2015 AUDI TT ROADSTER light

114 Airbag sys te m
- a small adu lt or teenager is on the front pas­
senger seat
- a passenger who is not sitting upright with
their back against a non-reclined backrest
with their feet on the vehicle floor in front
of the seat is on the front passenger seat.
I f the front passenger airbag deploys, the
Federal Standard requires the airbag to meet
the " low risk" deployment criteria to help re­
duce the risk of in jury through interaction
with the airbag . "Low risk" deployment occurs
in those cr ashes that take place at lower de­
celerations as defined in the electronic control un it
Q page 118 .
Always rem ember : Please be sure to read the
impor tant informa tion in the sections tha t
follow and be sure to heed all of the WARN ­
INGS .
A WARNING
To reduce the r isk of injury when an airbag
inf lates , a lways wear safety belts prope rly.
- If you are unrestrained, lean ing forward,
sitting sideways or out of position in any
way, your risk of in jury is much higher.
- You w ill also receive serious inju ries and
cou ld even be killed if you are up against
the a irbag or too close to it whe n it in­
flates - even with an Advanced Airbag
Q page 108.
A WARNING
-
A child in a rearward-facing child safety
seat insta lled on the front passenger seat
w ill be seriously injured and can be k illed if
the front a irbag inflates - even with an Ad­
vanced Airbag System .
- Although the Advanced A irbag System in
your vehicle is designed to turn off the
front a irbag when a rearward -fac ing
child restraint has been installed on the
front passenger seat, nobody can abso­ l u te ly guarantee that deployment is im ­
poss ible in a ll conce ivable situations th at
may happen d uring the useful life of your
vehicle. -
The inflating airbag will h it the ch ild
safety seat or infant carrier with great
force and will smash the child safety seat and child aga inst the backrest, door, or
roof.
- If you must install a rearward fac ing
child safety seat on the front passenger
seat because of exceptiona l circumstan­
ces and t he
PASSENGER AIR BAG OFF
light does not come on and s tay on have
the airbag system inspecte d by your Audi
dealer.
A WARNING
--=
If, in exceptiona l circumstances, you m ust
i nstall a forward -facing child restraint on
the front passenger's seat:
- Always make sure the forward- facing
seat has been designed and certified by
its manufacturer for use on a front seat
wit h a passenger front and s ide a irbag.
- Never p ut the fo rward-facing chi ld re ­
straint up against or very near the instru­
ment panel.
- Always move the passenger seat into its
rea rmost pos ition in the seat's fore and
aft ad justment range, as far away from
the airbag as possible, before install ing
the forward-fac ing ch ild restra int . The
backrest must be ad justed to an up right
position.
- Make sure that the
PASSENGER AIR BAG
OFF
li ght comes on a nd stays o n all the
time wheneve r the ignit ion is switched
on .
Advanced Airbag System components
The front passenge r seat in yo ur vehicle has a
lot of very important parts of the Advanced
Airbag System in it . These parts i nclude the
weight-sensing mat, sensors, wiring, brack­ ets, and more. The funct ion of the system in
the front passenger seat is checked by the electron ic control unit when the ignition is on .
The cont rol unit monito rs the Advanced A ir­
bag System and turns the airbag indicato r
li ght on w hen a malfun ct io n in t he system

components is detected . The function of the
airbag indicator light is described in greater
deta il below . Because the front passenger
seat contains important parts of the Ad­
vanced Airbag System, you must take care to
prevent it from being damaged. Damage to
the seat may prevent the Advanced A irbag for
the front passenger seat from doing its job in
a crash.
The f ront Ad vanc ed Airb ag S ystem
consists of the following:
- Crash sensors in the front of the veh icle that
measu re ve hicle acceleration/deceleration
to provide information to the Advanced Air­
bag System about the severity of the crash.
- An electronic control unit, with integrated
c rash sensors for front and side impacts.
T he contro l unit "decides" whether to fire
the front airbags based on the information
received from the crash sensors . The control
unit also "decides" whether the safety belt
pretensioners should be activated.
- An Advanced Airbag with gas generator for
the driver ins ide the steer ing wheel hub.
- An Advanced Airbag with gas generator in­
side the instr ument panel for the front pas­
senger.
- A weight-sensing mat under the upholstery
padding of the front passenger seat cushion
that measures the total weight on the seat.
The information registered is sent continu­
ously to the electron ic control unit to regu­
late dep loyment of the front Advanced Air­
bag on the passenger side.
- An a irbag monitoring system and indicator
li ght in the instrument cluster
¢page 118.
-The PASSENGER AIR BAG OFF light comes
on and stays on in the center of the instru­
ment pane l
¢page 119, fig. 113 and te lls
you when the front Adv anced Airbag on the
passenge r side has been turned off.
- A senso r below the safety belt latch for the
front seat passenger to me asure the tension
on the safety belt . The tens ion on the safety
belt and the weight registered by the
weight-sensing mat help the control unit
"dec ide" whether the front airbag for the
Airbag system 11 5
front passenger seat should be turned off or
not
¢ page 109, Child restraints on the
front seat -some important things to
know.
- A sensor in the safety belt latch for the driv­
er and for the front seat passenger that
senses whether that safety belt is latched or
not and transmits this information to the
electronic control unit .
.&, WARNING
Damage to the front passenger seat can
prevent the front airbag from wor king
properly.
- Improper repai r or d isassembly of the
front passenge r and dr iver seat will pre­
vent the Advanced Airbag System from
functioning properly.
- Repairs to the front passenge r seat must
be pe rformed by qualified and p roperly
trained workshop personne l.
- Never remove the front passenger o r
driver seat from the vehicle .
- Never remove the upholstery from the
front passenger seat.
- Neve r d isassemble o r remove parts from
the seat or disconnec t wires from it.
- Never carry sharp objects in you r pockets
or place t hem on the seat. If the weight­
sens ing ma t in the passenge r seat is
punctured it cannot work properly .
- Neve r carry things on you r lap or carry
objects on the passenger seat. Such
items can increase the weight registered
by the weight-sensing mat and send the
wrong information to the airbag co ntrol
un it.
- Never store items under the front pas­
senger seat. Parts o f the Advanced Air­
bag System under the passenger seat
could be damaged, preventing them and
the airbag system from working proper­ ly.
- Never p lace seat covers or rep lacement
upholstery that have not been specifica l­
ly approved by Audi on the front seats.
- Seat covers can prevent the Advanced
Airbag System from recognizing chi ld
Ill>
•
•

116 Airbag sys te m
res traints or occupants on the fr ont pas­
senger seat and prevent the sid e airbag
in t he seat backrest from deploying prop­
erly.
- Never use cushions, pillows, blankets or
similar items on t he front passenger
seat . The add itional padd ing will prevent
the weight-sensing mat in the seat from
accurately reg istering the ch ild restra int
or person on the seat and prevent the
Advanced Airbag System from function­ ing properly .
- If you mus t use a child restra int on the
front passenger seat and the ch ild re­
straint manufacturer's instructions re ­
quire the use of a towel, foam cushion or
something else to properly position the
child restraint, make certa in that the
PA SSENGER AIR BAG OFF light comes
on and stays on whenever the child re­
st raint is installed on the front passen­
ger seat .
- If the
PA SSENGER AIR BAG OFF light
does not come on and stay on, have the
airbag system inspected by your Audi
dealer.
How the Advanced Airbag System
components work together
The front Advanced Airbag System and the
side airbags s upplement the protection of ­
fered by the front three-point safety be lts
with pretensioners and load limiters and the
adjustab le head restra ints to he lp reduce the
risk of injury in a w ide range of acc ident and
crash situat ions . Be sure to read the impo r­
tant information about safety and heed the
WARNINGS i n this chapter .
Deployment of the Advanced Airbag System
and the activat ion of the safety be lt preten­
sione rs depend on t he dece le rat ion meas ured
by the c rash senso rs and regis tered by the
e lectronic control un it . Crash severity depends
on speed and dece leration as well as the mass
and stiffness of the vehicle o r object involved
in the crash. When the e
lectronic contro l unit registe rs a
low severity cras h and the safety belt is being
u sed, the airbag will not dep loy.
If the sa fety
belt is not being used, the first stage deploys,
followed by the second stage after a much lat­ er t ime in t he crash sequence.
If the electron ic contro l unit registers a crash
of medium severity, the first stage of the air­
bag deploys followed by the second stage at a
much later time in the crash sequence -re ­
gardless of whether the safety belt is be ing
u sed or not . In higher sever ity c rashes as reg­
i ste red by the elec tronic con tro l un it, bo th the
first and se con d stages dep loy almost at the
same t ime.
On the passeng er side, rega rdless of safety
belt use, t he a irbag w ill be tu rned off if the
we ight on the passenger seat is less th an the
amount programmed in the e lectronic control
u nit . The front airbag on the passenge r side
will a lso be turned off if one of the child safe ­
ty seats that has been certified under Federal
Motor Vehicle Safety Standard 208 has been
recogni zed on the seat . The
PASSENGER AIR
BAG OFF light comes on and stays on to tell
yo u when the front Advanced A irbag on the
passenge r side has been turned off
¢ page 109, Child restraints on the front seat
- some important things to know .
.&_ WARNING ~
To reduce the risk of in ju ry when an a irba g
inflates , always wear safety be lts p roperly.
- If you are unrestra ined, leaning forw ard ,
sitt ing s ideways or o ut o f position in any
way, your risk of injury is m uch higher.
- You will a lso receive se rious injuries and
could even be killed if you a re up against
the airbag or too close to it when it in­
f lates - even with an Advanced A irbag
¢page 108.

118 Airbag sys te m
- The inflating airba g will hit the child
safety seat or infant carri er w it h great
force and w ill smash the ch ild safety seat
and child against the backrest, cente r
arm r est, door or ro of.
- Ne ver install a r earward facing child
sa fety seat on the fro nt passenger seat
unl ess the
PASSENGER AIR BAG OFF
ligh t co me s on and stays on. If the PA S­
SENGER AIR BAG OFF
ligh t does no t
come on and stay on, the inflating airbag
will hit the child safety seat or infant car ­
rier with great force and will smash the
child safety seat and child against the
backrest, door or roof. Have the airbag
system inspected immediately by your
authorized Audi dealer .
A WARNING
Objects between you and the a irbag will
increase the risk of injury in a crash by in­
terfering with the way the airbag unfolds
or by being pushed into you as the a irbag
inflates.
- Never hold th ings in your hands or on
yo ur lap when the vehicle is in use.
- Never transport items on or in the area
of the front passenge r seat. Objects
c ou ld move into the area of the front air­
bags dur ing braking or other s udden ma­
neuver and become dange rous projec ­
tiles that can cause serious personal in­
jury if the airbags inflate.
- Never place o r attach accessories or oth­
er objects (such as cup ho lders, tele­
phone brackets, large, heavy or b ulky ob­
jects) on the doors, over or near the area
marked "AIRBAG" on the steering wheel,
instrument panel, seat backrests or be­
tween those a reas and yourself. These
objects co uld cause injury in a crash, es­
pecially when the airbags inflate.
- Never recline the front passenger's seat
to transport objects. Items can also
move in to the area o f the side airb ag or
the front airbag dur ing braking or in a
sudden maneuver. Objects near the air -
-
bags can become projectiles and cause
inju ry, partic ularly when the seat is re­
clined.
A WARNING
The fine dust created when airbags deploy
can cause breathing prob lems for people
with a history of asthma or other breath­
i ng cond itions.
- To reduce the risk of breath ing problems,
those with asthma o r othe r respiratory
conditions shou ld get fresh air righ t
away by getting o ut of the ve hicle or
open ing win dows or doors.
- I f you are i n a collision in which airbags
deploy, wash your hands and fa ce with
mild soap and wate r before ea ting.
- Be ca reful not to get the dust into your
eyes, o r into any c uts or s cratches.
- If the res id ue should get into your eyes,
flush them w ith wate r.
Monitoring the
Advanced Airbag System
tii Airbag monitoring indicator light
Two separate indicators monitor the function
of the Advan ced Airbag Sy stem: the airbag
monitoring indicator light and the
PASSEN­
GER AIR BAG OFF
light.
T he Advanced A irbag Sys tem ( incl uding the
ele ctron ic cont rol unit, sensor circ uits and sys ­
tem wir ing) is monitored continuously to
make sure that it is functioning properly
whenever the ignition is on. Eac h time you
turn on the ignition, the a irbag monitoring in­
dicator light . will come on for a few sec­
onds (self diagnostics).
The system must be inspected when the
i ndicator light•=
-does not come on when the ignition is
sw itched on,
- does not go out a few seconds after you
have switched on the ignit ion, or

- comes on while driving.
I f an airbag system malfunct io n is dete cted ,
the ind icator light will firs t start flashing to
catch the driver 's attention and then stay on
continuously to serve as a constant reminder
to have the system inspected immed iately.
If a malfunction occurs tha t tur ns the fron t
ai rbag on the passenger side off, the
PA SSEN­
GER AIR BAG OFF
li ght wi ll come on and stay
on wheneve r the ignition is on.
A WARNING
An airbag system that is not funct ioning
properly cannot provide supplemental pro­
tection in a frontal crash.
- If the airbag indicator light comes on, it
means that the re may be somet hing
wrong with the Adva nced Airbag System .
It is possible that the airbag will inflate
w hen it is not s upposed to, or w ill not in­
flate when it should.
- Have the airbag system inspected imme­
diately by your Aud i dealer .
PASSENGER AIR BAG OFF light
Fig. 11 3 Section fr om the inst ru men t pa nel: PASS EN­
G ER AIR BAG O FF light
The PASSENGER AIR BAG OFF light is located
i n the cen ter of the instrument panel
c:> fig. 113 .
The PASSENGER AIR BAG OFF light will come
on and stay on to tell you when the front Ad ­
vanced A irbag on the passenger side h as been
turned off by t he e lectronic control u nit. Each
time you tu rn on the ign ition, the
PASSEN­
GER AIR BAG OF F
light will flash for a few
seconds and:
A irba g sy stem 119
- will stay on if the front passenger seat is not
occupied,
-w ill stay on i f there is a small ch ild or child
restraint on the front passenger seat,
- will go out if the fron t passenger seat is oc­
cupied by an adult as registered by the
weight-sensing mat .
T he
PAS SENGER AIR BAG OFF light must
com e on and sta y on
if t he igni tion is on and
- a car bed has been installed on the front
seat , or
- a rearward-facing child restraint has been installed on the front passenger seat, or
- a forward -fac ing ch ild restra int has been in ­
stalled on the front passenger seat, or
- the weight reg istered on the front passen ­
ger seat is equal to or less than the com­
bi ned weight of a typical 1 year-old restra in­
ed in one of the rear-facing or forward-fac­
ing infant restra ints listed in Federal Motor
Ve hicle Safety Standa rd 208 wi th which the
Advanced Airbag System in you r veh icle was
certified.
If t he fron t passenger seat is not occupied,
the fro nt airbag will not deploy, and the
PAS­
SENGER AIR BAG O FF
light will stay on . Nev ­
er install a rearward-facing child restraint on
the front passenger seat
c:> page 109 , Child
res train ts on the front sea t-some important
things to know
and c:> page 129, Child Safe ty .
If the PASSENGER AIR BAG OFF light come s
o n
when one of the cond itions listed above is
met, be sure to check the light regularly to
make certain that the
PASSENGER AIR BAG
OFF
light stays on continuously wheneve r the
ignition is on .
If the PASSENGER A IR BAG
OFF
light does not appear and not stay on all
the time, stop as soon as it is safe to do so and
- reactivate the system by turn ing the ign ition
off and then turn ing it on again;
- remove and reinstall the ch ild restra int .
Make s ure that the ch ild restraint is proper ly
installed and that the safety belt for the
front passenge r seat has been correc tly
rou ted aro und t he chi ld restraint as

120 Airbag sys te m
described in the child restraint manufactur­
er 's instructions;
- make sure that the convertible locking fea­
ture on the safety be lt for the front passen­
ger seat has been activated and that the
safety belt has been pulled tight. The belt
must not be loose or have loops of slack so
that the sensor below the safety belt latch
on the seat can do its job
c> page 13 7.
- make sure that things that may increase the
weight of the child and child safety seat are
not being transported on the front passen­
ger seat;
- make sure that the safety belt tension sen­ sor is not blocked . Shake the safety belt
latch on the front passenger seat back and
forth;
- If a strap or tether is bei ng used to tie the
child safety seat to t he front passenger
seat, make sure t hat it is no t so tight that it
ca uses the we ight -sensing mat to meas ure
more weight than is actua lly on the seat .
If the PASSENGER AIR BAG OFF light still
doe s not come on and does not stay on con­
tinuously (when the igni tion is sw itched on),
- take the ch ild restraint off the front passen-
ger seat and have the ai rbag system inspect­
ed by you r A udi dealer immediate ly .
The PASSEN GER AIR BAG OFF light should
NO T come on when the ign ition is on and an
adult is sitt ing in a p rope r seating pos it ion on
the front passenger seat. If the PASSENGER
AIR BAG OFF ligh t comes on and stays on or
flashes for about 5 seconds whi le driving, un ­
der these circumstances, make s ure that:
- the ad ult on the front passenger seat is
properly seated on the center of the seat
c u shion with his or her back up against the
backrest and the backrest is not reclined
c> page 92, Prop er occupant seating posi­
tions,
- th e ad ult is not taking weight off the seat by
ho lding on to the passenger assist handle
above the front passenger door, - the sa
fety belt is being properly wo rn and
that there is not a lot of s lack in the safety
be lt webb ing,
- accessory seat covers or cushions or other
things that may cause an incorrect reading
or impression on the weight-sensing mat
under the upho lstery of the seat have been
removed from the fron t passenger seat,
- a safety belt extender has not been left in the safety belt latch for the front passenger
seat .
In addition to the PASSENGER AIR BAG O FF
li ght in the center of the instr ument panel,
the message PASSENGER AIR BAG OFF or
PASSENGER AIR BAG ON will briefly appear
i n the i nstr ument cluster d isplay. This is to i n­
form the dr iver of the current front passenge r
airbag status.
Important safety instructions on
monitoring the Advanced Airbag System
A WARNING
An a irbag system that is not functioning
p roperly cannot p rovide supplemental pro­
tection in a frontal c rash.
- If the airbag ind icator light comes on, i t
means that there may be something
wrong with t he Advanced Airbag System.
It is poss ible that the ai rbag w ill inflate
when it is not supposed to, or will not in­
f late when it sho uld .
- Have the airbag system inspected imme­
d iate ly by yo ur Audi dealer.
A WARNING
If the front airbag inflates, a child without
a child restraint, in a rea rward-facing child
safety seat or in a forward-facing child re­
straint that has not been properly installed
will be serious ly injured and can be killed.
- Even tho ugh your vehicle is equipped
with an Advanced A irbag System, make
certain that all children, espec ially 12
yea rs and younger, always ride properly
restrained fo r their age and size.
-

-If you must install a rearward facing
child safety seat on the front passenger
seat because of exceptional circumstan­ ces and the
PA SSE NGER AI R BAG OFF
light does not appear and stay on have
the a irbag system inspected by your Audi
dealer.
- A tight tether or other strap on a rear­
ward-fac ing child restra int attached to
the front passenger seat can put too much pressure on the weight-sens ing
mat in the seat and register more weight
than is actually on the seat. The heavier
weight registered can make the system
work as though an adu lt were on the seat
and deploy the Advanced Airbag when it
must be suppressed caus ing serious or
even fatal injury to the child .
- If, in exceptional circ umstances, you
must install a forward-facing child re­
st raint on the front passenger seat, a l­
ways move the seat into its rearmost po­
sit ion in the seat's fo re and aft adjust­
ment range, as far away from the airb ag
as possib le . The backrest m ust be adjust­
ed to an upright position. Make sure that
the
PASSENGER AIR BAG OFF light
comes on and stays on all the t ime when­
ever the ignition is switched on.
A WARNING
- If the PASSENGER AIR BAG OFF light
does not go out when an adult is sitting
on the front passenger seat after taking
the steps described above, have the air­
bag system inspected by your Aud i deal­
er before transporting anyone on the
front passenger seat.
(Di Tips
If the weight-sensing mat in the front pas­
senger seat detects an empty seat, the
front airbag on the pa ssenge r side will be
t urned off, and
PASSENGER AIR BAG OFF
w ill stay on .
Airbag system 12 1
Repair, care and disposal of the airbags
Parts of the airbag system are i nstalled at
many diffe rent p laces o n your Aud i. Insta llin g,
removing, servicing or repa iring a part in an
area of the vehicle can damage a part of an
airbag system and prevent that system from
working properly in a coll is ion.
T he re a re some important t hings you have to
know to make sure that the effectiveness o f
the system wi ll not be impaired and that dis­
carded components do not cause injury or pol ­
lute the environment.
A WARNING
Improper care, serv ic ing and repair proce­
dures can increase the risk of personal in­
jury and death by preventing an a irbag
from deploying when needed or deploying
an a irbag unexpec tedly:
- Never cover, obst ruct, or change the
steer ing whee l horn pad or airbag cover
or the inst rument panel or mod ify them
in any w ay .
- Never attach any objects s uch as c up
holders or telephone mountings to the
surfaces covering the a irbag un its .
- For cleaning the horn pad or instr ument
panel, use only a soft, dry cloth or one
mo istened with pla in water. Solvents or
cleaners could damage the airbag cover
or change the st iffness or strength of the
material so that the airbag cannot de­
ploy and protect properly.
- Never repair, adjust, or change any parts
of the a irbag system.
- All work on the steering wheel, instru­
ment panel, front seats or e lectr ica l sys­
tem (including the installation of audio
equ ipment, cellular telephones and CB
radios, etc.) must be performed by a
qualified technic ian who has the training
and specia l equipment necessary.
- For any work on the airbag system, we
strongly recommend that you see your
author ized Audi dealer or qualified work-
shop.
~
•
•

_& WARNING
Items stored between the safety belt
buckle and the center console can cause
the sensors in the buckle to send the
wrong informat ion to the electronic con­
trol modu le and prevent the Advanced A ir­
bag System from working properly.
- Always make sure that noth ing ca n inte r­
fere w ith the safety belt buck les and that
t hey are not obstructed.
Knee airbags
Description of knee airbags
The knee airbag system can provide supple­
mental protection to properly restrained
front seat occupants.
F ig . 11 4 Drive r's a irbag
The driver knee a irbag is in the instrument
panel underneath the steering whee l
~ fig. 114, the airbag for the passenger is at
about the same height in the i nstrument pan­
e l underneath the g love compartment.
The knee airbag offers additiona l protection
to the driver's and passenger's knees and up­
per and lower thigh areas and supp lements
the protect ion by the safety be lts .
I f the front airbags deploy, the knee airbags
a lso deploy i n frontal collisions when the de­
p loyment threshold sto red in the cont ro l uni t
is met ~
page 117, More important things to
know about front airbags .
In addition to their normal safety function,
safety belts he lp keep the driver or front pas ­
senger in posit ion in a frontal coll is ion so that
A irba g sy stem 123
the ai rbags can provide supplemental protec­
tion .
T he airbag system is no t a subs tit ute for your
sa fety be lt . Rather, it is part of the overall oc­
cupant restraint system in your vehicle . A l­
ways remember that the airbag system can
only he lp to protect you if you are wearing
your safety be lt and wearing it properly. This
is why you should always wear your safety
belt, not just because the law requires you to
do so
r::;, page 100, General notes .
Remember too, airbags will deploy on ly once
and only in certain kinds of accidents -your
safety belts are always there to offer protec­
t ion in those accidents in wh ich airbags are
not supposed to dep loy o r when they have al­
r eady deployed, for example when your vehi ­
cl e strikes or is struck by another after the
f irst collision.
This is just one of the reasons why an airbag is
not a s ubstitute fo r the safety be lt. The ai rbag
system works most effect ively when used with
the safety be lts. Therefore, always wear yo ur
sa fety belts correct ly .
It is impo rtant to remembe r that wh ile the
s u pplementa l knee airbag system is designed
to reduce the likelihood of ser ious inju ries,
other injur ies, for example, swelling, bru ising,
minor ab rasions and friction burns can a lso
occur when an airbag inflates.
The knee airbag system basically consists
of:
- The e lectronic control module
- Two in flatable ai rbags (a irbag and gas gen -
erator), one for the d river and one for the
front passenger
- The ai rbag indicator light in the instrument
panel
The knee airbag system will not deploy:
- when the ignit io n is t urned off
- in frontal collisions when the deceleration
meas ured by the control unit is too low
- in side co llisions
- in rear-end collisions
- in rollovers