1990 VOLKSWAGEN TRANSPORTER light

Downloaded from www.Manualslib.com manuals search engine
AUXILIARY HEATER*
CONTROLS AND EQUIPMENT
~jrn the auxiliary heater on and off with the :amperature switch, located on the right of
fee steering column. Use the same switch

ID
regulate the heat.
depending on vehicle model, the warm air
lows from the footwell vents for the pas­ senger compartment and/or from a con-
tollable vent under the driving seat. The a r distribution cannot be controlled.
While driving, the heater can be operated rontinuously. When the engine is not run-

-:ng,
the heater will shut off automatically
after 10 minutes to save battery power.
"he auxiliary heater is running on fuel from our fuel tank. Fuel consumption varies
according to operating conditions and
-eat output (approx. 1 US qt or one liter
zer hour). 0
Switch knob positions 0 - Heater off.
0—1 — Heateron (engine stationary)
2 - Heateron (engine running)
2-3 - Temperature adjustment range. Engine stationary/ignition off
Heater on:
From position 0, push knob in and turn
clockwise. Switch knob control light will
come on. Knob will spring back out when
released.
Adjust temperature by turning
knob between positions 2 and 3.
Heater off:
The clockwork in the temperature regulat­ ing switch switches the heater off auto­
matically after about 10 minutes and the
lamp goes out.
To switch off before clockwork has run

down:
Turn temperature regulating switch
anti­

clockwise to 0. The lamp goes out and
clockwork runs down.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

Engine
running

Heater
on -
Turn knob clockwise to position 2. Switch knob control light will come on. Adjust
temperature by turning knob between positions 2 and 3.

Heater
off -
Turn switch knob counter-clockwise to position 0. Switch knob control light will go
out.
Notes

• Every time the heater is switched off,
the warm air and combustion air blowers continue running briefly to cool the heater
down quicker.
• To avoid draining the battery, do not
run the heater repeatedly when the engine

is
not running.
• When the heater is running on the
clockwork time switch, it must be switched
off by hand before attempting to start the
engine at low temperatures so
that
the

full
battery capacity is available to
turn
the
engine.

WARNING
Never
start
the
heater
or let the
engine

or the
heater
run in an enclosed, un-

ventilated
area.
Exhaust
fumes
from

the
engine
or the
heater
contain
carbon monoxide,
which
is colorless and
odorless. Carbon monoxide,
however
is a
very
harmful
gas, and may be
fatal

if inhaled.
Due to the
risk
of
fire
the
heater
must

not be used
when
vehicle
is
parked
on
dry grass, brush or leaves.
Maintenance

During the winter and when driving over
very poor roads, mud or snow may tend to

accumulate
in the exhaust and combus­
tion air intake pipes. Have these pipes
checked
for blockage from time to time so

that
the heater can continue to work.
58


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

Setting
the
time
•
Press
and hold clock button E.
• Set clock
with
buttons A.

The
display lights up as long as button is
oressed.
When button is released the dis­
play goes out or, if a time has been pre­

selected,
the selected time lights up for 2

sees.

To
switch
heater
on or off • This is done by pressing button
F.
When
-eater is switched on the warning lamp G ghts up.

To
ensure
that
the heater starts the lever ;or the heat output must be pushed fully to
:ie
right.
This
closes
an electrical contact.
Preselecting
starting
time
for
heater
stationary operation, ignition off)
With buttons C two different switch-on
:imes
can be selected within 24 hours.
•
Press
and hold button. The appropriate
*:gure 1 or 2 appears in display. The ready- •or-action lamp lights up.
• Set required switch-on time
with
but­
tons A. The display remains on for about 20 seconds after releasing button C.
To
ensure
that
the heater starts up at the

selected
time, the lever for the heat output must be pushed fully over to the
right.
In
addition to this the blower must be
switched to Stage 1. On account of the higher current consumption, a higher

stage
should only be selected in isolated

cases.

Switching
preselected
time
off • The preselected time can be switched
off by briefly pressing the appropriate but­
ton C. The ready-for-action lamp and the figure in display then go out.
Fuses

The
fuses for the auxiliary heater are in an additional holder behind the main fuse
box.
Notes

• Every time the heater is switched off,
the warm air and combustion air blowers
continue running briefly to cool the heater
down quicker.
• To avoid draining the battery, do not run
the heater repeatedly when the engine is not running.
• When driving through mud and snow,
the exhaust pipe may tend to get blocked.
Have
a look at it occasionally to see
that
it

is
clear.

WARNING
Never
start
the
heater
or let the
engine

or the
heater
run in an enclosed,
unventilated
area.
Exhaust
fumes
from

the
engine
or the
heater
contain
carbon monoxide,
which
is colorless and odor­

less.
Carbon monoxide,
however
is a

very
harmful
gas, and may be
fatal
if in­ haled.
Due to the
risk
of
fire
the
heater
must

not be used
when
vehicle
is
parked
on
dry grass, brush or leaves.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

SLIDING
ROOF*
SUN
ROOF*

To open pull crank handle out of recess
and
turn
counter-clockwise.
To close
turn
crank handle clockwise.

The
sliding roof is locked in any position.

WARNING

To
reduce
the
risk
of personal
injury
in an
accident
or sudden stop,
always

fold
the
handle
back
into
its recess
after
use.

Note:
If the roof is difficult to move after a while,

clean
and lubricate the guide rails. See
page
92.
The
roof is opened and closed
with
the
knurled disc in the headlining above the

front
seats.

The
roof can be
tilted
at the rear as desired or taken out altogether.
Raising
Turn knurled disc clockwise.
Lowering

Turn knurled disc anti-clockwise. To
take
out
• Turn retaining screw (A) in centre of
knurled disc one quarter
turn
clockwise
(e.g.
with
a coin)
with
roof
closed.

• Then raise roof and press it up.
•
Press
locking lever (B) up. • Detach roof.
• Lift roof from outside and pull it out tc
the rear.
To put
back
• Slide roof back into the hinges and let it
drop lightly into the retainers.

WARNING
Ensure
that
the
roof
is
properly
insert­

ed
into
the two
retaining
hinges at the

front,
and locked at the
rear.

The
roof
must
only
be unlocked
when
vehicle
is
stationary.

62 "where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

NTERIOR
LIGHTS

Switch
positions
-ront
interior
light:

Up
-ON-with doors open 3enter -OFF
Down -ON-with doors closed

Rear
interior
light:
Jp/front -ON-with doors open
3enter -OFF
Down/rear -ON-with doors closed

Reading
light
on the dashboard |p -Off
Down -On CIGARETTE
LIGHTER

•
Push
knob in.
When lighter is ready for use, it will spring
back.

The socket of the cigarette lighter may be
used
for 12
volt
appliances
with
maximum
consumption of up to 100 watts, such as hand spot
light,
small vacuum cleaner, etc.

WARNING
Cigarette lighter and socket remain
functional even after the ignition key is
removed.
Therefore, never leave
chil­

dren inside the vehicle
without
super­

vision.

63


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT
FLUORESCENT LAMP* CUP HOLDER*
1B25-544]
The switch found beside the fluorescent lamp is used to switch the lamp on and off.
Caution
To save battery power, do not leave the fluorescent light switched on when the ve­hicle is unattended. The cup holders in the passengers com­
partment should always be folded up
when not in use. Fold the upper part up
and the lower part downwards.
66 'where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION

OPERATE
YOUR VEHICLE SAFELY

A
lot has gone
into
the manufacture of your Volkswagen, including advanced engineering techniques, rigid quality
control and demanding inspections.

These
engineering and safety features will be enhanced by you, the safe driver,
• who knows the vehicle and all controls
• who maintains the vehicle properly
• who uses driving skills wisely.

For
your own safety as well as
that
of
those around you - be a responsible
driver. If you
drink,
do not
drive.
The use
of alcohol, drugs and certain medications
will seriously impair perception, reactions and driving ability, substantially increasing
the risk of an accident and personal
injury.
Do not
drive
if you are
tired,
ill or
under

emotional
stress.
The
following
points
are also
important
for
your
safety,
please
observe
them

all.
First
things
first...

• Turn the engine off before performing
any checks or repairs on the vehicle.
• Be sure tires are inflated correctly.

Check
for damage and
tire
wear.
• See
that
wheel bolts or nuts are pro­
perly tightened and not loose or missing.
• Check engine oil level, add if neces­

sary.
Make it a habit to have engine oil

checked
with
every fuel filling.
• Check coolant level to assure sufficient
engine cooling.
• Be sure you have a well charged
battery.
• Check brake fluid level. If too low, have
brake system checked.
• Replenish windshield washer fluid.
• Replace worn or cracked wiper blades.
• See
that
all windows are clear and un­
obstructed.
• Check whether all
light
lenses are

clean.
• Be sure all lights are working and head­
lights are aimed correctly.
• Check under vehicle for leaks.
• Make sure the movement of either

brake,
clutch or accelerator pedal is not hampered in any way.
• Be sure all luggage is stored securely.

You'll
find helpful hints on how to perform most of these checks in this manual. If in
doubt, have these checks performed by
your dealer or any other qualified
mechanic.

Emergency
equipment

It is good practice to carry emergency
equipment in your vehicle. Some of the
things you should have are: emergency
light,
first-aid kit, small shovel, and for the
winter
season,
an ice scraper, snow brush,
a
container or bag of sand or salt, etc.
70


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
OPERATION

In the
driver's
seat
•
Check operation of horn.

•
Adjust seat for easy reach of controls.

•
Adjust head restraints to your
size.

•
Adjust inside and outside rear view mir-
brs.

•
Use safety belts as directed.

•
Assure yourself
that
all passengers,

especially
children, are properly buckled up.

•
Check operation of
foot
and parking

orakes.

•
Check all warning and indicator lights
v/hen starting the engine.

•
Do not leave vehicle idling unattended.

•
Lock all doors
from
inside to prevent in­ advertent opening of doors
from
inside
and unwanted
entry
from
outside. On the
road

•
Always drive defensively. Expect the

unexpected.

•
Observe speed
limits
and obey road

signs.

•
Use signals to indicate
turns
and lane

changes.

•
Turn on headlights at dusk.

•
Always keep a safe distance
from
the
vehicle in
front
of you, depending on
traf­

fic, road and weather conditions.

•
Reduce speed at
night
and during incle­
ment weather.

•
If you smell gas fumes in the vehicle,
drive
with
the windows open, but keep the rear lid
closed.
Have the cause im­
mediately located and corrected.

•
Make frequent rest stops, at least
after

every two hours of driving.

•
When
tired
pull off the road, stop and
take a rest. Turn the engine off. Do not sit in the vehicle
with
engine idling. Engine ex­haust is dangerous if inhaled.
•
When stopped or parked, always set
the parking brake. Move the selector lever
to "P" (Automatic transmission) or move
the gearshift lever to reverse or
first
gear (Manual transmission). When parking on

hills,
turn
wheels
toward
the curb.

•
When stalled or stopped for repairs,
move the vehicle well off the road. Turn on
emergency flasher and use other warning

devices
to alert other motorists. Do not park or operate the vehicle in areas where
the hot exhaust system may come in
con­

tact
with
dry
grass,
brush, fuel spill or other material which can cause a fire.

•
Make it a habit to have the engine oil

checked
with
every fuel filling.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans