Page 147 of 284
10
Checks
145
Running out of fuel
(Diesel)
)Fill the fuel tank with at least five litres of
Diesel. )Open the bonnet. )Depending on version, unclip the cover togain access to the priming pump. )Squeeze and release the priming pump
until resistance is felt (could be from thefirst application) and fuel appears in the
transparent pipe with the green connector. )Operate the star ter until the engine star ts. )Depending on version, put the cover back
in position and clip it in place. )Close the bonnet.
If the engine does not star t at the firstattempt, do not try again. Operate the priming pump again, thenthe starter. I
f your vehicle is fitted with an HDI engine, the
fuel system must be primed if you run out of
fuel.
This system consists of a priming pump and a
transparent pipe under the bonnet.
Page 149 of 284
10
Checks
147
Diesel engines
1.
Screenwash fluid reservoir. 2.Coolant header tank.3.Air filter.4.
Brake fluid reservoir.
5. Battery.
6.Fusebox.7. Engine oil dipstick.8.Engine oil filler cap.9.
Priming pump (on fuel filter).
Page 179 of 284
11
Practical information
177
Fuse table
Fuse N°RatingFunctions
F
120 AEngine control unit supply, cooling fan unit control,multifunction engine control main relay.
F
215 AHorn.
F
310 AFront / rear wash-wipe.
F4 20
ADaytime running lamps.
F
515 ADiesel heater (Diesel engine), fuel pump(petrol engine)
F
610 A ABS/ESP control unit, ABS/ESP cut-off relay,secondary stop switch.
F7
10 AElectric power steering.
F
825 AStarter motor control.
F9
10 ASwitching and protection unit (Diesel).
F10
30 ADiesel engine injection pump valve, injectors and ignition coils (petrol engine) .
F1140 A Air conditioning fan.
Page 193 of 284
12
Technical data
191
*
For Russia only.
**
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defined in European legislation (directive 1999/99/CE).
PETROL ENGINESVTi 95VTi 115*VTi 120VTi 115 *VTi 120
Model codes:SH...8FP05FJ0*5FS05FJ8/P *5FS8/P
Cubic capacity (cc)
1 397 1 598 1 598
Bore x stroke
(mm)
77 x 75
77 x 85.8
77 x 85.8
Max power: EU standard (kW) **
70
84 *
88
84 *
88
Max power en
gine speed (rpm) 6 000
5 200
*
6 000
5 200
*6 000
Max torque: EU standard (Nm)13 6160
160
Max torque en
gine speed (rpm)
4 000
4 250
4 250
Fuel Unleaded
Unleaded
Unleaded
Catal
ytic converter yesyes yes
GEARBOXE
S
Manual(5-speed)
Manual (5-speed)Electronic gearbox system (6-speed)
OIL CAPACITIES
(in litres)
Engine (with filter replacement)
4.254.25 4.25
Engines and gearboxes
Page 195 of 284
12
Technical data
193
LPG ENGINEVTi 95
Model codes:SH...8FN0/GPL
Cubic capacit
y (cc)
1 397
Bore x stroke
(mm) 77 x 75
Max. power: EU standard
(kW) *
70
Max. power speed
(rpm)
6 000
Max torque: EU standard
(Nm)
13 6
Max. torque speed (rpm)
4 000
Fuel LPG / Unleaded
Catal
ytic converter
Yes
GEARBOX
Manual(5-speed)
OIL CAPACITY (in litres)
En
gine (with filter replacement)
4.25
*
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defined in European legislation (directive 1999/99/CE).
Engine and gearbox
Page 197 of 284
12
Technical data
195
DIESEL ENGINESHDi 90 PEFe-HDi 90 PEFHDi 115 PEF
Model codes: SH...9HP09HP8/P/S9HD8
Cubic capacity (cc) 1 5601 560
1 560
Bore x stroke (mm)
75 x 88.3
75 x 88.375 x 88.3
Max power: EU standard
(kW) *
68
68
84
Max power en
gine speed (rpm)
4 000
4 000
3 600
Max torque: EU standard (Nm)230
230
270
Max torque engine speed (rpm)
1 750 1 750 1 750
Fuel Diesel Diesel
Diesel
Catal
ytic converter yes yesyes
P
article emission filter yes
yesyes
GEARBOXE
SManual (5-speed)
Electronic gearbox system(6-speed)Manual (6-speed)
OIL CAPACITIES
(in litres)
Engine (with filter replacement) 3.75
3.753.75
.../
S : e-HDi model fitted with Stop & Star t.
Engines and gearboxes
*
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defined in European legislation (directive 1999/99/CE).
Page 200 of 284
Technical data
198
Identifi cation markings Various visible markings for the identification of your vehicle.
A.Vehicle Identification Number (VIN) on
the front right door pillar.This number is engraved on the bodyworknear the hinge.
For access to it, open the right-hand door.B
.VIN on the windscreen lower crossmember. The number is on a self-adhesive label
which is visible through the windscreen.
C.Manufacturer's label. This number is indicated on a self-
destroying label affixed to the centre pillar,
on the left-hand side.
The inflation pressures must be checked when the tyres are cold,at least once a month.
If the inflation pressures are too low, this increases fuel consumption.
D.Tyre/paint label. This label is affixed to the centre pillar, on the left-hand side.
It bears the followin
g information:
- the tyre inflation pressures with and withoutload,
- the wheel rim and tyre sizes,
- the brands of tyre recommended by the manufacturer,
- the inflation pressure of the spare wheel,
- the paint colour code.
Page 271 of 284
269
07
UNITS
FUEL CONSUMPTION:
KM/L - L/100 - MPG
1
2
2
SCREEN MENU MAP
DISPLAY ADJUST
MONTH
DATE
HOUR
MINUTES
YEAR
12 H/24 H MODE
LANGUAGE
ITALIANO
NEDERLANDS
PORTUGUES
PORTUGUES-BRASIL
FRANCAIS
DEUTSCH
ENGLISH
ESPANOL
1
2
2
2
2
2
2
1
2
2
2
2
2
2
2
2
