1993 BUICK ROADMASTER Owners Manual

TO BE SERVICED
(See Explanation of
Scheduled Maintenance
' Months, Whiche'ver Services Following:
Miles (kilometers) or
WHEN TO PERFORM
I
Schedules I and 11y
Item No.
~ Occurs First
7. Front Wheel bearing
~~
Repack See Explanation of Scheduled
Maintenance Service
,Following Schedules I and I1
9. Spark Plug
Replacement*
Inspection*?
I 11. EGR System Inspection*? I
I 12. Air Cleaner Filter
Replacement*
13. Air Cleaner Inspection*?
14.Fuel Tank, Cap
& Lines
Inspection*?
15. Engine Timing &
Distributor Check*
~~
Every 30 000 mi
(50 000 km)
MILES (000)
- KILOMETERS (000)
75 80
J
The services shown in. this schedule up to 48 000 miles (80 00.0 km) should be performed after
48 000 miles at the same intervals.
* An Emission Control Service.
-f- The U.S. Environmental F'rotection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of
vehicle useful life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded in "Section EMaintenance Record".

Sched.uled Maintenante Services Schedule I1
Follow Schedule. I1 ONLY if none of the driving conditions specified in Schedule I apply.
, TO BE SERVICED
(See Explanation of
Scheduled Maintenance Services Following Schedules
I and 11)
Item No.
I. Engine Oil Change"
Oil Filter Change"
2. Chassis Lubrication
3. Throttle Body Mounting Bolt Torque*
4. Tire & Wheel Inspection .& Rotation
5. Engine Accessory Drive Belt(s) Inspection*
6. Cooling System Service"
7. Front Wheel Bearing Repack.
WHEN TO PERFORM
Miles (kilometers)
or
Months, Whichever
Occurs First
, ..
I MILE,
KILOMEl
12.5 I 25 I 37.5
Every 7 500 mi. (12 500 km) or 12 mos. a 0 0
At first and then every other oil change a 0
Every 7 500 mi. (12 500 km) or 12 mos. 0 a 0
At 7 500 mi. (12.500 km) only 0
At 7 500 mi. (12 500 km) and then every
15 000 mi. (25 000 km) or as necessary Io
-~
Every 30 000 mi. (50 000 km) or 24 mos.
t ~~ .. Every 30 000 mi. (50 '000 km) ' ' '
; (000)
30 I 37.5 I 45
304

..
TO BE ,SERVICED
(See explanation of
Scheduled Maintenance Services Following
Schedules I'and
11)
Item No. - .
8. Transmission Service
9. Spark Plug Replacement"
10. Spark Plug. Wire.Inspection*T
11. EGR System Inspection*?
12. Air Cleaner Filter Replacement"
13. ~ir cleaner Inspection*?
14. Fuel Tank, Cap & Lines'Inspectiori*f
15. En&e Timing & Distributor Check!
WHEN TO PERFORM
., Miles (kilometers) or
Months, Whichever
Occurs First
See Explanation of Scheduled Maintenance
Services Following Schedules
I and 11
Every 30!000 mi. (50 000 km)
t-
KILOMETERS (000)
..
The'services shown in this schedule up to 45.000 miles (75 000 km) should be performed after 45 000
miles at the'same inte-Wals.
I I ..
* An Emission Control Service.
f The U.S. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of
vehicle useful life. Gerieml Motors, however; urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be.recorded in "Section EMaintenance
Record".
305

7.
8.
To help ensure-proper operation, we recommena a
pressure test of both’the cooling system and the
pressure cap. If you do not use your vehicle under any of these
conditions, change both the fluid and filter every
100,000 miles (1 60 000 km).
Front Wheel Bearing Repack - When your 9. Spark Plug Replacement* - Replace spark plugs
vehicle is used in such service as police work, as a with the proper type. See “Specifications Chart.’’ in
taxi or
in door-to-door delivery, clean and repackthe the Index.
front wheel bearings at each brake relining or
15,000 Spark plug Wire Inspection*? - Inspect for
miles (25 000 km), whichever comes first. If you
don’t use your vehicle in such service, clean
and
repack the bearings at each brake relining or 30,000 -
miles (50 000 km) whichever comes first. burns, cracks .or other damage. Check the boot fit
at
the distributor and at the spark plugs. Replace wires
as. needed.
Transmission Service - Change both the fluid and
filter every
15,000 miles (25 000 km) if the vehicle
is mainly driven under one or ‘more
of these
conditions:
In heayy city traffic where the outside
temperature regularly reaches
‘90 OF (32 C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police car or delivery
service.
11. Exhaust Gas Recirculation (EGR) System
Inspection*?
- Conduct the EGR system service
as described in the service manual.
To purchase a
service manual, see “Service Publications” in the
Index.
12. Air Cleaner Filter Replacement* - Replace every
30,000 miles (50 000 km) or more ofkn under dusty
conditions. Ask your dealer for the proper
replacement intervals for your driving conditions.
307
I

‘X: An Emission Control Service.
TheU.S. Ehyironmental Protection Agency has determined that the failure \
to perfo-
this maintenance itein will not nullify the emission warranty or limit recall liability prior to thecompletion of vel&cle. ’ useful Iife. Geneial Motors, however,.urges that all recommended maintenance services be performed.at the indicated intervals and the maintenance be recorded in “Section E:Maintenance Record”.

At Each Fuel Fill.
(It is important for you ‘or a service station. attendant
to perform these underhood
.ch~ecks ,,at each fuel fill.)
CHECK OR
SERVICE
Engine Oil
Level
Engine Coolant
Level
Winashield Washer Fluid
Level
.
WHAT TO DO .
Check the engine oil level and add
the. proper
oil. if necessary. See
Tngine Oil” in the Index for further
details.
Check the engine coolant level
In thy
coolant recovery tank and add the
’ proper coolant mix if necessary., See. “Coolant” in the Index for further
details.
Check the windshield washer fluid
level
in ‘the windshield washer tank
and add the proper fluid
if necessary.
See “Windshield Washer Fluid” in
the Index for ‘further details.
,, .,
At Least Once a Month
CHECK OR
‘SERVICE
Tire Inflation
WHAT TO DO ;
Check tire .inflation. Make sure they
are inflated to.the pressures specified
on the Tire-Loading Information
label located on, the rear edge
.of the
,driver’s door. See “Tires”
in the
Index for further details.
At Least Once a Year
s
CHECK-OR
I ’ SERVICE
Key Lock
I Cylinders
WHAT TO DO
Lubricate the key lock cylinders with
the. lubricant specified in Section D.
‘Lubricate all body door hinges. Also
lubricate all
hinges and. latches,
including those for, the hood, glove
box door and console .door. Section
D tells you what to use.
..
309