2014 MITSUBISHI OUTLANDER SPORT fuel

Instruments and Controls
Overview 1-2
1
Audio
*
Mitsubishi Multi Communication System (MMCS)
*
[For DISPLAY AUDIO and MMCS, refer to the separate owner’s manuals.]Digital clock
*
Accessory socket
* P.8-66
4WD lock switch P.7-19
Glove box P.8-68Card holder P.8-68Passenger’s ventilators P. 8 - 2
Bonnet release lever P. 1 1 - 3
Key slot P.7-13
Fuel tank filler door release lever P.2-13
Parking brake lever P.7-4
Selector lever (Joystick Type) P.7-14
Hazard warning flasher switchP. 6 - 4 5
Air conditioner P.8-4
Rear window demister switch P.6-53Wiper deicer switch* P.6-53
Fuse box P.11-15
Supplemental restraint system (SRS) - airbag (for front passenger’s seat) P.5-23
Floor console box P.8-69ArmrestAccessory socket P.8-66USB input terminal P.8-61
Heated seat switch
* P.5-4
Cup holder P.8-70
Electric tailgate power switch
* P.4-17
BK0203201EN.book 2 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Outside (Front)
Overview 1-6
1
E00100506751
Outside (Front)
Side turn-signal lamps
*
P. 6 - 4 5 , 1 1 - 2 2 , 1 1 - 2 5
Front fog lamps P.6-46, 11-22, 11-26
Front turn-signal lamps P.6-45, 11-22, 11-25
Headlamps, low beam P.6-42, 11-22, 11-23
Position lamps P.6-40, 11-22, 11-24
Headlamps, high beam P. 6 - 4 2 , 1 1 - 2 2 , 1 1 - 2 4
Headlamps, high beam P. 6 - 4 2 , 1 1 - 2 2 , 1 1 - 2 4
Position lamps P.6-40, 11-22, 11-24
Headlamps, low beam P.6-42, 11-22, 11-23
Front turn-signal lamps P.6-45, 11-22, 11-25
Electric window control P.4-29
Fuel tank filler P.2-13
Windscreen wipers P.6-47
Bonnet P.11-3
Sunroof* P.4-31
Except for high intensity discharge headlamp type
High intensity discharge headlamps type
BK0203201EN.book 6 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

2
General informationPlug-in Hybrid EV System .............................................................. 2-2Cautions and actions to deal with intense heat ................................2-8Cautions and actions to deal with intense cold ................................2-9Fuel selection ..................................................................................2-12Filling the fuel tank .........................................................................2-13Installation of accessories ............
...................................................2-14
Modification/alterations to the electrical or fuel systems ...............2-15Genuine Parts ..................................................................................2-15Safety and disposal information for used engine oil ......................2-15Do not carry fuel-filled containers or spray cans inside your vehicle ....................................................2-16Ta k i n g y o u r v e h i c l e o v e r s e a s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 1 6
BK0203201EN.book 1 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Plug-in Hybrid EV SystemGeneral information 2-3
2
Motion energy is converted into electric energy using the motor as a power generator.Then a braking force generates and converted electric energy will be charged to the drive battery.zIf you lift your foot off the accelerator pedal during driving, a braking force that equivalent to engine braking of a combusti
on engine vehicle
will be generated. Also, if you shift the select position into “B” (BRAKE) from “D” (DRIVE), effectiveness of the regenerative
braking is get-
ting strong. Shift the selector lever into “B” (
BRAKE) position according to the driving condition.
zRegenerative brake force increases with the foot brake force when the brake pedal is depressed.zIf a problem occurs in the Plug-in hybrid EV system, or if the
ABS and/or the ASC have been activated, the regenerative braking
will be
restricted. The foot brake will still operate.
E00203700027
zEven when the vehicle is driving in EVdrive mode, it may be automaticallychanged to series hybrid mode or parallelhybrid mode in the following cases:•The plug-in hybrid EV system is too hotor too cold.
•Quick acceleration is applied.•The air conditioner is operating.•The accelerator pedal is depressed hardon an uphill road or expressway.•In cold weather•The vehicle has not been refueled for along time.•The drive battery level is low.
In addition to the above, there are morecases where EV drive mode is automati-cally changed to series or parallel hybridmode.zEven while the vehicle is stopped, theengine may automatically be started in thefollowing cases:•The drive battery level is low.
The roles of the motors and engine in each drive mode
Motor
Engine
Driving conditions
EV Drive Mode
ON
OFF
Driving on streets and commuting
Series Hybrid Mode
ON
Generates electricity
Powerful acceleration uphill road
such as mountain road
Parallel Hybrid Mode
ON
Drivers front wheels and generates
electricity
High-speed driving
Regenerative braking Operation of gasoline engine
BK0203201EN.book 3 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Plug-in Hybrid EV System2-4 General information
2
•The plug-in hybrid EV system is too hotor too cold.•The air conditioner is used.•The vehicle has not been used for a longtime.•The engine has not been operated for along time.
E00203800028
zIf the warning display appears, refuel assoon as possible.If the vehicle is runs out of fuel, theengine will not start even in a situationneed to be generated electricity, the fol-lowing conditions will occur.•The driving performance falls (sinceonly the electrical power stored in thedrive battery can be used for the driv-ing).•The heating performance cannot beavailable (except vehicles with electricheater).•The effectiveness of the heater is insuffi-cient (vehicles with electric heater).•The catalytic converter may be damageddue to excessive high temperature.
Refer to “Filling the fuel tank” on page 2-13.Refer to “Fuel remaining display screen” onpage 6-9.
E00203900029
zIt is the battery to operate the motor andthe air conditioning.In addition to the drive battery, OutlanderPHEV has the auxiliary battery to operatelamps, wipers, etc.zCompact, light-weight lithium ion batterywith high energy density is used for thedrive battery.zThe drive battery has the following char-acteristics.Please read this carefully paying attentionto the following:zThe same as ordinary lithium-ion batter-ies, the battery capacity of the drive bat-tery gradually reduces with time, resultingin reduced cruising range. Depending onthe usage conditions, such as frequentquick acceleration/deceleration,extremely hot weather, storing the vehiclein high ambient temperatures, etc., therate of battery capacity drop will increase.
Refueling (gasoline)
CAUTIONzDepending on the opera
ting conditions of
your vehicle, the fuel in the fuel tank maynot be used for a long time and stay in thetank, resulting in deterioration of the fuelquality. As this may af
fect the engine and
fuel system parts, observe the followinginstructions:•Run the engine by pressing the batterycharge switch at least once in 3 months.Refer to “Battery charge switch” on page7-23.• Refuel 20 litres or more of fuel every 6months (to make the total refueling amountin 6 months be 20 litres or more).
zIf refueling of the above
amount is not possi-
ble due to a high fuel level because the vehi-cle has not been used for a long time or forsome other reason, consult a MITSUBISHIMOTORS Authorised Service Point.
Drive battery
WA R N I N GzA sealed lithium ion
high voltage battery
(drive battery) is
adopted for Outlander
PHEV. If the drive battery is disposed ofimproperly, there is a
risk of severe burns
and electrical shock that may result inserious injury or death and there is also arisk of environmental damage.
zNever attempt to use the drive battery forany other purpose.
Characteristics
WA R N I N G
BK0203201EN.book 4 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Plug-in Hybrid EV System2-6 General information
2
•Open the windows, doors and tailgate.•Put the operation mode in OFF.•Turn on the hazard warning flashers.• Move the key away from the vehicle toprevent unintended start-up of the sys-tem by inadvertent contact with a switchor impact from the crash.
zNever touch high-voltage wiring, connec-tors, and other high-vol
tage parts, such as
the inverter unit and drive battery. Anelectric shock may occur if exposed elec-tric wires are visible when viewed frominside or outside of
your vehicle. For their
locations, see “High-
voltage components”
on page 2-7.zIf the vehicle receives a strong impact tothe floor while driving, stop the vehicle ina safe place and
check the floor.
zNever start the plug-in hybrid EV systemif you found the leak
of a liquid (except
water of the air conditioner) while check-ing the outside of the vehicle because thereis possibility the fuel system has beendamaged and causing of fire or exploding.In such case, immediately contact yourMITSUBISHI MOTORS Authorized Ser-vice Point.WA R N I N G
zLeaks or damage to the drive battery mayresult in a fire. If you discover them, con-tact emergency services immediately.Since the fluid leak may be lithium man-ganite from the Lithium-ion battery, nevertouch any fluid leaking from the inside oroutside of the vehicle. If the fluid contactsyour skin or eyes, wash
it off immediately
with a large amount of water and receiveimmediate medical attention to help avoidserious injury.zIf you are unable to safely assess the vehi-cle due to vehicle damage, do not touchthe vehicle. Leave the vehicle and contactemergency services. Advise emergencyresponders that this is a Plug-in Hybridvehicle.zIf a fire occurs in this vehicle, leave thevehicle as soon as possible and contactemergency services. Do not attempt toextinguish a fire by yourself. If the fireinvolves a lithium-ion battery, it willrequire large, sustained volumes of waterfor extinguishment. Using a small amountof water or the incorrect fire extinguishercan result in serious injury or death fromelectrical shock.zWhen you leave the vehicle, if possible,open the windows, doors and tailgate toprevent accumulation of poisonous/com-bustible gasses. This will
also assist in the
rescue and fire fighting process.WA R N I N G
zAs with any vehicle fire, the byproducts ofcombustion can be toxic. Do not inhalesmoke, vapors, or gas from the vehicle.Move to a safe distance upwind and uphillfrom the vehicle fire and out of the way ofany oncoming traffic while awaiting thearrival of emergency responders.zIf you detect leaking fluids, sparks, smoke,flames, gurgling, popping or hissing noisesoriginating from the high voltage batterycompartment, contact emergency servicesimmediately. This may result in a fire.zPhysical damage to the vehicle or highvoltage battery may result in immediate ordelayed release of toxic and/or flammablegases and fire.zIf your vehicle needs to be towed, trans-port the vehicle on a
flatbed truck or tow
the vehicle with all wheels off the ground.If the any wheels are on the ground whentowing, this may cause damage to the elec-tric motors. This may also cause a fire, ifwiring in the electric motor unit roombecomes damaged. Refer to “Towing” onpage 9-19.zDo not attempt to repair a damaged Plug-in Hybrid vehicle by yourself. Please con-tact a MITSUBISHI MOTORS Author-ised Service Point for service.WA R N I N G
BK0203201EN.book 6 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Fuel selection2-12 General information
2
E00200104259
A mixture of up to 10 % ethanol (grain alco-hol) and 90 % unleaded petrol may be used in
your vehicle, provided the octane number isat least as high as that recommended forunleaded petrol.
NOTE
z*1: Refer to “Limited driving mode
warning display” on page 6-33.
Display of the Limited driving mode warni
ng display does not i
ndicate a malfunction.
z*2: Refer to “ready indicator” on page 6-37.
z*3: To make warm up the drive battery, you shoul
d perform to communicate with the wireless
LAN device (which conforms to IEEE 802
.11 b and supports
iOS or Android) for MITSUBISHI Remote Cont
rol to the vehicle. If the information of
“” mark on the wireless LAN device is displ
ayed, connect the
EV charging cable as soon as possible.Refer to “MITSUBISHI Remote
Control” on page 3-17.
If the warming up of the drive battery is activated during home
or public charging device (EVSE:
Electric Vehicles Supply Equip
ment) charging, the
charging and warming up of the
drive battery may be stopped.
While warm up the drive battery, the following phenomena may occur.• The operation sound of on board equipmen
t and the state of charge is displa
yed on the multi information display.
Refer to “Charging from rated
AC 240V outlet” on page 3-10.
• Inside of the vehicle may be heated automatically.•The drive battery may not become full charge, or th
e remaining capacity of
drive battery may decrease.
Fuel selection Recom-mended fuel
Unleaded petrol octane number 90 RON or higher
CAUTIONzYo u r v e h i c l e h a s a f u e l f i l l e r t u b e s p e c i a l l ydesigned to accept the smaller diameterunleaded fuel dispensing nozzles only.
Liquid Petroleum Gas (L.P.G.)
CAUTIONzYo u r v e h i c l e c a n n o t b e r u n o n L . P. G.Use of an L.P.G. fuel conversion may resultin significant damage to your vehicles fuelsystem, engine, engine
sensors and exhaust
system.
Ethanol
CAUTIONzDo not use more than 10 % concentration ofethanol (grain alcohol) by volume.Use of more than 10 % concentration maylead to damage to your vehicle fuel system,engine, engine sensor
s and exhaust system.
zDo not operate your ve
hicle on gasoline con-
taining methanol. Using this type of alcoholcould adversely affect
the vehicle’s perfor-
mance and damage critical parts of the vehi-cle’s fuel system.
BK0203201EN.book 12 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分

Filling the fuel tank
General information 2-13
2
E00200203572
45 litres1. Before filling with fuel, stop the plug-inhybrid EV system.
NOTE
zPoor quality petrol can cause problems suchas hard starting, sta
lling, engine noise and
hesitation. If your experience these prob-lems, try another brand and/or grade of pet-rol.If the check engine
warning lamp flashes,
have the system checked as soon as possibleat a MITSUBISHI MOTORS AuthorisedService Point.
Filling the fuel tank
WA R N I N GzWhen handling fuel, comply with thesafety regulations displayed by garagesand filling stations.zGasoline is highly flammable and explo-sive. You could be burned or seriouslyinjured when handling it. When refuelingyour vehicle, always
put the operation
mode of the power switch in OFF andkeep away from flames, sparks, and smok-ing materials. Always handle fuel in well-ventilated outdoor areas.zBefore removing the fuel cap, be sure toget rid of your body’s static electricity bytouching a metal part of the car or fuelpump. Any static electricity on your bodycould create a spark that ignites fuelvapor.
zPerform the whole refueling process(opening the fuel tank filler door, remov-ing the fuel cap, etc.) by yourself. Do notlet any other person come near the fueltank filler. If you allowed a person to helpyou and that person was carrying staticelectricity, fuel vapor could be ignited.zDo not perform chargi
ng and refueling at
the same time. If you charged with staticelectricity, fuel vapor could be ignited bythe discharge spark.zDo not move away from the fuel tank filleruntil refueling is finished. If you movedaway and did something else (for example,sitting on a seat) part-way through therefueling process, you could pick up afresh charge of st
atic electricity.
zBe careful not to inhale fuel vapor. Fuelcontains toxic substances.zKeep the doors and windows closed whilerefueling the vehicle. If they were open,fuel vapor could get into the cabin.zIf the tank cap must be replaced, use onlya MITSUBIHI MOTORS original part.WA R N I N G
CAUTIONzDepending on the opera
ting conditions of
your vehicle, the fuel in the fuel tank maynot be used for a long time and stay in thetank, resulting in deterioration of the fuelquality. As this may af
fect the engine and
fuel system parts, observe the followinginstructions:•Run the engine by pressing the batterycharge switch at least once in 3 months.Refer to “Battery charge switch” on page7-23.• Refuel 20 litres or more of fuel every 6months (to make the total refueling amountin 6 months be 20 litres or more).
zIf refueling of the above
amount is not possi-
ble due to a high fuel level because the vehi-cle has not been used for a long time or forsome other reason, consult a MITSUBISHIMOTORS Authorised Service Point.
Fuel tank capacity Refuelling
BK0203201EN.book 13 ページ ２０１３年１１月１９日　火曜日　午前１１時５０分