2012 YAMAHA XT660Z battery

Checking and lubricating the cables ..................\7...............7\f25
Checking and lubricating the throttle gri\b and cable ........7\f26
Checking and lubricating the brake and clutch levers ..................\7....7\f26
Lubricating the brake \bedal ............7\f27
Checking and lubricating the sidestand ..................\7..........7\f27
Lubricating the rear sus\bension......7\f27
Lubricating the swingarm \bivots .....7\f28
Checking the front fork..................\7..7\f28
Checking the steering ..................\7...7\f29
Checking the wheel bearings..........7\f29
Battery ..................\7..................\7.........7\f30
Re\blacing the fuses ..................\7......7\f31
Re\blacing a headlight bulb .............7\f33
Re\blacing a turn signal light bulb....7\f34
Re\blacing the license \blate light bulb ..................\7.................7\f\735
Re\blacing an auxiliary light bulb .....7\f35
Su\b\borting the motorcycle ..............7\f36
Front wheel ..................\7..................\7.7\f36
Rear wheel ..................\7..................\7..7\f38
Troubleshooting ..................\7............7\f39
Troubleshooting charts..................\7..7\f40 MOTORCYCLE CARE
AND STORAGE
..................\7.................8\7\f1
Care ..................\7..................\7..............8\f1
Storage ..................\7..................\7.........8\f3
SPECIFICATIONS ..................\7.............9\f1
CONSUMER INFORMATION ............10\f1
Identification numbers ..................\7...10\f1
Motorcycle noise regulation (for Australia) ..................\7..........10\f2
TABLE OF CONTENTS
03 ingles -austral\:ia 26/2/10 10:\f5 \: Página \b

1
2
3
4
5
6
7
8
9
10
3-2
DESCRIPTIO\f
10. Grab bar
11. Main fuse (\fage 7-31)
12. \battery (\fage 7-30)
13. Rear brake fluid reservoir (\fage 7-22)14. Coolant reservoir (\fage 7-13) 15. Front brake fluid reservoir (\fage 7-22)
16. Coolant drain bolt (\fage 7-12)
17. Engine oil filter element (\fage 7-11)
18. \brake \fedal (\fage 4-11)
EAU10420Righ\b view
XT660Z 01-03 ING-AUS:AUSTRALIA 11-05-2009 9:57 Pagina 15

1
2
3
4
5
6
7
8
9
10
INSTRUMENT \fND CONTRO\b FUNCTIONS
4-3
To unlock the steering
1\f Push
2\f Turn
Push the key into the \bain switch, and
then turn it to “OFF” while still pushing
it\f
EAU10941
F(Parking)
The steering is locked, and the tail-
light, license plate light and auxiliary
lights are on\f The hazard lights and
turn signal lights can be turned on, but
all other electrical syste\bs are off\f The
key can be re\boved\f
The steering \bust be locked before
the key can be turned to “ F”\f
ECA11020NOTICE
Do not use the parking position for
an extended length of time, other-
wise the battery may\ discharge.
EAU11004
Indicator and warning lights
1\f I\b\bobilizer syste\b indicator light “ ”
2\f Neutral indicator light “ N”
3\f Turn signal indicator light “ y”
4\f High bea\b indicator light “ 1”
5\f Engine trouble warning light “ U”
6\f Coolant te\bperature warning light “ u”
EAUB1510
Turn signal indicator light “y”
This indicator light flashes when the
turn signal switch is pushed to the left
or right\f
The electrical circuit of the turn signal
indicator light can be checked by turn-
ing the key to "ON"\f
If the indicator light does not co\be on
for a few seconds, then go off, have a
Ya\baha dealer check the electrical cir-
cuit\f
XT660Z 04-04 ING-AUS:MY03 01-03 ING 11-05-2009 9:54 Pagina 4-3

INSTRUMENT AND CONTROL FUNCTIONS
4-10
1
2
3
4
\f
6
7
8
\b
10
EAU12733
Hazard switch “r”
With the key in the \fON” \br Fp\bsiti\bn,
use this switch t\b turn \bn the hazard
lights (simultane\bus flashing \bf all turn
signal lights).
The hazard lights are used in case \bf
an emergency \br t\b warn \bther drivers
when y\bur vehicle is st\bpped where it
might be a traffic hazard.
ECA10061
NOTICE
Do not use the hazard lights for an
extended length of time with the
engine not running, otherwise the
battery may discha\4rge.
EAU12820
Clutch lever
1. Clutch lever
The clutch lever is l\bcated at the left
handlebar grip. T\b disengage the
clutch, pull the lever t\bward the han-
dlebar grip. T\b engage the clutch, re-
lease the lever. The lever sh\buld be
pulled rapidly and released sl\bwly f\br
sm\b\bth clutch \bperati\bn.
The clutch lever is equipped with a
clutch switch, which is part \bf the igni-
ti\bn circuit cut-\bff system. (See page
4-17).
1
EAU12870
Shift pedal
1. Shift pedal
The shift pedal is l\bcated \bn the left
side \bf the engine and is used in c\bm-
binati\bn with the clutch lever when
shifting the gears \bf the 5-speed c\bn-
stant-mesh transmissi\bn equipped \bn
this m\bt\brcycle.
XT660Z 04-04 ING-AUS:MY03 01-03 ING 11-05-2009 9:54 Pagina 4-10

OPERATION AND IMPORTANT RIDING POINTS
3. Start the engine by pushing thestart switch.
TIP
\ff the engine fails to start\b release the
start switch\b wait a few seconds\b and
then try again. Each starting attempt
should be as short as possible to pre-
serve the battery. Do not crank the en-
gine more than 10 seconds on any one
attempt.
ECA11040
NOTICE
For max\fmum en\b\fne l\ffe, never ac-
celerate hard when the en\b\fne \fs
cold!
TIP
The engine is warm when it quickly re-
sponds to the thrott\cle.
EAU16671
Sh\fft\fn\b
1. Shift pedal
N. Neutral position
Shifting gears lets you control the
amount of engine power available for
star ting off\b accelerating\b climbing
hills\b etc.
The gear positions are shown in the il-
lustration.
TIP
To shift the transmission into the neu-
tral position\b press the shift pedal down
repeatedly until it reaches the end of its
travel\b and then slightly raise it.
6-2
1
2
3
4
5
6
7
8
9
10
ECAB0070
NOTICE
The follow\fn\b warn\fn\b l\f\bhts and \fn-
d\fcator l\f\bhts should come on for a
few seconds, then \bo o\xff.
●Neutral \fnd\fcator l\f\b\xht
●Turn s\f\bnal \fnd\fcator l\f\bht\x
●H\f\bh beam \fnd\fcator l\f\b\xht
●En\b\fne trouble warn\fn\b l\f\bht
●Coolant temperature warn\fn\b
l\f\bht
●Immob\fl\fzer system \fnd\fcator
l\f\bht
If a warn\fn\b or \fnd\fcator l\f\bht does
not \bo off, see pa\be 4-3 for the cor-
respond\fn\b warn\fn\b and \fnd\fcator
l\f\bht c\frcu\ft check.
2. Shift the transmission into the neutral position.
TIP
When the transmission is in the neu-
tral position\b the neutral indicator light
should be on\b otherwise have a Yama-
ha dealer check the electrical circuit.
XT660Z 05-07 ING-AUS:MY03 04-06 ING 11-05-2009 10:09 Pagina 6

PERIODIC MAINTENANCE AND ADJUSTMENT
7-30
1
2
3
4
\f
6
7
8
\b
10
EWA10760
WARNING0
●Electrolyte is poisonous and
dangerous since it contains
sulfuric acid, which causes se-
vere burns. Avoid any contact
with skin, eyes or clothing and
always shield your eyes when
working near batteries. In case
of contact, administer the fol-
lowing FIRST AID.
 EXTERNAL: Flush with plenty
of water.
 INTERNAL: Drink large quan-
tities of water or milk and im-
mediately call a p\4hysician.
 EYES: Flush with water for 1\f
minutes and seek prompt
medical attention.\4
●Batteries produce explosive hy-
drogen gas. Therefore, keep
sparks, flames, cigarettes, etc.,
away from the battery and pro-
vide sufficient ventilation when
charging it in an enclosed space.
●KEEP THIS AND ALL BATTER-
IES OUT OF THE REACH OF
CHILDREN.
EAUB1432
Battery
This \fode\b is equipped with a VRLA
(Va\bve Regu\bated Lead Acid) battery.
There is no need to check the e\bec-
tro\byte or to add disti\b\bed water. Howev-
er, the battery \bead connections need
to be checked and, if necessary, tight-
ened.
ECA10620
NOTICE
Never attempt to remove the bat-
tery cell seals, as this would perma-
nently damage the \4battery.
1. Positive battery ter\fina\b
2. Negative battery ter\fina\b
To access the battery
Re\fove the battery ho\bder bracket by
re\foving the bo\bts.
To charge the battery
Have a Ya\faha dea\ber charge the bat-
tery as soon as possib\be if it see\fs to
have discharged. Keep in \find that
the battery tends to discharge \fore
quick\by if the vehic\be is equipped with
optiona\b e\bectrica\b accessories.
XT660Z 05-07 ING-AUS:MY03 04-06 ING 11-05-2009 10:10 Pagina 7-30

1
2
3
4
5
6
7
8
9
10
PERIODIC M\fINTEN\fNCE \fND \fDJ\bSTMENT
7-31
ECA16520
NOTICE
To charge a VRL\f (Valve Regulated
Lead \fcid) battery, a special (con-
stant-voltage) battery charger is re-
quired. \bsing a conventional battery
charger will damage the battery. If
you do not have access to a con-
stant-voltage battery charger, have
a Yamaha dealer charge your bat-
tery.
To store the battery 1. If the veh\fcle w\fll \bot be used for more tha\b o\be mo\bth, remove the
battery, fully charge \ft, a\bd the\b
place \ft \f\b a cool, dry place. NO-
TICE: When removing the bat-
tery, be sure the key is turned
to “OFF”, then disconnect the
negative lead before discon-
necting the positive \Mlead.
2. If the battery w\fll be stored for more tha\b two mo\bths, check \ft at
least o\bce a mo\bth a\bd fully
charge \ft \ff \becessar\vy.
3. Fully charge the battery before \f\b- stallat\fo\b. 4. After \f\bstallat\fo\b, make sure that
the battery leads are properly
co\b\bected to the battery term\f-
\bals.
ECA16530
NOTICE
\flways keep the battery charged.
Storing a discharged battery can
cause permanent batte\Mry damage.
EAUB1490
Replacing the fuses
1. Ma\f\b fuse
2. Reserve fuse
XT660Z 05-07 ING-AUS:MY03 04-06 ING 11-05-2009 10:10 Pagina 7-31

PERIODIC MAINTENANCE AND ADJUSTMENT
7-40
1
2
3
4
\f
6
7
8
\b
10
EAU42131Troubleshooting charts
Starting problems or poor engine performance
1. Fuel
2. Compression
3. Ignition
4. Battery
Check the fue\f \feve\f in the
fue\f t\bnk.
Oper\bte the e\fectric
st\brter.
Remove the sp\brk p\fug
\bnd check the e\fectrodes.
Oper\bte the e\fectric
st\brter.
There is enough
fue\f.
There is
compression.
Wet.
The engine turns
over quick\fy.
There is no fue\f.
There is no
compression.
Dry.
The engine turns
over s\fow\fy.
Check the
compression.
Check the ignition.
Wipe off with \b dry c\foth \bnd correct
the sp\brk p\fug g\bp, or rep\f\bce the
sp\brk p\fug.
The b\bttery is good.
H\bve \b Y\bm\bh\b de\b\fer check the
vehic\fe.
Check the b\bttery \fe\bd connections,
\bnd ch\brge the b\bttery if necess\bry.
Oper\bte the e\fectric st\brter.
The engine does not st\brt.
Check the b\bttery.
The engine does
not st\brt. H\bve \b
Y\bm\bh\b de\b\fer
check the vehic\fe.
Supp\fy fue\f.
H\bve \b Y\bm\bh\b de\b\fer check
the vehic\fe.
The engine does not st\brt.
Check the compression.
XT660Z 05-07 ING-AUS:MY03 04-06 ING 11-05-2009 10:10 Pagina 7-40