2009 FIAT SEDICI steering

224
(1)(2)
80JM123
(1)
(2)
80JM11480JM071
(3)
79JM025
Front turn signal light (1)
Front position light (2)
Front fog light
(for versions/markets, where provided)
NOTE To replace the bulb easily, turn the
steering wheel to the opposite side of the
replacing fog light.
❒ Insert a flat blade screwdriver into the
hole (2) and remove the clips (1) by twi-
st the driver as shown in the illustration.
❒ Remove the bolts (3).❒ Open the fender cover. Disconnect the
coupler with pushing the lock release.
❒ Turn the bulb holder counterclockwi-
se and remove it.
183-230 SEDICI LUM FL GB 1E 19-06-2009 11:00 Pagina 224

235
2-WHEEL DRIVE (2WD)
MANUAL TRANSAXLE
Manual transaxle vehicles may be towed
using either of the following methods.
❒From the front, with the front wheels
lifted and the rear wheels on the
ground. Before towing, make sure that
the parking brake is released.
❒From the rear, with the rear wheels lift-
ed and the front wheels on the ground,
provided the steering and drivetrain are
in operational condition. Before tow-
ing, make sure that transaxle is in neu-
tral, the steering wheel is unlocked (the
ignition key should be in the “ACC” po-
sition), and the steering wheel is se-
cured with a clamping device designed
for towing service.
IMPORTANT The steering column is not
strong enough to withstand shocks trans-
mitted from the front wheels during tow-
ing. Always unlock the steering wheel be-
fore towing.
TOWING
If you need to have your vehicle towed,
contact a professional service. Your deal-
er can provide you with detailed towing
instructions.
IMPORTANT To help avoid damage to
your vehicle during towing, proper equip-
ment and towing procedures must be
used.
2- WHEEL DRIVE (2WD)
AUTOMATIC TRANSAXLE
Automatic transaxle vehicles may be
towed using either of the following meth-
ods.
❒From the front, with the front wheels
lifted and the rear wheels on the
ground. Before towing, make sure that
the parking brake is released.
❒From the rear, with the rear wheels lift-
ed and a dolly under the front wheels.
IMPORTANT Towing your vehicle with
the front wheels on the ground can result
in damage to the automatic transaxle.4-WHEEL DRIVE (4WD)
Your vehicle should be towed under one
of the following conditions:
❒With all four wheels on a flat-bed truck.
❒With the front or rear wheels lifted and
a dolly under the other wheels.
❒If you can shift the 2WD/4WD switch
to the “2WD” mode, and if the steer-
ing and drive train are in good condi-
tion and the engine can be started, the
vehicle may also be towed according to
the instructions in the “Towing Your
Vehicle (recreational towing)” section.
IMPORTANT Towing your vehicle with
front and/or rear wheels on the ground
can result in damage to the automatic
transaxle and/or the 4WD drive system.
231-238 SEDICI LUM FL GB 1E 19-06-2009 11:06 Pagina 235

249
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
ENGINE................................................................................... 250
FUEL FEED – IGNITION..................................................... 250
ELECTRICAL COMPONENTS.......................................... 251
BULBS...................................................................................... 251
TRANSMISSION.................................................................... 252
BRAKES................................................................................... 252
SUSPENSIONS....................................................................... 252
STEERING ............................................................................... 252
WHEELS.................................................................................. 253
DIMENSIONS......................................................................... 253
WEIGHTS............................................................................... 254
PERFORMANCE................................................................... 254
CAPACITIES ........................................................................... 254
12
249-254 SEDICI LUM FL GB 1E 19-06-2009 11:09 Pagina 249

252
BRAKES
Service brakes Front
Rear
Parking brake
Vacuum brake
SUSPENSIONS
Front
Rear
STEERING
Type
Minimum steering cycleDisc (Ø 280 mm - 11 in.)
Disc (Ø 280 mm - 11 in.)
Controlled by hand lever, it works on rear brakes
10”
Mc Pherson independent wheels
Bent twisting axle
Power steering, electric
11 m (433 in.)
TRANSMISSION
Drive 4WD
Clutch
Gearbox1.6 16V M/T
1.6 16V A/T
2.0 Multijet4-wheel drive, electronic-control self-locking differential
Dry single disc, Belleville washer, hydraulic control
5 forward gears + reverse
4 forward gears + reverse
6 forward gears + reverse
249-254 SEDICI LUM FL GB 1E 19-06-2009 11:10 Pagina 252

263
Mirrors
– Defroster......................................... 93
– Electric mirrors.............................. 28
– Inside rearview mirror ................. 27
– Outside rearview mirror ............. 27
MP3/WMA Player ................................ 119
Odometer ........................................... 87
Operating your vehicle....................... 149
Original spare parts............................. 2
Other controls and equipment......... 129
Parking brake lever ........................... 130
Parking lights ......................................... 63
Pedals..................................................... 131
Performance ......................................... 254
Pretensioners for seat belts .............. 45
Radio antenna...................................... 147
Rear door.............................................. 23
Rear fog light......................................... 64
Rear window washer
– Switch............................................... 66
Rear window wiper
– Blades............................................... 229
– Control ............................................ 66
Recirculated air.............................100-104
Refuelling/Capacities....................10-254
Remote audio controls....................... 126
Roof rails or roof rack anchors ........ 147
Running-in.............................................. 167
Seat back pocket ................................ 145
Seat belts............................................... 31
– Height adjuster............................... 36
– Pretensioners................................. 45
– Seat belt hangers............................ 36
– Seat belt inspection....................... 37
– Seat belt reminder (S.B.R.) .......... 35
– Use.................................................... 33
– Warnings......................................... 31
Seats
– Front (adjustment) ........................ 29
– Front seat heater........................... 139
– Seat back pocket............................ 145
Service station guide........................... 3
Shopping hook...................................... 145
Snow chains .......................................... 171
Spare tire........................................144-211
Spark plugs............................................ 202
Speedometer........................................ 84
Spot light................................................ 138
Starting the engine............................... 152
– If the engine is flooded................. 236
– If the starter does not operate... 236
– Jump starting................................... 233
Steering.................................................. 207
Steering column controls................... 57
Sun visors .............................................. 137
Supplement (declaration
of conformity).................................... 255 Instrument cluster............................... 73
– Meter illumination (control) ....... 90
Instrument panel.............................71-72
Interior light.......................................... 138
Isofix type child restraint system
(installation)..................................41-42
Jack ......................................................... 144
Jacking instructions.............................. 232
Jump starting instructions .................. 233
Keys ....................................................... 11
– Battery replacement..................... 20
– Keyless Entry.................................. 18
Keyless Entry System.......................... 18
Keyless Start System........................... 15
Luggage compartment
– Luggage compartment cover....... 146
– Luggage compartment light ......... 146
– Luggage restraint loops ................ 145
Main beam headlights ........................ 63
– Bulb replacement........................... 222
Maintenance (programmed) .............. 183
– Maintenance schedule................... 185
– Severe driving conditions............. 190
Manual heating and air conditioning
system.................................................. 100
– Maintenance............................108-230
261-268 SEDICI LUM FL GB 1E 19-06-2009 11:12 Pagina 263

264
– Inspection ........................................ 208
– Rotation........................................... 210
– Technical data................................ 253
Vehicle cleaning.................................. 242
Vehicle identification........................... 246
Vehicle loading and towing ......... 173-174
Ventilation.................................98-101-107
Warning and indicator lights ........... 74
Weights.................................................. 254
Wheels
– Changing .......................................... 212
– Technical data................................ 253
Windows
– Electric window controls............. 24
– Manual window controls ............. 24
Windshield defroster..............98-101-107
Windshield washer
– Control ............................................ 65
– Fluid.................................................. 201
Windshield wiper
– Blades............................................... 227
– Control ............................................ 65
2WD/4WD switch.......................92-159 Suspensions ........................................... 252
Symbols (battery)................................. 4
Tachometer ........................................ 83
Tailgate................................................... 23
Technical specifications...................... 249
Theft deterrent light ........................... 95
Thermometer....................................... 88
Tilt steering lock lever........................ 67
Tools...................................................... 144
Towing the vehicle
– Frame hooks................................... 143
– Instructions..............................174-179
Trailer towing....................................... 174
Transaxle (automatic) ......................... 156
– Changing oil .................................... 197
– Fluid level check............................. 196
– Specific fluid.................................... 196
Transaxle (manual).............................. 157
– Gear oil change .............................. 196
– Gearshift lever............................... 132
– Specification.................................... 195
– Using the transaxle........................ 157
Transmission......................................... 252
Trip meter............................................. 87
Turn signal............................................. 64
– Bulb replacement........................... 223
Tires
– Compact spare tire ....................... 211
261-268 SEDICI LUM FL GB 1E 19-06-2009 11:12 Pagina 264