1990 MITSUBISHI SPYDER inflation pressure

CONTENTS
GENERAL INFORMATION. . . . . . . . . . . . . . . . . .2
ON-VEHICLE SERVICE. . . . . . . . . . . . . . . . . . . . .5
Tire Inflation Pressure Check. . . . . . . . . . . . . . . . .
Tire Wear Check. . . . . . . . . . . . . . . . . . . . . . . . . . . .‘5
Wheel Check . . . . . . . .. . . . .. . . . . . . .5
SERVICE SPECIFICATIONS . . . . . . . . . .
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . .
WHEEL AND TIRE
.. . . . . . . . . . . . . . . . . . . . . . . . .

WHEEL AND TIRE
Symptom
Rapid wear at
shouldersProbable cause
Under-inflationor lack of
tion
Remedy Reference
Adjust the tire
Refer to
p r e s s u r e .
Rapid wear at
Over-inflation or
center
lack of rotation
I
treads Under-inflation Adjust the tireRefer to
pressure.
Wear on one side
Excessive
ber Check thecamber.
Refer to GROUP On-vehicle
Service.
Feathered edge Incorrect toe-in
Adjust the
toe-in.
Bald spots Unbalanced
wheel
Adjust the
wheels.
Scalloped wear Lack of rotation of tires or
worn orRotate the Refer to GROUP
out-of-alignment suspension check the front On-vehicle
suspension Service.
alignment.
TSB Revision

WHEEL AND TIRE On-vehicle Service/Wheel and Tire
Wear indicator
TIRE INFLATION PRESSURE CHECK
NOTERefer to the inflation pressure label on the driver ’s side door.
TIRE WEAR CHECK
Measure the tread depth of tires.
Limit: 1.6 mm
in.)
If the remaining tread depth is less than the limit , replace
the tire.
NOTE
When the tread depth of tires is reduced to 1.6 mm
or less, wear indicators will appear.
WHEEL
CHECK
Jack up the vehicle so that the wheels are clear of the floor.
While slowly turning the wheel, measure wheel with
a dial indicator.
Limit:
Radial
Steel wheel; 1.2 mm in.) or less
Aluminum wheel; 1.0 mm
in.) or less
Lateral
Steel wheel; 1.2 mm in.) or less
Aluminum wheel; 1.0 mm
in.) or less
If wheel
exceeds the limit, replace the wheel.
INSTALLATION SERVICE POINT
Tighten the wheel nut to the specified torque.
Tightening torque:
Nm
TSB Revision

FRONT __
TROUBLESHOOTING
, .
SymptomProbable cause
Remedy
Steering wheel is heavy, vibratesSuspension malfunction
or pulls to one side, ,
Ball jointAdjust or replace
Coil spring
Wheel alignment
Unbalanced or worn tires Adjust or replace
Adjust or
Adjust or replace
Excessive vehicle rollingBroken or deteriorated stabilizer
Shock absorber malfunction
Replace
Improper tire inflation pressure
NoiseLack of lubrication
Looseness and wear of each part
.
Broken coil spring
Shock absorber malfunction
Replace
FRONT WHEEL
ADJUSTMENT
Measure wheel alignment with alignment equipment on a
level surface.
The ‘front’ ‘suspension, and should
be serviced to normal to wheel
alignment.
TOE-IN
The suspension wheel be
t o
Standard value: 0 3 mm 0 in.
TSB Revision

SymptomProbable cause Remedy
Squeaks or other Loose rear suspension mounting bolts and nutsRetighten
normal noise Malfunction of shock absorber Replace
W o r n b u s h i n g s
Upper arms and/or lower arms and/or toe control
arm deformed or damaged
Trailing arms deformed or damaged
Crossmember deformed or damaged
Poor ride Excessive tire inflation pressure Adjust the pressure
Malfunction of shock absorber
Replace
Weak or broken springs
Stabilizer bar and/or stabilizer link
or damaged.
Body tilting Weak or deteriorated bushings Replace
Weak or broken springs
Upper arms and/or lower arms and/or toe control
arm deformed or damaged
Trailing arms deformed or damaged
Crossmember deformed or damaged
REAR SUSPENSION
TROUBLESHOOTING
TSB Revision

ALPHABETICAL INDEX5
GENERATOR ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE> . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERATOR OUTPUT LINE VOLTAGE DROP
Test ENGINE (NON-TURBO)> . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE> . . .
GLASS
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Quarter Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...42-15-1
G-SENSOR . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .HANDLING TUBING AND FITTINGS. . . . . . . . . . . . . . . .
HAZARD WARNING LIGHT SWITCH. . . . . . . . . . . . . . . .
HEADLIGHT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aiming. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HEADLIGHT BULB, Replacement. . . . . . . . . . . . . . . . . . .
HEADLINING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HEATED OXYGEN SENSOR
.
. .
.
.
.
On-vehicle Inspection E N G I N E ( N O N - T U R B O ) > . . . . .
ENGINE (TURBO) AND ENGINE> . .
HEATER CONTROL . . . . . . . . . . . . . . . . . . . . . .
HEATERCORE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HIGH-MOUNTED STOP LIGHT . . . . . . . . . . . . . .
HOOD .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HOUSING, Extension . . . . . . . . . . . . .
HOSEW a t e r ENGINE (NON-TURBO)> . . . . . . . ENGINE (TURBO) AND ENGINE> . .
HOSESPower Steering ENGINE (NON-TURBO)> . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE> . . . , .
Vacuum ENGINE (NON-TURBO)>. . . . . . .
ENGINE (TURBO) AND ENGINE> .
Brake, Maintenance. . . . . . . . . . . . . . . . . . . . .
Fuel, Maintenance . . . . . . . . . . . . . . . . . . . . . . . . .
HUB, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HUB BOLTReplacement, Front . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HUBFront . . . . . . . . . . . Rear. . . . . . . . . . . . .
HYDRAULIC CIRCUIT ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . . . .
HYDRAULIC PRESSURETest ENGINE (NON-TURBO)> . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE> .
HYDRAULIC UNIT. . . . . . . . . . . . . . . . . . . . . . . . .
IDLE AIR CONTROL MOTOR (Stepper Motor)Check . . . .
On-vehicle Inspection ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND . . . .
Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
, . , . , . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .. . . . . . .. . . . . . . . .
IDLE SPEED
Basic, Adjustment
ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . .
Curb, Check . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . ....
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
IDLE-UP OPERATION, Check. . . . . . . . . . . . .. . . . . . . . . . . . .
IGNITION CABLES, Maintenance. . . . . . . . . . . . . . . . . . . . . . .
COIL. Check ENGINE (NON-TURBO)> . .
IGNITION COIL PACK, Check ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . . . . .
IGNITION POWER TRANSISTOR, Check. . . . . . . . . . . . . . .
IGNITION PRIMARY VOLTAGE WAVEFORM, Check. . . . .
IGNITION SECONDARY VOLTAGE WAVEFORM, Check ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . . . . .
IGNITION SECONDARY VOLTAGE WAVEFORM, Check ENGINE (TURBO) AND ENGINE>.. . . . . . . . . . .
IGNITION SWITCH. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
IGNITION SYSTEM ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE (TURBO)>. . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
IGNITION TIMING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
...................................................
.........................
INFLATION PRESSURE, Tire, Check. . . . . . . . . . . . . . . . . . . . . .
INJECTOR ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . . . . .
On-vehicle Inspection ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . .
INPUT CLUTCHES . . . . . . . . . . . . . . . . . . . . . . . . .
INPUT SHAFT
Disassembly. . . . . . . . . . . . . . . . . . . . . . . . . . .
Reassembly. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
INSIDE REAR VIEW MIRROR. . . . . . . . . . . . . . . . . . . . . . . .
INSTRUMENT PANEL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
INTAKE AIR TEMPERATURE SENSOR ENGINE (NON-TURBO)>............................. . .
ENGINE (TURBO) AND ENGINE>.
On-vehicle Inspection ENGINE (NON-TURBO)> . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . .
INTAKE MANIFOLD ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
ENGINE (TURBO)>. . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Vacuum Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
INTERIOR LIGHT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
INTERLOCK SWITCHCheck and Adjustment................................................... ............Operating Check
INTERMEDIATE GEAR . . . . . .

ALPHABETICAL INDEX
Transfer, Replacement ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . OIL COOLER
Engine. . . . .
Transaxle ENGINE (NON-TURBO)> . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE> . . .
OIL FILTER, Engine, Maintenance . . . . . . . . . . , . . . . . . . .
Replacement .
OIL LEVEL
Transaxle, Check ENGINE (NON-TURBO)> . . . . . . , . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . . . .
Transfer, Check ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL PAN
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL PRESSURE GAUGE, Simple Check
OIL PUMP
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
11 1
. . . . . . . .
11
. . . . . . .
. . . . . . .
. . . . . . .
Power Steering ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND . . . . .
Pressure Test. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL PUMP SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL SCREEN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I
OIL SEAL(S) Camshaft
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshaft front . . . . . . . . . . . . . . . . . . . . .11. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Crankshaft rear . . . . . . . . . . . . . . . . . . . . .11. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Carrier . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drive Shaft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL Engine, Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transfer, Replacement ENGINE (TURBO) AND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OUTPUT CURRENT
Test
ENGINE (NON-TURBO)> . . . . . . . . . . . . . , . . .
ENGINE (TURBO) AND . . . .
OUTPUT GEAR, Disassembly . . . . . . . . . . . . . .
OUTPUT . . . . . . . . . . . . . . . .
PAD
Disc Brake, Front, Check and Replacement . . . . . . . . .
Disc Brake, Rear, Check and Replacement . . . . . . . . .
Disc Brake, Maintenance . . . . . . . . . . . . . . . . . . . . . . , . . . .
PARK/NEUTRAL POSITION SWITCH
Adjustment
ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Continuity Check ENGINE (NON-TURBO)> . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE> . . . . .
PARKING BRAKE CABLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..
. . . . . . . . . . . . . . . . . . . . . . . . . .
PARKING BRAKE DRUM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PARKING BRAKE LEVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PARKING BRAKE LEVER, Stroke Check. . . . . . . . . . . . . . . . . .
PARKING BRAKE SWITCH, Check. . . . . . . . . . . . . . . . . . . . . . .
PEDAL
Accelerator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake.. . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake, Check and Adjustment. . . . . . . . . . . . . . . . . . . . . . .
Clutch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clutch, Check and Adjustment. . . . . . . . . . . . . . . . . . . . . . .
PERFORMANCE TEST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PIPE
Exhaust. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Water ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . .
(TURBO) AND ENGINE>. . .
PISTON. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PLANETARY GEAR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PLATE, Drive
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PLAY
End, Wheel Bearing, Check. . . . . . . . . . . . . . . . . . . . . . . . . . .
End, Wheel Bearing, Check . . . . . . . . . . . . . . . . . . .
PLUGSpark, Check ENGINE (NON-TURBO)>. . . . . . . .
Spark, Cleaning ENGINE (NON-TURBO)>. . . . . .
Spark, Resistance Check ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . .
S p a r k , T e s t ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND . . . . .
Spark, Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
POSITION LIGHT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
POSITIVE CRANKCASE VENTILATION SYSTEM ENGINE . . . . . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . . . . . . . .
POSITIVE CRANKCASE VENTILATION VALVE
Check ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . .
POST-COLLISION DIAGNOSIS. . . . . . . . . . . . . . . . . . . . . . .
POWER RELAY, Check. . . . . . . . . . . . . . . . . . . . . . . . .. . . .
POWER STEERING GEAR BOX. . . . . . . . . . . . . . . . . . . . . .
POWER STEERING HOSES ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . . . . . .
POWER STEERING OIL PUMP
ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . . . . . .
POWER TRANSISTOR, Ignition. . . . . . . . . . . . . . . . . . . . . . . .
PRESSURE
Compression, Check . . . . . . . . . . . . . . . . .
. . . . . . . . . . . ... . . . .
. . . . . . . . . . . . . . . . . . . . .Fuel, Test ENGINE . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>. . . .
PRESSUREClutch Air, Tests ENGINE (NON-TURBO)> . . . . Inflation, Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . ,
Line, Adjustment ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

ALPHABETICAL INDEX
TENSIONDrive Belt, Check and Adjustment . . . . . . . .11. . . . . . . .. . . . . . . . . . . .
TENSION PULLEY ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . . . ENGINE (TURBO) AND ENGINE>.. . . . . . . . .TEST EQUIPMENT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .THEFT-ALARM SYSTEM. . . . . . . . . . . . . . . . . . . . . . . . . . . . .T H E R M O S T A T. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .THICKNESS
Front Brake Disc, Check. . . . . . . . . . . . . . . . . . . . . . . . . . .Rear Brake Disc, Check. . . . . . . . . . . . . . . . . . . . . . . . . . .
THROTTLE BODY
ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . . . . .THROTTLE BODY MINIMUM AIR FLOW, Check. . . . . . .THROTTLE BODY (THROTTLE VALVE AREA) ENGINE (TURBO) AND ENGINE>, Cleaning .
THROTTLE POSITION SENSORAdjustment
ENGINE (TURBO) AND ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . .On-vehicle ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . .
ENGINE (TURBO) AND . . .TIE ROD END BALL JOINT, Breakaway Torque Check. . . .TIMING BELT
. . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIMING BELT
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TIMING BELT, Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . .TIRE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TIRE INFLATION PRESSURE, Check. . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TOE CONTROL ARM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TORQUE CONVERTER STALLTesting
ENGINE (NON-TURBO)>. . . . . . . . . . . ENGINE (TURBO) AND ENGINE>TOTAL BACKLASH Rear Axle, Check. . . . . . . . . . . .TRAILING ARM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRANSAXLE ENGINE (NON-TURBO)>. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ENGINE (TURBO) AND . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ENGINE (TURBO) AND ENGINE> . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Cleaning and . . . . . . . . . . . . . . . . . . . . . ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . .M/T ENGINE (TURBO) AND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .M/T ENGINE (TURBO) AND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . .TRANSAXLECASEDisassembly
. . . . . . . . . . . . . . . . . . . . . . . . . . . .Reassembly. . . . . . . . . . . . . . . . . . . . . . . . . . . .TRANSAXLE CONTROL
ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . ENGINE (TURBO) AND ENGINE>. . . .A/T ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . ENGINE (TURBO) AND . . .
TRANSAXLE FLUID
Automatic, Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement ENGINE (NON-TURBO)> . . . . . . . . . . . . .
ENGINE (TURBO) . . . TRANSAXLE FLUID LEVELCheck ENGINE (NON-TURBO)> . . . . . . . . . . . . . . . . ENGINE (TURBO) AND ENGINE>. . . . .
TRANSAXLE MOUNTING . . . . . . . . . . . . . . . . . . . . . . . , . . TRANSAXLE OIL
Manual, Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement ENGINE . . . . . . . . . . . . . .
. . . . . .
TRANSAXLE OIL COOLER
ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>.. . . . . .
TRANSAXLE OIL LEVEL
Check
ENGINE (NON-TURBO)>.. . . . . . . . . . . . .
ENGINE (TURBO) AND ENGINE>..
TRANSAXLE RANGE SENSOR, Continuity Check ENGINE (NON-TURBO)>. . . . . . . . . . . . . . . . . . . . . .TRANSFER
ENGINE (TURBO) AND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TRANSFER CASE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TRANSFER CASE ADAPTER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRANSFER DRIVEN GEAR . . . . . . . . . . . . . . . . .TRANSFER OIL, Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . .TRANSFER OIL, Replacement ENGINE AND ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRANSFER OIL LEVEL
ENGINE AND ENGINE>. . . . . . . . . . - -
. . . . . . . . . . .
TRANSFER OIL, Replacement ENGINE (TURBO) AND ENGINE>. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRANSFER SHAFT
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRIM, Door. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRIMS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .TRUNK LID LOCK RELEASE CABLE. . . . . . . . . . . . . . . . . . . .
TRUNK LID LOOK RELEASE HANDLE. . . . . . . . . . . . . . . . . .TUBING AND FITTINGS, Handling. . . . . . . . . . . . . . . . . . . . . .TURBOCHARGER BYPASS VALVE, CHECK. . . . . . . . . .. . .
TURBOCHARGER WASTE GATE SOLENOID
Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .On-vehicle Inspection. . . . . . . . . . . . . . . . . . . . . . . . . . . .
UNDER COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ... . . . . .UPPER ARM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Suspension>. . . . . . . . . . . . . . . . . . . . ... . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . .. .
VACUUM
EGR Port, Check ENGINE ENGINE (TURBO) AND . . . . . . Manifold, Check . . . . . . . . . . . . . . . . . . . . 11 C-l
. . . . . . . . . . . . . . . . . . . . . .