2009 CHERY TIGGO steering wheel

Downloaded from www.Manualslib.com manuals search engine Wiper Switch
Removal & Installation
1. Disconnect the negative battery cable.
2. Remove the steering wheel (See Steering Wheel Removal & Installation in Section 11 Steering).
3. Remove the steering column shroud retainingscrews (1) and then remove the shroud.
4. Disconnect the wiper switch electrical connector.
5. Loosen the clamp and remove the wiper switch.
6. Installation is in the reverse order of removal.
WIPERS AND WASHERS
LTSM110031
LTSM150106
15–242Chery Automobile Co., Ltd.

Downloaded from www.Manualslib.com manuals search engine A/1Power Fuse Box B3
B /1Power Fuse Box B3
C /1Power Fuse Box B3
D /1Power Fuse Box B4
E /1Power Fuse Box B4
E-001 B/81 ECM D2
E-002 B/25 ABS Hydraulic Control Module D2
E-003 B/4A/C Pressure Switch D2
E-004 W-O/4 Upstream Oxygen Sensor D3
E-005 W-O/4 Downstream Oxygen Sensor (With EOBD) D3
E-006 B/3Crankshaft Position Sensor C4
E-007 B/3Camshaft Position Sensor C4
E-008 B/3Generator C2
E-009 B/5Air Flow Sensor C4
E-010 B/2Fuel Injector No.1 C3
E-011 B/2Fuel Injector No.2 C3
E-012 B/2Fuel Injector No.3 C3
E-013 B/2Fuel Injector No.4 C4
E-014 B/1Power Steering Switch B2
E-015 B/2A/C Compressor B2
E-016 W/1 Oil Pressure Switch B2
E-017 B/3Knock Sensor B3
E-018 B/1Starter Motor B4
E-019 B/2Engine Coolant Temperature Sensor C4
E-020 B/4Ignition Coil C4
E-021 B/2Backup Lamp Switch C4
E-022 B/3Canister Control Valve C4
E-023 B/3Vehicle Speed Sensor D4
E-024 GR/2 Brake Fluid Level Switch D4
E-025 GR/5 Front Wiper Motor D4
E-026 B/2Siren D3
E-027 B/6Electronic Throttle Control Actuator B3
E-028 B/2Front Wheel Speed Sensor LH D5
E-029 B/2Front Wheel Speed Sensor RH D1
E-030 B/2Front Fog Lamp LH B5
E-033 B/4Manifold Absolute Pressure Sensor (With
1.6L Engine) C3
E-034 B/10 Front Combination Lamp LH C5
E-035 B/3Accelerator Sensor C2
E-038 B/3Side Turn Signal Lamp LH D5
E-039 B/2Side Turn Signal Lamp RH D1
E-040 B/2Front Fog Lamp RH B1
E-041 B/4Downstream Oxygen Sensor (Without
EOBD) D3
E-042 B/10 Front Combination Lamp RH C1
VEHICLE HARNESS ROUTING MAPS
16
16–49Chery Automobile Co., Ltd.

Downloaded from www.Manualslib.com manuals search engine A/1Power Fuse Box B3
B /1Power Fuse Box B3
C /1Power Fuse Box B3
D /1Power Fuse Box B4
E /1Power Fuse Box B4
A-001 B/10 Front Combination Lamp LH B5
A-002 B/10 Front Combination Lamp RH B1
A-003 B/2Front Fog Lamp LH A5
A-004 B/2Front Fog Lamp RH A1
A-005 GR/1 Horn 1 B5
A-006 GR/2 Horn 2 B5
A-007 B/2Main Fan Motor B3
A-008 B/2Secondary Fan Motor B4
A-011 GR/3 Cooling Fan Control Module B4
A-017 W/14 Body Fuse And Relay Box (H) D5
A-018 B/1Body Fuse And Relay Box (C) D5
A-020 B/25 ABS Hydraulic Control Module C2
A-021 B/2Front Wheel Speed Sensor LH D5
A-022 B/2Front Wheel Speed Sensor RH D1
A-023 B/2A/C Compressor B2
A-024 B/1Power Steering Switch C2
A-025 W/16 Front Fuse And Relay Box (A) D2
A-026 W/8 Front Fuse And Relay Box (B) D2
A-027 W/14 Front Fuse And Relay Box (C) D2
A-028 B/1Front Fuse And Relay Box (D) D2
A-029 B/3Accelerator Sensor C2
A-032 B/2Turn Signal Lamp LH C5
A-033 B/2Turn Signal Lamp RH C1
A-034 B/2Side Turn Signal Lamp LH D5
A-035 B/2Side Turn Signal Lamp RH D1
A-036 GR/2 Brake Fluid Level Switch D4
A-037 GR/5 Front Wiper Motor D4
A-038 W/2 Front Washer Motor B1
A-039 B/2Rear Washer Motor B1
A-040 B/2Siren D3
A-041 B/1A/C Pressure Switch D2
A-042 B/1Front Fuse And Relay Box (E) D2
A-043 W/4 Front Fuse And Relay Box (F) D2
A-044 W/20 Front Fuse And Relay Box (G) D2
A-045 B/10 Front Fuse And Relay Box (H) D2
A-046 B/2Front Fuse And Relay Box (I) D2
BB B/1BCM (Body Control Module) (Battery) D2
A-100 W/18 To C-100 D4
A-101 W/18 To C-101 D4
VEHICLE HARNESS ROUTING MAPS
16–56Chery Automobile Co., Ltd.

Downloaded from www.Manualslib.com manuals search engine Cooling System.............................6-1
Cooling System Draining and Filling, Cooling System . . . 6-13
Crankshaft Position (CKP) Sensor, 1.6L & 1.8L Engine Controls .......................... 3-220
Crankshaft Position (CKP) Sensor, 2.0L Engine Controls ............................... 3-430
Crankshaft Position (CKP) Sensor, 2.4L Engine Controls ............................... 3-542
Crankshaft, 1.6L & 1.8L Engine Mechanical .........2-60
Crankshaft, 2.0L Engine Mechanical ..............2-133
Crankshaft, 2.4L Engine Mechanical ..............2-233
Cylinder Head Cover, 1.6L & 1.8L Engine Mechanical . . . 2-19
Cylinder Head Cover, 2.0L Engine Mechanical ........2-93
Cylinder Head Cover, 2.4L Engine Mechanical .......2-170
Cylinder Head Unit Repair, 1.6L & 1.8L Engine Mechanical .............................. 2-63
Cylinder Head Unit Repair, 2.0L Engine Mechanical ....2-136
Cylinder Head Unit Repair, 2.4L Engine Mechanical ....2-241
Cylinder Head, 1.6L & 1.8L Engine Mechanical . . . 2-23, 2-63
Cylinder Head, 2.0L Engine Mechanical ........2-136, 2-97
Cylinder Head, 2.4L Engine Mechanical .......2-175, 2-241
D
Diagnosing Electrical Failures, Electrical Circuit Diagnosis
Information .............................. 1-16
Diagnosis & Testing, 1.6L & 1.8L Engine Controls .....3-22
Diagnosis & Testing, 1.6L & 1.8L Engine Mechanical . . . 2-13
Diagnosis & Testing, 2.0L Engine Controls .........3-247
Diagnosis & Testing, 2.0L Engine Mechanical ........2-87
Diagnosis & Testing, 2.4L Engine Controls .........3-458
Diagnosis & Testing, 2.4L Engine Mechanical .......2-163
Diagnosis & Testing, 5-Speed Manual Transaxle ......8-259
Diagnosis & Testing, Air Distribution .............13-28
Diagnosis & Testing, Airbag System ...............14-8
Diagnosis & Testing, Alignment .................10-42
Diagnosis & Testing, Antilock Brakes .............12-45
Diagnosis & Testing, Base Brakes ................12-7
Diagnosis & Testing, Body Exterior ..............15-228
Diagnosis & Testing, Body Interior .........15-113, 15-64
Diagnosis & Testing, Charging System .............5-16
Diagnosis & Testing, DP0 Automatic Transaxle .......8-19
Diagnosis & Testing, Drive Shaft (4x4) .............9-26
Diagnosis & Testing, F4A4 Automatic Transaxle ......8-158
Diagnosis & Testing, Front Axle ..................9-4
Diagnosis & Testing, Front Suspension .............10-6
Diagnosis & Testing, Fuel Delivery System ..........4-12
Diagnosis & Testing, Manual Temperature Control ....13-12 Diagnosis & Testing, Parking Brake
..............12-82
Diagnosis & Testing, Power Steering Pump .........11-33
Diagnosis & Testing, Rear Axle ..................9-11
Diagnosis & Testing, Rear Suspension ............10-29
Diagnosis & Testing, Steering Column ............11-11
Diagnosis & Testing, Steering Gear ..............11-20
Diagnosis & Testing, Steering System .............11-4
Diagnosis & Testing, System Plumbing ............13-35
Diagnosis & Testing, Wheels and Tires ............10-50
Diagnosis and Testing, Cooling System .............6-11
Diagnosis and Testing, Exhaust System .............7-4
Diagnosis and Testing, Starting System .............5-6
Diagnostic Help, Antilock Brakes ................12-45
Diagnostic Trouble Code (DTC) List, Airbag System ....14-9
Diagnostic Trouble Code (DTC)

List, Antilock Brakes . . . 12-46
Diagnostic Trouble Code (DTC) List, Body Interior .......................... 15-114, 15-65
Diagnostic Trouble Code (DTC) List, DP0 Automatic Transaxle ................................ 8-20
Diagnostic Trouble Code (DTC) List, F4A4 Automatic Transaxle ............................... 8-159
Diagnostic Trouble Code (DTC) Tests, 1.6L & 1.8L Engine Controls ........................... 3-35
Diagnostic Trouble Code (DTC) Tests, 2.0L Engine Controls ............................... 3-261
Diagnostic Trouble Code (DTC) Tests, 2.4L Engine Controls ............................... 3-469
Diagnostic Trouble Code (DTC) Tests, Airbag System . . 14-11
Diagnostic Trouble Code (DTC) Tests, Antilock Brakes . . 12-47
Diagnostic Trouble Code (DTC) Tests, Body Interior .......................... 15-117, 15-66
Diagnostic Trouble Code (DTC) Tests, DP0 Automatic Transaxle ................................ 8-22
Diagnostic Trouble Code (DTC) Tests, F4A4 Automatic Trans- axle .................................. 8-160
Differential Carrier, Front Differential ..............8-312
Differential Unit Repair, Front Differential ...........8-312
Door Lock Assembly, Body Interior ..............15-35
Door Lock Switch, Body Interior ................15-35
Door Locks, Body Interior ..................... 15-29
Doors, Body Exterior ....................... 15-167
DP0 Automatic Transaxle .......................8-1
DPO Automatic Transaxle Assembly, DP0 Automatic Transaxle ............................... 8-136
Drive Shaft (4x4) ........................... 9-24
Driver Side Airbag, Airbag System ...............14-46
INDEX
AI-2

Downloaded from www.Manualslib.com manuals search engine Front Strut, Front Suspension..................10-21
Front Sub-Frame Assembly, Front Suspension .......10-17
Front Suspension ........................... 10-1
Front Wheel Alignment, Alignment ...............10-44
Front Wheel Speed Sensor, Antilock Brakes .........12-77
Front Windshield, Body Exterior ................15-219
Front Wiper Arm, Body Exterior ................15-240
Front Wiper Link, Body Exterior ................15-241
Front Wiper Motor, Body Exterior ...............15-238
Fuel Delivery System ..........................4-1
Fuel Door, Body Exterior ..................... 15-200
Fuel Door, Body Exterior ........................200
Fuel Filter, Fuel Delivery System .................4-18
Fuel Injector Rail, Fuel Delivery System ............4-19
Fuel Injector, Fuel Delivery System ................4-20
Fuel Pressure Regulator - With Mitsubishi 2.4L Engine, Fuel Delivery System ..................4-23
Fuel Pressure Relief Procedure, Fuel Delivery System . . . 4-15
Fuel Pump, Fuel Delivery System .................4-15
G
Gear Selector & Shifter Assembly, 5-Speed Manual
Transaxle ............................... 8-264
General Information, 1.6L & 1.8L Engine Controls ......3-3
General Information, 1.6L & 1.8L Engine Mechanical ....2-3
General Information, 2.0L Engine Controls ..........3-229
General Information, 2.0L Engine Mechanical .........2-77
General Information, 2.4L Engine Controls ..........3-442
General Information, 2.4L Engine Mechanical ........2-151
General Information, 5-Speed Manual Transaxle ......8-247
General Information, Air Distribution ..............13-26
General Information, Airbag System ...............14-2
General Information, Alignment .................10-39
General Information, Antilock Brakes .............12-35
General Information, Base Brakes ................12-2
General Information, Body Interior ..............15-104
General Information, Charging System .............5-12
General Information, Clutch System ..............8-317
General Information, Cooling System ...............6-2
General Information, DP0 Automatic Transaxle .........8-3
General Information, Drive Shaft (4x4) .............9-25
General Information, Evaporative Emissions .........3-577
General Information, Exhaust System ...............7-2
General Information, F4A4 Automatic Transaxle ......8-144
General Information, Front Axle ...................9-2
General Information, Front Differential .............8-308General Information, Front Suspension
.............10-2
General Information, Fuel Delivery System ...........4-2
General Information, Ignition Control .............3-566
General Information, Interactive Torque Management (ITM) System (4x4) ...............9-17
General Information, Manual Temperature Control .....13-2
General Information, Parking Brake ..............12-80
General Information, Power Steering Pump .........11-32
General Information, Rear Axle ...................9-9
General Information, Rear Suspension ............10-26
General Information, Seat Belt System ............14-51
General Information, Starting System ...............5-2
General Information, Steering Column .............11-9
General Information, Steering Gear ...............11-19
General Information, Steering System ..............11-2
General Information, System Controls .............13-19
General Information, System Plumbing ............13-33
General Information, T

ransfer Case (4x4)..........8-327
General Information, Vehicle Fuse Box Information ....16-38
General Information, Vehicle Ground Distribution .....16-28
General Information, Vehicle Power Distribution ......16-13
General Information, Vehicle Wiring Harness Layout . . . 16-45
General Information, Wheels and Tires ............10-48
General Information, Wiring Information ............16-2
Generator, Charging System ....................5-17
Grille, Body Exterior ........................ 15-201
Grille, Body Exterior ...........................201
H
Headlamp, Body Exterior ..................... 15-191
Headliner, Body Interior ...................... 15-15
Heated Seat Element, Body Interior ..............15-109
Heated Seat Switch, Body Interior ..............15-109
Heater Core, System Plumbing .................13-47
High Mounted Stop Lamp, Body Exterior ..........15-197
Hood Release Cable, Body Exterior ..............15-203
Hood, Body Exterior ........................ 15-202
Hood, Body Exterior ...........................202
Horn, Body Exterior .................. 15-206, 15-208
How To Locate Electrical Schematics In The Service Manual, Electrical Information ............1-25
How To Read Electrical Schematics, Electrical Information .............................. 1-21
How To Use This Manual, Service Information ........1-2
HVAC Housing, Air Distribution .................13-29
INDEX
AI-4

Downloaded from www.Manualslib.com manuals search engine On-Vehicle Service, Interactive Torque Management (ITM)System (4x4) ............................. 9-21
On-Vehicle Service, Manual Temperature Control .....13-15
On-Vehicle Service, Parking Brake ...............12-84
On-Vehicle Service, Power Steering Pump ..........11-34
On-Vehicle Service, Rear Axle ...................9-12
On-Vehicle Service, Rear Suspension .............10-30
On-Vehicle Service, Seat Belt System .............14-52
On-Vehicle Service, Starting System ................5-7
On-Vehicle Service, Steering Column .............11-12
On-Vehicle Service, Steering Gear ...............11-21
On-Vehicle Service, Steering System ..............11-6
On-Vehicle Service, System Controls .............13-24
On-Vehicle Service, System Plumbing .............13-37
On-Vehicle Service, Transfer Case (4x4) ...........8-328
On-Vehicle Service, Wheels and Tires .............10-51
Output Gear For Reverse Gear, 5-Speed Manual Transaxle ......................... 8-296
Output Shaft, 5-Speed Manual Transaxle ...........8-287
Outside Mirror, Body Exterior ..................15-214
Oxygen Sensor, 1.6L & 1.8L Engine Controls .......3-218
Oxygen Sensor, 2.0L Engine Controls .............3-428
Oxygen Sensor, 2.4L Engine Controls .............3-533
P
Paint Codes, Body Exterior ...................15-215
Paint, Body Exterior ........................ 15-215
Parking Brake ............................. 12-79
Parking Brake Cable, Parking Brake ..............12-85
Parking Brake Lever, Parking Brake ..............12-84
Parking Brake Shoes, Parking Brake ..............12-86
Pedal Pad, Body Interior ...................... 15-14
Pistons, 1.6L & 1.8L Engine Mechanical ............2-53
Pistons, 2.0L Engine Mechanical ................2-126
Pistons, 2.4L Engine Mechanical ................2-221
Positive Battery Cable, Starting System .............5-8
Power Brake Booster - LHD, Base Brakes ..........12-14
Power Brake Booster - RHD, Base Brakes ..........12-16
Power Fuse Box, Vehicle Fuse Box Information ......16-38
Power Outlet, Body Interior .................... 15-93
Power Steering Filling and Flushing, Steering System . . . 11-6
Power Steering Fluid Reservoir, Power Steering Pump ........................... 11-36
Power Steering Pressure and Return Lines - 1.6L & 1.8L & 2.0L, Power Steering Pump . . 11-37
Power Steering Pressure and Return Lines - 2.4L, Power Steering Pump ........................... 11-39
Power Steering Pump ....................... 11-31Power Steering Pump - 1.6L & 1.8L & 2.0L,
Power Steering Pump ...................... 11-34
Power Steering Pump - 2.4L, Power Steering Pump . . . 11-35
Power Window Motor, Body Interior .............15-100
Power Window Switch, Body Interior ............15-100
Power Window, Body Interior ..................15-96
Proper Service Practices, Service Information .........1-5
R
Radiator Support, Body Exterior................15-216
Radiator Support, Body Exterior ...................216
Radiator, Cooling System ...................... 6-17
Radio, Body Interior ......................... 15-8
Rear Axle ..................................9-8
Rear Axle Assembly (4x4), Rear Axle ..............9-13
Rear Brake Backing Plate, Base Brakes ............12-23
Rear Brake Caliper, Base Brakes ...........12-19, 12-30
Rear Brake Pads, Base Brakes ..................12-25
Rear Brake Rotor, Base Brakes .................12-22
Rear Coil Spring, Rear Suspension ...............10-33
Rear Combination Lamp Assembly, Body Exterior ....15-190
Rear Crankshaft Oil Seal, 1.6L & 1.8L Engine Mechanical .............................. 2-27
Rear Crankshaft Oil Seal, 2.0L Engine Mechanical ....2-100
Rear Crankshaft Oil Seal, 2.4L Engine Mechanical ....2-179
Rear Door Weatherstrip, Body Exterior ...........15-232
Rear Door, Body Exterior .................... 15-173
Rear Fog Lamp, Body Exterior .................15-193
Rear Hub and Bearing, Rear Axle ................9-12
Rear Intermediate Drive Shaft, Drive Shaft (4x4) ......9-27
Rear Lower Control Arm, Rear Suspension .........10-30
Rear Seat Belt and Pre-Tensioner, Seat Belt System . . . 14-54
Rear Seats, Body Interior .................... 15-107
Rear Shock Absorber, Rear Suspension ...........10-32
Rear Stabilizer Bar Link, Rear Suspension ..........10-32
Rear Suspension ........................... 10-25
Rear Trailing Arm Assembly, Rear Suspension .......10-35
Rear Upper Control Arm, Rear Suspension .........10-31
Rear Wheel Alignment, Alignment ...............10-45
Rear Wheel Speed Sensor, Antilock Brakes .........12-78
Rear Window, Body Exterior ..................15-221
Rear Wiper Arm, Body Exterior ................15-240
Rear Wiper Motor, Body Exterior ...............15-239
Recirculation Door Actuator, System Controls .......13-24
Remote Keyless Entry (RKE) Inoperative, Body Interior ........................... 15-115
Restraints Control Module (RCM), Airbag System .....14-49
INDEX
AI-6

Downloaded from www.Manualslib.com manuals search engine S
Scuff Plate, Body Interior..................... 15-14
Seat Belt Slider Track, Seat Belt System ...........14-53
Seat Belt System ........................... 14-50
Seats, Body Interior ........................ 15-104
Service Information ...........................1-1
Spare Tire Support, Body Exterior ..............15-205
Spare Tire Support, Body Exterior .................205
Spark Plug 1.6L & 1.8L & 2.0L, Ignition Control .....3-574
Spark Plug 2.4L, Ignition Control ................3-575
Spark Plug Wire 1.6L & 1.8L & 2.0L, Ignition Control .......................... 3-573
Spark Plug Wire 2.4L, Ignition Control ............3-574
Speed Control System, 2.0L Engine Controls ........3-432
Starter Motor Assembly, Starting System ............5-9
Starting System .............................5-1
Stationary Glass, Body Exterior ................15-217
Steering Column ............................ 11-8
Steering Column Shaft, Steering Column ...........11-15
Steering Column Shroud, Steering Column .........11-14
Steering Gear ............................. 11-18
Steering Gear - LHD, Steering Gear ..............11-21
Steering Gear - RHD, Steering Gear ..............11-25
Steering System ............................ 11-1
Steering Wheel, Steering Column ................11-12
Suction Line, System Plumbing .................13-45
Sun Visor, Body Interior ...................... 15-14
Sunroof Control Module, Body Exterior ...........15-230
Sunroof Glass, Body Exterior ..................15-229
Sunroof Motor, Body Exterior .................15-230
Sunroof Sun Visor, Body Exterior ...............15-229
Sunroof, Body Exterior ...................... 15-224
Symptom Diagnostic Tests, 2.4L Engine Symptom Diagnosis .............................. 3-544
System Controls ........................... 13-18
System Plumbing .......................... 13-32
T
Tail/Backup/Stop Lamp, Body Exterior ............15-194
Thermostat, Cooling System ....................6-14
Throttle Control Actuator, 2.4L Engine Controls ......3-538
Throttle Position Sensor (TPS), 2.4L Engine Controls . . 3-540
Tie Rod, Steering Gear ....................... 11-29
Timing Belt Automatic Tensioner, 2.4L Engine Mechanical
............................. 2-196
Tire Repair, Wheels and Tires ..................10-51
Tire Rotation, Wheels and Tires .................10-53
Transaxle Clutch Housing Assembly, 5-Speed Manual Transaxle ............................... 8-301
Transaxle Control Module (TCM), DP0 Automatic Transaxle ....................... 8-142
Transaxle Main Housing Assembly, 5-Speed Manual Transaxle ............................... 8-305
Transaxle, 5-Speed Manual Transaxle .............8-270
Transfer Case (4x4) ......................... 8-326
Transfer Case Unit Repair, Transfer Case (4x4) ......8-329
Transfer Case, Transfer Case (4x4) ..........8-328, 8-329
Turn Signal Lamp, Body Exterior ...............15-195
U
Unit Repair, Base Brakes ..................... 12-27
Unit Repair, Front Suspension ..................10-21
Upper Balance Shaft Timing Belt, 2.4L Engine Mechanical ............................. 2-198
Upper Balance Shaft, 2.4L Engine Mechanical .......2-204
V
Valve & Valve Guides, 1.6L & 1.8L Engine Mechanical . . 2-70
Valve & Valve Guides, 2.0L Engine Mechanical ......2-143
Valve & Valve Guides, 2.4L Engine Mechanical ......2-246
Valve Springs, 1.6L & 1.8L Engine Mechanical .......2-73
Valve Springs, 2.0L Engine Mechanical ............2-146
Valve Springs, 2.4L Engine Mechanical ............2-252
Vapor Canister 1.6L & 1.8L & 2.0L, Evaporative Emissions .............................. 3-585
Vapor Canister 2.4L, Evaporative Emissions .........3-586
Vehicle Clearance, Body Exterior ................15-154
Vehicle Fuse Box Information ..................16-37
Vehicle Ground Distribution .................... 16-27
Vehicle Harness Routing Maps, Vehicle Wiring Harness Layout .......................... 16-46
Vehicle Identification Number (VIN), Vehicle Information .............................. 1-10
Vehicle Information ...........................1-9
Vehicle Power Distribution .................... 16-12
Vehicle Service Preparation, Service Information .......1-3
Vehicle Speed Sensor, 1.6L & 1.8L Engine Controls . . . 3-221
Vehicle Wiring Harness Layout .................16-44
INDEX
AI
AI-7