1993 CHEVROLET CAVALIER service interval

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more
of the following conditions:
When most trips are less than 4 miles
When most trips are less than 10 miles
(6 km).
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When operating in dusty ,areas.
Schedule I should also be followed if
the vehicle is used for delivery service,
police, taxi
or other commercial
applications.
*An Emission Control Service.
b me US. Environmental Protection Agency
has determined that the failure to pelform this
maintenance item will not
nullifi the emission
warranty or limit recall liability prior to the
completion
of vehicle use&/ life. General
Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
I I
TO BE SERVICED ITEM
NO. See Explanation of Scheduled Maintenance
Sewices
following Schedules I and II.
WHEN TO PERFORM
Miles (kiloineters) or Months
(whichever
occurs first).
Chassis Lubrication 1 Every other oil change. I
I Engine Accessory Drive Belt Inspection* I Every 30,000 Miles (50 OOO km) or 24 Months. I
(ll
Transaxle Service See Explanation of Scheduled Maintenance
Services
following Schedules I and 11.
I 10 I Air Cleaner Filter Replacement* I Every 30,000 Miles (50 000 km). I
264

Downloaded from www.Manualslib.com manuals search engine The services shown in this schedule up to 48,OOO miles (80 OOO km) are to be
performed
after 48,OOO miles at the same intervals.
MILES (000)
KILOMETERS (0001
3 16 19 112115118121 124127130133136139142145148
lllll Ill1 IIIIIIII
265

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule I/
Follow Schedule II ONLY if none of
the driving conditions specified in Schedule
I apply.
*An Emission Control Service.
~2 The US. Environmental Protection Agency
has determined that the failure to pelform this
maintenance item will not nullify the emission warranty or limit recall liability prior
to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be pei$ormed at the indicated intervals and the maintenance be
recorded in Section E: Maintenance Record.
TO BE SERVICED
See Explanation of Scheduled Maintenance
Services
following Schedules I and II.
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
I 2 I Chassis Lubrication I Every 7,500 Miles (12 500 km) or 12 Months.
I 4 I Engine Accessory Drive Belt Inspection* I Every 30,000 Miles (50 OOO km) or 24 Months.
16/
Transaxle Service See Explanation of Scheduled Maintenance Services
following Schedules I and 11.
(!-Spark Plug wire Inspection** I Every 30,000 Miles (50 OOO km).
F] Air Cleaner Filter Replacement* 1 Every 30,000 Miles (50 OOO km).
266

Downloaded from www.Manualslib.com manuals search engine r
The services shown in this schedule up to 45,000 miles (75 OOO km) are to be
performed after
45,000 miles at the same intervals.
I MILES (000) I .
1 7.5 1 15 22.5 30 37.5 45 I
KILOMETERS (000)
12.5 I 25 I 37.5 I 50 62.5 I 75
I I I I I I 0
I I I I I I I
267

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
ITEM
NO. SERVICE
10 Air Cleaner Filter Replacement*-Replace every
30,000 miles (50 OOO km) or more often under
dusty conditions.
Ask your dealer for the proper
replacement intervals for your driving conditions.
ITEM
NO. SERVICE
11 Fuel Tank, Cap and Lines Inspection**-
Inspect fuel
tank, cap and lines (including fuel rails
and injection assembly)
for damage or leaks.
Inspect fuel cap gasket for an even filler neck
imprint
or any damage. Replace parts as needed.
Periodic replacement of the fuel filter
is not
required.
*An Emission Control Service.
~2 The US. Environmental Protection Agency has determined that the fuilure to pe$orm this maintenance item will not nullijE the emission warranty or
limit recall liability prior to the completion of vehicle usefirl life. General Motors, however, urges that all r\
ecommended maintenance sewices be
per$ormed at the indicated intervals and the maintenance be recorded in Section
E: Maintenance Record.
270

Downloaded from www.Manualslib.com manuals search engine Section B: Owner Checks & Services
Listed below are owner checks and services which should
be performed at the intervals specified to help
ensure the
safety, dependability and emission control performance of
your vehicle. Be
sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown in
Section D.
At Each Fuel Fill (It is important for you or a service station attendant to perform these underhood checks at \
each fuel fill.)
CHECK
OR SERVICE I WHAT TO DO
Engine Oil Level
1
Check the engine oil level and add the proper oil if necessary. See the Index under Engine Oil for
further details.
Engine Coolant Level Check the engine coolant level
in the coolant recovery tank or surge tank and add the proper
coolant
mix if necessary. See the Index under Coolant for further details.
Windshield Washer Check the windshield washer fluid level
in the windshield washer tank and add the proper fluid
Fluid Level if necessary. See the
Index under Windshield Washer Fluid for further details. I
At Least Once a Month
CHECK
I OR SERVICE I WHAT TO DO
Tire Inflation
Check tire inflation. Make sure they are inflated to the pressures specified on the Tire-Loading
Information label located on the rear edge of
the driver’s door. See the Index under fires for
further details.
27 I I..