2008 MITSUBISHI SHOGUN air filter

For pleasant driving
5-19
5
Air conditioning system
refrigerant and lubri-
cant recommendationsIf the air conditioning seems less
effective than usual, the cause
might be a refrigerant leak. We recommend you to have the system inspected.The air conditioning system in your vehicle must be charged with the refrigerant HFC-134a
and the lubricant ND-OIL8.
Use of any other refrigerant or
lubricant will cause severe dam-
age which will result in the n
eed to replace your vehicle’s
entire air conditioning system. The release of refrigerant into the atmosphere is not recommended.The new refrigerant HFC-134a in
your vehicle will not harm
the ozone layer. It is recommended that the refr
igerant be recovered and recy-
cled for further use.During a long period of disuseThe air conditioning should be operated for at least five min- utes each week, even in cold weather. This is to prevent the compressor from seizing and to maintain the air conditioningin the best operating condition.
Air purifier (with deodorizing function)
E00708400183
An air filter is incorporated in
to the air conditioning system to
remove pollen, dust, tobacco
smells and exhaust smells.
The air filter’s ability to collect pollen and dirt is reduced as itbecomes dirty, so replace it pe
riodically. For the maintenance
interval, refer to th
e “SERVICE BOOKLET”.
NOTE●
Operation in certain conditions such as driving on a dusty road and frequent use of th
e air conditioning can lead to
reduction of service life of
the filter. When the air flow
rate suddenly drops or when the windscreen or windowsstart to fog up easily, the ai
r filter requires replacement.
We recommend you to have it checked.
BK-BK2008E1ENUK.en-uk-Section8.fm Page
19 Wednesday, January 9, 2008 4:41 PM

For emergencies
6-9
6
Bleeding the fuel system
(diesel-powered vehicles only)
E00800700149
The fuel system should be bled to remove air as described below if the fuel supply is exhausted during travel. Pump the hand pump (A) at the top of the fuel filter until the hand pump becomes stiff.Then try again to start the engine. If the engine does not star
t, repeat the process above.
Removal of water from the fuel filter
(diesel-powered vehicles only)
E00800800140
If the fuel filter indication lamp in the instrument panel illumi- nates during driving, it indicates
that water has accumulated in
the fuel filter. If this occurs, remove the water as describedbelow. 1. Loosen the drain plug (A) at the bottom of the fuel filter.
BK-BK2008E1ENUK.en-uk-Section9.fm Page 9 Wednesday, January 9, 2008 4:46 PM

6-10 For emergencies
6
2. Operate the hand pump (B) slowly 6 or 7 times in order to
force the water out through the drain plug.
3. Tighten the drain plug when water no longer comes out. 4. Bleed the air in the fuel system.
(Refer to “Bleeding the fu
el system” on page 6-9.)
5. Check to be sure that the fuel filter indication lamp illumi-
nates when the ignition switch is turned to “ON”, and that it goes off when the engine is started. If in doubt, we rec- ommend you to have your vehicle inspected.
CAUTION
!●
Do not smoke or have any other open flame near the vehicle while bleedin
g the fuel system.
●
Be sure to carefully clean away any water drained out because any fuel mixe
d with the water could
ignite and cause a fire.
BK-BK2008E1ENUK.en-uk-Section9.fm Page
10 Wednesday, January 9, 2008 4:46 PM

Specifications
9-17
9
*: Rear washer fluid container is lo
cated on the backdoor. (Refer to “Rear window washer fluid” on page 8-12.)
No.
Item
Quantity
Lubricants
1
Engine oil
3200 models
Oil pan 7.5 litres
Refer to page 8-6
Oil filter 1.0 litreOil cooler 1.3 litres
3800 models
Oil pan 4.3 litresOil filter 0.3 litreOil cooler 0.3 litre
2
Automatic transmission fluid 9.7 litres DIA QUEEN ATF SP III
3
Brake fluid As required
Brake fluid DOT 3 or DOT 4
4
Clutch fluid As required
5
Washer fluid
Front 5.1 litres
—
Rear
*
1.4 litres
6
Power steering fluid As required
Genuine MITSUBISHI Power Steering Fluid or ATF
DEXRON III/DEXRON II
7
Engine coolant(Includes 0.65 litre in the reserve tank)
Without rear air conditioning 9.0 litres
DIA QUEEN SUPER LONG LIFE COOLANT or equiva-
lent
With rear air conditioning 10.5 litres
8
Manual transmission oil 3.2 litres
Hypoid gear oil API classification GL-4 SAE 75W-85 or
75W-90
9
Transfer oil 2.8 litres
BK-BK2008E1ENUK.en-uk-Section12.fm Page 17 Thursday, January 10, 2008 7:49 AM

Alphabetical index 2Changing a fuse 8-34 Charge warning lamp 3-16Check engine warning lamp 3-15Child restraint 2-44Child-protection rear doors 1-11Cigarette lighter 5-82CleaningAluminium wheel 7-8Chrome parts 7-8Exterior of your vehicle 7-4Genuine leather 7-4Interior of your vehicle 7-3Plastic, vinyl leather, etc 7-3Polishing 7-7Sunroof 7-9Washing 7-4Waxing 7-6ClutchFluid 8-14, 9-16Combination headlamps and dipper switch 3-58Convenient hook 5-105Coolant (engine) 8-10, 9-16Cruise control 4-70Cup holder 5-99Curtain airbag system 2-70
D
Daytime dipper button 3-9Demister (rear window) 3-77
Diesel particulate filter (DPF) 4-22 Diesel preheat indication lamp 3-12Dimensions 9-4Dipper (High/Low beam change) 3-61Door courtesy lamps 5-91, 8-38, 8-53Door-ajar warning lamp 3-17DoorsCentral door locks 1-9Child-protection 1-11Lock and unlock 1-7Driving, alcohol and drugs 4-3
E
Economical driving 4-2Electric window control 1-16Electrical system 9-12Electronic immobilizer (Ant
i-theft starting system) 1-3
Emergency starting 6-2EngineCoolant 8-10, 9-16MIVEC 4-20Number 9-3Oil 8-6, 9-16Overheating 6-6Specifications 9-11Used engine oils safety instructions and disposalinformation 8Water temperature gauge 3-9Error codes 5-72
BK-BK2008E1ENUK.en-ukIX.fm Page 2 Thursday, January 10, 2008 7:53 AM

Alphabetical index
3
Exterior and interior lamp operation 8-27
F
Fluid Automatic transmission fluid 9-16Brake fluid 8-13, 9-16Clutch fluid 8-14, 9-16Engine coolant 8-10, 9-16Manual transmission fluid 9-16Power steering fluid 8-16, 9-16Washer fluid 8-11, 9-16Fog lamp switch 3-66Foot lamps and ceiling lamp 5-89For cold and snowy weather 8-28Front automatic air conditioning 5-4Front fog lampsBulb capacity 8-36Indication lamp 3-12Replacement 8-42Switch 3-66Front seats 2-6Front turn-signal lampsBulb capacity 8-36Replacement 8-41FuelFilling the fuel tank 3Fuel filter indication lamp 3-13Fuel gauge 3-7Fuel selection 2
Low fuel warning lamp 3-8 Modification/alterations to th
e electrical or fuel systems 7
Tank capacity 3Fuel consumption 9-14Fuses 8-29Fusible links 8-29
G
Gauges 3-2, 3-10General maintenance 8-27General vehicle data 9-4Genuine parts 7Glove box 5-93Glove box lampBulb capacity 8-38Replacement 8-55
H
Handling of compact discs 5-74Hazard warning flasher switch 3-66Hazard warning indication lamps 3-12Head restraints 2-16Headlamp levelling 3-62Headlamp washer switch 3-76HeadlampsBulb capacity 8-36Headlamp flasher 3-61Replacement 8-38Switch 3-58
BK-BK2008E1ENUK.en-ukIX.fm Page 3 Thursday, January 10, 2008 7:53 AM

Alphabetical index 6Replacement 8-44 Rear window demister switch 3-77Rear-view camera 4-84Rear-view mirrorInside 4-9Rear-view mirrorOutside 4-11Refill capacities 9-16Removal of water from the fuel filter 6-9Replacement of lamp bulbs 8-36Reversing lampsBulb capacity 8-36Replacement 8-44Reversing sensor system 4-78Roof carrier precaution 4-89Room & map lamps 5-87Bulb capacity 8-38Replacement 8-50Running-in recommendations 4-5
S
Safe driving techniques 4-3Seat belt 2-38Adjustable seat belt anchor 2-41Child restraint 2-44Force limiter system 2-44Inspection 2-58Pregnant women restraint 2-43Pre-tensioner system 2-43
Rear / second, third seat belt storage 2-41 Seat belt reminder/warning lamp 2-40SeatsAdjustment 2-5Armrest 2-10, 2-14Front seats 2-6Head restraints 2-16Heated seats 2-12Lumbar support 2-10Making a flat seat 2-35Making a luggage area 2-19Rear seats 2-13Seat arrangement 2-3Second seats 2-13Third seat 2-16Service precaution 8-2Service reminder 3-3, 3-4Side airbag system 2-69Side box 5-97Snow tyres 8-22Spark plug 9-12Specifications 9-2Starting 4-18SteeringPower steering fluid 8-16, 9-16Power steering system 4-63Steering wheel heig
ht adjustment 4-8
Steering wheel lock 4-18Steering wheel remote control switch 5-70
BK-BK2008E1ENUK.en-ukIX.fm Page 6 Thursday, January 10, 2008 7:53 AM