2009 OPEL CORSA spare wheel

204 Self-help, vehicle careTyre repair kit
3
Minor damage to the tyre tread or side wall
can be repaired using the tyre repair kit
(does not apply to run-flat tyres).
Do not remove the foreign body from the
tyre.
T y r e d a m a g e e x c e e d i n g 4 m m o r t ha t i s o n
the rim cannot be repaired with the tyre
repair kit.

Important 3207.
In the event of a flat tyre:
z Switch on hazard warning lights, apply
handbrake, engage 1st or reverse gear,
in the case of automatic transmission 3
move selector lever to position P.
z Erect warning triangle 3 as specified.
Warning triangle 3196.
Picture no: 18317s.tif
The tyre repair kit is located in the
compartment to the right in the luggage
compartment.
To open the compartment, disengage the
cover and open it.
Picture no: 18318s.tif
1. Remove the sealant bottle and holder
with the air tube from the compartment.
9
Warning
Do not drive faster than 80 km/h.
Do not use the temporary spare wheel
for a lengthy period.
Steering and handling may be affected.
Back to overview

234 Opel Service, maintenance⊕Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
30 2
60 3
90 4
120 5
150
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60 000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mounting and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
⊕
Germany only: carry out emissions check, main inspection
First time after three years, then every 2 years
If used commercially to transport passengers, taxis, ambulances, hire cars etc. annually
Back to overview

237
Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
Back to overview

264 Technical DataTyres Not all tyres available on the market
currently meet the structural requirements.
We recommend that you consult an Opel
Partner concerning suitable tyre makes.
These tyres have undergone special tests
to establish their reliability, safety and
specific suitability for Opel vehicles.
Despite continuous market monitoring, we
are unable to assess these attributes for
other tyres, even if they have been granted
approval by the relevant authorities or in
some other form.
Further information 3168. Wheels Wheel bolt tightening torque: 110 Nm. Winter tyres
3
Tyres of size 195/60 R 15, 215/45 R 17
and 225/35 R 18 must not be used as
winter tyres.
Tyres of size 185/60 R 15 are only approved
as winter tyres.
Tyres of size 185/65 R 15 are only
a p p r o v e d a s w i n te r t y r e s o n ve h i c l e s w i t h a
sports chassis. We recommend that you
contact your Opel partner in order to find
out whether your vehicle is equipped with a
sports chassis. If you use winter tyres, the spare wheel
3
m a y s t i l l b e f i t t e d w i t h a s u m m e r t y r e . I f y o u
use the spare wheel the vehicle’s handling
may be altered. Obtain a replacement for
the faulty tyre as soon as possible, and
have the wheel balanced and fitted to the
vehicle.
Further information 3 172.
Tyre chains
3
Tyre chains may be used on the front
wheels only.
We recommend the use of tyre chains with
a fine mesh that add no more than 10 mm
to the running surface and the insides of
the tyres (including chain lock).
Tyre chains are not permitted on tyre sizes
195/60 R 15, 215/45 R 17 and 225/35 R 18.
Tyre chains are only approved on tyres of
size 185/60 R 15 on vehicles with a sports
chassis. We recommend that you contact
your Opel partner in order to find out
whether your vehicle is equipped with a
sports chassis.
Further information 3172. Spare wheel
3
Depending on the version, the spare wheel
will be in the form of a temporary spare
wheel 3. The vehicle may handle
differently if a spare wheel has been fitted. Replace defective tyre as soon as possible,
balance wheel and fit to vehicle.
Please pay attention to the notes on this
page and on pages 173, 196.
On vehicles with alloy wheels
3 the spare
wheel may have a steel rim.
The spare wheel can be fitted with a
smaller tyre
1) and a smaller rim than the
wheels fitted on the vehicle.
Tyre pressure (overpressure) The specified tyre pressures are valid for
cold tyres. The increased tyre pressure
resulting from extensive driving must not
be reduced. The tyre pressures specified on
the following pages apply to both summer
and winter tyres.
Always inflate the spare wheel 3 to the tyre
pressure for full load – see tables on the
following pages.
Temporary spare wheel tyre pressure 3 –
see tables on the following pages.
Further information 3168 to 3172.1)Country-specific version: The spare wheel is
only to be used as a temporary spare wheel.
Back to overview

275
Index
SSafeguard against unauthorised use .... 16
Safety accessories ........................... 63, 196
Saving energy ........................................ 151
Seat adjustment ........................................ 2
Seat belts ............................................ 58, 62
Seat height adjustment ....................... 3, 49
Seat position ............................................ 50
Seats ........................................................... 2Heated ............................................ 50, 51
Selector lever .................................. 137, 145
Selector lever lock ............................ 15, 145
Self-diagnosis .............................61, 74, 166
Self-help .................................................. 190 Central locking ..................................... 34
Electric sun roof .................................... 47
Electric windows ................................... 46
Information display ............................. 96
Remote control ..................................... 31
Service interval display ......................... 240
Service intervals ..................................... 231 Additional work .................................. 238
Hard driving conditions ..................... 238
Main inspection .................................. 231
Service work ........................................... 240
Side airbags ............................................. 71
Signal system ........................................... 12
Spare keys ................................................ 26
Spare wheel ........................... 196, 197, 200
Speed .............................................. 151, 152 Fuel consumption ...................... 151, 152 Speed warning ......................................... 92
Speedometer ........................................... 90
Sport programme .................................. 140
Starting the engine .......................... 27, 137
Steam-jet cleaners ................................. 230
Steering column lock ......................... 16, 17
Steering wheel adju
stment ....................... 5
Steering wheel remote control ....... 21, 118
Stowage compartments ......................... 82
Sun roof ............................................ 46, 230
Sunblind ................................................... 47
System settings ........................................ 98
TTachometer .............................................. 90
Tail lamps ............................................... 108 Bulb replacement .............................. 221
Tailgate .................................................... 36
Tank Fuel gauge ........................................... 90
Technical data ....................................... 250
Telephone, see Mobile telephone ........ 119
Temperature regulation ............... 123, 130
Tempomat, see cruise control .............. 160
Temporary spare wheel ................ 173, 197
Tightening torque .......................... 203, 264
Time .......................................................... 96
To fold backrest .................................. 3, 49
Tools ....................................................... 198
Top speed .............................................. 254
Top-Tether ............................................... 68
Towing .................................................... 193
Towing equipment ........................ 184, 269 Towing eye .................................... 193, 195
Transmission
Manual transmission ......................... 144
Transmission display ............... 91, 136, 144
Transmission, automatic ........................ 15 Automatic mode ............................... 145
Driving programme ........................... 146
Fault ................................................... 148
Interruption of power supply ............ 148
Kickdown ............................................ 146
Selector lever ............................... 15, 145
Selector lever lock ................................ 15
Winter programme ............................ 146
Transmission, Easytronic Driving programmes ......................... 139
Fault ................................................... 142
Interruption of power supply ............ 143
Kickdown ............................................ 141
Selector lever ............................... 15, 138
Sport programme .............................. 140
Winter programme ............................ 140
Transmission, manual ............................. 14
Tread depth ........................................... 170
Trip computer ............................ 20, 92, 101
Trip odometer .................................... 92, 93
Triple information display ...................... 94
Turn signal lamps .................................... 11
Turn signals Bulb replacement ...................... 220, 221
Tyre chains ..................................... 172, 264
Tyre condition ........................................ 170
Tyre pressure ........................... 22, 169, 264
Tyre repair kit ........................................ 204
Back to overview