight does not light up. (Headlight does not light up)
1. Light Control Switch
2. Headlight Bulb
3. Wire HarnessBE-16
-
-
Headlight does not light up with light control SW in HEAD.
1. Light Control Switch
2. D.R.L. Main Relay
3. D.R.L. No.4 Relay (R/B No.5)
4. Daytime Resistor
5. Wire HarnessBE-16
BE-16
BE-16
BE-16
-
Headlight does not go out with light control SW in OFF.1. Headlight Control Relay (Engine Room R/B)
2. Wire HarnessBE-16
-
Taillight does not light up with light control SW in TAIL.
1. Taillight Control Relay (I/P J/B)
2. Light Control Switch
3. Wire HarnessBE-16
BE-16
-
Taillight does not go out with light control SW in OFF.
1. Taillight Control Relay (I/P J/B)
2. Light Control Switch
3. Wire HarnessBE-16
BE-16
-
Headlight do not light up with engine running and light control SW
in OFF.
1. DOME Fuse (Engine Room R/B)
2. ECU-IG Fuse (I/P J/B)
3. DRL Fuse (Engine Room R/B)
4. D.R.L. Main Relay
5. D.R.L. No.4 Relay (R/B No.5)
6. Daytime Resistor
7. Wire Harness
8. Generator L Terminal
9. Parking Brake Switch
10.Brake Fluid Level Warning Switch-
-
-
BE-16
BE-16
BE-16
-
-
BE-38
BE-38
TURN SIGNAL AND HAZARD WARNING SYSTEM
TroubleParts nameSee page
ºHazardº and ºTurnº do not light up.
1. Hazard Warning Switch
2. Turn Signal Flasher
3. Wire HarnessBE-22
BE-22
-
No of blinks for Hazard.
(Turn is abnormal)1. Bulb
2. Turn Signal Flasher
3. Wire Harness-
BE-22
-
Hazard warning light does not light up.
(Turn signal is normal)1. HAZ-HORN Fuse (Engine Room R/B)
2. Wire Harness-
-
Hazard waning light does not light up in one direction.1. Hazard Warning Switch
2. Wire HarnessBE-22
-
Turn signal does not light up.
(Combination meter, wiper and washer do not operate.)
1. Ignition Switch
2. TURN Fuse (Engine Room R/B)
3. Turn Signal Switch
4. Wire HarnessBE-1 1
-
BE-22
-
Turn signal does not light up.
(Combination meter, wiper and washer are normal.)1. TURN Fuse (Engine Room R/B)
2. Turn Signal Switch
3. Wire Harness-
BE-22
-

- BODY ELECTRICALBODY ELECTRICAL SYSTEM
BE-7
1996 TERCEL (RM440U) Fuel Level Warning Light does not light up.
1. Bulb
2. Fuel Level Warning Switch
3. Meter Circuit
4. Wire Harness-
BE-38
BE-35
-
Low Oil Pressure Warning Light does not light up.
1. Bulb
2. Low Oil Pressure Warning Switch
3. Meter Circuit
4. Wire Harness-
BE-38
BE-35
-
Door Open Warning Light does not light up.
1. Bulb
2. DOME Fuse (Engine Room R/B)
3. Door Courtesy Switch
4. Meter Circuit
5. Wire Harness-
-
BE-38
BE-35
-
Discharge Warning Light does not light up.
1. Bulb
2. IGN Fuse (I/P J/B)
3. Generator
4. Meter Circuit
5. Wire Harness-
-
-
BE-35
-
COMBINATION METER (INDICATOR LIGHTS)
TroubleParts nameSee page
SRS Indicator Light does not light up.
1. Bulb
2. Wire Harness
3. Airbag Sensor Assembly-
-
DI-146
ABS Indicator Light does not light up.
1. Bulb
2. Wire Harness
3. ABS ECU-
-
DI-109
Malfunction Indicator Light does not light up.
1. Bulb
2. ECM
3. Wire Harness-
-
-
O/D OFF Indicator Light does not light up.
1. Bulb
2. O/D Main Switch
3. ECM
4. Meter Circuit
5. Wire Harness-
-
-
BE-35
-
Turn Indicator Light does not light up.
1. Bulb
2. Turn Signal and Hazard Warning System
3. Meter Circuit
4. Wire Harness-
BE-21
BE-35
-
High Beam Indicator Light does not light up.
1. Bulb
2. Headlight System
3. Meter Circuit
4. Wire Harness-
BE-13
BE-35
-
Security Indicator Light does not light up.
1. Bulb
2. Theft Deterrent System
3. Meter Circuit
4. Wire Harness-
DI-215
BE-35
-

Z09752
From Back Side
Z08444
Z08449
N12797
BE-18
- BODY ELECTRICALHEADLIGHT AND TAILLIGHT SYSTEM
1996 TERCEL (RM440U)
(b) Connect the wire harness side connector to the relay and
inspect wire harness side connector from the back side,
as shown.
Tester connectionConditionSpecified condition
5 - GroundLight control switch OFF or TAILNo continuity
5 - GroundLight control switch HEADContinuity
17 - Ground* Headlight dimmer switch LONo voltage
17 - Ground* Headlight dimmer switch High or FlashBattery positive voltage
* With light control switch turned to HEAD
If circuit is as specified, try replacing the relay with a new one.
If circuit is not as specified, inspect the circuit connected to oth-
er parts.
7. INSPECT D.R.L. No.4 RELAY CONTINUITY
ConditionTester connectionSpecified condition
Constant1 - 2Continuity
Apply B+ between
terminals 1 and 2.3 - 4Continuity
If continuity is not as specified, replace the relay.
8. INSPECT DAYTIME RESISTOR RESISTANCE
ConditionTester connectionSpecified condition
Constant1 - 2Approx. 337 MW
If resistance is not as specified, replace the resistor
9. INSPECT INTEGRATION RELAY OPERATION
(a) Connect the positive (+) lead from the battery to terminal
3.
(b) Connect the negative (-) lead from the battery to termi-
nals 7 and 11.
(c) Check that the bulb lights and the chime sounds for 4 -
8 seconds.
(d) Return to step (a), and operate the chime again.

I16684
No.Wiring Connector Side
1
2
3
4
5
6
7GAUGE Fuse
10
11
12
13
1
2
3
4
5
7
8
1
2
3
4
5
6
7
8
9
10Generator
IGN Fuse
SRS Fuse
Airbag Sensor Assembly
Seat Belt Buckle Switch
Low Oil Pressure Warning Switch
Igniter
TAIL Fuse
Door Courtesy Switch
DOME Fuse
Fuel Level Warning Switch
Engine Coolant Temperature Sender Gauge
ABS ECU
ECM
O/D Off Switch
Light Control Rheostat
Ground
Headlight Dimmer Switch
Turn Signal Switch (Left) Ground
Fuel Sender Gauge
Theft Deterrent ECU
Speed Control Unit
Ground
Starter Relay
Brake Fluid Level Warning Switch
and Parking Brake Switch
Turn Signal Switch (Right) A
B
C
F
E
T: Fuel Receiver Gauge
: Engine Coolant Temperature Receiver Gauge
: Tachometer
Hi-Grade
SRS Warning Illumination Open Door Warning Hi-Beam Indicator Security Indicator Left Turn Indicator Right Turn Indicator Discharge Warning Seat Belt Warning O/D Off Indicator Brake WarningBulb Check Relay Malfunction Indicator Low Oil Pressure Warning ABS Warning Fuel Lever Warning Speed Sensor
A5 B7 A12 C2 A2
A6
B5 C9 B4 A7 B3 B1 A10 B8 B9 C7 C4
A4 A11 A13C1 C5C3 C10A3 C8C6 A1TE F BE-36
- BODY ELECTRICALCOMBINATION METER
1996 TERCEL (RM440U)

I16685
No.Wiring Connector Side
1
2
3
4
5
6
7GAUGE Fuse
10
11
12
13
1
3
4
5
7
1
2
3
4
5
6
7
8
9
10Generator
IGN Fuse
SRS Fuse
Airbag Sensor Assembly
Seat Belt Buckle Switch
Low Oil Pressure Warning Switch
Igniter
TAIL Fuse
Door Courtesy Switch
DOME Fuse
Fuel Level Warning Switch
ABS ECU
ECM
O/D Off Switch
Light Control Rheostat
Headlight Dimmer Switch
Turn Signal Switch (Left) Ground
Fuel Sender Gauge
Theft Deterrent ECU
Speed Control Unit
Ground
Starter Relay
Brake Fluid Level Warning Switch
and Parking Brake Switch
Turn Signal Switch (Right) A
B
C
F
E
T: Fuel Receiver Gauge
: Engine Coolant Temperature Receiver Gauge
: Tachometer
8
9Ground
Engine Coolant Temperature Sender Gauge
A4 A11 A13C1 C5C3 C10A3 C8C6 A1
A5 B7 A12 C2 A2
A6
B5 C9 B4 A7 B3 B1 A10 A8 A9 C7 C4
SRS Warning Illumination Open Door Warning Hi-Beam Indicator Security Indicator Left Turn Indicator Right Turn Indicator Discharge Warning Seat Belt Warning O/D Off Indicator Brake WarningBulb Check Relay Malfunction Indicator Low Oil Pressure Warning ABS Warning
Fuel Lever Warning Speed Sensor TE F Lo-Grade
- BODY ELECTRICALCOMBINATION METER
BE-37
1996 TERCEL (RM440U)