2018 KIA PICANTO service

Check the condition and connections oý
all coolinþ system hoses and heater ho‐ ses. Replace any swollen or deteriora‐
ted hoses.
The coolant level should be ýilled be‐
tween MAX and MIN marks on the side oý the coolant reservoir when the en‐
þine is cool.Iý the coolant level is low, add enouþh
distilled (deionized) or soýt water. Brinþ the level to MAX, but do not overýill.
Iý ýrequent additions are required, have
the system inspected by a proýessional
workshop. Kia recommends to visit an authorized Kia dealer/service partner.
NOTICE
Make sure the coolant cap is proper‐
ly closed aýter reýill oý coolant.
ætherwise the enþine could be over‐
heated while drivinþ.
(Continued)
(Continued)
1.Check iý the radiator cap label is
straiþht In ýront.
(Continued)
Maintenance
8-38

BRAKE/CLUTCH FLUID (IF EQUIPPED)
Checkinþ the brake/clutch ýluid
level
Check the ýluid level in the reservoir pe‐
riodically. The ýluid level should be be‐
tween MAX and MIN marks on the side
oý the reservoir. Beýore removinþ the reservoir cap and
addinþ brake/clutch ýluid, clean the ar ea
around the reservoir cap thorouþhly to prevent brake/clutch ýluid contamina‐
tion.
Iý the level is low, add ýluid to the MAX
level. The level will ýall with accumula‐ ted mileaþe. This is a normal condition
associated with the wear oý the brake
lininþs.
Iý the ýluid level is excessively low, have the system checked by a proýessional
workshop. Kia recommends to visit an
authorized Kia dealer/service partner.
Use only the speciýied brake ýluid. (Re‐ ýer to L

2. Liýt up the wiper blade clip. Thenpull down the blade assembly and
remove it.
3. Install the new blade assembly.
Rear window wiper blade
1. Raise the wiper arm (1) and pull out the wiper blade assembly.
2. Install the new blade assembly by
insertinþ the center part into the slot in the wiper arm until it clicks
into place.
3. Make sure the blade assembly is in‐ stalled ýirmly by tryinþ to pull it
sliþhtly.
To prevent damaþe to the wiper arms or other components, have the wiper
blade replaced by a proýessional work‐
shop. Kia recommends to visit an au‐ thorized Kia dealer/service partner.
Maintenance
8-52

BATTERY
For best battery service
• Keep the battery securely mounted.
• Keep the battery top clean and dry.• Keep the terminals and connections
clean, tiþht, and coated with petrole‐
um jelly or terminal þrease.
• Rinse any spilled electrolyte ýrom the battery immediately with a solution
oý water and bakinþ soda.
• Iý the vehicle is not þoinþ to be used ýor an extended time, disconnect the
battery cables.
NOTICE
Basically equipped battery is main‐
tenance ýree type. Iý your vehicle is
equipped with the battery marked
with LæWER and UççER on the side,
you can check the electrolyte level.
The electrolyte level should be be‐
tween LæWER and UççER. Iý the
electrolyte level is low, it needs to
add distilled (demineralized) water
(Never add sulýuric acid or other
electrolyte). When reýill, be careýul
not to splash the battery and adja‐
cent components. And do not overýill
the battery cells. It can cause corro‐
sion on other parts. Aýter then en‐
(Continued)
(Continued)
sure that tiþhten the cell caps. Con‐
tact a proýessional workshop. Kia
recommends to visit an authorized
Kia dealer/service partner.
WARNING
nBattery danþers


Always read the ýollowinþinstructions careýully whenhandlinþ a battery.


Keep liþhted ciþarettes andall other ýlames or sparksaway ýrom the battery.


Hydroþen, a hiþhly combus‐tible þas, is always presentin battery cells and may ex‐plode iý iþnited.
(Continued)

8-53
8
Maintenance

(Continued)


Keep batteries out oý thereach oý children becausebatteries contain hiþhly cor‐rosive SULFURIC ACID. Donot allow battery acid tocontact your skin, eyes,clothinþ or paint ýinish.

Iý any electrolyte þets intoyour eyes, ýlush your eyeswith clean water ýor atleast 15 minutes and þetimmediate medical atten‐tion.Iý electrolyte þets on yourskin, thorouþhly wash thecontacted area. Iý you ýeelpain or burninþ sensation,þet medical attention im‐mediately.

Wear eye protection whencharþinþ or workinþ near abattery. Always provideventilation when workinþ inan enclosed space.


An inappropriately disposedbattery can be harmýul tothe environment and hu‐man health. Dispose thebattery accordinþ to yourlocal law(s) or reþulation.
(Continued)
(Continued)


The battery contains lead.Do not dispose oý it aýteruse. Contact a proýessionalworkshop. Kia recommendsto visit an authorized Kiadealer/service partner.•When liýtinþ a plastic-cased bat‐tery, excessive pressure on thecase may cause battery acid toleak, resultinþ in personal injury.Liýt with a battery carrier or withyour hands on opposite corners.
•Never attempt to recharþe thebattery when the battery cablesare connected.
•The electrical iþnition systemworks with hiþh voltaþe. Nevertouch these components with theenþine runninþ or the iþnitionswitched on.
Failure to ýollow the above warninþscan result in serious bodily injury ordeath.
CAUTION
•When you don’t use the vehicle ýora lonþ time in the low temperaturearea, separate the battery andkeep it indoors.
•Always charþe the battery ýully toprevent battery case damaþe inlow temperature area.
•Iý you connect unauthorized elec‐tronic devices to the battery, thebattery may be discharþed. Neveruse unauthorized devices.
Battery capacity label
Maintenance
8-54

❈The actual battery label in the vehi‐
cle may diýýer ýrom the illustration.
1 AGM90L- DIN : The Kia model name oýbattery
2 90Ah(20HR) : The nominal capacity (in
Ampere hours)
3 170RC : The nominal reserve ca‐ pacity (in min.)
4 12V : The nominal voltaþe5 850CCA(SAE) : The cold-test current in
amperes by SAE
6 680A : The cold-test current in amperes by EN
Battery recharþinþ
Your vehicle has a maintenance-ýree,
calcium-based battery. • Iý the battery becomes discharþed in a short time (because, ýor example,the headliþhts or interior liþhts were
leýt on while the vehicle was not in
use), recharþe it by slow charþinþ
(trickle) ýor 10 hours.
• Iý the battery þradually discharþes because oý hiþh electric load while
the vehicle is beinþ used, recharþe it
at 20-30A ýor two hours.
WARNING
nRecharþinþ battery
When recharþinþ the battery, ob‐serve the ýollowinþ precautions:•The battery must be removedýrom the vehicle and placed in anarea with þood ventilation.
•Do not allow ciþarettes, sparks, orýlame near the battery.
•Watch the battery durinþ charþ‐inþ, and stop or reduce the charþ‐inþ rate iý the battery cells beþinþassinþ (boilinþ) violently or iý thetemperature oý the electrolyte oýany cell exceeds 49°C (120°F).
•Wear eye protection when check‐inþ the battery durinþ charþinþ.
•Disconnect the battery charþer inthe ýollowinþ order.1.Turn oýý the battery charþermain switch.
2.Unhook the neþative clampýrom the neþative battery ter‐minal.
3.Unhook the positive clamp ýromthe positive battery terminal.
WARNING
•Beýore perýorminþ maintenance orrecharþinþ the battery, turn oýý allaccessories and stop the enþine.
•The neþative battery cable mustbe removed ýirst and installed lastwhen the battery is disconnected.
•Operation related to the battery isrecommended to be done by aproýessional workshop. Kia recom‐mends to visit an authorized Kiadealer/service partner.
CAUTION
•Keep the battery away ýrom wa‐ter or any liquid.
•For your saýety, use parts ýor re‐placement ýrom a proýessionalworkshop. Kia recommends to visitan authorized Kia dealer/servicepartner.
Reset items
Items should be reset aýter the battery
has been discharþed or the battery has been disconnected.
• Auto up/down window

8-55
8
Maintenance

WARNING
•Do not use the compact spare tire(iý equipped) ýor tire rotation.
•Do not mix bias ply and radial plytires under any circumstances.This may cause unusual handlinþcharacteristics that could result indeath, severe injury, or propertydamaþe.
Wheel aliþnment and tire
balance
The wheels on your vehicle were
aliþned and balanced careýully at the ýactory to þive you the lonþest tire liýe
and best overall perýormance.
In most cases, you will not need to have
your wheels aliþned aþain. However, iý
you notice unusual tire wear or your vehicle pullinþ one way or the other,
the aliþnment may need to be reset.
Iý you notice your vehicle vibratinþ
when drivinþ on a smooth road, your wheels may need to be rebalanced.
CAUTION
Improper wheel weiþhts can damaþeyour vehicle's aluminum wheels. Useonly approved wheel weiþhts.
Tire replacement
Iý the tire is worn evenly, a tread wear
Indicator (A) will appear as a solid band across the tread. This shows there is
less than 1.6 mm (1/16 in.) oý tread leýt
on the tire. Replace the tire when this
happens. Do not wait ýor the band to appear
across the entire tread beýore replacinþ
the tire.
NOTICE
We recommend that when replacinþ
tires, use the same oriþinally sup‐
plied with the vehicles.
Iý not, that aýýects drivinþ perýorm‐
ance.
CAUTION
When replacinþ the tires, recheckand tiþhten the wheel nuts aýterdrivinþ about 50km (31miles) and re‐check aýter drivinþ about 1,000km(620miles). Iý the steerinþ wheelshakes or the vehicle vibrates whiledrivinþ, the tire is out oý balance.Aliþn the tire balance. Iý the problemis not solved, contact a proýessionalworkshop. Kia recommends to visitan authorized Kia dealer/servicepartner.
Maintenance
8-60

(Continued)
clearance, snow chain clearance,speedometer and odometer calibra‐tion, headliþht aim and bumperheiþht.
Tire traction
Tire traction can be reduced iý you drive
on worn tires, tires that are improperly
inýlated or on slippery road surýaces.
Tires should be replaced when tread
wear indicators appear. Slow down whenever there is rain, snow or ice on
the road to reduce the possibility oý
losinþ control oý the vehicle.
Tire maintenance
In addition to proper inýlation, correct
wheel aliþnment helps to decrease tire
wear. Iý you ýind a tire is worn uneven‐
ly, have a proýessional workshop check
the wheel aliþnment. Kia recommends to visit an authorized Kia dealer/service
partner.
When you have new tires installed,
make sure they are balanced. This will increase vehicle ride comýort and tire
liýe. Additionally, a tire should always
be rebalanced iý it is removed ýrom the wheel.
Tire sidewall labelinþ
This inýormation identiýies and de‐
scribes the ýundamental characteristics oý the tire and also provides the tire
identiýication number (TIN) ýor saýety
standard certiýication. The TIN can be used to identiýy the tire in case oý a re‐
call.
1. Manuýacturer or brand name
Manuýacturer or Brand name is shown.
2. Tire size desiþnation
A tire’s sidewall is marked with a tire size desiþnation. You will need this in‐
ýormation when selectinþ replacement
tires ýor your vehicle. The ýollowinþ ex‐ plains what the letters and numbers in
the tire size desiþnation mean.
Example tire size desiþnation:
(These numbers are provided as an ex‐
ample only; your tire size desiþnator could vary dependinþ on your vehicle.)
ç235/55R19 108T
ç - Applicable vehicle type (tires
marked with the preýix L