1993 BUICK ROADMASTER service schedule

Air Cleaner
The air cleaner is located behind the engine fan. To
access the filter, lift up on the latches and let the cover
down. Replace the filter and snap the latches.
Refer
to the Maintenance Schedule to determine when
to replace-the air filter and the
PCV filter.
See “Scheduled .Maintenance Services”
in the Index.
Operath e engine wltn tne air cleaner off can
cause you or others to be burned. The air
cleaner not only cleans the air,
it stops flame i
the engine backfires. If it isn’t there, and the
engine backfires, you could be burned. Don’t
drive
with it off, and be careful working on tT
engine with t‘ air cf - - -- -8r om-
_.
I
253

Automatic Transmission Fluid
When to Check and Change:
A good time to check your auiomatic transmission fluid
level is when the engine oil is changed. Refer to the
Maintenance Schedule to determine when to change
your fluid. See “Scheduled Maintenance Services” in
the Index.
How to Check:
Because this operation can be a little difficult, you may
choose to have this done at
a Buick,dealership Service
Department.
If
you do it yourself, be sure to follow all the
instructions here, or you could get a false reading on the
.
dipstick. Wait
at least
30 minutes before checking the
transmission fluid level
if you have been driving:
0 When outside temperatures are above. 90 F ‘(32 C);
0 At high speed for quite a while. I
In heavy traffic - &specially in hot weathEr.: . .
While pulling a trailer.
To get the right reading, the fluid should be at normal
operating temperature, which is
180 F to 200 *F (82 C
To check transmission fluid hot: Get the vehicle ‘warmed
up
by driving about 15 miles (24 krn) when outside
temperatures are above
50 F (1 0 C). If it’s colder than
50 F ( 10 C), drive the vehicle in “D” (3rd Gear) until
the engine temperature gage moves and then remains
steady for ten minutes. Then follow the hot check
procedures.
To check transmission fluid cold: A cold check is made
after the vehicle has been sitting for
8 hours or more
with the engine
off and is used only as a reference. Let
the engine run at idle for
5 minutes if outside
temperatures are
50 F (10 C) or more. If ‘it’s colder
than
50 OF (10 * C), you may have to idle the engine
longer.
A hot check must €0110~ when fluid is added
during
a cold check.
..
to 93 C).
254

When to Check: Check your tires once .a month or
more.
Don’t forget
your compact spare-tire (if SO equipped). It
should be at 60 psi (420 Pa).
How to Check: Use a good quality pocket-type gage to
check tire pressure. Simply looking at the tires will not
tell you the pressure, especially if
you have radial tires
- which may look properly inflated even if they’re
underinflated.
If your tires have valve caps, be sure to put them back
.on. They help prevent leaks by keeping
out dirt and
moisture.
Tire Inspection and Rotation
To make your tires last longer, have them inspected and
rotated at the mileages recommended in the, Maintenance Schedule. See “Scheduled Maintenance Services”
in the Index.
Use this rotation pattern.
t
273

Part 7 Main.tenance Schedule
dependability and emission control performance. Part
7 includes:
Introduction
......................................................................
A Word About Maintenance .....................................................
Your Vehicle and the Environment ................................................
How This Part is Organized .....................................................
Section A: Scheduled Maintenance Services .............................................
Using Your Maintenance Schedules ...............................................
SelectingtheRightSchedule ....................................................
Schedule1 ...................................................................
Schedule11 ..................................................................
Explanation of Scheduled Maintenance Services .....................................
Section B: Owner Checks and Services .................................................
AtEachFuelFill ..............................................................
AtLeastOnceaMonth .........................................................
AtLeastOnceaYear ...........................................................
Section C: Periodic Maintenance Inspections ............................................
Section D: Recommended Fluids and Lubricants .........................................
Section E: Maintenance Record .......................................................

I
Section A: Scheduled Maintenance
Services
Using Your Maintenance Schedules
This section tells you the maintenance services you
should have done and when
you should schedule them.
Your Buick dealer knows your vehicle best and wants
you to be happy with it.
If you go to your dealer for your
service needs, you’ll
know that GM-trained and
supported service people will perform the work using
genuine GM parts.
These schedules are
for vehicles that:
carry passengers and cargo within recommefided
limits.
You will find these limits on your vehicle’s
Tire-Loading Information label. See “Loading Your
Vehicle” in the Index.
are driven on reasonable road surfaces within legal
driving limits.
a use the recommended unleaded fuel. See “Fuel” in
the Index.
Selecting the Right Schedule
First you’ll need to decide which of the two schedules is
right for your vehicle. Here’s how to decide which
schedule to follow:
Schedule I
Is any one of these true for your vehicle?
a Most trips are less than 4 miles (6 km).
Most trips are less than 10 miles (16 km) when
outside temperatures are below freezing.
The engine is at low speed most of the time (as in
door-to-door .deliveryy or in stop-and-go traffic).
0 You operate your vehicle in dusty areas.
You tow a trailer.
If any one (or more) of these is true.for your driving,
follow Schedule
I.
Schedule Il
Follow Schedule 11 only if none of the above conditions
is true.
301

Scheduled Maintenance Services Schedule I
Follow Schedule'I if your car is MAINLY driven under one or more of the following conditions:
0 When most trips are less than 4 miles (6 kilometers).
e -When most trips are' less than 10 miles (16 kilometers) and outside temperatures remain below freezing.
.e When mosttrips include extended idling and/oi- frequent low-speed operation as \
in stop-and-go traffic.
e Towing a trailer.*?
0 When operating in dusty areas.
Schedule I should also be followed if the car is used for delivery service, police, taxi\
or other commercial applications.
TO~BE SERVICED WHEN TO PERFORM (See Explanation of
Scheduled Maintenance Miles (kilometers) or
Services Following Months, Whichever
Schedules I and 11j Occurs First
I 1. Engine Oil & Oil Filter Every 3 000 mi. (5000 km)
Change* or 3 months.
I 2. Chassis Lubrication I Every other oil change
I
3. Throttle Body Mounting At 6 OQd)..mi,~10~000 km)
Bolt Torque*
I
At 6,000 mi. (10 000 km) and
km) or as necessary
4. Tire 8L Inspection ' then every 15 000 mi. (25 000 Rotation
5. Engine Accessory Drive
Belt(s) Inspection" Every
30 000 mi. (50 000 km) or 24 months.
MILES (000) I
LO 10 15
0
0
0
20 25
00
.
KILOMETER;
35 40 45
000
0
0
000)
50 55 60 65
000.
0 a
0
0
302

TO BE SERVICED
(See Explanation of
Scheduled Maintenance
' Months, Whiche'ver Services Following:
Miles (kilometers) or
WHEN TO PERFORM
I
Schedules I and 11y
Item No.
~ Occurs First
7. Front Wheel bearing
~~
Repack See Explanation of Scheduled
Maintenance Service
,Following Schedules I and I1
9. Spark Plug
Replacement*
Inspection*?
I 11. EGR System Inspection*? I
I 12. Air Cleaner Filter
Replacement*
13. Air Cleaner Inspection*?
14.Fuel Tank, Cap
& Lines
Inspection*?
15. Engine Timing &
Distributor Check*
~~
Every 30 000 mi
(50 000 km)
MILES (000)
- KILOMETERS (000)
75 80
J
The services shown in. this schedule up to 48 000 miles (80 00.0 km) should be performed after
48 000 miles at the same intervals.
* An Emission Control Service.
-f- The U.S. Environmental F'rotection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of
vehicle useful life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded in "Section EMaintenance Record".

Sched.uled Maintenante Services Schedule I1
Follow Schedule. I1 ONLY if none of the driving conditions specified in Schedule I apply.
, TO BE SERVICED
(See Explanation of
Scheduled Maintenance Services Following Schedules
I and 11)
Item No.
I. Engine Oil Change"
Oil Filter Change"
2. Chassis Lubrication
3. Throttle Body Mounting Bolt Torque*
4. Tire & Wheel Inspection .& Rotation
5. Engine Accessory Drive Belt(s) Inspection*
6. Cooling System Service"
7. Front Wheel Bearing Repack.
WHEN TO PERFORM
Miles (kilometers)
or
Months, Whichever
Occurs First
, ..
I MILE,
KILOMEl
12.5 I 25 I 37.5
Every 7 500 mi. (12 500 km) or 12 mos. a 0 0
At first and then every other oil change a 0
Every 7 500 mi. (12 500 km) or 12 mos. 0 a 0
At 7 500 mi. (12.500 km) only 0
At 7 500 mi. (12 500 km) and then every
15 000 mi. (25 000 km) or as necessary Io
-~
Every 30 000 mi. (50 000 km) or 24 mos.
t ~~ .. Every 30 000 mi. (50 '000 km) ' ' '
; (000)
30 I 37.5 I 45
304