1996 Mercury Villager Owner's Manuals

Instrument Panel Controls
97
[IP05400(ALL)04/95]
13-1/2 pica
art:0040301-A
Heating and air conditioning climate control system panel
[IP05500(ALL)09/93]
The standard heating system and the heating portion of the
heating and air conditioning system are essentially identical.
There is one exception, however; the air conditioning
compressor may automatically engage when the Defrost position
is selected to aid in defogging and defrosting the inside glass.
When Defrost is selected, the A/C compressor will
automatically operate when the outside temperature is above
approximately40ÊF (4ÊC),whether or not the A/C button is
illuminated. Manual selection and illumination of the A/C
button in defrost mode does not override the automatic
compressor operation discussed above. Refer to the heating
system operating instructions covered previously for a more
detailed explanation of heating system operation.
[IP05600(ALL)01/93]
Turning on the air conditioner
*
[IP05700(ALL)09/93]
To cool your vehicle quickly in warm weather:
[IP05800(ALL)01/93]1.
Press one of the function selector buttons (typically Panel,
but Panel/Floor, Floor or Mix can be selected).
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

98
[IP05900(ALL)01/93]2.
Turn the temperature control knob to COOL.
[IP06000(ALL)01/93]3.
Press the A/C button. The indicator light on the A/C button
will illuminate.
[IP06100(ALL)09/93]4.
The air intake selector button may be in the outside air
mode or the recirculated air mode. The recirculated air mode
is recommended for best A/C performance when the vehicle
interior is very warm. As interior air comfort is reached, you
may decide to switch to the outside air mode.
[IP06200(ALL)01/93]5.
Turn the fan speed knob to the position of your choice.
[IP06300(ALL)01/93]6.
If your vehicle is equipped with the rear passenger
compartment air conditioning unit, it will be on when the
front A/C is on and the rear climate control lever is set to
REAR, 1, 2, 3, or 4. Refer to the previous section for an
explanation of the heating system.
[IP06400(ALL)01/93]7.
Adjust your instrument panel registers.
[IP06500(ALL)04/94]8.
If the inside of your vehicle is very warm, you may want to
drive for a few minutes with the windows down and the air
conditioner on. This forces most of the hot, stale air out of
the vehicle and allows the air conditioner to cool down the
interior more quickly.
*
[IP06600(ALL)05/95]
The air conditioner may be used to cool the outside air being
drawn into your vehicle, but using recirculated air is more
economical and cools your vehicle more quickly.
[IP06700(ALL)07/93]
NOTE: The A/C button independently toggles the A/C
system's compressor signal and indicator light ON and
OFF in the Panel, Panel/Floor, Floor, Defrost and Mix
functions. The A/C button will not operate or light
when the system is set in the OFF position. The A/C
button will operate in defrost but will not override
previously discussed automatic operation.
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

Instrument Panel Controls
99
*
[IP06800(ALL)07/93]
Cooling your vehicle with outside air
[IP06900(ALL)01/93]
Cooling your vehicle with air conditioned outside air is quieter
but less economical than using recirculated air. It also has less
cooling capacity.
*
[IP07000(ALL)07/93]
To cool your vehicle using outside air:
[IP07100(ALL)04/95]1.
Turn the air intake selector button off (the outside air
position). The air conditioning unit directs outside air
through the instrument panel registers.
[IP07200(ALL)01/93]2.
Press one of the function selector buttons.
[IP07300(ALL)01/93]3.
Press the A/C button. The indicator light on the A/C button
will illuminate.
[IP07400(ALL)01/93]4.
Turn the temperature control knob to COOL.
[IP07500(ALL)01/93]5.
Turn the fan speed knob to the position of your choice.
[IP07600(ALL)04/95]6.
Make sure the registers in the instrument panel are open.
[IP07700(ALL)01/93]
During periods of high humidity, vapor may be emitted from
the air outlets when using the A/C with outside air. Correct
this by switching to recirculated air with the A/C button.
[IP07800(ALL)01/93]
Ventilating your vehicle with outside air
[IP07900(ALL)01/93]
In mild weather, you can ventilate your vehicle with outside air.
If the outside temperature is less than70ÊF (21ÊC), you can add
cool air to your vehicle without using air conditioning. You will
get better fuel economy this way.
[IP08000(ALL)01/93]
The procedure for ventilating your vehicle with the standard
heating system or with the air conditioning system is the same.
Refer to the previous section for instructions on how to ventilate
with outside air.
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

100
*
[IP08100(ALL)06/94]
Improving fuel economy
[IP08200(ALL)04/94]
Whenever you turn on the air conditioning, your vehicle uses
more fuel because the air conditioning compressor is running.
To get better fuel economy while cooling your vehicle, do not
use the air conditioner on mild days. Instead, set the air intake
selector button in the outside air position and turn the
temperature control knob to the COOL position.
*
[IP08300(ALL)04/95]
Operating tips
[IP08400(ALL)04/95]
When stopped in traffic for long periods of time in hot weather,
place the automatic transaxle gearshift selector lever in P (Park)
or in N (Neutral) to increase the engine idle speed. This aids in
engine cooling and air conditioner efficiency. If the engine
overheats, choose the outside air position and turn off the A/C
to stop the compressor for a short time.
*
[IP08500(ALL)10/93]
When your vehicle's engine is operated at full throttle, the air
conditioner compressor will automatically be turned off to allow
maximum engine power. This may occur during passing or
when climbing steep grades. The compressor will return to
normal operation within a few seconds after full throttle is no
longer needed.
[IP08600(ALL)06/94]
NOTE: The compressor will not operate when the outside
temperature is less than about40ÊF (4ÊC).
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

Instrument Panel Controls
101
[IP10000(ALL)06/95]
Rear Passenger Compartment Climate Control System
for Vehicles with Non-Automatic Temperature Control
Systems (If equipped)
[IP10100(ALL)04/95]
If your vehicle is equipped with rear passenger compartment
climate controls, the rear seat occupants can select their own
personal climate comfort level.
[IP10150(ALL)04/95]
The rear seat climate control system is controlled from the main
climate control system on the instrument panel. If the main
system is off, the rear system will also be off. If the rear
passenger compartment climate control lever is set in OFF, the
rear climate controls are turned off. If the lever is set in any of
the fan speed positions (1-4), air will be discharged from the
rear seat vents at the corresponding speed. However, when the
lever is set at REAR, rear seat passengers can control their own
fan speed.
[IP10200(ALL)04/95]
The rear passenger compartment climate control system has a
fan speed knob which controls the speed at which air is
discharged from the vents. The vent selection switch determines
whether the air is discharged from the upper vents or the lower
(floor) vents. The temperature control knob controls the air
temperature.
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

102
[IP10250(ALL)06/95]
13-1/2 pica
art:0040079-A
Rear seat climate control system panel
[IP10300(ALL)04/95]
NOTE: For maximum heating and cooling for front seat
passengers, set the rear fan switch to the OFF
position.
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

Instrument Panel Controls
103
[IP10305(ALL)06/95]
Automatic Temperature Control System
[IP10310(ALL)06/95]
The control for your Automatic Temperature Control (ATC) is
located at the center of the instrument panel above the radio.
The ATC operates only when the ignition key is turned to the
ON position and the vehicle is running.
[IP10315(ALL)06/95]
17-1/2 pica art:0040072-E[IP10320(ALL)06/95]
To turn the ATC on, push the AUTOMATIC button or any of
the five airflow function selector buttons:P,V,Q,S,
orR.
[IP10323(ALL)06/95]
To turn the ATC off, press the OFF button.
[IP10325(ALL)06/95]
To change the temperature in the display window, select any
temperature between65ÊF (18ÊC) and 85ÊF (29ÊC)using the
NTEMPMbutton.
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996

104
[IP10330(ALL)06/95]
The ATC maintains the temperature you select and
automatically controls the airflow for your comfort. It also
allows you to override the automatic operation of airflow and
fan speed with manual function selector buttons and the fan
speed dial.
[IP10335(ALL)06/95]
When you select the AUTOMATIC button, the system
determines airflow location and fan speed automatically. It also
automatically determines whether you will be receiving fresh
outside airflow, recirculated interior airflow, or a combination of
both. You can manually override the airflow source (outside or
recirculated air) and airflow location by selecting one of the
function selector buttons. You can also manually override the
fan speed by rotating the fan speed dial.
[IP10340(ALL)06/95]
Whether you operate in the AUTOMATIC mode or manually
override the AUTOMATIC mode settings, the ATC will continue
to maintain the air temperature you have selected. However, if
you choose to manually override the airflow location by
selecting one of the function selector buttons, you will also need
to select the A/C button if you desire cool air-conditioned air.
(Your ATC automatically operates the air conditioning [if
required] when you are in the AUTOMATIC mode without
illuminating the A/C button, but the system requires you to
manually select the A/C button if you desire A/C operation
when you manually override airflow location.)
[IP10350(ALL)06/95]
If you want continuous maximum cooling, push theNside of
the TEMP button until60ÊF (16ÊC)shows in the display
window. The ATC will cool at its maximum level and disregard
the 60ÊF (16ÊC)setting until a warmer temperature is selected. If
you want continuous maximum heating, push theMside of the
TEMP button until90ÊF (32ÊC)shows in the display window.
The ATC will provide maximum heat regardless of the90ÊF
(32ÊC) setting until a cooler temperature is selected.
File:06vxipn.ex
Update:Mon Jun 3 14:33:05 1996