2017 CHEVROLET EXPRESS CARGO VAN coolant

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
Vehicle Care 233
Washer Fluid
What to Use
When the vehicle needs windshieldwasher fluid, be sure to read themanufacturer's instructions beforeuse. If operating the vehicle in anarea where the temperature may fallbelow freezing, use a fluid that hassufficient protection againstfreezing.
Adding Washer Fluid
Open the cap with the washersymbol on it. Add washer fluid untilthe tank is full. SeeEngineCompartment Overview0218forreservoir location.
Caution
.Do not use washer fluid thatcontains any type of waterrepellent coating. This cancause the wiper blades tochatter or skip.
.Do not use engine coolant(antifreeze) in thewindshield washer. It candamage the windshieldwasher system and paint.
.Do not mix water withready-to-use washer fluid.Water can cause thesolution to freeze anddamage the washer fluidtank and other parts of thewasher system.
.When using concentratedwasher fluid, follow themanufacturer instructions foradding water.
.Fill the washer fluid tankonly three-quarters full whenit is very cold. This allowsfor fluid expansion if
(Continued)
Caution (Continued)
freezing occurs, which coulddamage the tank if it iscompletely full.
Brakes
Disc brake pads have built-in wearindicators that make a high-pitchedwarning sound when the brake padsare worn and new pads are needed.The sound can come and go or canbe heard all the time when thevehicle is moving, except whenapplying the brake pedal firmly.
{Warning
The brake wear warning sound
means that soon the brakes will
not work well. That could lead to
acrash.Whenthebrakewear
warning sound is heard, have the
vehicle serviced.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
258 Vehicle Care
Belt:Arubbercoatedlayerof
cords between the plies and the
tread. Cords may be made from
steel or other reinforcing
materials.
Bead:The tire bead contains
steel wires wrapped by steel
cords that hold the tire onto
the rim.
Bias Ply Tire:Apneumatictire
in which the plies are laid at
alternate angles less than
90 degrees to the centerline of
the tread.
Cold Tire Pressure:The
amount of air pressure in a tire,
measured in kPa (kilopascal)
or psi (pounds per square inch)
before a tire has built up heat
from driving. SeeTire
Pressure0260.
Curb Weight:The weight of a
motor vehicle with standard and
optional equipment including the
maximum capacity of fuel, oil,
and coolant, but without
passengers and cargo.
DOT Markings:Acodemolded
into the sidewall of a tire
signifying that the tire is in
compliance with the U.S.
Department of Transportation
(DOT) Motor Vehicle Safety
Standards. The DOT code
includes the Tire Identification
Number (TIN), an alphanumeric
designator which can also
identify the tire manufacturer,
production plant, brand, and
date of production.
GVWR:Gross Vehicle Weight
Rating. SeeVehicle Load
Limits0171.
GAWR FRT:Gross Axle Weight
Rating for the front axle. See
Vehicle Load Limits0171.
GAWR RR:Gross Axle Weight
Rating for the rear axle. See
Vehicle Load Limits0171.
Intended Outboard Sidewall:
The side of an asymmetrical tire
that must always face outward
when mounted on a vehicle.
Kilopascal (kPa):The metric
unit for air pressure.
Light Truck (LT-Metric) Tire:A
tire used on light duty trucks and
some multipurpose passenger
vehicles.
Load Index:An assigned
number ranging from 1 to 279
that corresponds to the load
carrying capacity of a tire.
Maximum Inflation Pressure:
The maximum air pressure to
which a cold tire can be inflated.
The maximum air pressure is
molded onto the sidewall.
Maximum Load Rating:The
load rating for a tire at the
maximum permissible inflation
pressure for that tire.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
298 Service and Maintenance
ayearandtheoillifesystemmustbe reset. Your trained dealertechnician can perform this work.If the engine oil life system is resetaccidentally, service the vehiclewithin 5 000 km/3,000 mi since thelast service. Reset the oil lifesystem when the oil is changed.SeeEngine Oil Life System0221.
Tire Rotation and Required
Services Every 12 000 km/
7,500 mi
Rotate the tires, if recommended forthe vehicle, and perform thefollowing services. SeeTireRotation0265.
.Check engine oil level and oillife percentage. If needed,change engine oil and filter, andreset oil life system. SeeEngineOil0219andEngine Oil LifeSystem0221.
.Check engine coolant level. SeeEngine Coolant0227.
.Check windshield washer fluidlevel. SeeWasher Fluid0233.
.Visually inspect windshield wiperblades for wear, cracking,or contamination. SeeExteriorCare0288.Replacewornordamaged wiper blades. SeeWiper BladeReplacement0239.
.Check tire inflation pressures.SeeTire Pressure0260.
.Inspect tire wear. SeeTireInspection0265.
.Visually check for fluid leaks.
.Inspect engine air cleaner filter.SeeEngine Air Cleaner/Filter0225.
.Inspect brake system. SeeExterior Care0288.
.Visually inspect steering,suspension, and chassiscomponents for damaged, loose,or missing parts or signs ofwear. SeeExterior Care0288.
.Check restraint systemcomponents. SeeSafety SystemCheck054.
.Visually inspect fuel system fordamage or leaks.
.Visually inspect exhaust systemand nearby heat shields forloose or damaged parts.
.Lubricate body components. SeeExterior Care0288.
.Check starter switch. SeeStarterSwitch Check0238.
.Check automatic transmissionshift lock control function. SeeAutomatic Transmission ShiftLock Control FunctionCheck0238.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
Service and Maintenance 305
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
This maintenance section applies to vehicles with a gasoline engine. If the vehicle has a diesel engine, see themaintenance schedule section in the Duramax diesel supplement.
Fluids and lubricants identified below by name, part number, or specification can be obtained from your dealer.
Usage Fluid/Lubricant
Automatic Transmission DEXRON®-VI Automatic Transmission Fluid.
Chassis Lubrication, Parking BrakeCable GuidesChassis Lubricant (GM Part No. 12377985, in Canada 88901242) orlubricant meeting requirements of NLGI #2, Category LB or GC-LB.
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL®Coolant.SeeEngine Coolant0227.
Engine Oil Engine oil meeting the dexos1™specification of the proper SAE viscositygrade. ACDelco dexos1 Synthetic Blend is recommended. SeeEngineOil0219.
Front Wheel Bearings Wheel bearing lubricant meeting requirements of NLGI #2, Category GC orGC-LB (GM Part No. 1051344, in Canada 993037).
Hydraulic Brake System DOT 3 Hydraulic Brake Fluid (GM Part No. 19299818, inCanada 19299819).
Key Lock Cylinders, Hood Hinges Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, inCanada 10953474).
Power Steering System GM Power Steering Fluid (GM Part No. 19329450, in Canada 89021186).

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
338 Index
Climate Control Systems (cont'd)
Air Conditioning . . . . . . . . . . . . . . 158
Heating . . . . . . . . . . . . . . . . . . . . . . . 158
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Rear Heating System . . . . . . . . . 160
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Cluster, Instrument . . . . . . . . . . . . . . 95
Collision Damage Repair . . . . . . . 319
Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . . . 85
Compass . . . . . . . . . . . . . . . . . . . . . . . . 90
Messages . . . . . . . . . . . . . . . . . . . . .113
Connections
OnStar®...................... 328
Control
Traction and Electronic
Stability . . . . . . . . . . . . . . . . . . . . . 190
Control of a Vehicle . . . . . . . . . . . . . 166
Convex Mirrors . . . . . . . . . . . . . . . . . . 35
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 227
Engine Temperature Gauge . . . . 98
Cooling System . . . . . . . . . . . . . . . . . 226
Engine Messages . . . . . . . . . . . . .113
Courtesy Transportation
Program . . . . . . . . . . . . . . . . . . . . . . . 318
Cruise Control . . . . . . . . . . . . . . . . . . 192
Light . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Customer Assistance . . . . . . . . . . . 315
Offices . . . . . . . . . . . . . . . . . . . . . . . . 314
Te x t Te l e p h o n e ( T T Y )
Users . . . . . . . . . . . . . . . . . . . . . . . 315
Customer Information
Service Publications
Ordering Information . . . . . . . . 321
Customer Satisfaction
Procedure . . . . . . . . . . . . . . . . . . . . . 312
D
Damage Repair, Collision . . . . . . . 319
Danger, Warning, and Caution . . . . 3
Data Collection
Infotainment System . . . . . . . . . . 325
OnStar . . . . . . . . . . . . . . . . . . . . . . . 325
Data Recorders, Event . . . . . . . . . 324
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . . . 126
Defensive Driving . . . . . . . . . . . . . . . 165
Delayed Locking . . . . . . . . . . . . . . . . . 29
Devices
Auxiliary . . . . . . . . . . . . . . . . . . . . . . 146
Diagnostics
OnStar®...................... 330
Distracted Driving . . . . . . . . . . . . . . . 165
Dome Lamps . . . . . . . . . . . . . . . . . . . 129
Door
Ajar Messages . . . . . . . . . . . . . . . .113
Door (cont'd)
Cargo Door Relocking . . . . . . . . . . 29
Delayed Locking . . . . . . . . . . . . . . . . 29
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Power Locks . . . . . . . . . . . . . . . . . . . . 29
Rear Doors . . . . . . . . . . . . . . . . . . . . . 32
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Sliding . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Drive Belt Routing, Engine . . . . . . 311
Driver Information
Center (DIC) . . . . . . . . . . . . . . . . . . 108
Driving
Characteristics and
To w i n g T i p s . . . . . . . . . . . . . . . . . 2 0 2
Defensive . . . . . . . . . . . . . . . . . . . . . 165
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 166
For Better Fuel Economy . . . . . . . 22
Hill and Mountain Roads . . . . . . 169
If the Vehicle is Stuck . . . . . . . . . 171
Loss of Control . . . . . . . . . . . . . . . 167
Off-Road Recovery . . . . . . . . . . . 167
Vehicle Load Limits . . . . . . . . . . . 171
Wet Roads . . . . . . . . . . . . . . . . . . . 168
Winter . . . . . . . . . . . . . . . . . . . . . . . . 169
Dual Tire
Rotation . . . . . . . . . . . . . . . . . . . . . . 266

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
Index 339
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 199
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 212
Electrical System
Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 246
Floor Console Fuse Block . . . . 249
Fuses and Circuit Breakers . . . 246
Overload . . . . . . . . . . . . . . . . . . . . . 245
Emergency
OnStar®...................... 327
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 225
Check and Service Engine
Soon Light . . . . . . . . . . . . . . . . . . 102
Compartment Overview . . . . . . . 218
Coolant . . . . . . . . . . . . . . . . . . . . . . . 227
Coolant Temperature Gauge . . . . 98
Cooling System . . . . . . . . . . . . . . . 226
Cooling System Messages . . . .113
Drive Belt Routing . . . . . . . . . . . . .311
Exhaust . . . . . . . . . . . . . . . . . . . . . . 182
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Heater . . . . . . . . . . . . . . . . . . . . . . . . 179
Oil Life System . . . . . . . . . . . . . . . 221
Oil Messages . . . . . . . . . . . . . . . . . .114
Oil Pressure Gauge . . . . . . . . . . . . 97
Engine (cont'd)
Oil Pressure Light . . . . . . . . . . . . 106
Overheating . . . . . . . . . . . . . . . . . . 230
Power Messages . . . . . . . . . . . . . .114
Running While Parked . . . . . . . . 183
Starting . . . . . . . . . . . . . . . . . . . . . . . 177
Enhanced Technology Glass . . . . 38
Entry/Exit Lighting . . . . . . . . . . . . . . 130
Equipment, Towing . . . . . . . . . . . . . 210
Event Data Recorders . . . . . . . . . . 324
Extender, Safety Belt . . . . . . . . . . . . 53
Exterior Lamp Controls . . . . . . . . . 125
Exterior Lamps Off Reminder . . . 126
F
Fan
Engine . . . . . . . . . . . . . . . . . . . . . . . . 231
Fast Idle System . . . . . . . . . . . . . . . . 178
Filter,
Engine Air Cleaner . . . . . . . . . . . 225
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 126
Flashers, Hazard Warning . . . . . . 128
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 273
Changing . . . . . . . . . . . . . . . . . . . . . 274
FlexFuel
E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 199
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 295
Fluid
Automatic Transmission . . . . . . 222
Fluid (cont'd)
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 234
Power Steering . . . . . . . . . . . . . . . 232
Washer . . . . . . . . . . . . . . . . . . . . . . . 233
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . 322
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 41
Front Storage . . . . . . . . . . . . . . . . . . . . 85
Front Turn Signal
Bulb Replacement . . . . . . . . . . . . 242
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Additives . . . . . . . . . . . . . . . . . . . . . 199
Economy Driving . . . . . . . . . . . . . . . 22
Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 202
Filling the Tank . . . . . . . . . . . . . . . 200
Foreign Countries . . . . . . . . . . . . 199
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Low Fuel Warning Light . . . . . . . 107
Requirements, California . . . . . 199
System Messages . . . . . . . . . . . . .115
Full-Size Spare Tire . . . . . . . . . . . . 282
Fuses
Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 246
Floor Console Fuse Block . . . . 249
Fuses and Circuit Breakers . . . 246

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9967827) - 2017 - crc - 5/2/16
340 Index
G
Gauges
Engine Coolant Temperature . . . 98
Engine Oil Pressure . . . . . . . . . . . . 97
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Odometer . . . . . . . . . . . . . . . . . . . . . . . 96
Speedometer . . . . . . . . . . . . . . . . . . . 96
Trip Odometer . . . . . . . . . . . . . . . . . . 96
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . 99
Warning Lights and
Indicators . . . . . . . . . . . . . . . . . . . . . 94
General Information
Service and Maintenance . . . . . 296
To w i n g . . . . . . . . . . . . . . . . . . . . . . . . 2 0 2
Vehicle Care . . . . . . . . . . . . . . . . . . 215
Glass, Enhanced Technology . . . . 38
GM Mobility Reimbursement
Program . . . . . . . . . . . . . . . . . . . . . . . 316
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 240
Hazard Warning Flashers . . . . . . . 128
Head Restraints . . . . . . . . . . . . . . . . . 41
Headlamps . . . . . . . . . . . . . . . . . . . . . 241
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 240
Automatic . . . . . . . . . . . . . . . . . . . . . 127
Bulb Replacement . . . . . . . . . . . . 240
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . 126
Headlamps (cont'd)
Flash-to-Pass . . . . . . . . . . . . . . . . . 126
High-Beam On Light . . . . . . . . . . 107
High/Low Beam Changer . . . . . 126
Heated Mirrors . . . . . . . . . . . . . . . . . . . 36
Heater
Engine . . . . . . . . . . . . . . . . . . . . . . . . 179
Heating and Air Conditioning . . . 158
High-Beam On Light . . . . . . . . . . . . 107
Hill and Mountain Roads . . . . . . . . 169
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
How to Wear Safety Belts
Properly . . . . . . . . . . . . . . . . . . . . . . . . 47
I
Idle System
Fast . . . . . . . . . . . . . . . . . . . . . . . . . . 178
Ignition Positions . . . . . . . . . . . . . . . 176
Ignition Transmission Lock
Check . . . . . . . . . . . . . . . . . . . . . . . . . 239
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 33
Infants and Young Children,
Restraints . . . . . . . . . . . . . . . . . . . . . . 68
Infotainment . . . . . . . . . . . . . . . . . . . . 132
Infotainment System . . . . . . . . . . . . 325
Instrument Cluster . . . . . . . . . . . . . . . 95
Interior Rearview Mirrors . . . . . . . . . 36
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North
America . . . . . . . . . . . . . . . . . . . . . . . 282
K
Key and Lock Messages . . . . . . . . 115
Keyless Entry
Remote (RKE) System . . . . . . . . . 25
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
L
Labeling, Tire Sidewall . . . . . . . . . . 254
Lamps
Daytime Running (DRL) . . . . . . 126
Dome . . . . . . . . . . . . . . . . . . . . . . . . . 129
Exterior Controls . . . . . . . . . . . . . . 125
Exterior Lamps Off
Reminder . . . . . . . . . . . . . . . . . . . 126
License Plate . . . . . . . . . . . . . . . . . 244
Malfunction Indicator . . . . . . . . . 102
Messages . . . . . . . . . . . . . . . . . . . . .115
Reading . . . . . . . . . . . . . . . . . . . . . . 130
Ta i l l a m p s . . . . . . . . . . . . . . . . . . . . . 2 4 3
Lamps, Bulb Replacement . . . . . . 242
Lap-Shoulder Belt . . . . . . . . . . . . . . . 48
LATCH System
Replacing Parts after a
Crash . . . . . . . . . . . . . . . . . . . . . . . . . 79