2012 Lancia Flavia oil change

CAUTION!(Continued)
 Car maintenance should be done
at a LANCIA Dealership. For rou-
tine and minor maintenance op-
erations you wish to carry out
yourself, we do recommend you
have the proper equipment, genu-
ine LANCIA spare parts and the
necessary fluids; do not however
carry out these operations if you
have no experience.
 Your vehicle has been built with
improved fluids that protect the
performance and durability of
your vehicle and also allow ex-
tended maintenance intervals. Do
not use chemical flushes in these
components as the chemicals can
damage your engine, transmis-
sion, power steering or air condi-
tioning. Such damage is not cov-
ered by the New Vehicle Limited
Warranty. If a flush is needed be-
cause of component malfunction,
use only the specified fluid for the
flushing procedure. ENGINE OIL
Checking Oil Level
To assure proper engine lubrication of
your
vehicle's engine, the engine oil
must be maintained at the correct
level. The best time to check the en-
gine oil level is about five minutes
after a fully warmed engine is shut off.
Do not check oil level before starting
the engine after it has sat overnight.
Checking engine oil level when the
engine is cold will give you an incor-
rect reading.
Checking the oil while the vehicle is
on level ground and only when the
engine is hot, will improve the accu-
racy of the oil level readings. Maintain
the oil level between the range mark-
ings on the dipstick. Either the range
markings consist of a crosshatch zone
marked SAFE or a crosshatch zone
marked with MIN at the low end of
the range and MAX at the high end of
the range. Adding 1.0 Liter of oil
when the reading is at the low end of
the range marking will raise the oil
level to the high end of the range
marking.
CAUTION!
 Do not overfill the engine. Over- filling the engine will cause oil
aeration, which can lead to loss of
oil pressure and an increase in oil
temperature. This could damage
your engine. Also, be sure the oil
fill cap is replaced and tightened
after adding oil.
 Car maintenance should be done
at a LANCIA Dealership. For rou-
tine and minor maintenance op-
erations you wish to carry out
yourself, we do recommend you
have the proper equipment, genu-
ine LANCIA spare parts and the
necessary fluids; do not however
carry out these operations if you
have no experience.
Change Engine Oil
Refer to the “Maintenance Schedule”
for the proper maintenance intervals.
Engine Oil Selection
SAE Grade 5W-20 SELENIA K
POWER fully synthetic engine oil that
meets FIAT Qualification 9.55535
API SN, ILSAC GF-5 or equivalent.
183

The engine oil filler cap also shows the
recommended engine oil viscosity for
your vehicle. For information on en-
gine oil filler cap location, refer to
“Engine Compartment” in “Main-
taining Your Vehicle” for further in-
formation.
Synthetic Engine Oils
You may use synthetic engine oils pro-
vided the recommended oil quality
requirements are met, and the recom-
mended maintenance intervals for oil
and filter changes are followed.
Materials Added To Engine Oil
Do not add any supplemental materi-
als, other than leak detection dyes, to
the engine oil. Engine oil is an engi-
neered product and its performance
may be impaired by supplemental ad-
ditives.
Disposing Of Used Engine Oil And
Oil Filters
Care should be taken in disposing of
used engine oil and oil filters from
your vehicle. Used oil and oil filters,
indiscriminately discarded, can pres-
ent a problem to the environment.
Contact your authorized dealer, ser-vice station, or governmental agency
for advice on how and where used oil
and oil filters can be safely discarded
in your area.
ENGINE OIL FILTER
The engine oil filter should be re-
placed with a new filter at every en-
gine oil change.
Engine Oil Filter Selection
The manufactur
er's engines have a
full-flow type disposable oil filter. Use
a filter of this type for replacement.
The quality of replacement filters var-
ies considerably. Only high-quality
filters should be used to assure most
efficient service. LANCIA engine oil
filters are high-quality oil filters and
are recommended.
ENGINE AIR CLEANER
FILTER
Refer to the “Maintenance Schedule”
for the proper maintenance intervals.
WARNING!
The air induction system (air
cleaner, hoses, etc.) can provide a
measure of protection in the case of
engine backfire. Do not remove the
air induction system (air cleaner,
hoses, etc.) unless such removal is
necessary for repair or maintenance.
Make sure that no one is near the
engine compartment before starting
the vehicle with the air induction
system (air cleaner, hoses, etc.) re-
moved. Failure to do so can result in
serious personal injury.
Engine Air Cleaner Filter
Selection
The quality of replacement engine air
cleaner filters varies considerably.
Only high quality filters should be
used to assure most efficient service.
LANCIA engine air cleaner filters are
a high quality filter and are recom-
mended.
184

EXHAUST SYSTEM
The best protection against carbon
monoxide entry into the vehicle body
is a properly maintained engine ex-
haust system.
If you notice a change in the sound of
the exhaust system; or if the exhaust
fumes can be detected inside the ve-
hicle; or when the underside or rear of
the vehicle is damaged; have an au-
thorized technician inspect the com-
plete exhaust system and adjacent
body areas for broken, damaged, de-
teriorated, or mispositioned parts.
Open seams or loose connections
could permit exhaust fumes to seep
into the passenger compartment. In
addition, have the exhaust system in-
spected each time the vehicle is raised
for lubrication or oil change. Replace
as required.
WARNING!
Exhaust gases can injure or kill.
They contain carbon monoxide
(CO), which is colorless and odor-
less. Breathing it can make you un-
conscious and can eventually poison
you. To avoid breathing CO, refer to
“Safety Tips/Exhaust Gas” in
“Things To Know Before Starting
Your Vehicle” for further informa-
tion.CAUTION!
 The catalytic converter requiresthe use of unleaded fuel only.
Leaded gasoline will destroy the
effectiveness of the catalyst as an
emissions control device and may
seriously reduce engine perfor-
mance and cause serious damage
to the engine.
(Continued)
CAUTION!(Continued)
 Damage to the catalytic converter
can result if your vehicle is not
kept in proper operating condi-
tion. In the event of engine mal-
function, particularly involving
engine misfire or other apparent
loss of performance, have your ve-
hicle serviced promptly. Contin-
ued operation of your vehicle with
a severe malfunction could cause
the converter to overheat, result-
ing in possible damage to the con-
verter and vehicle.
Under normal operating conditions,
the catalytic converter will not require
maintenance. However, it is impor-
tant to keep the engine properly tuned
to assure proper catalyst operation
and prevent possible catalyst damage.
NOTE:
Intentional tampering with emis-
sions control systems can result in
civil penalties being assessed
against you.
189

MAINTENANCE
SCHEDULE
The Scheduled Maintenance services
listed in this manual must be done at
the times or mileages specified to pro-
tect your vehicle warranty and ensure
the best vehicle performance and reli-
ability. More frequent maintenance
may be needed for vehicles in severe
operating conditions, such as dusty
areas and very short trip driving. In-
spection and service should also be
done anytime a malfunction is sus-
pected.
The oil change indicator system will
remind you that it is time to take your
vehicle in for scheduled maintenance.On Electronic Vehicle Information
Center (EVIC) equipped vehicles “Oil
Change Required” will be displayed
in the EVIC and a single chime will
sound, indicating that an oil change is
necessary.
NOTE:
 The oil change indicator mes-
sage will not monitor the time
since the last oil change. Change
your vehicles oil if it has been
12 months since your last oil
change even if the oil change in-
dicator message is NOT illumi-
nated.  Under no circumstances should
oil change intervals exceed
12 000 km or 12 months, which-
ever comes first.
Your authorized dealer will reset the
oil change indicator message after
completing the scheduled oil change.
CAUTION!
Failure to perform the required
maintenance items may result in
damage to the vehicle.
Thousands Of Kilometers 24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Flush and replace the engine coolant (or at 60 months). 
Inspect and replace PCV valve if necessary. 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if neces-
sary.        
212

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Replace air filter cartridge.    
Change engine oil and replace oil filter.*
Change brake fluid (or every 24 months).  
Replace pollen filter.        
* The engine oil and the oil filter must
be changed when the instrument
panel warning light comes on or in
any case every 12 months.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades. Every
3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;  check cleanliness of hood and trunk
locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
214

About Your Brakes . . . . . . . . . 145
ABS
(Anti-Lock Brake System) . . . 146
Adding Engine Coolant
(Antifreeze) . . . . . . . . . . . . . . 191
Adding Washer Fluid . . . . . . . 188
Additives, Fuel . . . . . . . . . . . 160
Air Cleaner, Engine
(Engine Air Cleaner Filter) . . . 184
Air Conditioner
Maintenance . . . . . . . . . . . . . 186
Air Conditioning Filter . . . 128,186
Air Conditioning Refrigerant . . 186
Air Conditioning
System . . . . . . . . . . . . . . 124,186
Air Conditioning, Operating
Tips . . . . . . . . . . . . . . . . . . . 129
Air Pressure, Tires . . . . . . . . . 151
Airbag . . . . . . . . . . . . . . . . . . 30
Airbag Deployment . . . . . . . . . 34
Airbag Light . . . . 32,33,36,46,108
Airbag Maintenance . . . . . . . . . 35
Airbag, Side . . . . . . . . . . 31,32,33
Airbag, Window
(Side Curtain) . . . . . . . . . . . . . 32
Alarm (Security Alarm) . . . . . . 14
Alarm System
(Security Alarm) . . . . . . . . 14,112Alterations/Modifications,
Vehicle . . . . . . . . . . . . . . . . . . . 7
Anti-Lock Brake System
(ABS) . . . . . . . . . . . . . . . . . . 146
Anti-Lock Warning Light . . . . 146
Anti-Theft Security Alarm
(Theft Alarm) . . . . . . . . . . . . . 14
Antifreeze
(Engine Coolant) . . . . . . . 191,206
Disposal . . . . . . . . . . . . . . 192
Appearance Care . . . . . . . . . . 196
Ashtray . . . . . . . . . . . . . . . . . 100
Auto Down Power Windows . . . 19
Auto Unlock, Doors . . . . . . . . . 18
Automatic Door Locks . . . . . . . 18
Automatic Headlights . . . . . . . 91
Automatic Oil Change
Indicator . . . . . . . . . . . . 110,117
Automatic Temperature
Control (ATC) . . . . . . . . . . . . 124
Automatic Transaxle . . . . . 12,134 Adding Fluid . . . . . . . . . . . 207
Selection Of Lubricant . . . . 207
Automatic Transmission . . 135,194 Adding Fluid . . . . . . . . . . . 195
Fluid and Filter Changes . . . 195
Fluid Level Check . . . . . . . 195
Fluid Type . . . . . . . . . . . . . 195
Gear Ranges . . . . . . . . . . . 137 Special Additives . . . . . . . . 195
Autostick . . . . . . . . . . . . . . . 141
Battery . . . . . . . . . . . . . . . . . 185
Keyless Transmitter
Replacement (RKE) . . . . . . . 17
Location . . . . . . . . . . . . . . 185
Belts, Seat . . . . . . . . . . . . . 23,45
Body Mechanism
Lubrication . . . . . . . . . . . . . . 187
Brake Assist System . . . . . . . . 148
Brake Fluid . . . . . . . . . . . . . . 207
Brake System . . . . . . . . . . . . 193 Anti-Lock (ABS) . . . . . . . . 146
Fluid Check . . . . . . . . 194,207
Master Cylinder . . . . . . . . . 194
Parking . . . . . . . . . . . . . . . 145
Warning Light . . . . . . . . . . 108
Brake, Parking . . . . . . . . . . . 145
Brake/Transmission
Interlock . . . . . . . . . . . . . . . . 136
Brakes . . . . . . . . . . . . . . . . . 193
Break-In Recommendations,
New Vehicle . . . . . . . . . . . . . . 44
Bulb Replacement . . . . . . . . . 203
Bulbs, Light . . . . . . . . . . . 47,203
Calibration, Compass . . . . . . . 118
216

Electronic Speed Control
(Cruise Control) . . . . . . . . . . . 97
Electronic Stability Control
(ESC) . . . . . . . . . . . . . . . . . . 149
Electronic Vehicle Information
Center (EVIC) . . . . . . . . . . . . 115
Emergency Deck Lid Release . . 21
Emergency Trunk Release . . . . 21
Emergency, In Case ofJump Starting . . . . . . . . . . 172
Towing . . . . . . . . . . . . . . . 176
Engine . . . . . . . . . . . . . . . . . 181 Air Cleaner . . . . . . . . . . . . 184
Break-In Recommendations . . 44
Checking Oil Level . . . . . . . 183
Coolant (Antifreeze) . . . 190,206
Cooling . . . . . . . . . . . . . . . 190
Exhaust Gas Caution . . . . . . 45
Fails to Start . . . . . . . . . . . 134
Flooded, Starting . . . . . . . . 134
Fuel Requirements . . . . 158,206
Jump Starting . . . . . . . . . . 172
Oil . . . . . . . . . . . . . . . 183,206
Oil Change
Interval . . . . . . . . 110,117,183
Oil Filler Cap . . . . . . . . . . . 181
Oil Filter . . . . . . . . . . . . . . 184
Oil Filter Disposal . . . . . . . 184
Oil Selection . . . . . . . . . . . 206 Oil Synthetic . . . . . . . . . . . 184
Overheating . . . . . . . . . . . . 166
Starting . . . . . . . . . . . . . . . 134
Temperature Gauge . . . . . . 107
Enhanced Accident Response
Feature . . . . . . . . . . . . . . . . . . 34
Entry System, Illuminated . . . . 16
Ethanol . . . . . . . . . . . . . . . . 159
Event Data Recorder . . . . . . . . 36
Exhaust Gas Caution . . . . . . . . 45
Exhaust System . . . . . . . . 45,189
Exterior Lights . . . . . . . . . . . . 47
Filler Location Fuel . . . . . 107,160
Filters Air Cleaner . . . . . . . . . . . . 184
Air Conditioning . . . . . 128,186
Automatic Transmission . . . 195
Engine Oil . . . . . . . . . . 184,206
Engine Oil Disposal . . . . . . 184
Flash-To-Pass . . . . . . . . . . . . . 93
Flashers . . . . . . . . . . . . . . . . 166 Hazard Warning . . . . . . . . . 166
Turn Signal . . . . . . . 47,93,205
Flooded Engine Starting . . . . . 134
Floor Console . . . . . . . . . . . . 101
Fluid Capacities . . . . . . . . . . . 206
Fluid Leaks . . . . . . . . . . . . . . 47 Fluid Level Checks
Automatic Transmission . . . 195
Brake . . . . . . . . . . . . . 194,207
Cooling System . . . . . . . . . 190
Engine Oil . . . . . . . . . . . . . 183
Power Steering . . . . . . 144,207
Fluid, Brake . . . . . . . . . . . . . 207
Fluids . . . . . . . . . . . . . . . . . . 206
Fluids, Lubricants and
Genuine Parts . . . . . . . . . . . . 206
Fog Light Service . . . . . . . . . . 204
Fog Lights . . . . . . . 91,92,112,204
Freeing A Stuck Vehicle . . . . . 174
Fuel . . . . . . . . . . . . . . . . . . . 158 Additives . . . . . . . . . . . . . . 160
Diesel . . . . . . . . . . . . . . . . 206
Ethanol . . . . . . . . . . . . . . . 159
Filler Cap (Gas Cap) . . 107,160
Filler Door (Gas Cap) . . 107,160
Gasoline . . . . . . . . . . . . . . 158
Gauge . . . . . . . . . . . . . . . . 107
Light . . . . . . . . . . . . . . . . . 107
Octane Rating . . . . . . . 158,206
Requirements . . . . . . . 158,206
Specifications . . . . . . . . . . . 206
Tank Capacity . . . . . . . . . . 206
Fuel System Caution . . . . . . . 161
Fuses . . . . . . . . . . . . . . . . . . 200
218

Monitor, Tire Pressure
System . . . . . . . . . . . . . . . . . 155
Multi-Function Control Lever . . 91
New Vehicle Break-In Period . . 44
Occupant Restraints . . . . 21,32,34
Occupant Restraints
(Sedan) . . . . . . . . . . . . . . . 31,32
Octane Rating, Gasoline
(Fuel) . . . . . . . . . . . . . . 158,206
Odometer . . . . . . . . . . . . . . . 109Trip . . . . . . . . . . . . . . 109,111
Oil Change Indicator . . . . 110,117
Oil Change Indicator,
Reset . . . . . . . . . . . . . . . 110,117
Oil Filter, Change . . . . . . . . . 184
Oil Filter, Selection . . . . . . . . 184
Oil Pressure Light . . . . . . . . . 108
Oil, Engine . . . . . . . . . . . 183,206 Capacity . . . . . . . . . . . . . . 206
Change Interval . . . 110,117,183
Checking . . . . . . . . . . . . . . 183
Dipstick . . . . . . . . . . . . . . . 183
Disposal . . . . . . . . . . . . . . 184
Filter . . . . . . . . . . . . . 184,206
Filter Disposal . . . . . . . . . . 184
Materials Added to . . . . . . . 184
Recommendation . . . . . . . . 206 Synthetic . . . . . . . . . . . . . . 184
Viscosity . . . . . . . . . . . . . . 206
Onboard Diagnostic System . . 182
Operating Precautions . . . . . . 182
Operator Manual
(Owner's Manual) . . . . . . . . . . . 6
Outside Rearview Mirrors . . . . . 64
Overheating, Engine . . . . . . . 166
Owner's Manual
(Operator Manual) . . . . . . . . . . 6
Paint Care . . . . . . . . . . . . . . . 196
Parking Brake . . . . . . . . . . . . 145
Passenger Seat Back Tilt
(Easy Entry System) . . . . . . . . 88
Passing Light . . . . . . . . . . . . . 93
Personal Settings . . . . . . . . . . 121
Pets . . . . . . . . . . . . . . . . . . . . 44
Phone, Cellular . . . . . . . . . . . . 65
Phone, Hands-Free
(Uconnect™) . . . . . . . . . . . . . 65
Power Deck Lid Release . . . . . . . . . 20
Door Locks . . . . . . . . . . . . . 18
Mirrors . . . . . . . . . . . . . . . . 64
Outlet (Auxiliary Electrical
Outlet) . . . . . . . . . . . . . . . . 98
Seats . . . . . . . . . . . . . . . . . . 85
Steering . . . . . . . . . . . . . . . 144 Windows . . . . . . . . . . . . . . . 19
Power Steering Fluid . . . . . . . 207
Power Transfer Unit . . . . . . . . 207
Pregnant Women and Seat
Belts . . . . . . . . . . . . . . . . . . . . 29
Pretensioners Seat Belts . . . . . . . . . . . . . . 27
Programmable Electronic
Features . . . . . . . . . . . . . . . . 121
Radial Ply Tires . . . . . . . . . . . 152
Radiator Cap (Coolant
Pressure Cap) . . . . . . . . . . . . 192
Radio (Sound Systems) . . . . . 122
Radio Operation . . . . . . . . . . 123
Radio Remote Controls . . . . . . 123
Rear Cupholder . . . . . . . . . . . 101
Rear Window Defroster . . . . . 102
Rear Window Features . . . . . . 102
Recorder, Event Data . . . . . . . . 36
Recreational Towing . . . . . . . . 163
Refrigerant . . . . . . . . . . . . . . 186
Release, Hood . . . . . . . . . . . . . 90
Reminder, Lights On . . . . . . . . 91
Reminder, Seat Belt . . . . . . . . . 29
Remote Control
Door Locks . . . . . . . . . . . . . 16
Security Alarm . . . . . . . . . . . 14
221