2012 Lancia Voyager check oil

CAUTION!
 It is essential when replacing thecables on the battery that the
positive cable is attached to the
positive post and the negative
cable is attached to the negative
post. Battery posts are marked
positive (+) and negative (-) and
are identified on the battery case.
Cable clamps should be tight on
the terminal posts and free of cor-
rosion.
 If a “fast charger” is used while
the battery is in the vehicle, dis-
connect both vehicle battery
cables before connecting the char-
ger to battery. Do not use a “fast
charger” to provide starting volt-
age.
AIR CONDITIONER
MAINTENANCE
For best possible performance, your
air conditioner should be checked and
serviced by an authorized dealer at
the start of each warm season. This
service should include cleaning of the
condenser fins and a system perfor- mance check. Drive belt tension
should also be checked at this time.
CAUTION!
Do not use chemical flushes in your
air conditioning system as the
chemicals can damage your air con-
ditioning components. Such damage
is not covered by the New Vehicle
Limited Warranty.WARNING!
 Use only refrigerants and com-
pressor lubricants approved by
the manufacturer for your air con-
ditioning system. Some unap-
proved refrigerants are flammable
and can explode, injuring you.
Other unapproved refrigerants or
lubricants can cause the system to
fail, requiring costly repairs.
 The air conditioning system con-
tains refrigerant under high pres-
sure. To avoid risk of personal in-
jury or damage to the system,
adding refrigerant or any repair
requiring lines to be disconnected
should be done by an experienced
repairman. Refrigerant Recovery And
Recycling
R-134a air conditioning refrigerant is
a hydrofluorocarbon (HFC) that is
endorsed by the Environmental Pro-
tection Agency and is an ozone-saving
product. However, the manufacturer
recommends that air conditioning
service be performed by an autho-
rized dealer, or other authorized ser-
vice facility, using recovery and recy-
cling equipment.
NOTE:
Use only manufacturer-approved
A/C System Sealers, Stop Leak
Products, Seal Conditioners, Com-
pressor Oil, or Refrigerants.
292

CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we do
recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
WINDSHIELD WIPER
BLADES
Clean the rubber edges of the wiper
blades and the windshield periodi-
cally with a sponge or soft cloth and a
mild nonabrasive cleaner. This will
remove accumulations of salt or road
film.
Operation of the wipers on dry glass
for long periods may cause deteriora-
tion of the wiper blades. Always use
washer fluid when using the wipers to
remove salt or dirt from a dry wind-
shield.
Avoid using the wiper blades to re-
move frost or ice from the windshield.
Keep the blade rubber out of contact with petroleum products such as en-
gine oil, gasoline, etc.
NOTE:
Life expectancy of wiper blades
varies depending on geographical
area and frequency of use. Ex-
amples of poor blade performance
include chattering, marks, water
lines, and wet spots. If any of these
conditions are present, clean the
wiper blades or replace as neces-
sary.
Adding Washer Fluid
The windshield, rear window, and
headlamp washers share a common
fluid reservoir. It is located in the en-
gine compartment and should be
checked at regular intervals. Fill the
reservoir with windshield washer sol-
vent (not radiator antifreeze) and op-
erate the system for a few seconds to
flush out any residual water.
When refilling the washer fluid reser-
voir, apply some washer fluid to a
cloth or towel and wipe the wiper
blades clean. This will help blade per-
formance.
To prevent freeze-up of your wind-
shield washer system in cold weather,
select a solution or mixture that meets
or exceeds the temperature range of
your climate. This rating information
can be found on most washer fluid
containers.
The washer fluid reservoir will hold
4 Liters of fluid when the Low Washer
Fluid Light illuminates.
WARNING!
Commercially available windshield
washer solvents are flammable.
They could ignite and burn you.
Care must be exercised when filling
or working around the washer solu-
tion.
After the engine has warmed, operate
the defroster for a few minutes to re-
duce the possibility of smearing or
freezing the fluid on the cold wind-
shield. Use All Weather Windshield
Washer Solution or equivalent, used
with water as directed on the con-
tainer, aids cleaning action, reduces
the freezing point to avoid line clog-
ging, and is not harmful to paint or
trim.
294

Master Cylinder – Brake Fluid
Level Check
The fluid level in the master cylinder
should be checked when performing
underhood services, or immediately if
the “Brake System Warning Light”
indicates system failure.
Clean the top of the master cylinder
area before removing the cap. Add
fluid to bring the level up to the top of
the “FULL” mark on the side of the
master cylinder reservoir.
Overfilling of fluid is not recom-
mended because it may cause leaking
in the system.
Add enough fluid to bring the level up
to the requirements described on the
brake fluid reservoir. With disc
brakes, fluid level can be expected to
fall as the brake pads wear. However,
low fluid level may be caused by a
leak and a checkup may be needed.
Use only manufacturer's recom-
mended brake fluid. Refer to “Fluids,
Lubricants and Genuine Parts” in
“Maintaining Your Vehicle” for fur-
ther information.
WARNING!
 Use only manufacturer's recom-mended brake fluid. Refer to
“Fluids, Lubricants and Genuine
Parts” in “Maintaining Your Ve-
hicle” for further information. Us-
ing the wrong type of brake fluid
can severely damage your brake
system and/or impair its perfor-
mance. The proper type of brake
fluid for your vehicle is also iden-
tified on the original factory in-
stalled hydraulic master cylinder
reservoir.
 To avoid contamination from for-
eign matter or moisture, use only
new brake fluid or fluid that has
been in a tightly closed container.
Keep the master cylinder reservoir
cap secured at all times. Brake
fluid in a open container absorbs
moisture from the air resulting in
a lower boiling point. This may
cause it to boil unexpectedly dur-
ing hard or prolonged braking,
resulting in sudden brake failure.
This could result in a accident.
(Continued)
WARNING!(Continued)
 Overfilling the brake fluid reser-
voir can result in spilling brake
fluid on hot engine parts, causing
the brake fluid to catch fire. Brake
fluid can also damage painted and
vinyl surfaces, care should be
taken to avoid its contact with
these surfaces.
 Do not allow petroleum based
fluid to contaminate the brake
fluid. Brake seal components
could be damaged, causing partial
or complete brake failure. This
could result in an accident.
AUTOMATIC
TRANSMISSION
The automatic transmission and dif-
ferential assembly are contained
within a single housing.
Selection Of Lubricant
It is important that the proper lubri-
cant is used in the transmission to
assure optimum transmission perfor-
mance. Use only the manufacturer's
recommended transmission fluid. Re-
fer to “Fluids, Lubricants and Genu-
ine Parts” in “Maintaining Your Ve-
299

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Check exhaust gas emissions.        
Check engine management system operation (via diag-
nostic socket).        
Change the automatic transmission fluid and filter (*). 
Replace spark plugs. 
Replace air filter cartridge. 
Change engine oil and replace oil filter. Every 12 000 km or 12 months whichever comes first
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 000 km
or 48 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi-
tion;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;  short, repeated journeys (less than
7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
320

 visually inspect conditions of: en-gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner. MAINTENANCE
SCHEDULE – DIESEL
ENGINE
To help you have the best driving
experience possible, the manufacturer
has identified the specific vehicle
maintenance service intervals that are
required to keep your vehicle operat-
ing properly and safely.
The manufacturer recommends that
these maintenance intervals be per-
formed at your selling dealer. The
technicians at your dealership know
your vehicle best, and have access to
factory trained information, genuine
LANCIA parts, and specially designed electronic and mechanical tools that
can help prevent future costly repairs.
The maintenance intervals shown
should be performed as indicated in
this section.
NOTE:
Under no circumstances should oil
change intervals exceed 25 000 km
or 12 months, whichever comes
first.
CAUTION!
Failure to perform the required
maintenance items may result in
damage to the vehicle.
321

Thousands Of Kilometers20 40 60 80 100 120 140 160 180 200
Months 12 24 36 48 60 72 84 96 108 120
Check and, if necessary, top up fluid levels (brakes,
windshield washer, battery, engine coolant, etc.).          
Visually inspect the condition of accessory drive
belt/s. 

Check toothed timing drive belt conditions. 
Check the handbrake lever stroke and adjust it, if
necessary.          
Check exhaust gas emissions.          
Check engine management system operation (via
diagnostic socket).          
Drain and refill the automatic transmission fluid.
Replace main sump filter and spin-on cooler return
filter (for versions/markets, where provided). 

Replace fuel filter (diesel version). 
Replace accessory drive belt/s. 
Replace toothed timing drive belt (*). 
Replace air filter cartridge.          
Change engine oil and replace oil filter (**).
Change brake fluid (or every 24 months). 
Replace pollen filter.          
(*) Regardless of the distance cov-
ered, the timing belt must be changed
every 4 years for particularly de- manding use (cold climates, city driv-
ing, long periods of idling) or at least
every 5 years.
(**) The actual oil and oil filter re-
placement interval depends on the carusage conditions and is indicated by a
warning light or message on the in-
strument panel, or in any case every
12 months.
323

Periodic Checks
Every1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level. Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than
7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;  visually inspect conditions of: en-
gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
324

Bulbs, Light . . . . . . . . . . . 65,308
Calibration, Compass . . . 172,181
Camera, Rear . . . . . . . . . . . . 135
Capacities, Fluid . . . . . . . . . . 311
Caps, FillerFuel . . . . . . . . . . . . . . . . . 258
Oil (Engine) . . . . . . . . . . . . 286
Power Steering . . . . . . . . . . 238
Radiator (Coolant
Pressure) . . . . . . . . . . . . . . 297
Car Washes . . . . . . . . . . . . . . 301
Carbon Monoxide Warning . . . . 63
Cargo (Vehicle Loading) . . . . . 148
Cargo Compartment Luggage Carrier . . . . . . . . . 153
Caution, Exhaust Gas . . . . . . . 33
Cellular Phone . . . . . . . . . 82,208
Center High Mounted Stop
Light . . . . . . . . . . . . . . . . . . 311
Chains, Tire . . . . . . . . . . . . . 249
Changing A Flat Tire . . . . . . . 269
Check Engine Light
(Malfunction Indicator
Light) . . . . . . . . . . . . . . . . . . 166
Checking Your Vehicle For
Safety . . . . . . . . . . . . . . . . . . . 63
Checks, Safety . . . . . . . . . . . . . 63
Child Restraint . . . . . . . . 53,56,57 Child Restraint Tether
Anchors . . . . . . . . . . . . . . . . . 58
Child Safety Locks . . . . . . . . . . 31
Child Seat . . . . . . . . . . . . . . . . 62
Clean Air Gasoline . . . . . . . . . 257
Cleaning
Wheels . . . . . . . . . . . . . . . 302
Climate Control . . . . . . . . . . . 209
Coat Hook . . . . . . . . . . . . . . 148
Coin Holder . . . . . . . . . . . . . 148
Cold Weather Operation . . . . . 227
Compact Disc (CD)
Maintenance . . . . . . . . . . . . . 208
Compact Spare Tire . . . . . . . . 247
Compass . . . . . . . . . 170,172,180
Compass Calibration . . . . 172,181
Compass Variance . . . . . . 170,181
Computer, Trip/Travel . . . . . . 179
Connector
UCI . . . . . . . . . . . . . . . . . . 187
Universal Consumer
Interface (UCI) . . . . . . . . . . 187
Conserving Fuel . . . . . . . . . . . 178
Console . . . . . . . . . . . . . . . . . 148
Console, Floor . . . . . . . . . . . . 148
Console, Overhead . . . . . . . . . 136
Console, Removable . . . . . . . . 150
Cool Down, Turbo . . . . . . . . . 229 Coolant Pressure Cap
(Radiator Cap) . . . . . . . . . . . 297
Cooling System . . . . . . . . . . . 295
Adding Coolant
(Antifreeze) . . . . . . . . . . . . 296
Coolant Capacity . . . . . . . . 311
Coolant Level . . . . . . . 295,297
Disposal of Used Coolant . . . 297
Drain, Flush, and Refill . . . . 296
Inspection . . . . . . . . . . . . . 297
Points to Remember . . . . . . 298
Pressure Cap . . . . . . . . . . . 297
Radiator Cap . . . . . . . . . . . 297
Selection of Coolant
(Antifreeze) . . . . . 296,311,312
Cupholders . . . . . . . . . . . 144,303
Data Recorder, Event . . . . . . . . 52
Defroster, Rear Window . . . . . 152
Defroster, Windshield . . . . 64,217
Diagnostic System, Onboard . . 287
Diesel Fuel . . . . . . . . . . . 258,312
Diesel Fuel Requirements . . . . 258
Dimmer Control . . . . . . . . . . 120
Dipsticks Automatic Transaxle . . . . . . 300
Oil (Engine) . . . . . . . . . . . . 288
Power Steering . . . . . . . . . . 238
Disabled Vehicle Towing . . . . . 281
327